Significance of different mixing conditions on performance and microbial communities in anaerobic digester amended with granular and powdered activated carbon.

Conductive materials amendment in anaerobic digestion (AD) is a promising strategy for boosting the methanogenesis process. Despite mixing is a critical parameter, the behavior of digesters amended with conductive additives upon different mixing conditions has rarely been investigated. This study investigated continuous mixing, intermittent mixing (10 min in every 12 h), and non-mixing conditions for digesters amended with granular activated carbon (GAC) and powdered activated carbon (PAC). The non-mixed GAC digester provided the highest methane yield (318 ± 28 mL/g COD) from synthetic blackwater, while intermittently mixed GAC and control exhibited similar methane yields (290-294 mL/g COD). For non-mixed systems, microbial richness and diversity increased with GAC and PAC amendment. In contrast, continuous and intermittent mixing increased microbial diversity and richness in control reactors while reduced the same in GAC and PAC amended reactors. Overall, various mixing conditions distinctly changed the degree of enrichment/retention of microbes and consequently influenced methane recovery.

Transitions of microbial communities in the solid and liquid phases during high-solids anaerobic digestion of organic fraction of municipal solid waste.

This study presents a microbiological diagnosis of a mesophilic high-solids anaerobic digestion (HSAD) system with percolate recirculation. The results demonstrated a significant decrease in microbial diversity in both the solid digestate and the liquid percolate. Also, the digestate from the top and middle sections of the digester had similar diversity, whereas the digestate from the bottom of the tank had a slightly lower diversity. These results suggest that despite percolate recirculation, substrate gradients might have developed across the system. Archaeal communities showed shifts towards known hydrogenotrophic and ammonia-tolerant methanogens (genera Methanocelleus, Methanolinea, Methanosarcina, vadin CA11, etc.), which was a consequence of decreased volatile fatty acids and increased ammonia-nitrogen levels over time. Compared to initial solid and liquid inoculum, the relative abundances of some bacteria (phyla Proteobacteria and Firmicutes) and archaea of the genus Methanosarcina changed between two phases in the opposite direction, indicating a shift of microbes between two phases.

Enhanced biomethane recovery from fat, oil, and grease through co-digestion with food waste and addition of conductive materials.

In this study, the effect of conductive additives on co-digestion of fat, oil, and grease (FOG) and food waste (FW) was evaluated. Initially, biochemical methane potential (BMP) test was conducted for optimization of mixing ratio of FW and FOG. The optimal methane production (800 L (kg VS)-1) was obtained from co-digestion of 70% FW + 30% FOG (w/w), which was 1.2 times and 12 times of that obtained from mono-digestion of FW and FOG, respectively. This optimal mixing ratio was used for subsequent fed-batch studies with the addition of two conductive additives, granular activated carbon (GAC) and magnetite. The addition of GAC significantly shortened the lag phase (from 7 to 3 d), reduced accumulation of various volatile fatty acids (VFAs), and enhanced methane production rate (50-80% increase) compared to the control and magnetite-amended bioreactor. Fourier transformation infrared (FTIR) analysis suggested that the degradation of lipids, protein and carbohydrates was the highest in GAC amended reactor, followed by magnetite and control reactors. GAC addition also enriched more abundant and diverse bacteria and methanogens than control. Magnetite addition also showed similar trends but to a lesser degree. The substantial enrichment of syntrophic LCFA ß-oxidizing bacteria (e.g. Syntrophomonas) and methanogenic archaea in the GAC-amended bioreactor likely attributed to the superior methanogenesis kinetics in GAC amended bioreactor. Our findings suggest that the addition of GAC could provide a sustainable strategy to enrich kinetically efficient syntrophic microbiome to favor methanogenesis kinetics in co-digestion of FW and FOG.