[Analysis of silica dust detection results in workplace air of somewhere in enterprise].

Objective: To understand the occupational hazard and distribution of silica dust (free SiO(2)≥10%) in the workplace environment of the enterprises in Fengxian District, and to provide scientific basis for improving the working environment and protecting the physical and mental health of the workers. Methods: Individual sampling monitoring and on-site labor hygiene investigation were conducted on 421 workers involved in 87 silicon dust enterprises in the jurisdiction from 2014 to 2018, and measured concentration-time weighted average (C(TWA)) . Results: The results showed that the range of the C(TWA) was (0.021~17.000) mg/m(3), the median was 1.600 mg/m(3), and the qualified rate of 30.88%. The difference of total dust concentration was statistically significant in different years (Z=38.831, P<0.05) . The qualified rate of small-scale enterprises is higher than that of medium-scale enterprises (χ(2)=9.472, P<0.05) . The qualified rate of other domestic enterprises is higher than that of private enterprises and foreign enterprises (χ(2)=10.089, P<0.05) . The acceptance rate of metal products manufacturing is lower than that of general equipment manufacturing and other manufacturing enterprises (χ(2)=64.626, P<0.05) . The qualification rate of natural ventilation is higher than that of mechanical ventilation (χ(2)=6.278, P<0.05) . Conclusion: The enterprises involved in silicon production in Fengxian District need to further strengthen the production process reform and improve the ventilation and dust removal protection measures. Widely carry out the publicity of occupational disease prevention and control law, conduct targeted pre-job training, improve workers' awareness of self-protection, and protect the occupational health of workers in many ways.

[Application of systematic etiological analysis in final and differential diagnosis of hereditary hemolytic anemia].

OBJECTIVE: Study on the application of the systematic analysis strategies of etiology in final and differential diagnosis of hereditary hemolytic anemia (HHA). METHODS: Analysis of 1 506 patients with suspected hemolytic anemia (HA) in systematic hemolytic etiological analysis. RESULTS: ①1 413(94%) of the total 1 506 patients [male 799, female 707, median age 22-year-old (4 days to 86-year-old) ]were caused by membranopathy, hemoglobinopathy and enzymopathy, documented the three major causes of HHA. 369 cases (26%) of the 1 413 patients showed complex type of HA, which had the coexistence of two or more hereditary defects concerning HA in red cells, the other 1 044 cases (74%) were HA with single hemolytic cause. ②In 1 044 cases of single HA, hemoglobinopathy, membranopathy and enzymopathy was 22%, 63% and 15%, respectively. When single HA plused complex HA, the hemoglobinopathy, membranopathy and enzymopathy was 29%, 57% and 14% respectively. The difference was not statistically significant (P >0.05). ③ The most common double heterozygosis with different genetic defects was hemoglobinopathy complicated with membranopathy (50%, 184/369). The complex HA was also found in patients with the enzymopathy complicated with membranopathy (18%, 66/369) and with hemoglobinopathy (4%, 13/369). Some of complex HA patients had the same kinds of genetic defects which means double hemoglobinopathies (29 cases, 8% ), membranopathies (57 cases, 15% ) and enzymopathies (9 cases, 2%). Other kinds (11 cases, 3%) of complex HA, anemia and jaundice were seen in HAA patients accompanied with acquired and secondary defects or other system abnormalities. CONCLUSION: The parallel etiologic examination of three major genetic hemolytic diseases can be 94% of patients for classification. The results showed that the first cause of HAA was membranopathy, second hemoglobinopathy and then enzymopathy. Complex hemolysis is not uncommon and single factor analysis alone is not enough to provide scientific basis for diagnosis.

A centrifugal particle concentrator for use in inhalation toxicology.

Epidemiologic studies have provided strong evidence that episodic exposure to ambient particulate matter is associated with increases in morbidity and mortality. These adverse effects have been demonstrated at concentrations far below the National Ambient Air Quality Standard (NAAQS), and thus, the biological plausibility of these effects has been questioned. For the purpose of exposing test animals to relevant and reproducible exposure concentrations of ambient particulate matter (PM), we have developed a simple and inexpensive concentrator system that can concentrate ambient particles 10-fold. A high-volume blower is used to deliver ambient air to the inlet manifold of a centrifugal concentrator and the entrained particles travel along a concentric annulus formed by a stationary solid outer cylinder and a porous inner cylinder rotating at high speed (up to 12,500 rpm). Suction applied at one end of the porous shaft causes the dispersion medium (air) to pass through the porous cylinder and into the shaft. Since the rotational velocity of airborne particles is comparable to that of the rotating cylinder near its surface, the particles move radially outward due to the centrifugal force, in addition to their motion laterally along the cylinder and inward due to the suction of air into the rotating porous cylinder. The particles reach their highest concentration near the outlet manifold, where they enter the exposure chamber under positive pressure ( approximately 0.4 cm H2O). Except for coarse particle loss due to impaction and diffusional loss of ultrafine particles in the concentrator, the increase in particle concentration is the ratio of the flow rates for the inlet air and the air delivered to the exposure chamber. We have used the centrifugal concentrator to deliver concentrated ambient urban PM to a nose-only exposure chamber and examined the concentrating effect across ambient particle sizes.

Deposition of charged particles on lung airways.

The effect of a single electric charge on the efficiency with which ultrafine particles deposit in human airways has been investigated. When inhaled short-lived radon progeny are attached to electrically neutral particles their deposition efficiency is controlled by diffusion. But most ambient particles carry one, or a few, charges. We measured and compared the deposition (DE) of singly charged, charge-neutralized, and zero-charge 20-nm and 125-nm particles in hollow-cast models of human airways. These particle sizes were selected because they are about where modal peaks occur for the activity of the short-lived radon progeny in indoor air. For singly charged 20-nm particles deposition (+/- standard error) in the casts was 3.4 +/- 0.3 times that for charge neutralized aerosols and 5.3 +/- 0.3 times the amount deposited for zero-charged particles. Corresponding ratios for the 125-nm particles were 2.3 +/- 0.3 and 6.2 +/- 0.7. Since most ambient particles are charged this effect must be considered when models are used to predict dose from inhaled ultrafine particles.

Generation of stable test atmospheres of cocaine base and its pyrolyzate, methylecgonidine, and demonstration of their biological activity.

Generating controlled test atmospheres of known chemical identity and airborne concentration upon demand is a significant technical obstacle that limits the scope and repeatability of studies of inhaled substances. We addressed this problem as applied to the generation of atmospheres that result from heating crack cocaine, which include both cocaine and its pyrolyzate methylecgonidine (MEG). A condensation aerosol generator was used to generate atmospheres comprised of monodisperse particles of cocaine, MEG, or mixtures of both that are of submicron size suitable for deposition in the alveolar region of primates. Compressed air seeded with nanometer-size sodium chloride particles was passed through a constant depth of molten cocaine or MEG in a bead bed, reheated, and condensed to an aerosol within an annulus of cold air. To achieve control of a mixture of both compounds, MEG was condensed onto cocaine particles in a separate coating step. On-line analytical instruments provided verification of airborne concentration, estimates of particle size, and dispersion as well as chemical identity. Specific airway conductance (SGaw), heart rate, and rectal and skin temperatures were measured in squirrel monkeys breathing atmospheres containing condensation aerosols of cocaine or MEG free base. SGaw was reduced after inhalation of either base, and both induced temperature and cardiovascular changes, demonstrating that the aerosols so generated had biological activity.

Methylecgonidine coats the crack particle.

Crack is a form of cocaine base self-administered by smoking. When heated, it volatilizes and may partially pyrolyze to methylecgonidine (MEG). Upon cooling, a condensation aerosol forms. Heating cocaine base in model crack pipes produced particles of about 1 micron in diameter, regardless of the amount heated; however, MEG concentration increased from < or = 2% at 10 mg per heating to as much as 5% at 30 mg per heating. Methylecgonidine was < or = 1% of the recovered material when cocaine was vaporized off a heated wire coil, but the particles were larger (2-5 microns), and the distribution disperse. The vapor pressure of MEG was higher [log P(mm Hg) = 9.994 - 3530/T] than cocaine base, consistent with MEG coating the droplet during condensation, and with evaporation during aging or dilution. Disappearance of MEG from a chamber filled with crack smoke was a two-component process, one proceeding at the rate of cocaine particle removal, and the other at the desorption rate from other surfaces. Particle diameter influences the deposition site in the respiratory tract; thus, the likely different patterns of deposition in the respiratory tract of humans and animals of crack aerosols produced by different techniques warrant consideration, as they may influence our understanding of immediate and delayed sequelae of the inhalation of cocaine and its pyrolysis product, MEG.

Effect of flow rate on aerosol bolus penetration in a hollow canine lung airway cast.

A cast of dog tracheobronchial airways, which is complete to airways of 1 mm in diameter, was used for experimental studies of the effect of flow rate on aerosol bolus penetration during a tidal breath. Aerosol boli of 35 cm3 were injected during a 1-L inhalation of air. The recoveries of aerosol particles in expired air were measured after various breathholding times. The results show that the penetration depth of an aerosol bolus increases with decreasing flow rate, especially for flow in transition from a flat profile to a parabolic profile.

Dispersion of aerosol particles in an airway cast of a dog.

Aerosol bolus dispersion was measured in the first branching generations of a replicate hollow cast. The cast was made from a solid cast of a beagle-dog tracheobronchial tree. The dispersion was measured after penetration of boluses into different volumetric depths, with different particle sizes and flow rates into the cast. An enhanced flow rate led to a decreasing dispersion in the cast. Particle size up to about 4 microns has no significant effect on dispersion.

Effect of lung airway branching pattern and gas composition on particle deposition in bronchial airways: III. Experimental studies with radioactively tagged aerosol in human and canine lungs.

Particle penetration into lung airways during normal respiration is affected by the exchange of inspired air and residual gas. In this study, particle penetration during the inspiratory phase was investigated using gamma-tagged monodisperse particles (0.70, 0.90, 0.96, and 1.44 microns) suspended in various carrier gases having a wide range of kinematic viscosity. A 40-mL bolus of tagged aerosol was drawn into excised human and dog lungs at the end of a tidal breath, followed by a long breathhold to allow for complete particle deposition by sedimentation. The lungs were then fixed, sectioned, and autoradiographed to determine tidal front locations. In human lungs, particles suspended in He-O2 penetrated deeper than particles suspended in air; particles penetrated least in SF6-O2. Dog lungs, which have more asymmetrical airway branching patterns than human lungs, had no significant particle penetration differences associated with carrier gas composition. It is concluded that particle penetration during the inspiratory phase is dependent on factors that determine flow profile development, such as branching pattern and the Reynolds number of the carrier gas. The bolus front at the end of an air inspiration extended into about 10% of human lung airways of 1 mm diameter, and into about 0.1% of 0.5-mm airways. It is concluded that rapid particle penetration to 1-mm airways during high-frequency oscillatory ventilation of lung casts is due to cumulative axial core transport during multiple breathing cycles. Similarly, the dispersion of an aerosol bolus from large airways to small airways during in vivo breathholding studies appears to be due to oscillatory flow created by the heartbeat.

A novel system for the in vitro exposure of pulmonary cells to acid sulfate aerosols.

While ambient acid aerosols are considered a potential respiratory health hazard, the mechanism by which they induce responses in the lungs is not known. Attempts to ascertain these mechanisms using inhalation exposures are complicated by a number of technical difficulties, chief among which are neutralization of inhaled acids by endogenous ammonia and variations in deposition with inhaled particle size. To control for these variables, a novel in vitro exposure system allowing experimental evaluation of factors which influence biologic responses to acid sulfate particles was developed. The system consists of two subunits, a generation/delivery component and a cell exposure component. Sulfuric acid aerosols are generated by nebulizing dilute acid solutions. Particles larger than a specified size of interest (based upon the specific exposure conditions desired) are removed, and particles at the desired size and mass concentration are uniformly delivered onto a target cell monolayer. The system is capable of delivering acid particles larger than 0.7 micron (mass median diameter), yet at constant particle mass concentrations. This paper describes the design of the exposure system and its performance characteristics and presents initial results of some biological responses obtained using it. In conjunction with inhalation studies, this exposure system may provide additional insights into mechanisms by which acid aerosols adversely affect the respiratory tract and into the physical characteristics of acid particles which modulate toxicity.

Aerosol tracer study of gas convective transport to 0.1-cm airways by high-frequency ventilation in a human lung airway cast.

A cast of human tracheobronchial airways, which is complete to airways less than 0.1 cm in diameter, was employed for experimental studies of gas convective transport by high-frequency ventilation (HFV). The cast was ventilated with gases of different kinematic viscosity (He, air, and SF6) and tidal volumes of 10-60 mL. The convective transport through the cast was followed by labeling the tidal volume with 0.5-micron aerosol particles. Such particles undergo little diffusion and have a short relaxation time and, therefore, can serve as tracers of stream flow. The time of arrival of particles transported to isolated peripheral segments of the cast during HFV was measured with an optical particle counter at various oscillatory tidal volumes and frequencies. Distally directed particle transport was found to be substantial in He and air, but weak in SF6. The extent of transport increased with increasing tidal volume. These results provide evidence for a distally directed axial flow during quasi-steady-state tidal breathing of lung airways over a wide range of frequency. This superimposed distal flow along the axial core is consistent with (1) the demonstrated efficacy of O2-CO2 exchange during HFV, and (2) concentrations of particles deposited on bifurcations of alveolar ducts as observed during normal breathing in small animal inhalation studies.