Recovering rhamnogalacturonan-I pectin from sugar beet pulp using a sequential ultrasound and microwave-assisted extraction: Study on extraction optimization and membrane purification.

This research focuses on the integrated recovery of rhamnogalacturonan-I (RG-I) pectin from sugar beet pulp (SBP). First, the extraction of RG-I pectin through sequential ultrasound-assisted extraction (UAE) and microwave-assisted extraction (MAE) was assessed. Optimization using a response surface methodology identified the optimal conditions as initial pH 4, 10 min of UAE, and 157 °C for MAE, achieving a 66.0 % recovery of pectooligosaccharides (POS). Additionally, purification through continuous diafiltration and concentration via ultrafiltration of the POS using membranes with different molecular weight cut-offs (MWCO) was explored. In contrast to previous research using discontinuous diafiltration, the use of continuous diafiltration allowed a decrease in the extract viscosity and obtained higher yields using a higher MWCO membrane. The refined RG-I pectin solids exhibited a high global yield (39-40 g pectin/100 g SBP), and high-methoxyl characteristics, as well as purity levels (70-80 %) similar to commercial prebiotics.

Liquid fertilizer production from organic waste by conventional and microwave-assisted extraction technologies: Techno-economic and environmental assessment.

The use of mineral fertilizers in agriculture has significantly increased to support the growing global food demand. Organic fertilizers are produced from renewable waste materials to overcome the drawbacks of inorganic fertilizers. The development of novel production processes of organic fertilizers entails a significant advance towards the circular economy that reincorporates waste materials into the production cycle. In this work, the economic and environmental feasibility of an industrial plant with a treatment capacity of 300 kg/h of organic waste for the production of liquid fertilizers has been performed. Two extraction technologies (conventional and microwave) and two solvents (water and alkaline) have been compared to select the most sustainable and profitable scenario for scaling-up. The extraction process consists of 2 steps: extraction followed by a concentration stage (necessary only if water extraction is applied). The resolution of the mass balances shows that the fertilizer production under alkaline conditions is ten times higher than for water-based extraction. The economic analysis demonstrated that the total investment cost of microwave technology (>3.5 M€) is three times higher compared to the conventional extraction technology (<1.5 M€), mainly due to the higher complexity of the equipment. These facts directly impact the minimum selling price, because the fertilizers obtained by conventional extraction with alkaline solvent would have a lower selling price (about 1 €/L). As for environmental assessment, the indicators show that the environmental impact produced by water-based extraction is higher than alkaline-solvent extraction, mainly due to the necessity of a concentration stage of the liquid extract to meet the requirements of European regulations. In view of the results obtained in the economic and environmental evaluation, it could be concluded that the most favourable scenario for scaling up the production of liquid fertilizers from organic waste is the conventional extraction under alkaline conditions.