Phosphorus release capacity in different dietary commercial phytases through performance and bone characteristics assessment of broiler chickens.

A trial was conducted to evaluate phosphorus release capacity in different commercial phytases throught performance and bone characteristics of broilers. A total of 2,400-day-old male Cobb 500® chicks were assigned in a completely randomized design with 12 dietary treatments ((1 to 5: with increasing levels of non-phytate phosphorus (NPP) (0.20; 0.25; 0.30; 0.35 and 0.40%) without phytase); and 6 to 12: with 0.20% supplemented with different commercial phytases), 8 replicates and 25 birds per pen. There was a linear increase (P<0.05) in the feed intake and body weight gain and a linear improvement (P<0.05) in the feed conversion ratio of broilers fed increasing NPP. The tested phytases did not release similar amounts of phytic phosphorus. Based on body weight gain response, 500 FTU/kg of diet releases a minimum and maximum of 0.074 to 0.152%, 0.062 to 0.157 and 0.059 to 0.169% of PP among the studied phytases in the periods from 1 to 21, 1 to 35 and 1 to 42 days, respectively. In conclusion, the commercial phytases released different concentrations of phytate phosphorus from the diets. Thus, is necessary to have a better method to evaluate phytase activity in order to avoid subnormal levels of available P in diets.

Amino acid digestibility coefficient values of animal protein meals with dietary protease for broiler chickens.

A digestibility experiment was conducted to evaluate the effects of dietary exogenous monocomponent protease on the coefficient of apparent total tract digestibility (ATTD) and coefficient apparent ileal digestibility (AID) of amino acids in meat and bones meal (MBM), poultry byproducts meal (PBPM), and feather meal (FM). A total of 512 Cobb-500 male broiler chickens (aged 14 d) were randomly placed into 64 metabolism cages (8 birds per pen) and were allocated to eight treatments with eight replicates in a semi-controlled environmental room. The experimental diets consisted of the basal diet (corn/SBM) and the replacement of 300 g/kg on a weight basis with MBM, PBPM, or FM. The excreta were collected during 3 d (19 to 21 d), and the ileal digesta (using Celite as an indigestible marker) only 1 d (21 d). The protease contained 75,000 PROT units/g. The use of the enzyme increased (P < 0.05) ATTD for alanine, cysteine, glycine, and threonine in the basal diet and AID for the amino acids alanine, cysteine, glycine, lysine, threonine, and valine for the basal diet (vegetable). Regarding meals, there was an increase (P < 0.05) in the amino acid digestibility in large part due to the amino acids of MBM (14) and PBPM (9), with only five amino acids for FM. The amino acids glycine and threonine showed increases (P < 0.05) in both total and ileal digestibility for all animal meals and for the diet based on corn and soybean meal, which indicates a high specificity of the enzyme for these amino acids. The overall results obtained in this study found satisfactory effectiveness of this exogenous protease. The total collection method was lower by 1.83% of amino acids digestibility than the ileal method.

Supplemental phytase derived from E. coli in different concentrations on performance, bone mineralization and cost of broilers diets.

The trial was conducted to evaluate the supplementation of E. coli phytase on performance, weight and ash of bones, as well as to determine the bioavailability of P and cost/benefit of its use in diets. A total 1,890 Cobb male day old chicks were assigned to six treatments and seven replicates with 45 birds each, distributed in a completely randomized design. The treatments were: Positive Control; Negative Control (NC1) - reduction of 0.06% avP; Negative Control 2 (NC2) - reduction of 0.12% avP; NC2 + Phytase (120 OTU); NC2 + Phytase (180 OTU); NC2 + Phytase (240 OTU), being 1 OTU equivalent to approximately 2 FTU. With different phytase inclusions, it was possible to verify a gradual increase on body weight gain, feed intake, feed conversion ratio, viability and even the bone characteristics of broilers fed diets containing reduction of P. The closest levels to the highest studied (240 OTU) showed the best results. The replacement of dicalcium phosphate by phytase supplementation is economically viable when the cost per OTU does not exceed US$ 1.4 × 10-5, US$1.2 × 10-5 and US$ 1.0 × 10-5 for the concentrations of 120, 180 and 240 OTU, respectively.