A field-pilot for passive bioremediation of As-rich acid mine drainage.

A field-pilot bioreactor exploiting microbial iron (Fe) oxidation and subsequent arsenic (As) and Fe co-precipitation was monitored during 6 months for the passive treatment of As-rich acid mine drainage (AMD). It was implemented at the Carnoulès mining site (southern France) where AMD contained 790-1315 mg L-1 Fe(II) and 84-152 mg L-1 As, mainly as As(III) (78-83%). The bioreactor consisted in five shallow trays of 1.5 m2 in series, continuously fed with AMD by natural flow. We monitored the flow rate and the water physico-chemistry including redox Fe and As speciation. Hydraulic retention time (HRT) was calculated and the precipitates formed inside the bioreactor were characterized (mineralogy, Fe and As content, As redox state). Since As(III) oxidation improves As retention onto Fe minerals, bacteria with the capacity to oxidize As(III) were quantified through their marker gene aioA. Arsenic removal yields in the pilot ranged between 3% and 97% (average rate (1.8 ±â€¯0.8) ✕ 10-8 mol L-1 s-1), and were positively correlated to HRT and inlet water dissolved oxygen concentration. Fe removal yields did not exceed 11% (average rate (7 ±â€¯5) ✕ 10-8 mol L-1 s-1). In the first 32 days the precipitate contained tooeleite, a rare arsenite ferric sulfate mineral. Then, it evolved toward an amorphous ferric arsenate phase. The As/Fe molar ratio and As(V) to total As proportion increased from 0.29 to 0.86 and from ∼20% to 99%, respectively. The number of bacterial aioA gene copies increased ten-fold during the first 48 days and stabilized thereafter. These results and the monitoring of arsenic speciation in the inlet and the outlet water, provide evidences that As(III) oxidized in the pilot. The biotreatment system we designed proved to be suitable for high As DMA. The formation of sludge highly enriched into As(V) rather than As(III) is advantageous in the perspective of long term storage.

Biological attenuation of arsenic and iron in a continuous flow bioreactor treating acid mine drainage (AMD).

Passive water treatments based on biological attenuation can be effective for arsenic-rich acid mine drainage (AMD). However, the key factors driving the biological processes involved in this attenuation are not well-known. Here, the efficiency of arsenic (As) removal was investigated in a bench-scale continuous flow channel bioreactor treating As-rich AMD (∼30-40 mg L-1). In this bioreactor, As removal proceeds via the formation of biogenic precipitates consisting of iron- and arsenic-rich mineral phases encrusting a microbial biofilm. Ferrous iron (Fe(II)) oxidation and iron (Fe) and arsenic removal rates were monitored at two different water heights (4 and 25 mm) and with/without forced aeration. A maximum of 80% As removal was achieved within 500 min at the lowest water height. This operating condition promoted intense Fe(II) microbial oxidation and subsequent precipitation of As-bearing schwertmannite and amorphous ferric arsenate. Higher water height slowed down Fe(II) oxidation, Fe precipitation and As removal, in relation with limited oxygen transfer through the water column. The lower oxygen transfer at higher water height could be partly counteracted by aeration. The presence of an iridescent floating film that developed at the water surface was found to limit oxygen transfer to the water column and delayed Fe(II) oxidation, but did not affect As removal. The bacterial community structure in the biogenic precipitates in the bottom of the bioreactor differed from that of the inlet water and was influenced to some extent by water height and aeration. Although potential for microbial mediated As oxidation was revealed by the detection of aioA genes, removal of Fe and As was mainly attributable to microbial Fe oxidation activity. Increasing the proportion of dissolved As(V) in the inlet water improved As removal and favoured the formation of amorphous ferric arsenate over As-sorbed schwertmannite. This study proved the ability of this bioreactor-system to treat extreme As concentrations and may serve in the design of future in-situ bioremediation system able to treat As-rich AMD.

A new bacterial strain mediating As oxidation in the Fe-rich biofilm naturally growing in a groundwater Fe treatment pilot unit.

A bacterial strain B2 that oxidizes arsenite into arsenate was isolated from the biofilm growing in a biological groundwater treatment process used for Fe removal. This strain is phylogenetically and morphologically different from the genus Leptothrix commonly encountered in biological iron oxidation processes. T-RFLP fingerprint of the biofilm revealed that this isolated strain B2 corresponds to the major population of the bacterial community in the biofilm. Therefore, it is probably one of the major contributors to arsenic removal in the treatment process.