Tolerability and pharmacokinetic evaluation of inhaled dry powder hydroxychloroquine in healthy volunteers.

RATIONALE: Inhaled antimicrobials enable high local concentrations where needed and, compared to orally administration, greatly reduce the potential for systemic side effects. In SARS-CoV-2 infections, hydroxychloroquine sulphate (HCQ) administered as dry powder via inhalation could be safer than oral HCQ allowing higher and therefore more effective pulmonary concentrations without dose limiting toxic effects. OBJECTIVES: To assess the local tolerability, safety and pharmacokinetic parameters of HCQ inhalations in single ascending doses of 5, 10 and 20 mg using the Cyclops dry powder inhaler. METHODS: Twelve healthy volunteers were included in the study. Local tolerability and safety were assessed by pulmonary function tests, electrocardiogram and recording adverse events. To estimate systemic exposure, serum samples were collected before and 0.5, 2 and 3.5 h after inhalation. RESULTS AND DISCUSSION: Dry powder HCQ inhalations were well tolerated by the participants, except for transient bitter taste in all participants and minor coughing irritation. There was no significant change in QTc-interval or drop in FEV1 post inhalation. The serum HCQ concentration remained below 10 µg/L in all samples. CONCLUSION: Single doses of inhaled dry powder HCQ up to 20 mg are safe and well tolerated. Our data support that further studies with inhaled HCQ dry powder to evaluate pulmonary pharmacokinetics and efficacy are warranted.

Colistin dry powder inhalation with the Twincer™: An effective and more patient friendly alternative to nebulization.

BACKGROUND: Nebulization of antimicrobial drugs such as tobramycin and colistin is a cornerstone in the treatment of patients with cystic fibrosis (CF) infected with Pseudomonas aeruginosa. However, nebulization has a high treatment burden. The Twincer™ is a dry powder inhaler specifically developed for the inhalation of antibiotics such as colistin. The aim of this study was to compare patient outcomes and experience with colistin dry powder by the Twincer with nebulization of colistin or tobramycin in adult CF patients in a real-life setting. METHODS: This was a retrospective study from 01-01-2015 until 01-07-2018. Effectiveness was evaluated by comparing FEV1 decline and exacerbation rate during a mean of 4.1 years of nebulization therapy prior to the initiation of the Twincer against the same values during a mean of 1.7 years of treatment with the Twincer. RESULTS: Twenty-one patients were evaluated, of whom twelve could be included in the effectiveness analysis, with a total of twenty patient years. Of all patients 71.4% preferred therapy with the Twincer over nebulization. Twincer use resulted in high treatment adherence with an average adherence rate of 92.5%. There was no significant difference in annual decline in FEV1%pred prior to and after start changing from nebulization to the use of the Twincer powder inhaler (median decline -1.56 [-5.57-5.31] and 1.35 [-8.45-6.36]) respectively, p = 0.45 (linear mixed effect model)). No significant difference was found in the number of intravenous or combined total intravenous and oral antibiotic courses during Twincer therapy compared to when using nebulization (1.68 and 2.49 courses during Twincer therapy versus 1.51 and 2.94 courses during nebulization, p = 0.88 and p = 0.63). CONCLUSION: Colistin dry powder inhalation with the Twincer is a more patient friendly alternative to nebulization, and we did not observe significant differences in the clinical outcome, regarding lung function and exacerbation rates.

Dry powder inhalation: past, present and future.

INTRODUCTION: Early dry powder inhalers (DPIs) were designed for low drug doses in asthma and COPD therapy. Nearly all concepts contained carrier-based formulations and lacked efficient dispersion principles. Therefore, particle engineering and powder processing are increasingly applied to achieve acceptable lung deposition with these poorly designed inhalers. Areas covered: The consequences of the choices made for early DPI development with respect of efficacy, production costs and safety and the tremendous amount of energy put into understanding and controlling the dispersion performance of adhesive mixtures are discussed. Also newly developed particle manufacturing and powder formulation processes are presented as well as the challenges, objectives, and new tools available for future DPI design. Expert opinion: Improved inhaler design is desired to make DPIs for future applications cost-effective and safe. With an increasing interest in high dose drug delivery, vaccination and systemic delivery via the lungs, innovative formulation technologies alone may not be sufficient. Safety is served by increasing patient adherence to the therapy, minimizing the use of unnecessary excipients and designing simple and self-intuitive inhalers, which give good feedback to the patient about the inhalation maneuver. For some applications, like vaccination and delivery of hygroscopic formulations, disposable inhalers may be preferred.

Can Patients with Parkinson's Disease Use Dry Powder Inhalers during Off Periods?

Because of its rapid onset of action, pulmonary administration of levodopa is an interesting alternative to oral administration for the rescue treatment of Parkinson's disease patients in an off period. We studied the ability of Parkinson's disease patients to operate a dry powder inhaler (DPI) correctly during an off period. We used an instrumented test inhaler with three different resistances to air flow to record flow curves and computed various inhalation parameters. We observed that all (13) patients were able to generate pressure drops > 2 kPa over the highest resistance and 10 out of 13 patients achieved at least 4 kPa. Inhaled volumes (all resistances) varied from 1.2 L to 3.5 L. Total inhalation time and the time to peak inspiratory flow rate both decreased with decreasing inhaler resistance. Twelve out of thirteen patients could hold their breath for at least five seconds after inhalation and nine could extend this time to ten seconds. The data from this study indicate that patients with Parkinson's disease will indeed be able to use a dry powder inhaler during an off period and they provide an adequate starting point for the development of a levodopa powder inhaler to treat this particular patient group.