Micro-Oxygenation in Upflow Anaerobic Sludge Bed (UASB) Reactors Using a Silicon Membrane for Sulfide Oxidation.

Sulfide produced by sulphate-reducing bacteria in anaerobic reactors can seriously affect biogas quality. Microaeration has become a reliable way to remove sulfide, by promoting its oxidation. However, limited research is available regarding its application in upflow anaerobic sludge bed (UASB) reactors. In this research, silicon membranes were studied as a mechanism to dose oxygen in USAB reactors. Two configurations were tested: the membrane placed inside the reactor or in an external module. Our results show that the external membrane proved to be a more practical alternative, providing conditions for sulfide oxidation. This led to a reduction in its concentration in the liquid effluent and biogas. External membrane configuration achieved a sulfide conversion rate of 2.4 g-S m2 d-1. Since the membrane was not sulfide-selective, methane losses were observed (about 9%). In addition, excessive oxygen consumption was observed, compared to the stoichiometric requirement. As is the case for many membrane-based systems, membrane area is a key factor determining the correct operation of the system.

Seasonal variation of the organic and inorganic composition of sugarcane vinasse: main implications for its environmental uses.

Sugarcane vinasse is the main waste stream of the Brazilian agroindustry. The typical composition of sugarcane vinasse gives it a high polluting potential that implies the necessity to define sustainable strategies for managing this waste. Knowledge of the inorganic and organic composition of vinasse and its seasonal variation is extremely important to conduct scientific research to define alternative managements for vinasse disposal other than fertigation. This study evaluated the variability of vinasse composition throughout the same harvesting season and among three harvesting seasons of one Brazilian annexed biorefinery (2015-2017). The contents of chemical oxygen demand (COD), biochemical oxygen demand (BOD5), total solids (TS), suspended solids (SS), salinity (K+, Na+, Ca2+, Mg2+, Cl-, F-), nutrients (N, P, S), trace metals (Al3+, As2+, Ba2+, Cd2+, Cr3+, Co2+, Cu2+, Fe2+, Pb2+, Mn2+, Hg2+, Mo2+, Ni2+, Se2+, Zn2+), and specific soluble organic compounds (sugars, alcohols, and organic acids), as well as pH and conductivity, were monitored in 13 samples. The results indicated that sugarcane vinasse is a suitable feedstock for biological treatments, such as anaerobic digestion processes for energy recovery, as well as substrate for biomass (e.g., microalgae, energy crops, lignocellulosic biomass) growth. The application of a previous treatment makes vinasse a more environmentally friendly natural fertilizer for land fertigation.

A membrane aerated biofilm reactor for sulfide control from anaerobically treated wastewater.

A upflow anaerobic sludge blanket reactor was operated combined to a membrane aerated biofilm reactor for sulfate removal and for elemental sulfur reclamation. A commercial silicon tube was used as an oxygen delivery diffuser. The process achieved high rates of sulfide removal from the liquid phase (90%). The hydrogen sulfide removal was influenced by the pH value and at pH value of 7.5, 98% of the H2S was removed. The elemental sulfur was observed inside the membrane, with content in the biomass of 21%. Through the massive sequencing of the samples, the microbial community diversity and the stratification of biomass inside the silicon tube was demonstrated, confirming the presence of sulfide-oxidizing bacteria on the membrane wall. The most important genera found related to the sulfur cycle were Sulfuricurvum, Geovibrio, Flexispira and Sulforospirillum.

Fast start-up of the single-stage nitrogen removal using anammox and partial nitritation (SNAP) from conventional activated sludge in a membrane-aerated biofilm reactor.

The single-stage nitrogen removal using anammox and partial nitritation (SNAP) is a promising alternative for low-cost ammonium removal from wastewaters. This study aimed to evaluate the anammox biomass enrichment and SNAP process start-up in a laboratory-scale membrane-aerated biofilm reactor (MABR) at nitrogen loading rates of 50 g N.m-3.d-1 (period 1) and 100 g N.m-3.d-1 (period 2). Anammox activity was observed after 48 days, and the SNAP process was stable after 80 days. In period 1, the average total nitrogen (TN) removal was 78 ±â€¯6%, and the maximum removal was 84%. In period 2, the average TN removal was 61 ±â€¯5%, and the maximum was 69%. Higher dissolved oxygen levels may have caused imbalances in the microbial community in period 2, decreasing the reactor performance. These results demonstrated the potential of the MABR for the fast implementation of the single-stage partial nitritation and anammox processes.