The use of 3-[2-(N,N-diethyl-N-methylammonium)ethyl]-7-methoxy-4-methylcoumarin (AMMC) as a specific CYP2D6 probe in human liver microsomes.

Recently, a novel nonfluorescent probe 3-[2-(N,N-diethyl-N-methylammonium)-ethyl]-7-methoxy-4-methylcoumarin (AMMC), which produces a fluorescent metabolite AMHC (3-[2-(N,N-diethyl-N-methylammonium)ethyl]-7-hydroxy-4-methylcoumarin) was used with microsomes containing recombinant enzymes (rCYP) to monitor CYP2D6 inhibition in a microtiter plate assay. This article describes the studies that were performed in human liver microsomes (HLM) to establish the selectivity of AMMC toward CYP2D6. Metabolism studies in HLM showed that AMMC was converted to one metabolite identified by mass spectrometry as AMHC. Kinetic studies indicated an apparent K(m) of 3 microM with a V(max) of 20 pmol/min. mg of protein for the O-demethylation reaction. The O-demethylation of AMMC in HLM was inhibited significantly in the presence of a CYP2D6 inhibitory antibody. Using a panel of various HLM preparations (n = 12), a good correlation (r(2) = 0.95) was obtained between AMMC O-demethylation and bufuralol metabolism, a known CYP2D6 substrate, but not with probes for the other major xenobiotic metabolizing CYPs. Finally, only rCYP2D6 showed detectable metabolism in experiments conducted with rCYPs using AMMC at a concentration of 1.5 microM (near K(m)). However, at a concentration of 25 microM AMMC, rCYP1A also contributed significantly to the formation of AMHC. Knowing the experimental conditions under which AMMC was selective for CYP2D6, a microtiter assay was developed to study the inhibition of various compounds in HLM using the fluorescence of AMHC as an indication of CYP2D6 activity. The inhibition potential of various chemicals was found to be comparable to those determined using the standard CYP2D6 probe, bufuralol, which requires high-performance liquid chromatography separation for the analysis of its CYP2D6-mediated 1'-hydoxylated metabolite.

In vitro metabolism considerations, including activity testing of metabolites, in the discovery and selection of the COX-2 inhibitor etoricoxib (MK-0663).

Characterization of the metabolites of the COX-2 inhibitor etoricoxib (MK-0663 and L-791,456) produced in vitro indicate formation of an N-oxide pyridine and hydroxymethyl pyridine that can further be glucuronidated or oxidized to an acid. Significant turnover is observed in human hepatocytes. Several CYPs are involved in the oxidative biotranformations and, from in vitro studies, etoricoxib is not a potent CYP3A4 inducer or inhibitor. Based on an in vitro whole blood assay, none of the metabolites of etoricoxib inhibits COX-1 or contributes significantly to the inhibition of COX-2.

In vitro metabolism of the COX-2 inhibitor DFU, including a novel glutathione adduct rearomatization.

The metabolic profile of DFU [5,5-dimethyl-3-(3-fluorophenyl)-4-(4-methylsulphonyl)phenyl-2(5H)-furanone], a potent and selective COX-2 inhibitor, was characterized using in vitro microsomal and hepatocyte incubations. A single product, corresponding to p-hydroxylation, p-OH-DFU [(5,5-dimethyl-3-(3-fluoro-4-hydroxyphenyl)-4-(4-methylsulphonyl)phenyl-2(5H)-furanone)], was produced in rat microsomal incubations of DFU. In contrast, three metabolites were produced in incubations using suspensions of freshly isolated rat hepatocytes. Microsomal production of the p-O-glucuronide metabolite of DFU from synthetic p-OH-DFU was shown to have chromatographic and mass spectrometric properties identical to the earliest eluting hepatocyte metabolite (M1). The molecular weights of the other two hepatocyte metabolites were readily obtained using capillary high-performance liquid chromatography continuous-flow liquid secondary ion mass spectrometry (HPLC/CF-LSIMS); however, the elemental composition of these metabolites was not. Unlike typical metabolic products, which produce readily identified increments in molecular weight, metabolites M2 and M3 produced molecular ions in positive- and negative-ion CF-LSIMS that were consistent with oxidation of DFU (+16 Da), followed by addition of glutathione (+306 Da) and subsequent loss of 20 and 18 Da, respectively. Capillary HPLC/high-resolution CF-LSIMS was used to generate accurate mass data for M2 and M3 that provided evidence that the losses of 20 and 18 Da, respectively, corresponded to a rearomatization through loss of HF or H(2)O. Isolation and NMR characterization provided the definitive structural proof for these metabolites. Overall, the metabolism of DFU in rat hepatocytes is proposed to proceed through an epoxide intermediate, which then either rearranges to the p-OH-DFU and is conjugated with glucuronic acid, or is trapped with glutathione, followed by rearomatization with loss of HF (M2) or H(2)O (M3).

Application of rat hepatocyte culture to predict in vivo metabolic auto-induction: studies with DFP, a cyclooxygenase-2 inhibitor.

The drug candidate DFP [5,5-dimethyl-3-(2-isopropoxy)-4-(4-methanesulfonylphenyl)-2(5H)-furanone] is a selective cyclooxygenase-2 inhibitor under evaluation for analgesic and anti-inflammatory therapy. The in vitro metabolic pathways (rat microsomes) involve hydroxylation of the isopropyl side chain at either of two positions, the methyl or the methine, thus producing a hydroxylated metabolite (DFHP) or a dealkylated metabolite (DFH). DFH formation was the major pathway. Using hepatic microsomes from rats treated with agents that induce specific CYP isozymes, it was shown that the dexamethasone-inducible rat CYP3A isozyme(s) play a major role in DFH formation. The roles of CYP3A1 and -3A2 were confirmed with genetically engineered rat CYP enzymes. The potential for induction of rat CYP3A by DFP was evaluated by incubating DFP in rat hepatocyte cultures and measuring the CYP3A levels. Both CYP3A immunoreactive protein and enzyme activity were induced in a dose-dependent manner. The induction was confirmed in vivo by dosing rats with DFP at 100 mg/kg for 4 days. Microsomes prepared from the excised livers showed that DFP gave approximately 55% of the induction observed with dexamethasone, as determined by Western blot. In vitro metabolic auto-induction of DFP was assessed by measuring the metabolism of DFP in hepatocytes treated with DFP. DFH formation was significantly enhanced in the DFP-treated cells. In vivo, treating rats with DFP at doses of 10 to 100 mg/(kg.day) for 13 weeks indicated that DFP induced its own metabolism. The C(max) and plasma drug area under the curve values during the thirteenth week were significantly lower than that on the first day, and the effect was dose-dependent.

Investigation of the in vitro metabolism profile of a phosphodiesterase-IV inhibitor, CDP-840: leading to structural optimization.

CDP-840 is a selective and potent phosphodiesterase type IV inhibitor, whose in vitro metabolism profile was first investigated using liver microsomes from different species. At least 10 phase I oxidative metabolites (M1-M10) were detected in the microsomal incubations and characterized by capillary high-performance liquid chromatography continuous-flow liquid secondary ion mass spectrometry (CF-LSIMS). Significant differences in the microsomal metabolism of CDP-840 were found between rat and other species. The major route of metabolism in rat involved para-hydroxylation on the R4 phenyl. This pathway was not observed in human and several other species. The in vitro metabolism profile of CDP-840 was further examined using freshly isolated hepatocytes from rat, rabbit, and human. The hepatocyte incubations indicated more extensive metabolism relative to that in microsomes. In addition to the phase I oxidative metabolites observed in microsomal incubations, several phase II conjugates were identified and characterized by CF-LSIMS. Interspecies differences in phase II metabolism were also found in these hepatocyte incubations. The major metabolite in human hepatocytes was identified as the pyridinium glucuronide, which was not detected in rat hepatocytes. Simple structural modification on R4, such as p-Cl substitution, greatly reduced the species differences in microsomal metabolism. Furthermore, modifications on R3, such as the N-oxide, eliminated the N-glucuronide formation in human. These results not only helped in determining the suitability of animal species used in the preclinical safety studies but also provided valuable directions for the synthetic efforts in finding backup compounds that are more metabolically stable.

Synthesis, characterization, and activity of metabolites derived from the cyclooxygenase-2 inhibitor rofecoxib (MK-0966, Vioxx).

Metabolites of the COX-2 inhibitor rofecoxib (MK-0966, Vioxx) were prepared by synthetic or biosynthetic methods. Metabolites include products of oxidation, glucuronidation, reduction and hydrolytic ring opening. Based on an in vitro whole blood assay, none of the known human metabolites of rofecoxib inhibits COX-1 nor contributes significantly to the inhibition of COX-2.

Description of a 96-well plate assay to measure cytochrome P4503A inhibition in human liver microsomes using a selective fluorescent probe.

The standard method to evaluate CYP3A inhibition is to study the conversion of the specific CYP3A probe testosterone to its 6 beta-hydroxy metabolite in human liver microsomes, in the absence and presence of potential inhibitors. Quantification of the 6 beta-hydroxy metabolite is achieved by HPLC resulting in a tedious and time-consuming assay. In order to increase the P450 inhibition throughput, efforts were made to find a CYP3A probe that would produce a fluorescent metabolite. This paper reports the discovery of DFB as a potential CYP3A fluorescent probe. DFB was significantly metabolized in human microsomes (approximately 1-2 nmol/(min. mg protein)) to give the fluorescent compound DFH. The involvement of CYP3A in the metabolism of DFB was determined using multiple approaches. First, incubations conducted with microsomes made from cell lines expressing single CYPs (Gentest Supersomes) indicated that CYP3A played a major role in the metabolism of DFB. Secondly, immunoinhibition studies conducted with CYP3A antibody resulted in >95% inhibition of DFB metabolism in HLM. Thirdly, inhibition studies with specific CYP1A1, 1A2, 2C8/9, 2C19, 2D6, and 2E1 chemical inhibitors did not suppress DFB activity in HLM. However, ketoconazole, miconazole, nicardipine, and nifedipine, all known CYP3A inhibitors, completely abolished the formation of DFH in HLM. The potency of several inhibitors determined using DFB and testosterone as CYP3A probes was consistent (R = 0.98). Finally, a good agreement was obtained for the formation of DFH and production of 6 beta-hydroxytestosterone when DFB and testosterone were incubated separately with various human liver microsome preparations (R = 0.94, N = 11). In order to use DFH as a fluorescent CYP3A marker in a 96-well plate format, it was important to remove the excess of NADPH at the end of the incubation because the fluorescence of NADPH interferes with DFH detection. This was achieved by adding oxidized glutathione and glutathione reductase to convert NADPH to NADP(+) which is not fluorescent. The liquid-handling steps were fully automated in a 96-well plate format and a template was designed to generate IC(50) curves and to address potential fluorescent interferences from the test compounds. The assay was found to be reproducible (intraday variability <10% and interday variability indicated less than a 2-fold variation in the IC(50) values) and is now routinely used in our laboratory to evaluate CYP3A inhibition of NCEs.

2,3-Diarylcyclopentenones as orally active, highly selective cyclooxygenase-2 inhibitors.

Cyclopentenones containing a 4-(methylsulfonyl)phenyl group in the 3-position and a phenyl ring in the 2-position are selective inhibitors of cyclooxygenase-2 (COX-2). The selectivity for COX-2 over COX-1 is dramatically improved by substituting the 2-phenyl group with halogens in the meta position or by replacing the phenyl ring with a 2- or 3-pyridyl ring. Thus the 3,5-difluorophenyl derivative 7 (L-776,967) and the 3-pyridyl derivative 13 (L-784,506) are particularly interesting as potential antiinflammatory agents with reduced side-effect profiles. Both exhibit good oral bioavailability and are potent in standard models of pain, fever, and inflammation yet have a much reduced effect on the GI integrity of rats compared to standard nonsteroidal antiflammatory drugs.

Effect of common organic solvents on in vitro cytochrome P450-mediated metabolic activities in human liver microsomes.

In this study, we report the effect of methanol, dimethyl sulfoxide (DMSO), and acetonitrile on the cytochrome P450 (P450)-mediated metabolism of several substrates in human liver microsomes: phenacetin O-deethylation for P4501A2, coumarin 7-hydroxylation for P4502A6, tolbutamide hydroxylation for P4502C8/2C9, S-mephenytoin 4'-hydroxylation for P4502C19, dextromethorphan O-demethylation for P4502D6, chlorzoxazone 6-hydroxylation for P4502E1, and testosterone 6beta-hydroxylation for P4503A4. DMSO was found to inhibit several P450-mediated reactions (2C8/2C9, 2C19, 2E1, and 3A4) even at low concentrations (0.2%). There was no measurable effect on the catalytic activity of the various P450s when methanol was present at levels

In vitro comparison of cytochrome P450-mediated metabolic activities in human, dog, cat, and horse.

As domestic animals such as cat, horse, and dog increasingly become the clinical targets for drug discovery programs, the need to understand how these animals metabolize xenobiotics becomes more important. In the present study, substrates and inhibitors that were reported to be selective for particular P450 isozymes were used as probes to study in vitro metabolism in horse, dog, cat, and human liver microsomes. Seven selective catalytic activity markers for cytochrome P450-mediated reactions were measured: phenacetin O-deethylase (P4501A1/2), coumarin 7-hydroxylase (P4502A6), tolbutamide hydroxylase (P4502C8/9), S-mephenytoin 4'-hydroxylase (P4502C19), dextromethorphan O-demethylase (P4502D6), chlorzoxazone 6-hydroxylase (P4502E1), and testosterone 6beta-hydroxylase (P4503A4). Metabolic activity was found in every species with each substrate. Under the conditions of this study, it was observed that no one species was more active for any given substrate. However, rather large interspecies differences were observed. There was no marked sex difference in the way the various species metabolized the different substrates. The effect of selective P450 inhibitors on the various activities was tested with furafylline (P4501A2), mouse monoclonal antibody inhibitory to CYP2A6, sulfaphenazole (P4502C9), tranylcypromine (P4502C19), quinidine (P4502D6), diethyldithiocarbamate (P4502E1), and troleandomycin (P4503A4). In most cases, these inhibitors were effective to varying degrees against the activity seen in horse, dog, and cat liver microsomes. However, even at high concentrations, furafylline did not inhibit phenacetin O-deethylase activity in cat and troleandomycin did not affect testosterone 6beta-hydroxylase activity in horse. Sulfaphenazole was not tested in dog and cat because of the low tolbutamide hydroxylase activity. Overall, these results show that there are also large interspecies differences in the way the selective P450 inhibitors affect the in vitro metabolism of the various substrates in horse, dog, and cat liver microsomes.

Dioxabicyclooctanyl naphthalenenitriles as nonredox 5-lipoxygenase inhibitors: structure-activity relationship study directed toward the improvement of metabolic stability.

Naphthalenic lignan lactone 3a (L-702,539), a potent and selective 5-lipoxygenase (5-LO) inhibitor, is extensively metabolized at two different sites: the tetrahydropyran and the lactone rings. Early knowledge of the metabolic pathways triggered and directed a structure-activity relationship study aimed toward the improvement of metabolic stability in this series. The best modifications discovered, i.e., replacement of the lactone ring by a nitrile group, replacement of the tetrahydropyran ring by a 6,8-dioxabicyclo[3.2.1]octanyl moiety, and replacement of the pendant phenyl ring by a 3-furyl ring, were incorporated in a single molecule to produce inhibitor 9ac (L-708,780). Compound 9ac inhibits the oxidation of arachidonic acid to 5-hydroperoxy-eicosatetraenoic acid by 5-LO (IC50 = 190 nM) and the formation of leukotriene B4 in human polymorphonuclear leukocytes (IC50 = 3 nM) as well as in human whole blood (IC50 = 150 nM). The good inhibitory profile shown by naphthalenenitrile 9ac is accompanied by an improved resistance to oxidative metabolism. In addition, 9ac is orally active in the functional model of antigen-induced bronchoconstriction in allergic squirrel monkeys (95% inhibition at 0.1 mg/kg).

Microsomal metabolism of the 5-lipoxygenase inhibitors L-746,530 and L-739,010 to reactive intermediates that covalently bind to protein: the role of the 6,8-dioxabicyclo[3.2.1]octanyl moiety.

Hepatic microsomes from different species were used to study the oxidative metabolism of L-746,530 and L-739,010, two potent and specific 5-lipoxygenase inhibitors. HPLC analysis of the incubates obtained from the microsomal incubations of L-739,010 and L-746,530 showed only traces of metabolites. However, recovery of the starting material in the supernatant was less than quantitative in all of the species studied (approximately 90% in rat, approximately 70% in the dexamethasone-induced rat, approximately 70-90% in humans, and approximately 60% in the rhesus monkey for both compounds). The recovery of the starting material was found to be time- and NADPH-dependent, suggesting that metabolite(s) were formed and reacting with the microsomal proteins. Evidence that the cytochrome P4503A (CYP3A) contributed to the formation of the reactive metabolite(s) was shown by the low recovery of material that was observed upon incubation with microsomes obtained from dexamethasone-treated rats (a CYP3A inducer), compared with microsomes obtained from untreated rats. Also, the recovery of material was improved when troleandomycin, a CYP3A inhibitor, was added to rhesus monkey microsomal incubations (25% more parent compound detected in the supernatant with 100 microM of troleandomycin). Using radiolabeled L-746,530 and gel electrophoresis analysis, it was confirmed that radiolabeled material was covalently bound to the microsomal protein. Incubations of L-739,010 and L-746,530 in the presence of semicarbazide resulted, in both cases, in the formation of two adducts. Using a combination of NMR, liquid secondary-ion MS, and UV techniques, these adducts were identified as isomers of an oxidized metabolite that had been trapped by semicarbazide. The site of oxidation was determined to be on the dioxabicyclo moiety. The importance of this moiety in the formation of reactive metabolite(s) was verified by incubating analogs of the 5-lipoxygenase inhibitors that contained blocking methyl groups at the proposed site of oxidation on the bicyclo moiety. Incubations of these gemdimethyl analogs of L-746,530 and L-739,010 with microsomes from different species resulted in significantly improved recovery of the starting material (approximately 94% in the rat, 85% in the dexamethasone-induced rat, 95% in humans, and 85% in the rhesus monkey for both compounds) and significantly less radioactive binding to the microsomal protein.

Integrated application of capillary HPLC/continuous-flow liquid secondary ion mass spectrometry to discovery stage metabolism studies.

The application of capillary HPLC/continuous-flow liquid secondary ion mass spectrometry (CF-LSIMS) as part of an integrated approach for characterizing discovery stage in vitro metabolites, using a specific inhibitor for 5-lipoxygenase as a model compound, was investigated. CF-LSIMS demonstrated excellent sensitivity in detecting the metabolites in both the positive and the negative ion modes, with a good full-scan mass spectrum obtained when 5 pmol of metabolite was injected onto the capillary column. Strong pseudomolecular ions and key fragment ions were observed in the primary spectra of the parent drug and its three oxidative in vitro metabolites, allowing the site of metabolism to be pinpointed to particular substructures. This technique demonstrated versatility and offered a very rapid screening procedure for metabolite identification.

In vitro and in vivo biotransformations of the naphthalenic lignan lactone 5-lipoxygenase inhibitor, L-702,539.

It has been reported previously that the tetrahydropyranyl naphthtalenic lignan lactone L-702,539 is a potent nonredox, 5-lipoxygenase inhibitor that has the advantage that it can be dosed either as the lactone or as the corresponding nonactive hydroxy acid L-702,618 (opened lactone). Studies with hepatic microsomes from the rat, rhesus monkey, and human were undertaken in a phosphate buffer and suggested that the closure of the hydroxy acid L-702,618 to the lactone L-702,539 was an enzymatic process. The incubation of L-702,539 under oxidative conditions with these specific hepatic microsomes resulted in the formation of three significant metabolites (> 0.4 nmol/mg protein/hr) as determined by HPLC with UV detection. These metabolites were isolated from large microsomal incubations and were characterized by MS and NMR spectroscopy. Data showed that the lactone and tetrahydropyran portions of the molecule were both susceptible to hydroxylation, and the hydroxylated tetrahydropyran was further oxidized to the hydroxy acid. Analysis of plasma samples obtained from rat and rhesus monkeys following L-702,618 administration indicated that the in vivo metabolic pathway was similar to the one observed in vitro using hepatic microsomes. Studies conducted with microsomes from genetically engineered human cell lines expressing individual cytochrome P450s indicated that the isozyme responsible for the metabolism at the tetrahydropyran ring, was P4503A4. These findings were supported by studies conducted in human microsomes using an inhibitory P4503A4 antibody and troleandomycin, which is a potent P4503A inhibitor.

CYP1A1 specificity of Verlukast epoxidation in mice, rats, rhesus monkeys, and humans.

It has previously been shown that Verlukast is converted to Verlukast dihydrodiol in microsomes from beta-naphthoflavone (BNF)-treated, but not uninduced Swiss Webster mice and Sprague-Dawley rats. We have examined the involvement of CYP1A1 in this reaction in more detail. It is concluded that this reaction is catalyzed exclusively by CYP1A1 in rats, mice, and humans based on the following criteria: 1) the epoxidation of Verlukast is negligible in uninduced rats, which express CYP1A2 but not CYP1A1; 2) Verlukast epoxidation is highly inducible by BNF treatment (60- to 200-fold); 3) Verlukast epoxidation in BNF-treated rat microsomes was inhibited by alpha-naphthoflavone (ANF) treatment, indicating that this activity was mediated by the CYP1A subfamily; 4) > 95% of Verlukast epoxidation in BNF-treated rat microsomes was inhibited by antibodies raised against CYP1A1; and 5) Verlukast was epoxidized by human CYP1A1 but not CYP1A2. Thus, Verlukast epoxidation appears to be specific for rat, mouse, and human CYP1A1. Additional studies showed that Verlukast was metabolized to Verlukast dihydrodiol in microsomes from uninduced rhesus monkeys. This reaction was inhibited by nanomolar concentrations of ANF in rhesus monkey microsomes implicating the involvement of the CYP1A subfamily. In addition, the 8-hydroxylation of R-warfarin, a pathway that is selective for rodent and human CYP1A1 activity, was also catalyzed at significant rates by rhesus monkey microsomes. These findings indicate that, unlike rats, mice, and humans, which have very low constitutive levels of hepatic CYP1A1 activity, the uninduced rhesus monkey is able to catalyze reactions specific to CYP1A1 in rodents and humans.(ABSTRACT TRUNCATED AT 250 WORDS)

Characterization of verlukast metabolites arising from an epoxide intermediate produced with hepatic microsomes from beta-naphthoflavone-treated rodents (P-4501A1).

Verlukast, (R)3-((((3-(2-(7-chloroquinolin-2-yl)-(E)-ethenyl)phenyl)-3- dimethylamino-3-oxopropylthio)methyl)thio)-propionic acid (also known as MK-0679 and L-668,019), is a potent leukotriene D4 antagonist. Verlukast was incubated with hepatic microsomes from beta-naphthoflavone (beta NF) or isosafrole-treated rodents to evaluate whether P-4501A1 or 1A2 mediated biotransformations could occur. With beta NF-induced mouse or rat microsomes, in which the induction of P-4501A1 had been proven by Western blot analysis, incubations produced new metabolites that were separated by reversed-phase HPLC and were initially characterized by UV (photodiode array). Metabolites were subsequently isolated and characterized by NMR and MS, and were assigned as the 5",6"-dihydrodiol and 6"-phenol (on the quinoline ring). The presumed 5",6"-epoxide intermediate was also detected and was characterized by UV (photodiode array) and MS. Microsomes from isosafrole-treated rodents produced the dihydrodiol to a much lesser extent and did not yield any other new metabolites. alpha-Naphthoflavone inhibited the dihydrodiol formation in incubations with microsomes from isosafrole- and beta NF-treated rats. In incubations with microsomes from beta NF-treated rats, to which the epoxide hydrolase inhibitor 3,3,3-trichloropropene 1,2-oxide had been added, the formation of dihydrodiol was inhibited, consistent with a microsomal epoxide hydrolase hydrolysis of the epoxide intermediate. When glutathione was added to incubations with microsomes from beta NF-treated rats, the dihydrodiol, phenol, and epoxide peaks were reduced in size and a new material, the glutathione adduct, was formed.(ABSTRACT TRUNCATED AT 250 WORDS)

Effect of polymeric adsorbents on the production of sanguinarine by Papaver somniferum cell cultures.

The suitability of adsorbent polymeric resins, Amberlite XAD-4 and XAD-7 (Rohm and Hass, Inc.), was investigated for the accumulation of sanguinarine from Papaver somniferum cell cultures. The adsorption and desorption of sanguinarine from aqueous solution was most effective with XAD-7. In addition to sanguinarine, the resins were found to absorb growth regulators and vitamins from the culture medium. Growth inhibition was overcome by delaying for approximately 4 days resin addition after cell inoculation in fresh medium. Resin addition (5% wt/vol) to actively growing uneclicited cultures led to increases in sanguinarine production and release of 30% to 40% and 60%, respectively. The addition of resins to elicited cultures led to increases in alkaloid production of up to 50% to 85% with similar increases in alkaloid release as observed for nonelicited cells. Overall yield of sanguinarine increased from 21 mg . g biomass dry weight(-1) (dw) for elicited cultures to more than 39 mg . gdw(-1) when elicitation was combined with resin addition. Higher quantities of resin (10% to 20% wt/vol) increased marginally the release of sanguinarine into the medium, and on the resin, up to 85% of total production. The use of resin appears promising for the development of a bioprocess for sanguinarine production by cultured plant cells.

Growth characteristics of Sanguinaria canadensis L. cell suspensions and immobilized cultures for production of benzophenanthridine alkaloids.

Sanguinaria canadensis L. plants were harvested from a local forest and calli were initiated from leaf explants. The production of benzophenanthridine alkaloids (i.e. sanguinarine, sanguilutine, sanguirubine, chelerythrine, chelilutine and chelirubine) by S. canadensis cell grown in modified B5 and IM2 media was compared to the alkaloid content of rhizomes. Sanguinarine accounted for approximately 80% of the total alkaloid content of cultured cells (1.3%, g g-1) while sanguinarine and sanguirubine accounted for 70% of rhizome alkaloids (9.0%, g g-1). Sanguinarine, chelirubine and chelerythrine were the only known alkaloids detected in cultured S. canadensis cells. Maximum alkaloid production of cultures performed using B5 medium, containing half the original nitrate concentration, was observed following extracellular nitrate and sugar depletion. The scale-up of this culture was successfully performed in a 2-1 immobilization bioreactor. The consumption of sugar and nitrate as well as the oxygen (OTR) and carbon dioxide (CTR) transfer rates of the immobilized cell culture were monitored for 15 days. The maximum sugar and nitrate consumption rates were 1.8 g l-1 per day and 2.3 mM per day respectively. The maximum OTR and CTR of the immobilized cell culture were 0.8 mmol O2 l-1 h-1 and 0.95 mmol CO2 l-1 h-1 respectively. The sanguinarine yield of this culture reached 1.0% based on biomass dry weight (g g-1 dw) by day 15.

Detection of ginkgolide A in Ginkgo biloba cell cultures.

Ginkgo biloba cells were cultured in two 500 mL shake flasks and in 2 L and 6 L immobilization bioreactors using MS medium supplemented with 1 mg.L(-1) NAA, 0.1 mg.L(-1) K and 30 g.L(-1) sucrose. Specific growth rates were 0.06 d(-1), 0.11 d(-1) and 0.07 d(-1) for the 2 L and 6 L bioreactors and shake flask cultures, respectively. Extracellular phosphate, nitrate, ammonium and carbohydrate uptake rates of the bio reactor cultures were approximately 17 to 39% slower than those of shake flask cultures. The specific oxygen uptake and carbon dioxide transfer rates of immobilized Ginkgo biloba cells ranged from 0.027 to 0.041 mmol O2.g(-1).d.w.hr(-1) (maximum uptake at 14 days) and 0.020 to 0.057 mmol CO2g. (-1).d.w.hr(-1) (maximum production at 14 days). Extracts from the biomass of the two immobilized and shake flask suspension cultures were analysed for ginkgolide A by GC-MS. Yields of 7, 17, 19 and 7 ng.g. (-1)d.w. of ginkgolide A were determined for shake flask 1, shake flask 2 and the 2 L and 6 L immobilized cultures, respectively. Traces of ginkgolide B were detected with the signal to noise ratio, however, being too low for positive confirmation of this last product.