A retrieval analysis of the Precice intramedullary limb lengthening system.

OBJECTIVES: The Precice nail is the latest intramedullary lengthening nail with excellent early outcomes. Implant complications have led to modification of the nail design. The aim of this study was to perform a retrieval study of Precice nails following lower-limb lengthening and to assess macroscopical and microscopical changes to the implants and evaluate differences following design modification, with the aim of identifying potential surgical, implant, and patient risk factors. METHODS: A total of 15 nails were retrieved from 13 patients following lower-limb lengthening. Macroscopical and microscopical surface damage to the nails were identified. Further analysis included radiology and micro-CT prior to sectioning. The internal mechanism was then analyzed with scanning electron microscopy and energy dispersive x-ray spectroscopy to identify corrosion. RESULTS: Seven male and three female patients underwent 12 femoral lengthenings. Three female patients underwent tibial lengthening. All patients obtained the desired length with no implant failure. Surface degradation was noted on the telescopic part of every nail design, less on the latest implants. Microscopical analysis confirmed fretting and pitting corrosion. Following sectioning, black debris was noted in all implants. The early designs were found to have fractured actuator pins and the pin and bearings showed evidence of corrosive debris. The latest designs showed evidence of biological deposits suggestive of fluid ingress within the nail but no corrosion. CONCLUSION: This study confirms less internal corrosion following modification, but evidence of titanium debris remains. We recommend no change to current clinical practice. However, potential reuse of the Precice nail, for secondary limb lengthening in the same patient, should be undertaken with caution.Cite this article: V. C. Panagiotopoulou, K. Davda, H. S. Hothi, J. Henckel, A. Cerquiglini, W. D. Goodier, J. Skinner, A. Hart, P. R. Calder. A retrieval analysis of the Precice intramedullary limb lengthening system. Bone Joint Res 2018;7:476-484. DOI: 10.1302/2046-3758.77.BJR-2017-0359.R1.

The "Good, Bad and Ugly" pin site grading system: A reliable and memorable method for documenting and monitoring ring fixator pin sites.

Although there is much in the literature regarding pin site infections, there is no accepted, validated method for documenting their state. We present a system for reliably labelling pin sites on any ring fixator construct and an easy-to-remember grading system to document the state of each pin site. Each site is graded in terms of erythema, pain and discharge to give a 3-point scale, named "Good", "Bad" and "Ugly" for ease of recall. This system was tested for intra- and inter-observer reproducibility. 15 patients undergoing elective limb reconstruction were recruited. A total of 218 pin sites were independently scored by 2 examiners. 82 were then re-examined later by the same examiners. 514 pin sites were felt to be "Good", 80 "Bad" and 6 "Ugly". The reproducibility of the system was found to be excellent. We feel our system gives a quick, reliable and reproducible method to monitor individual pin sites and their response to treatment.

Lengthening of the congenital short femur using the Ilizarov technique: a single-surgeon series.

We present a retrospective review of a single-surgeon series of 30 consecutive lengthenings in 27 patients with congenital short femur using the Ilizarov technique performed between 1994 and 2005. The mean increase in length was 5.8 cm/18.65% (3.3 to 10.4, 9.7% to 48.8%), with a mean time in the frame of 223 days (75 to 363). By changing from a distal to a proximal osteotomy for lengthening, the mean range of knee movement was significantly increased from 98.1 degrees to 124.2 degrees (p = 0.041) and there was a trend towards a reduced requirement for quadricepsplasty, although this was not statistically significant (p = 0.07). The overall incidence of regenerate deformation or fracture requiring open reduction and internal fixation was similar in the distal and proximal osteotomy groups (56.7% and 53.8%, respectively). However, in the proximal osteotomy group, pre-placement of a Rush nail reduced this rate from 100% without a nail to 0% with a nail (p < 0.001). When comparing a distal osteotomy with a proximal one over a Rush nail for lengthening, there was a significant decrease in fracture rate from 58.8% to 0% (p = 0.043). We recommend that in this group of patients lengthening of the femur with an Ilizarov construct be carried out through a proximal osteotomy over a Rush nail. Lengthening should also be limited to a maximum of 6 cm during one treatment, or 20% of the original length of the femur, in order to reduce the risk of complications.

Short-term results of hemi-resurfacing for osteonecrosis of the femoral head.

Published evidence has supported the use of femoral head resurfacing for patients with osteonecrosis of the femoral head. Between June 1999 and April 2001 we prospectively studied 15 femoral heads resurfaced in 12 patients with the Conserve Resurfacing Hemiarthroplasty. The male to female ratio was 8:4 and the mean age 38.7 years (range 26-60). The mean follow-up was 22.8 months (range 4-36). The senior author performed all procedures. There was one case of Ficat stage II, 9 cases of stage III and 5 cases of early stage IV. The mean time from onset of symptoms to surgery was 33.5 months (range 9-60). There were no intra or post-operative complications associated with any of the hemiarthroplasty procedures. RESULTS: Nine of the fifteen patients had a poor result that warranted revision surgery within two years of prosthesis implantation. We conclude that in our hands the results of femoral resurfacing hemiarthroplasty are unpredictable and advise caution when recommending the procedure to patients with osteonecrosis of the femoral head. (Hip International 2004; 14: 174-81).

Diaphyseal forearm fractures in children treated with intramedullary fixation: outcome of K-wire versus elastic stable intramedullary nail.

Intramedullary fixation of children's diaphyseal forearm fractures is becoming the surgical technique of choice, in those cases that warrant surgical intervention. This method offers both technical advantages and patient benefits over alternative techniques and implants that have been used in the past. We present a two-centre study assessing the outcome of either Kirschner wires or elastic stable intramedullary nails (ESIN) as the method of fracture stabilisation in such diaphyseal forearm fractures.A total of 36 children underwent K-wire fixation and 24 children underwent ESIN fixation. All fractures united with no resultant subjective disability. The complication rate following K-wires was 16% and that following nail fixation 9%. Loss of forearm rotation was documented in four children in the K-wire group and three children stabilised with nails. These results confirm an excellent outcome following intramedullary fixation. We have demonstrated no difference in outcome between K-wires and ESIN, although the nails do offer some theoretical advantages.

Assessment of the efficacy of Proguard RR-2 radio-protective gloves during forearm manipulation.

The hazards of ionising radiation are well known and precautions, such as lead aprons and thyroid shields are routinely used. Orthopaedic surgeon's hands are at particular risk from direct and scatter radiation, when manipulating forearm fractures, due to the proximity of the image intensifier. The use of lead gloves has been recommended in the literature but are seldom employed. Proguard RR-2 gloves provide similar tactile sensitivity to double gloves and are claimed by the manufacturer to provide up to 55% protection in vitro at a direct beam energy level of 60 kV. This claim was tested in a clinical setting. The gloves were worn during forearm manipulations and the radiation dose measured using thermoluminescent dosimeters (TLDs). The results demonstrated a radiation attenuation of 60-64%. These gloves appear to achieve a good compromise between protection and sensitivity and should be included in routine protection against ionising radiation during MUA.

The operative management of displaced intra-articular fractures of the calcaneum: a two-centre study using a defined protocol.

The management of intra-articular calcaneal fractures remains controversial with strong arguments supporting both conservative and operative management. This study assesses the results of open reduction and internal fixation (ORIF) of displaced intra-articular fractures of the calcaneum in two independent centres where the indications for operative management had been strictly defined.Forty-seven patients (51 fractures) who had sustained such injuries underwent an ORIF performed by one of the senior surgeons using the technique described by Eastwood et al. [JBJS 75-B(1993)189] All of the fractures were assessed by plain X-ray and CT scan and graded according to the Sanders classification [Clin. Orthop. 290(1993)97]. Patients were assessed at a minimum of 2 years post-surgery both clinically and with a standardised questionnaire based on that described by Kerr et al. [Injury 27(1996)35]. The mean age at operation was 42 and 50 years for the two centres, and the mean follow-up was 44 months. Seventy-six per cent of the patients were male. Eighty-eight per cent of the injuries were due to a fall from a height. Fifteen patients had contralateral foot/ankle injuries. Thirty-four of 46 patients were in employment at the time of the injury, 24 of these were in physical jobs and 20 sustained their injury whilst at work.Overall, the satisfaction rate was 90%. Ninety-four per cent of patients in work returned to work at a median of 6 months. Bilateral injuries were associated with a significantly poorer outcome as were those with heel pad pain. Delay to operation greater than 14 days was associated with a higher infection rate. Smoking was not related to infection rate.