Drying behaviour and visualization of surfactants after co-spray drying of surfactant-stabilized aqueous suspensions.

Surfactants are widely used in many industries as dispersants or flocculants for suspensions. As the addition of low concentrations of surfactant is sufficient to execute their effect, they barely alter the formulation composition. In this research it was examined whether surfactants, in particular polysorbate 80 (PS80), were suitable as suspension stabilizers for co-spray drying of drug-filler combinations. Therefore, their drying behaviour at different process and formulation settings was studied and mapped by means of fluorescently labelled PS80. Co-spray drying of 10% w/w aqueous suspensions stabilized with 0.1% w/w PS80 resulted in excessive loss of sticky powder in the conical lower part of the drying chamber and the powder conveyor ducts. Up to 16% of powder was lost in the first transporter (i.e. the first part of the conveyor ducts). The amount of powder deposited in the first transporter, and by extension the stickiness of the recovered powder, was correlated with the presence of PS80 on the surface of the spray dried particles. Redistribution of free surfactant molecules during droplet drying depended on the process and formulation parameters. Enrichment of PS80 at the particle surface was most pronounced after co-spray drying of liquid feedstocks with low suspended fraction at process conditions favouring rapid droplet drying.

Laser-induced vapor nanobubbles improve diffusion in biofilms of antimicrobial agents for wound care.

Being responsible for delayed wound healing, the presence of biofilms in infected wounds leads to chronic, and difficult to treat infections. One of the reasons why antimicrobial treatment often fails to cure biofilm infections is the reduced penetration rate of antibiotics through dense biofilms. Strategies that have the ability to somehow interfere with the integrity of biofilms and allowing a better penetration of drugs are highly sought after. A promising new approach is the use of laser-induced vapor nanobubbles (VNB), of which it was recently demonstrated that it can substantially enhance the penetration of antibiotics into biofilms, resulting in a marked improvement of the killing efficiency. In this study, we examined if treatment of biofilms with laser-induced vapor nanobubbles (VNB) can enhance the potency of antimicrobials which are commonly used to treat wound infections, including povidone-iodine, chlorhexidine, benzalkonium chloride, cetrimonium bromide and mupirocin. Our investigations were performed on Pseudomonas aeruginosa and Staphylococcus aureus biofilms, which are often implicated in chronic wound infections. Pre-treatment of biofilms with laser-induced VNB did enhance the killing efficiency of those antimicrobials which experience a diffusion barrier in the biofilms, while this was not the case for those compounds for which there is no diffusion barrier. The magnitude of the enhanced potency was in most cases similar to the enhancement that was obtained when the biofilms were completely disrupted by vortexing and sonication. These results show that laser-induced VNB are indeed a very efficient way to enhance drug penetration deep into biofilms, and pave the way towards clinical translation of this novel approach for treatment of wound infections.

Mucus-penetrating solid lipid nanoparticles for the treatment of cystic fibrosis: Proof of concept, challenges and pitfalls.

Nanocarrier-mediated transmucosal drug delivery based on conventional mucoadhesive, muco-inert or mucus-penetrating nanoparticles (NPs) is a growing field especially in challenging diseases like cystic fibrosis (CF). Efficacy of such systems dictates profound investigation of particle-mucus interaction and factors governing the whole process. Although variable techniques studying particle diffusion in mucus have been introduced, standardized procedures are lacking. The study comprised different methods based on micro- and macro-displacement as well as colloidal stability and turbidimetric experiments. Artificial sputum medium (ASM), CF sputum and mucus-secreting cell line (Calu-3 air interface culture, AIC) were applied. Solid lipid nanoparticles (SLNs) coated with variable hydrophilic sheath (poloxamer, Tween 80 or PVA) represented the nanocarriers under investigation. Both micro-displacement studies based on single particle tracking and macro-displacement experiments based on 3D-time laps confocal imaging revealed faster diffusion of poloxamer- > Tween- > PVA-coated SLNs. Compared to ASM, CF sputum showed not only lower diffusion rates but also remarkable discrepancies in particle-mucus diffusion rate due to sputum heterogenicity. Meanwhile, in case of Calu-3 AIC, thickness of the mucosal layer as well as density of mucus network were key determinants in the diffusion process. The points emphasized in this study highlight the road towards in vivo relevant particle-mucus interaction research.

Fertility preservation for trans men: frozen-thawed in vitro matured oocytes collected at the time of ovarian tissue processing exhibit normal meiotic spindles.

PURPOSES: At the moment of sex reassignment surgery (SRS), the ovarian tissue is sometimes cryopreserved as fertility preservation option for female-to-male trans men, also called trans men. During this preparation, cumulus-oocyte-complexes (COCs) can be found and in vitro matured. It is not known if these oocytes are developmentally competent. In order to use these oocytes for fertility preservation and subsequent fertilization, a normal spindle structure before and after vitrification is necessary. METHODS: A total of 680 COCs were collected from trans men (n = 16) at the time of SRS and after testosterone treatment. The COCs were subjected to in vitro maturation and those that reached the metaphase II stage (MII) were collected and split into two groups; group 1 was immediately fixed for spindle staining and group 2 was first vitrified and warmed followed by spindle staining. Statistical analysis was performed by Fisher's exact test. RESULTS: After 48 h in vitro maturation, 38.1% of COCs were at MII stage. Those oocytes were split in two groups: (1) 126 MII oocytes in the noncryopreservation group and (2) 133 MII oocytes underwent cryopreservation through vitrification. The oocyte survival rate, after 2 h warming, was 67.7%. Both the noncryopreserved and the vitrified group showed comparable results concerning normal spindle structure and chromosomes alignment, 85.7% vs. 92.2% (P = 0.27). CONCLUSIONS: Spindle structure analysis and chromosomal alignment after vitrification seem normal in in vitro matured COCs collected during the tissue processing of ovaries in trans men at the time of SRS. The MII oocytes do not seem to be morphologically affected by prolonged testosterone treatment.

Fluorescent Labeling of Plasmid DNA and mRNA: Gains and Losses of Current Labeling Strategies.

Live-cell imaging has provided the life sciences with insights into the cell biology and dynamics. Fluorescent labeling of target molecules proves to be indispensable in this regard. In this Review, we focus on the current fluorescent labeling strategies for nucleic acids, and in particular mRNA (mRNA) and plasmid DNA (pDNA), which are of interest to a broad range of scientific fields. By giving a background of the available techniques and an evaluation of the pros and cons, we try to supply scientists with all the information needed to come to an informed choice of nucleic acid labeling strategy aimed at their particular needs.

Chitosan nanoparticles for siRNA delivery: optimizing formulation to increase stability and efficiency.

This study aims at developing chitosan-based nanoparticles suitable for an intravenous administration of small interfering RNA (siRNA) able to achieve (i) high gene silencing without cytotoxicity and (ii) stability in biological media including blood. Therefore, the influence of chitosan/tripolyphosphate ratio, chitosan physicochemical properties, PEGylation of chitosan as well as the addition of an endosomal disrupting agent and a negatively charged polymer was assessed. The gene silencing activity and cytotoxicity were evaluated on B16 melanoma cells expressing luciferase. We monitored the integrity and the size behavior of siRNA nanoparticles in human plasma using fluorescence fluctuation spectroscopy and single particle tracking respectively. The presence of PEGylated chitosan and poly(ethylene imine) was essential for high levels of gene silencing in vitro. Chitosan nanoparticles immediately released siRNA in plasma while the inclusion of hyaluronic acid and high amount of poly(ethylene glycol) in the formulation improved the stability of the particles. The developed formulations of PEGylated chitosan-based nanoparticles that achieve high gene silencing in vitro, low cytotoxicity and high stability in plasma could be promising for intravenous delivery of siRNA.

Thiazolidinedione derivatives as novel agents against Propionibacterium acnes biofilms.

AIMS: The aim of the present study was to determine the effect of two thiazolidinedione derivatives on Propionibacterium acnes biofilm formation in vitro and to assess their effect on the susceptibility of P. acnes biofilms towards antimicrobials. METHODS AND RESULTS: The compounds were shown to have a moderate to strong antibiofilm activity when used in subinhibitory concentrations. These compounds do not affect P. acnes attachment but lead to increased dispersal of biofilm cells. This dispersal results in an increased killing of the P. acnes biofilm cells by conventional antimicrobials. CONCLUSION: The antibiofilm effect and the effect on biofilm susceptibility of the thiazolidinedione-derived quorum sensing inhibitors were clearly demonstrated. SIGNIFICANCE AND IMPACT OF THE STUDY: Propionibacterium acnes infections are difficult to treat due to the presence of biofilms at the infection site and the associated resistance towards conventional antimicrobials. Our results indicate that these thiazolidinedione derivatives can be promising leads used for the treatment of P. acnes infections and as anti-acne drugs.

Self-calibrated concentration measurements of polydisperse nanoparticles.

Quantitative characterization of nanoparticles, e.g. accurate estimation of concentration distributions, is critical to many pharmaceutical and biological applications. We present a method that enables for the first time highly accurate size and absolute concentration measurements of polydisperse nanoparticles in solution, based on fluorescence single particle tracking, that are self-calibrated in the sense that the detection region volume is estimated based on the tracking data. The method is evaluated using simulations and experimental data of polystyrene nanospheres in water/sucrose solution. In addition, the method is used to quantify aggregation and clearance of different types of liposomes after intravenous injection in rats, where additional and more accurate information can be obtained that was previously unavailable, which can help elucidate their usefulness as drug carriers.

Measuring absolute nanoparticle number concentrations from particle count time series.

Single-particle microscopy is important for characterization of nanoparticulate matter for which accurate concentration measurements are crucial. We introduce a method for estimating absolute number concentrations in nanoparticle dispersions based on a fluctuating time series of particle counts, known as a Smoluchowski process. Thus, unambiguous tracking of particles is not required and identification of single particles is sufficient. However, the diffusion coefficient of the particles must be estimated separately. The proposed method does not require precalibration of the detection region volume, as this can be estimated directly from the observations. We evaluate the method in a simulation study and on experimental data from a series of dilutions of 0.2- and 0.5-µm polymer nanospheres in water, obtaining very good agreement with reference values.

siRNA and pharmacological inhibition of endocytic pathways to characterize the differential role of macropinocytosis and the actin cytoskeleton on cellular uptake of dextran and cationic cell penetrating peptides octaarginine (R8) and HIV-Tat.

Cell penetrating peptides (CPPs) have been extensively studied as vectors for cellular delivery of therapeutic macromolecules. It is widely accepted that they can enter cells directly across the plasma membrane but also gain access through endocytic pathways that are yet to be fully defined. Here we developed siRNA methods in epithelial cell lines, HeLa and A431, to inhibit endocytic pathways regulated by clathrin heavy chain, flotillin-1, caveolin-1, dynamin-2 and Pak-1. In each case, functional uptake assays were developed to characterize the requirement for these proteins, and the pathways they regulate, in the internalisation of defined endocytic probes and also the CPPs octaarginine and HIV-Tat. Peptide uptake was only inhibited in A431 cells depleted of the macropinocytosis regulator Pak-1, but experimental variables including choice of cell line, pharmacological inhibitor, macropinocytic probe and serum starvation significantly influence our ability to assess and assign this pathway as an important route for CPP uptake. Actin disruption with Cytochalasin D inhibited peptide entry in both cell lines but the effects of this agent on dextran uptake was cell line dependent, reducing uptake in HeLa cells and increasing uptake in A431 cells. This was further supported in experiments inducing actin stabilisation by Jasplakinolide, emphasising that the actin cytoskeleton can both promote and hinder endocytosis. Overall the data identify important aspects regarding the comparative mechanisms of CPP uptake and macropinocytosis, and accentuate the significant methodological challenges of studying this pathway as an endocytic portal and an entry route for drug delivery vectors.

An in vitro assay based on surface plasmon resonance to predict the in vivo circulation kinetics of liposomes.

The adsorption of blood proteins onto liposomes and other colloidal particles is an important process influencing the circulation time. Proteins adsorbed to the surface of liposomes can mediate recognition of the liposomes by macrophages of the reticuloendothelial system (RES) facilitating their clearance from the circulation. Coating liposomes with poly(ethylene glycol) (PEG) decreases the blood clearance considerably, most likely due to reduced protein adsorption and/or liposome aggregation. By using the relation between clearance and protein binding, the present study introduces an in vitro assay measuring interactions of liposomes with proteins to predict their blood clearance in vivo. Such assay is valuable since it limits time and costs, and importantly reduces the number of animals required for pharmacokinetic investigations of new formulations. In the current study, Surface Plasmon Resonance (SPR) and fluorescence Single Particle Tracking (fSPT) were used to study liposome-protein interactions and blood induced liposome aggregation in vitro. By means of SPR the interactions between proteins and liposomes coated with PEG of different molecular weights and at different densities (PEG(2000) in 2.5%, 5% and 7%; PEG(5000) in 0.5%, 1.5% and 2.5%), were measured for several plasma proteins: human serum albumin (HSA), apolipoprotein E (ApoE), α2-macroglobulin (α2-M), ß2-glycoprotein (ß2-G) and fibronectin (Fn). Liposomes coated with PEG interacted less with all proteins, an effect which increased with the PEG surface density. In parallel, fSPT analysis showed that the exposure of liposomes to full blood did not change the liposome size, indicating that aggregation is not a strong attributive factor in the clearance of these liposomes. In addition, the SPR measurements of the interactions between liposomes and proteins were correlated with the blood clearance of the liposomes. For each protein, the degree of protein-liposome interaction as determined by SPR showed a moderate to strong positive correlation with the clearance of the liposome type.

Effect of a low concentration of a cationic steroid antibiotic (CSA-13) on the formation of a biofilm by Pseudomonas aeruginosa.

AIMS: Cationic steroids like CSA-13 have been designed by analogy with antimicrobial cationic peptides and have bactericidal properties. The purpose of this work was to evaluate the effect of a low concentration (1 mg l(-1)) of CSA-13 on the formation of a biofilm by eight strains of Pseudomonas aeruginosa (four mucoid and four nonmucoid strains) on an inert surface. METHOD AND RESULTS: The biofilm formation was measured with the Crystal Violet method. CSA-13 inhibited the formation of a biofilm by three strains. The zeta potential varied among the strains. The inhibition by the cationic steroid analogue affected the populations of bacteria with the lowest zeta potential. P. aeruginosa bound a fluorescent, more hydrophobic analogue of CSA-13 but there was no correlation between this binding and the inhibition by CSA-13 of biofilm formation. The interaction of CSA-13 with bacteria did not modify their ability to produce rhamnolipids. CONCLUSIONS: A low concentration of CSA-13 inhibits the formation of a biofilm by P. aeruginosa through electrostatic interactions and without affecting the production of rhamnolipids. SIGNIFICANCE AND IMPACT OF THE STUDY: A low, nontoxic concentration of CSA-13 might be beneficial for the prevention of biofilm formation.

Photopolymerized thermosensitive hydrogels for tailorable diffusion-controlled protein delivery.

In this paper the possibility to tailor degradation and protein release behavior of photopolymerized thermosensitive hydrogels is studied. The hydrogels consist of ABA triblock copolymer, in which the thermosensitive A-blocks are methacrylated poly(N-(2-hydroxypropyl)methacrylamide lactate)s and the B-block is poly(ethylene glycol) with molecular weight of 10 kDa. These hydrogels are prepared by using a combination of physical and chemical cross-linking methods. When a solution of a thermosensitive methacrylated p(HPMAm-lac)-PEG-p(HPMAm-lac) is heated above its cloud point a viscoelastic material is obtained, which can be stabilized by introducing covalent cross-links by photopolymerization. By varying the polymer concentration, hydrogels with different mechanical properties are formed, of which the cross-linking density, mesh size, swelling and degradation behavior can be tuned. It was demonstrated that the release rate of three model proteins (lysozyme, BSA and IgG, with hydrodynamic diameters ranging from 4.1 to 10.7 nm) depended on the protein size and hydrogel molecular weight between cross-links and was governed by the Fickian diffusion. Importantly, the encapsulated proteins were quantitatively released and the secondary structure and the enzymatic activity of lysozyme were fully preserved demonstrating the protein friendly nature of the studied delivery system.

Synergism between particle-based multiplexing and microfluidics technologies may bring diagnostics closer to the patient.

In the field of medical diagnostics there is a growing need for inexpensive, accurate, and quick high-throughput assays. On the one hand, recent progress in microfluidics technologies is expected to strongly support the development of miniaturized analytical devices, which will speed up (bio)analytical assays. On the other hand, a higher throughput can be obtained by the simultaneous screening of one sample for multiple targets (multiplexing) by means of encoded particle-based assays. Multiplexing at the macro level is now common in research labs and is expected to become part of clinical diagnostics. This review aims to debate on the "added value" we can expect from (bio)analysis with particles in microfluidic devices. Technologies to (a) decode, (b) analyze, and (c) manipulate the particles are described. Special emphasis is placed on the challenges of integrating currently existing detection platforms for encoded microparticles into microdevices and on promising microtechnologies that could be used to down-scale the detection units in order to obtain compact miniaturized particle-based multiplexing platforms.

Can we better understand the intracellular behavior of DNA nanoparticles by fluorescence correlation spectroscopy?

The use of non-viral gene carriers to deliver small nucleic acids like antisense oligonucleotides (ODNs) and small interfering RNA (siRNA) remains an attractive but challenging goal in antisense therapy. Indeed, different barriers need to be overcome in the delivery process before a therapeutic effect can be obtained. One promising technique which we have been evaluating to improve our understanding of the intracellular behavior of nucleic acids/carrier complexes is Fluorescence Correlation Spectroscopy (FCS). In particular, we have used FCS for studying the protection of the nucleic acids against enzymatic degradation, and the association and dissociation of the nucleic acids with their carrier, both in buffer and in living cells. In this report, we will review our experience and findings on the use of FCS for that purpose and discuss the strengths and weaknesses of this interesting technique.

Protection of oligonucleotides against enzymatic degradation by pegylated and nonpegylated branched polyethyleneimine.

Among the cationic polymers, polyethyleneimine (PEI) is a promising candidate for delivery of oligodeoxynucleotides (ODNs). In this study, we wondered whether pegylation of PEI influences the complexation with ODNs. We especially aimed to investigate whether ODNs are differently protected against enzymatic degradation in PEI and polyethylene glycol-polyethyleneimine (PEG-PEI) polyplexes. Using fluorescence resonance energy transfer combined with fluorescence correlation spectroscopy, we found that PEI/ODN polyplexes remain to protect the ODNs they carry over a prolonged period of time while in PEG-PEI/ODN polyplexes the degradation of the ODNs slowly proceeds. We attribute this to the fact that PEI seems to compact the ODNs more firmly in the polyplexes' core than PEG-PEI, which apparently also results in a better protection against enzymatic degradation. These observations may also influence the efficiency of PEI-based ODN delivery in vivo, where pegylation is an attractive strategy to enhance the stability of the polyplexes in the blood stream.

Influence of free chains on the swelling pressure of PEG-HEMA and dex-HEMA hydrogels.

Insight in the osmotic behavior of degrading hydrogels is of great importance in the design of biodegradable hydrogels for biomedical applications. This study compares the degradation behavior of PEG-HEMA (hydroxyethylmethacrylated polyethylene glycol) and dex-HEMA (hydroxyethylmethacrylated dextran) hydrogels. The degradation of PEG-HEMA gels takes several months to over a year, while that of dex-HEMA gels takes only days or weeks. The faster degradation kinetics of dex-HEMA networks can be attributed to stabilization of the keto-enol form by hydroxyl groups. Upon degradation of PEG-HEMA and dex-HEMA hydrogels, respectively, free PEG and free dextran chains are produced. We investigated the effect of unattached PEG and dextran chains on the swelling pressure of the degrading gels. It is found that low molecular weight free chains significantly increase the swelling pressure. However, the contribution of higher molecular weight free chains (M(w)>10 kDa) is similar to that of the network chains.

Pegylation of liposomes favours the endosomal degradation of the delivered phosphodiester oligonucleotides.

Liposomal vesicles have been widely investigated as carriers for the intracellular delivery of oligonucleotides (ONs). To avoid unspecific uptake by the reticulo endothelial system, 'pegylation' of the liposomes, by incorporating polyethyleneglycol (PEG) at the surface, has been an attractive strategy. While pegylation has a clear benefit on the systemic level, one could wonder if pegylation also benefits the delivery efficacy of liposomes at the intracellular level. We compared the intracellular distribution of non-pegylated and pegylated liposomes, with special attention to the integrity of the oligonucleotides they are carrying. After uptake in the cells, the non-pegylated liposomes efficiently escaped from the endosomes thereby releasing phosphodiester oligonucleotides (PO-ONs) in the cytoplasm of the cells. The PO-ONs were however rapidly degraded in the intracellular environment. In contrast to non-pegylated liposomes, pegylated liposomes failed in protecting the PO-ONs they were carrying, leading to rapid degradation of the PO-ONs in the endosomal compartment. Furthermore, the PEG chains inhibited the endosomal escape of the degraded ONs. These intracellular findings explain why pegylated liposomes failed in establishing an antisense effect.

Delivery of phosphodiester oligonucleotides: can DOTAP/DOPE liposomes do the trick?

Delivering phosphodiester ONs (PO-ONs) remains an attractive but challenging goal in antisense therapy. Both in the literature and in our experiments, most cationic liposomes fail in generating an antisense effect with PO-ONs, while they succeed with chemically modified ONs such as phosphothioate ONs (PS-ONs). This work aims to explain the biological activity of PO- and PS-ONs delivered by DOTAP/DOPE liposomes based on a detailed understanding of their cell biological behavior by means of fluorescence correlation spectroscopy and confocal laser scanning microscopy. We conclude that DOTAP/DOPE liposomes are not suited to deliver PO-ONs due to the release of naked PO-ONs in the cytosol at the time of the endosomal escape of the liposomes and the subsequent rapid degradation of the naked PO-ONs. Carriers that would not release the PO-ONs upon endosomal escape but would continue to carry the PO-ONs until they arrive at the target mRNA could therefore be better suited to delivering PO-ONs. In the case of PS-ONs, the ONs are not degraded upon release at the time of the endosomal escape of the liposomes, creating a pool of intact, biologically active PS-ONs and thus making DOTAP/DOPE liposomes mainly suitable for delivering nuclease resistant ONs. However, the cells seemed to display an export pathway for removing intact PS-ONs from the cells, limiting the presence of naked PS-ONs in the nucleus to approximately 8 h following the delivery.