Effect of lignin chemistry on the enzymatic hydrolysis of woody biomass.

The impact of lignin-derived inhibition on enzymatic hydrolysis is investigated by using lignins isolated from untreated woods and pretreated wood pulps. A new method, biomass reconstruction, for which isolated lignins are precipitated onto bleached pulps to mimic lignocellulosic biomass, is introduced, for the first time, to decouple the lignin distribution issue from lignin chemistry. Isolated lignins are physically mixed and reconstructed with bleached pulps. Lignins obtained from pretreated woods adsorb two to six times more cellulase than lignins obtained from untreated woods. The higher adsorption of enzymes on lignin correlates with decreased carbohydrate conversion in enzymatic hydrolysis. In addition, the reconstructed softwood substrate has a lower carbohydrate conversion than the reconstructed hardwood substrate. The degree of condensation of lignin increases significantly after pretreatment, especially with softwood lignins. In this study, the degree of condensation of lignin (0.02 to 0.64) and total OH groups in lignin (1.7 to 1.1) have a critical impact on cellulase adsorption (9 to 70%) and enzymatic hydrolysis (83.2 to 58.2%); this may provide insights into the more recalcitrant nature of softwood substrates.

Biodegradation of PCB congeners by white rot fungus, Ceriporia sp. ZLY-2010, and analysis of metabolites.

Polychlorinated biphenyls (PCBs) are difficult to degrade due to poor solubility, toxicity, and thermal stability. In the present study, the feasibility of PCB congener biodegradation by Ceriporia sp. ZLY-2010 was evaluated. The biodegradation rates of four PCB congeners, 4,4'-dichlorobiphenyl, 2,3',4',5-tetrachlorobiphenyl, 2,2',4,5,5'-pentachlorobiphenyl, and 2,2',4,4',5,5'-hexachlorobiphenyl were evaluated. The degradation rate of 4,4'-dichlorobiphenyl was 34.03% on incubation day 13, while that of 2,2',4,4',5,5'-hexachlorobiphenyl reached 40.05% on incubation day 17. Therefore, Ceriporia sp. ZLY-2010 was degrading the higher PCB congeners more efficiently. PCB congener degradation products were extracted using acetone and ethyl acetate. No 2,2',4,5,5'-pentachlorobiphenyl metabolites were detected in Ceriporia sp. ZLY-2010 culture, whereas 2,2',4,4',5,5'-hexachlorobiphenyl appeared to degrade to benzoic acid. However, intermediates of 2,2',4,4',5,5'-hexachlorobiphenyl were not detected during degradation. Therefore, additional studies should be performed to explore the mechanisms of PCB degradation. Our results indicate that Ceriporia sp. ZLY-2010 is able to degrade highly chlorinated biphenyls and has potential for use in PCB biodegradation and bioremediation.

Inhibitory effect of the essential oil from Chamaecyparis obtusa on the growth of food-borne pathogens.

In this study, the antibacterial activity of essential oil from Chamaecyparis obtusa (Sieb. et Zucc) leaves and twigs was investigated. The test strains were Klebsiella pneumoniae, Listeria monocytogenes, Salmonella typhimurium, Staphylococcus aureus, Escherichia coli, Legionella pneumophila, and Methicilline-resistant Staphylococcus aureus. Antibacterial activity was estimated by measuring bacterial growth inhibition. Histopathological examination was also performed. C. obtusa oil distinctly inhibited the growth of all test strains and exhibited the strongest antibacterial activity against L. monocytogenes. It was chromatographically divided into several fractions. The fractions were further tested against antibacterial activity and their chemical compositions were analyzed. The fraction containing terpinen-4-ol (TA) showed high antibacterial activity toward all strains tested. Tests with authentic samples showed that TA played a major role in the antibacterial activity of C. obtusa oil, and in a mice test, the oil actively minimized inflammation by S. aureus.

The essential oils of Chamaecyparis obtusa promote hair growth through the induction of vascular endothelial growth factor gene.

Chamaecyparis obtusa (C. obtusa) is a conifer in the cypress family Cupressaceae, native to northeast Asia. The essential oils of C. obtusa have antibacterial and antifungal effects and several products such as hygienic bands, aromatics, and shampoos contain these oils as a natural source of antimicrobial/antifungal agents. Interestingly, some consumers suffering from baldness and/or other forms of hair loss have reported a hair growth promoting effect of shampoos containing these oils. In the present study, the hair growth promoting effect of C. obtusa oils was elucidated in an animal model. C. obtusa oils promoted the early phase of hair growth in shaved mice. In addition, we examined the molecular effect of C. obtusa oils on the regulation of hair morphogenesis and hair growth using the human keratinocyte cell line HaCaT. In the current study of hair growth regulating genes, the expressions of vascular endothelial growth factor (VEGF), transforming growth factor (TGF beta 1), and keratinocyte growth factor(KGF) have been analyzed by real-time PCR in HaCaT cells. The essential oils of C. obtusa were divided into seven fractions for treatment of HaCaT cells. VEGF transcripts were induced by fractions 6 and 7; however, TGF beta 1 and KGF mRNA levels were unchanged by C. obtusa oils or fractions. Fraction 7 was separated into seven sub-fractions and studied further. Sub-fractions E and D significantly increased VEGF and KGF gene expression without up-regulating the hair growth inhibition factor, TGF beta 1. The components of the two sub-fractions were further analyzed by gas chromatography and mass spectrometry. Cuminol, eucarvone, and calamenene were common to these two sub-fractions, although the effects of these individual components were not determined. Taken together, these results suggest that C. obtusa oils promote hair growth in an animal model and a positive regulator of hair growth, VEGF, was induced by particular components of these oils.

The beneficial effect of the sap of Acer mono in an animal with low-calcium diet-induced osteoporosis-like symptoms.

The sap of Acer mono has been called 'bone-benefit-water' in Korea because of its mineral and sugar content. In particular, the calcium concentration of the sap of A. mono is 37.5 times higher than commercial spring water. In the current study, we examined whether A. mono sap could improve or prevent osteoporosis-like symptoms in a mouse model. Male mice (3 weeks old) were fed a low-calcium diet supplemented with 25, 50 or 100 % A. mono sap, commercial spring water or a high calcium-containing solution as a beverage for 7 weeks. There were no differences in weekly weight gain and food intake among all the groups. Mice that were given a low-calcium diet supplemented with commercial spring water developed osteoporosis-like symptoms. To assess the effect of sap on osteoporosis-like symptoms, we examined serum calcium concentration, and femur density and length, and carried out a histological examination. Serum calcium levels were significantly lower in mice that received a low-calcium diet supplemented with commercial spring water (the negative control group), and in the 25 % sap group compared to mice fed a normal diet, but were normal in the 50 and 100 % sap and high-calcium solution groups. Femur density and length were significantly reduced in the negative control and 25 % sap groups. These results indicate that a 50 % sap solution can mitigate osteoporosis-like symptoms induced by a low-calcium diet. We also examined the regulation of expression of calcium-processing genes in the duodenum and kidney. Duodenal TRPV6 and renal calbindin-D9k were up-regulated dose-dependently by sap, and the levels of these factors were higher than those attained in the spring water-treated control. The results demonstrate that the sap of A. mono ameliorates the low bone density induced by a low-calcium diet, most likely by increasing calcium ion absorption.

Characterization of xylanase from Lentinus edodes M290 cultured on waste mushroom logs.

Extracellular enzymes from Lentinus edodes M290 on normal woods (Quercus mongolica) and waste logs from oak mushroom production were comparatively investigated. Endoglucanase, cellobiohydrolase, beta-glucosidase, and xylanase activities were higher on waste mushroom logs than on normal woods after L. edodes M290 inoculation. Xylanase activity was especially different, with a three times higher activity on waste mushroom logs. When the waste mushroom logs were used as a carbon source, a new 35 kDa protein appeared. After the purification, the optimal pH and temperature for xylanase activity were determined to be 4.0 and 50 degrees C, respectively. More than 50% of the optimal xylanase activity was retained when the temperature was increased from 20 to 60 degrees C, after a 240 min reaction. At 40 degrees C, the xylanase maintained 93% of the optimal activity, after a 240 min reaction. The purified xylanase showed a very high homology to the xylanase family 10 from Aspergillus terreus by LC/MS-MS analysis. The highest Xcorr (1.737) was obtained from the peptide KWI SQGIPIDGIG SQTHLGSGGS WTVK originated from Aspergillus terreus, indicating that the 35 kDa protein was xylanase. This protein showed low homology to a previously reported L. edodes xylanase sequence.

Antifungal activities of the essential oils in Syzygium aromaticum (L.) Merr. Et Perry and Leptospermum petersonii Bailey and their constituents against various dermatophytes.

This study was carried out in order to investigate the potential of using plant oils derived from Leptospermum petersonii Bailey and Syzygium aromaticum L. Merr. Et Perry as natural antifungal agents. The antifungal effects of essential oils at concentrations of 0.05, 0.1, 0.15, and 0.2 mg/ml on the dermatophytes Microsporum canis (KCTC 6591), Trichophyton mentagrophytes (KCTC 6077), Trichophyton rubrum (KCCM 60443), Epidermophyton floccosum (KCCM 11667), and Microsporum gypseum were evaluated using the agar diffusion method. The major constituents of the active fraction against the dermatophytes were identified by gas chromatography-mass spectrometry and high-performance liquid chromatography analysis. The antifungal activities of S. aromaticum oil (clove oil) against the dermatophytes tested were highest at a concentration of 0.2 mg/ml, with an effectiveness of more than 60%. Hyphal growth was completely inhibited in T. mentagrophytes, T. rubrum, and M. gypseum by treatment with clove oil at a concentration of 0.2 mg/ml. Eugenol was the most effective antifungal constituent of clove oil against the dermatophytes T. mentagrophytes and M. canis. Morphological changes in the hyphae of T. mentagrophytes, such as damage to the cell wall and cell membrane and the expansion of the endoplasmic reticulum, after treatment with 0.11 mg/ml eugenol were observed by transmission electron microscopy (TEM). At a concentration of 0.2 mg/ml, L. petersonii oil (LPO) was more than 90% effective against all of the dermatophytes tested, with the exception of T. rubrum. Geranial was determined to be the most active antifungal constituent of L. petersonii oil. Taken together, the results of this study demonstrate that clove and tea tree oils exhibited significant antifungal activities against the dermatophytes tested in this study.

Biological pretreatment of softwood Pinus densiflora by three white rot fungi.

The effects of biological pretreatment on the Japanese red pine Pinus densiflora, was evaluated after exposure to three white rot fungi Ceriporia lacerata, Stereum hirsutum, and Polyporus brumalis. Change in chemical composition, structural modification, and their susceptibility to enzymatic saccharification in the degraded wood were analyzed. Of the three white rot fungi tested, S. hirsutum selectively degraded the lignin of this sortwood rather than the holocellulose component. After eight weeks of pretreatment with S. hirsutum, total weight loss was 10.7%, while lignin loss was the highest at 14.52% among the tested samples. However, holocellulose loss was lower at 7.81% compared to those of C. lacerata and P. brumalis. Extracelluar enzymes from S. hirsutum showed higher activity of ligninase and lower activity of cellulase than those from other white rot fungi. Thus, total weight loss and changes in chemical composition of the Japanese red pine was well correlated with the enzyme activities related with lignin- and cellulose degradation in these fungi. Based on the data obtained from analysis of physical characterization of degraded wood by X-ray Diffractometry (XRD) and pore size distribution, S. hirsutum was considered as an effective potential fungus for biological pretreatment. In particular, the increase of available pore size of over 120 nm in pretreated wood powder with S. hirsutum made enzymes accessible for further enzymatic saccharification. When Japanese red pine chips treated with S. hirsutum were enzymatically saccharified using commercial enzymes (Cellulclast 1.5 L and Novozyme 188), sugar yield was greatly increased (21.01%) compared to non-pretreated control samples, indicating that white rot fungus S. hirsutum provides an effective process in increasing sugar yield from woody biomass.