Diverging fates of cadmium and glyphosate during pasta cooking.

Durum wheat cultivars with varying abilities to accumulate cadmium were grown and treated in the field with a glyphosate-containing herbicide at different stages of maturity to produce grain with higher and lower concentrations of cadmium (0.066-0.214 mg/kg) and glyphosate (0.474-0.874 mg/kg). The grain was milled, and fractions were analysed for cadmium and glyphosate. The highest concentrations for both cadmium and glyphosate were associated with bran and shorts, although the percentage of total cadmium mass in bran (23-25%) was less than glyphosate (38%). The preparation of dried pasta from semolina and flour milling fractions reduced concentrations by a factor of 1.8 for glyphosate and 1.4 for cadmium. Dried pasta was cooked and analysed along with the cooking water for cadmium and glyphosate at seven-time points from 0 to 15 min. Concentrations of glyphosate in cooked pasta decreased significantly with cooking time; no decrease was observed for cadmium concentrations. Analysis of cooking water demonstrated that glyphosate migrated from pasta to the cooking water. After 15 min of cooking, approximately 73% of the total glyphosate mass had transferred from pasta to cooking water. Over the same time period, only 5% of the total cadmium mass had transferred from pasta to cooking water.

Impact of Quality Improvement and Milling Innovations on Durum Wheat and End Products.

There are long-standing established intrinsic quality requirements of end products made from durum wheat semolina, with color, textural, and cooking properties of pasta and couscous representing persistent key attributes for consumers. Over time, traditional efforts to advance development in these areas with respect to raw material, equipment, and process improvements have been influenced by growing awareness of issues around food safety, health and nutrition, and climate change, necessitating that development strategies incorporate specific considerations relating to safety, traceability, and sustainability. We examined improvements in durum wheat quality and innovations in milling and the resulting impact on product quality in light of these considerations, which are now fundamental to the planning and development of any food process, as required by consumers and regulators alike.

Challenges and opportunities for proteomics and the improvement of bread wheat quality.

Wheat remains a critical global food source, pressured by climate change and the need to maximize yield, improve processing and nutritional quality and ensure safety. An enormous amount of research has been conducted to understand gluten protein composition and structure in relation to end-use quality, yet progress has become stagnant. This is mainly due to the need and inability to biochemically characterize the intact functional glutenin polymer in order to correlate to quality, necessitating reduction to monomeric subunits and a loss of contextual information. While some individual gluten proteins might have a positive or negative influence on gluten quality, it is the sum total of these proteins, their relative and absolute expression, their sub-cellular trafficking, the amount and size of glutenin polymers, and ratios between gluten protein classes that define viscoelasticity of gluten. The sub-cellular trafficking of gluten proteins during seed maturation is still not completely clear and there is evidence of dual pathways and therefore different destinations for proteins, either constitutively or temporally. The trafficking of proteins is also unclear in endosperm cells as they undergo programmed cell death; Golgi disappear around 12 DPA but protein filling continues at least to 25 DPA. Modulation of the timing of cellular events will invariably affect protein deposition and therefore gluten strength and function. Existing and emerging proteomics technologies such as proteoform profiling and top-down proteomics offer new tools to study gluten protein composition as a whole system and identify compositional patterns that can modify gluten structure with improved functionality.

Effect of cooking duration on carotenoid content, digestion and potential absorption efficiencies among refined semolina and whole wheat pasta products.

The bioaccessibility of carotenoids varies among different foods due to factors such as food matrix composition and type or extent of processing. Hence it is important to understand the extent to which these factors influence carotenoid bioaccessibility after the consumption and digestion of food. This study evaluated the carotenoid content, micellization efficiency, digestive stability, antioxidant activity and bioaccessibility of carotenoids as impacted by wheat cultivar and cooking duration among whole wheat flour (WWF) and refined semolina (RS) pasta. WWF and RS pasta were processed from three durum wheat cultivars (AAC Spitfire, CDC Precision, and Transcend) and cooked to al dente (Al), fully cooked (FCT) or overcooked (OC). The study showed that the wheat cultivar and cooking duration were significant functions of bioaccessible lutein in RS samples while only the cultivar influenced the bioaccessibility of zeaxanthin and lutein in WWF samples. In both WWF and RS, the effect of the cultivar on the bioaccessibility of lutein and zeaxanthin was similar and was as follows: Transcend > CDC Precision > AAC Spitfire. Cooking to Al significantly caused an increment in bioaccessible lutein in RS samples regardless of the wheat cultivar. This influence of cooking duration (Al > FCT > OC) was inversely related to the lutein concentrations in undigested pasta (OC = FCT > Al). DPPH scavenging activity among WWF samples was about 2-fold greater or more than that of RS samples regardless of the cultivar or cooking duration before and after digestion. Our data suggest that the effect of wheat cultivar and cooking duration modulates the bioaccessibility and antioxidant activity of RS and WWF pasta products.

Effect of Kernel Size and Its Potential Interaction with Genotype on Key Quality Traits of Durum Wheat.

This study was conducted to evaluate the influence of kernel size and its potential interaction with genotype on durum wheat quality with emphases on kernel physical characteristics, milling performance, and color-related quality parameters. Wheat samples of seven genotypes, selected from the 2018 Canadian durum variety registration trial, were segregated into large (LK), medium (MK), and small-sized kernels (SK). In general, the kernel size greatly affected the durum wheat milling performance. Within a given size fraction, a strong impact of genotype was shown on the test weight of SK and the milling yields of MK and LK. Particularly, the MK fraction, segregated from the genotypes with superior milling quality, had a higher semolina yield than LK from the genotypes of inferior milling quality, inferring the importance of intrinsic physicochemical properties of durum kernels in affecting milling quality. SK exhibited inferior milling quality regardless of the genotypes selected. A strong impact of genotype was shown for the total yellow pigment (TYP) content and yellowness of semolina, while the kernel size had a significant impact on the brightness and redness of the semolina and pasta. Despite SK possessing much higher TYP, the semolina and pasta prepared from SK were lower in brightness and yellowness but with elevated redness.

Wheat Fusarium Protease Specificity and Effect on Dough Properties.

Fusarium infection is a worldwide agricultural problem of billion dollar proportions globally, and it has increasingly threatened entire regional food supplies. In addition to the toxin deoxynivalenol (DON), Fusarium species express digestive enzymes that degrade starch and protein, affecting the quality of infected grains, especially wheat processing performance which depends largely on gluten proteins. In this study, the impact of Fusarium protease on the functionality of Canada Western Red Spring (CWRS) wheat was assessed by adding Fusarium-damaged kernels (FDK) to a FDK-free base wheat sample. Digestion of beta-casein by extracts of flours, milled from sound and FDK-spiked wheat samples, demonstrated elevated cleavage in FDK-spiked flour extracts as follows: N-terminal to lysine (eight-fold), N- and C-terminal to isoleucine (four-fold and three-fold, respectively), N-terminal to tyrosine (three-fold) and C-terminal to arginine at P1' (five-fold). Comparison of abbreviated (45 min) and standard (135 min) extensigraph test results indicated that desirable increases in dough resistance to extension (Rmax) due to gluten re-polymerization after longer resting were partially to completely counteracted in FDK-spiked flours in a dose-dependent manner. Baking tests confirmed that while loaf volume is similar, proofed dough from FDK-spiked samples caused detectable loaf collapse at 3% FDK. Extensigraph Rmax and Fusarium protease levels were inversely related, and effected by both the extent and severity of infection. While the current FDK tolerances for grading Canadian wheat can effectively control protease damage, prevalence of deoxynivalenol (DON) weak- and non-producing Fusarium strains/species (e.g., F. avenaceum) in some growing regions must be considered to protect functionality if grading is solely based on DON content.

Influence of cooking duration on carotenoids, physical properties and in vitro antioxidant capacity of pasta prepared from three Canadian durum wheat cultivars.

This study investigates the impact of different pasta cooking durations (al dente, fully cooked or overcooked) on the carotenoid content and physical properties of whole wheat and refined semolina pasta prepared from three Canadian durum wheat cultivars. Carotenoids were analyzed using HPLC and spectrophotometry. Generally increasing cooking duration non-significantly increased lutein, zeaxanthin, total carotenoids, significantly increased the cis carotenoids but decreased carotenoid retention and firmness regardless of flour type or wheat cultivar. Despite this decrease, whole wheat pasta was significantly firmer than semolina when overcooked regardless of wheat cultivar. Antioxidant capacity was highly influenced by flour type but did not show a clear trend with cooking duration. Overall analysis indicates that increasing cooking duration of whole wheat or semolina pasta above 7 or 8 mins respectively allows for the maximum extraction of carotenoids with possible accessibility by digestive enzymes when consumed but this affects cooking quality including high cooking loss.

Conditional Mapping Identified Quantitative Trait Loci for Grain Protein Concentration Expressing Independently of Grain Yield in Canadian Durum Wheat.

Grain protein concentration (GPC) is an important trait in durum cultivar development as a major determinant of the nutritional value of grain and end-use product quality. However, it is challenging to simultaneously select both GPC and grain yield (GY) due to the negative correlation between them. To characterize quantitative trait loci (QTL) for GPC and understand the genetic relationship between GPC and GY in Canadian durum wheat, we performed both traditional and conditional QTL mapping using a doubled haploid (DH) population of 162 lines derived from Pelissier × Strongfield. The population was grown in the field over 5 years and GPC was measured. QTL contributing to GPC were detected on chromosome 1B, 2B, 3A, 5B, 7A, and 7B using traditional mapping. One major QTL on 3A (QGpc.spa-3A.3) was consistently detected over 3 years accounting for 9.4-18.1% of the phenotypic variance, with the favorable allele derived from Pelissier. Another major QTL on 7A (QGpc.spa-7A) detected in 3 years explained 6.9-14.8% of the phenotypic variance, with the beneficial allele derived from Strongfield. Comparison of the QTL described here with the results previously reported led to the identification of one novel major QTL on 3A (QGpc.spa-3A.3) and five novel minor QTL on 1B, 2B and 3A. Four QTL were common between traditional and conditional mapping, with QGpc.spa-3A.3 and QGpc.spa-7A detected in multiple environments. The QTL identified by conditional mapping were independent or partially independent of GY, making them of great importance for development of high GPC and high yielding durum.

Multiple wheat genomes reveal global variation in modern breeding.

Advances in genomics have expedited the improvement of several agriculturally important crops but similar efforts in wheat (Triticum spp.) have been more challenging. This is largely owing to the size and complexity of the wheat genome1, and the lack of genome-assembly data for multiple wheat lines2,3. Here we generated ten chromosome pseudomolecule and five scaffold assemblies of hexaploid wheat to explore the genomic diversity among wheat lines from global breeding programs. Comparative analysis revealed extensive structural rearrangements, introgressions from wild relatives and differences in gene content resulting from complex breeding histories aimed at improving adaptation to diverse environments, grain yield and quality, and resistance to stresses4,5. We provide examples outlining the utility of these genomes, including a detailed multi-genome-derived nucleotide-binding leucine-rich repeat protein repertoire involved in disease resistance and the characterization of Sm16, a gene associated with insect resistance. These genome assemblies will provide a basis for functional gene discovery and breeding to deliver the next generation of modern wheat cultivars.

Changes in Protein Non-Covalent Bonds and Aggregate Size during Dough Formation.

This research investigated changes in the amounts and sizes of monomeric proteins and protein aggregates during dough mixing, with a focus on the contribution of non-covalent bonds in the aggregation of gluten proteins. High protein flour (HF) and low protein flour (LF) were used in this study. As dough mixing progressed from flour to overmixed dough, the total amount of protein aggregates increased while the amount of monomeric protein decreased. Omega-gliadin was the major monomeric protein that decreased in quantity. Interestingly, the amount of larger-sized protein aggregates decreased and that of smaller-sized protein aggregates increased. The amount of gluten protein macro-polymer aggregated through strong non-covalent bonds decreased whereas aggregates formed with weaker non-covalent bonds increased. LF dough behaved similar to HF dough. Large-sized gluten protein aggregates disaggregated due to the weakening of non-covalent bonds and became smaller. Omega-gliadin was incorporated into gluten protein aggregates during dough mixing.

Inter-Relationships between Test Weight, Thousand Kernel Weight, Kernel Size Distribution and Their Effects on Durum Wheat Milling, Semolina Composition and Pasta Processing Quality.

Although most of the durum wheat produced in the Canadian prairies in 2017 and 2018 met the test weight (TW) requirements for the top grades of Canada Western Amber Durum (CWAD), some samples of top grades were inferior in milling quality. To understand the abnormality, this study was conducted to investigate TW, thousand kernel weight (TKW) and kernel size distribution (KSD) in relation to durum milling potential, semolina composition and pasta quality. With reduction of kernel size, semolina and total milling yields decreased progressively, and kernels passing through no.6 slotted sieve had detrimental impact on milling. The overall relationship between TW and milling yields appeared to be genotype dependent. At similar TW, variety showed lower milling yields had greater proportion of smaller kernels. By account for the difference in KSD, greater relationships (R2 > 0.91, p < 0.001) were found for TKW and proportion of kernels passing No.6 slotted sieve with milling yields than TW (R2 = 0.75, p < 0.001). This infers potential use of small kernels (passing No.6 slotted sieve) as a new objective grading factor for rapid prediction of milling quality of CWAD. Although small kernels exhibited much higher yellow pigment than the larger ones, pasta made from small kernels was duller, redder and less yellow, likely due to the higher semolina ash and protein contents, which adversely affected pasta color.

Fate of Ergot Alkaloids during Laboratory Scale Durum Processing and Pasta Production.

The fate of ergot alkaloids during the milling of durum and subsequent production and cooking of pasta was examined. Durum samples containing varying amounts of ergot sclerotia (0.01⁻0.1% by mass) were milled, and all milling product was analyzed for 10 ergot alkaloids using liquid chromatography with tandem mass spectrometry. Spaghetti was prepared from the semolina obtained during milling. Ergocristine, ergocristinine, and ergotamine were the predominant ergot alkaloids observed in the milling fractions and spaghetti. Approximately 84% of the total ergot alkaloid mass of the whole grain durum resided in the milling product fractions associated with the outer kernel layers (bran, shorts, feeds). No consistent loss of ergot alkaloids was observed during the production or cooking of spaghetti. However, changes in the ratio of R- to S-enantiomers occurred during the milling and cooking of spaghetti. Products containing bran, shorts, and feeds, as well as cooked spaghetti, contained a higher proportion of the less biologically active S-enantiomers. The results of this study emphasize the need to monitor R- and S-enantiomers, and to consider food and feed products, as opposed to whole grain, when assessing any exposure of consumers to ergot alkaloids.

Total Phenolic and Yellow Pigment Contents and Antioxidant Activities of Durum Wheat Milling Fractions.

The aim of this study was to investigate the distribution of total yellow pigments, total phenolic compounds, and their antioxidant activities in various durum wheat milling fractions. Carotenoid composition of yellow pigment extract was also examined using UPLC. The ABTS radical scavenging activity of the milling fractions decreased in the order of short bran/bran > feed flour > flour/semolina in both total phenolic and total yellow pigment extracts. Yellow pigments extracts from bran, short bran, and feed flour exhibited 5.6-15.4% higher antioxidant activity than those of total phenolic extracts from the corresponding milling fractions. The UPLC results showed a non-carotenoid peak at Rt 0.47 min which was present in fractions of the grain outer layers but absent in semolina and flour. This peak absorbed in the UV range of 271 to 327 nm. These observations suggest that the unknown peak could be composed of phenolic compounds co-extracted in their free form with carotenoids in the polar water-saturated butanol solvent. The compounds in this peak could result in overestimation of carotenoid content and antioxidant activity in bran, short bran and feed flour as the peak contributed to 18.3-26.0% of total carotenoids if it was taken into account.