Production of Biobased Ethylbenzene by Cascade Biocatalysis with an Engineered Photodecarboxylase.

Production of commodity chemicals, such as benzene, toluene, ethylbenzene, and xylenes (BTEX), from renewable resources is key for a sustainable society. Biocatalysis enables one-pot multistep transformation of bioresources under mild conditions, yet it is often limited to biochemicals. Herein, we developed a non-natural three-enzyme cascade for one-pot conversion of biobased l-phenylalanine into ethylbenzene. The key rate-limiting photodecarboxylase was subjected to structure-guided semirational engineering, and a triple mutant CvFAP(Y466T/P460A/G462I) was obtained with a 6.3-fold higher productivity. With this improved photodecarboxylase, an optimized two-cell sequential process was developed to convert l-phenylalanine into ethylbenzene with 82 % conversion. The cascade reaction was integrated with fermentation to achieve the one-pot bioproduction of ethylbenzene from biobased glycerol, demonstrating the potential of cascade biocatalysis plus enzyme engineering for the production of biobased commodity chemicals.

Co-Immobilization of a Multi-Enzyme Cascade: (S)-Selective Amine Transaminases, l-Amino Acid Oxidase and Catalase.

An enzyme cascade was established previously consisting of a recycling system with an l-amino acid oxidase (hcLAAO4) and a catalase (hCAT) for different α-keto acid co-substrates of (S)-selective amine transaminases (ATAs) in kinetic resolutions of racemic amines. Only 1 mol % of the co-substrate was required and l-amino acids instead of α-keto acids could be applied. However, soluble enzymes cannot be reused easily. Immobilization of hcLAAO4, hCAT and the (S)-selective ATA from Vibrio fluvialis (ATA-Vfl) was addressed here. Immobilization of the enzymes together rather than on separate beads showed higher reaction rates most likely due to fast co-substrate channeling between ATA-Vfl and hcLAAO4 due to their close proximity. Co-immobilization allowed further reduction of the co-substrate amount to 0.1 mol % most likely due to a more efficient H2 O2 -removal caused by the stabilized hCAT and its proximity to hcLAAO4. Finally, the co-immobilized enzyme cascade was reused in 3 cycles of preparative kinetic resolutions to produce (R)-1-PEA with high enantiomeric purity (97.3 %ee). Further recycling was inefficient due to the instability of ATA-Vfl, while hcLAAO4 and hCAT revealed high stability. An engineered ATA-Vfl-8M was used in the co-immobilized enzyme cascade to produce (R)-1-(3-ethoxy-4-methoxyphenyl)-2-(methylsulfonyl)ethanamine, an apremilast-intermediate, with a 1,000 fold lower input of the co-substrate.

Structure- and Data-Driven Protein Engineering of Transaminases for Improving Activity and Stereoselectivity.

Amine transaminases (ATAs) are powerful biocatalysts for the stereoselective synthesis of chiral amines. Machine learning provides a promising approach for protein engineering, but activity prediction models for ATAs remain elusive due to the difficulty of obtaining high-quality training data. Thus, we first created variants of the ATA from Ruegeria sp. (3FCR) with improved catalytic activity (up to 2000-fold) as well as reversed stereoselectivity by a structure-dependent rational design and collected a high-quality dataset in this process. Subsequently, we designed a modified one-hot code to describe steric and electronic effects of substrates and residues within ATAs. Finally, we built a gradient boosting regression tree predictor for catalytic activity and stereoselectivity, and applied this for the data-driven design of optimized variants which then showed improved activity (up to 3-fold compared to the best variants previously identified). We also demonstrated that the model can predict the catalytic activity for ATA variants of another origin by retraining with a small set of additional data.

Marine Bacteroidetes enzymatically digest xylans from terrestrial plants.

Marine Bacteroidetes that degrade polysaccharides contribute to carbon cycling in the ocean. Organic matter, including glycans from terrestrial plants, might enter the oceans through rivers. Whether marine bacteria degrade structurally related glycans from diverse sources including terrestrial plants and marine algae was previously unknown. We show that the marine bacterium Flavimarina sp. Hel_I_48 encodes two polysaccharide utilization loci (PULs) which degrade xylans from terrestrial plants and marine algae. Biochemical experiments revealed activity and specificity of the encoded xylanases and associated enzymes of these PULs. Proteomics indicated that these genomic regions respond to glucuronoxylans and arabinoxylans. Substrate specificities of key enzymes suggest dedicated metabolic pathways for xylan utilization. Some of the xylanases were active on different xylans with the conserved ß-1,4-linked xylose main chain. Enzyme activity was consistent with growth curves showing Flavimarina sp. Hel_I_48 uses structurally different xylans. The observed abundance of related xylan-degrading enzyme repertoires in genomes of other marine Bacteroidetes indicates similar activities are common in the ocean. The here presented data show that certain marine bacteria are genetically and biochemically variable enough to access parts of structurally diverse xylans from terrestrial plants as well as from marine algal sources.

A growth selection system for the directed evolution of amine-forming or converting enzymes.

Fast screening of enzyme variants is crucial for tailoring biocatalysts for the asymmetric synthesis of non-natural chiral chemicals, such as amines. However, most existing screening methods either are limited by the throughput or require specialized equipment. Herein, we report a simple, high-throughput, low-equipment dependent, and generally applicable growth selection system for engineering amine-forming or converting enzymes and apply it to improve biocatalysts belonging to three different enzyme classes. This results in (i) an amine transaminase variant with 110-fold increased specific activity for the asymmetric synthesis of the chiral amine intermediate of Linagliptin; (ii) a 270-fold improved monoamine oxidase to prepare the chiral amine intermediate of Cinacalcet by deracemization; and (iii) an ammonia lyase variant with a 26-fold increased activity in the asymmetric synthesis of a non-natural amino acid. Our growth selection system is adaptable to different enzyme classes, varying levels of enzyme activities, and thus a flexible tool for various stages of an engineering campaign.

Shifting the pH Optima of (R)-Selective Transaminases by Protein Engineering.

Amine transaminases (ATAs) are powerful biocatalysts for the stereoselective synthesis of chiral amines. However, wild-type ATAs usually show pH optima at slightly alkaline values and exhibit low catalytic activity under physiological conditions. For efficient asymmetric synthesis ATAs are commonly used in combination with lactate dehydrogenase (LDH, optimal pH: 7.5) and glucose dehydrogenase (GDH, optimal pH: 7.75) to shift the equilibrium towards the synthesis of the target chiral amine and hence their pH optima should fit to each other. Based on a protein structure alignment, variants of (R)-selective transaminases were rationally designed, produced in E. coli, purified and subjected to biochemical characterization. This resulted in the discovery of the variant E49Q of the ATA from Aspergillus fumigatus, for which the pH optimum was successfully shifted from pH 8.5 to 7.5 and this variant furthermore had a two times higher specific activity than the wild-type protein at pH 7.5. A possible mechanism for this shift of the optimal pH is proposed. Asymmetric synthesis of (R)-1-phenylethylamine from acetophenone in combination with LDH and GDH confirmed that the variant E49Q shows superior performance at pH 7.5 compared to the wild-type enzyme.

Characterization of proteins from the 3N5M family reveals an operationally stable amine transaminase.

Amine transaminases (ATA) convert ketones into optically active amines and are used to prepare active pharmaceutical ingredients and building blocks. Novel ATA can be identified in protein databases due to the extensive knowledge of sequence-function relationships. However, predicting thermo- and operational stability from the amino acid sequence is a persisting challenge and a vital step towards identifying efficient ATA biocatalysts for industrial applications. In this study, we performed a database mining and characterized selected putative enzymes of the ß-alanine:pyruvate transaminase cluster (3N5M) - a subfamily with so far only a few described members, whose tetrameric structure was suggested to positively affect operational stability. Four putative transaminases (TA-1: Bilophilia wadsworthia, TA-5: Halomonas elongata, TA-9: Burkholderia cepacia, and TA-10: Burkholderia multivorans) were obtained in a soluble form as tetramers in E. coli. During comparison of these tetrameric with known dimeric transaminases we found that indeed novel ATA with high operational stabilities can be identified in this protein subfamily, but we also found exceptions to the hypothesized correlation that a tetrameric assembly leads to increased stability. The discovered ATA from Burkholderia multivorans features a broad substrate specificity, including isopropylamine acceptance, is highly active (6 U/mg) in the conversion of 1-phenylethylamine with pyruvate and shows a thermostability of up to 70 °C under both, storage and operating conditions. In addition, 50% (v/v) of isopropanol or DMSO can be employed as co-solvents without a destabilizing effect on the enzyme during an incubation time of 16 h at 30 °C. KEY POINTS: • Database mining identified a thermostable amine transaminase in the ß-alanine:pyruvate transaminase subfamily. • The tetrameric transaminase tolerates 50% DMSO and isopropanol under operating conditions at 30 °C. • A tetrameric structure is not necessarily associated with a higher operational stability.

Recombinant l-Amino Acid Oxidase with Broad Substrate Spectrum for Co-substrate Recycling in (S)-Selective Transaminase-Catalyzed Kinetic Resolutions.

Chiral and enantiopure amines can be produced by enantioselective transaminases via kinetic resolution of amine racemates. This transamination reaction requires stoichiometric amounts of co-substrate. A dual-enzyme recycling system overcomes this limitation: l-amino acid oxidases (LAAO) recycle the accumulating co-product of (S)-selective transaminases in the kinetic resolution of racemic amines to produce pure (R)-amines. However, availability of suitable LAAOs is limited. Here we use the heterologously produced, highly active fungal hcLAAO4 with broad substrate spectrum. H2 O2 as byproduct of hcLAAO4 is detoxified by a catalase. The final system allows using sub-stoichiometric amounts of 1 mol% of the transaminase co-substrate as well as the initial application of l-amino acids instead of α-keto acids. With an optimized protocol, the synthetic potential of this kinetic resolution cascade was proven at the preparative scale (>90 mg) by the synthesis of highly enantiomerically pure (R)-methylbenzylamine (>99 %ee) at complete conversion (50 %).

Recent trends in biocatalysis.

Biocatalysis has undergone revolutionary progress in the past century. Benefited by the integration of multidisciplinary technologies, natural enzymatic reactions are constantly being explored. Protein engineering gives birth to robust biocatalysts that are widely used in industrial production. These research achievements have gradually constructed a network containing natural enzymatic synthesis pathways and artificially designed enzymatic cascades. Nowadays, the development of artificial intelligence, automation, and ultra-high-throughput technology provides infinite possibilities for the discovery of novel enzymes, enzymatic mechanisms and enzymatic cascades, and gradually complements the lack of remaining key steps in the pathway design of enzymatic total synthesis. Therefore, the research of biocatalysis is gradually moving towards the era of novel technology integration, intelligent manufacturing and enzymatic total synthesis.

Creation of (R)-Amine Transaminase Activity within an α-Amino Acid Transaminase Scaffold.

The enzymatic transamination of ketones into (R)-amines represents an important route for accessing a range of pharmaceuticals or building blocks. Although many publications have dealt with enzyme discovery, protein engineering, and the application of (R)-selective amine transaminases [(R)-ATA] in biocatalysis, little is known about the actual in vivo role and how these enzymes have evolved from the ubiquitous α-amino acid transaminases (α-AATs). Here, we show the successful introduction of an (R)-transaminase activity in an α-amino acid aminotransferase with one to six amino acid substitutions in the enzyme's active site. Bioinformatic analysis combined with computational redesign of the d-amino acid aminotransferase (DATA) led to the identification of a sextuple variant having a specific activity of 326 milliunits mg-1 in the conversion of (R)-phenylethylamine and pyruvate to acetophenone and d-alanine. This value is similar to those of natural (R)-ATAs, which typically are in the range of 250 milliunits mg-1. These results demonstrate that (R)-ATAs can evolve from α-AAT as shown here for the DATA scaffold.

Combining Photo-Organo Redox- and Enzyme Catalysis Facilitates Asymmetric C-H Bond Functionalization.

In this study, we combined photo-organo redox catalysis and biocatalysis to achieve asymmetric C-H bond functionalization of simple alkane starting materials. The photo-organo catalyst anthraquinone sulfate (SAS) was employed to oxyfunctionalise alkanes to aldehydes and ketones. We coupled this light-driven reaction with asymmetric enzymatic functionalisations to yield chiral hydroxynitriles, amines, acyloins and α-chiral ketones with up to 99 % ee. In addition, we demonstrate functional group interconversion to alcohols, esters and carboxylic acids. The transformations can be performed as concurrent tandem reactions. We identified the degradation of substrates and inhibition of the biocatalysts as limiting factors affecting compatibility, due to reactive oxygen species generated in the photocatalytic step. These incompatibilities were addressed by reaction engineering, such as applying a two-phase system or temporal and spatial separation of the catalysts. Using a selection of eleven starting alkanes, one photo-organo catalyst and 8 diverse biocatalysts, we synthesized 26 products and report for the model compounds benzoin and mandelonitrile > 97 % ee at gram scale.

Molecular recognition of the beta-glucans laminarin and pustulan by a SusD-like glycan-binding protein of a marine Bacteroidetes.

Marine bacteria catabolize carbohydrate polymers of algae, which synthesize these structurally diverse molecules in ocean surface waters. Although algal glycans are an abundant carbon and energy source in the ocean, the molecular details that enable specific recognition between algal glycans and bacterial degraders remain largely unknown. Here we characterized a surface protein, GMSusD from the planktonic Bacteroidetes-Gramella sp. MAR_2010_102 that thrives during algal blooms. Our biochemical and structural analyses show that GMSusD binds glucose polysaccharides such as branched laminarin and linear pustulan. The 1.8 Å crystal structure of GMSusD indicates that three tryptophan residues form the putative glycan-binding site. Mutagenesis studies confirmed that these residues are crucial for laminarin recognition. We queried metagenomes of global surface water datasets for the occurrence of SusD-like proteins and found sequences with the three structurally conserved residues in different locations in the ocean. The molecular selectivity of GMSusD underscores that specific interactions are required for laminarin recognition. In conclusion, our findings provide insight into the molecular details of ß-glucan binding by GMSusD and our bioinformatic analysis reveals that this molecular interaction may contribute to glucan cycling in the surface ocean.

Solid-Phase Agar Plate Assay for Screening Amine Transaminases.

Agar plate assays represent a useful method for high-throughput prescreening of larger enzyme libraries derived from for example error-prone PCR or multiple site-saturation mutagenesis to decrease screening effort by separating promising variants from less active, inactive, or neutral variants. In order to do so, colonies are directly applied for enzyme expression and screening on adsorbent and microporous membranes instead of elaborately preparing cell lysates in 96-well plates. This way, 400-800 enzyme variants can be prescreened on a single membrane, 10,000-20,000 variants per week and per single researcher respectively (25 membranes per week).The following chapter gives a detailed protocol of how to screen transaminase libraries in solid phase, but it also intends to provide inspiration to establish a direct or coupled agar plate assay for screening variable enzymatic activities by interchanging assay enzymes and adapting assay conditions to individual needs.

Photometric Characterization of the Reductive Amination Scope of the Imine Reductases from Streptomyces tsukubaensis and Streptomyces ipomoeae.

Imine reductases (IREDs) have emerged as promising enzymes for the asymmetric synthesis of secondary and tertiary amines starting from carbonyl substrates. Screening the substrate specificity of the reductive amination reaction is usually performed by time-consuming GC analytics. We found two highly active IREDs in our enzyme collection, IR-20 from Streptomyces tsukubaensis and IR-Sip from Streptomyces ipomoeae, that allowed a comprehensive substrate screening with a photometric NADPH assay. We screened 39 carbonyl substrates combined with 17 amines as nucleophiles. Activity data from 663 combinations provided a clear picture about substrate specificity and capabilities in the reductive amination of these enzymes. Besides aliphatic aldehydes, the IREDs accepted various cyclic (C4 -C8 ) and acyclic ketones, preferentially with methylamine. IR-Sip also accepted a range of primary and secondary amines as nucleophiles. In biocatalytic reactions, IR-Sip converted (R)-3-methylcyclohexanone with dimethylamine or pyrrolidine with high diastereoselectivity (>94-96 % de). The nucleophile acceptor spectrum depended on the carbonyl substrate employed. The conversion of well-accepted substrates could also be detected if crude lysates were employed as the enzyme source.

Structural Basis for Phospholyase Activity of a Class†III Transaminase Homologue.

Pyridoxal-phosphate (PLP)-dependent enzymes catalyse a remarkable diversity of chemical reactions in nature. A1RDF1 from Arthrobacter aurescens TC1 is a fold type I, PLP-dependent enzyme in the class III transaminase (TA) subgroup. Despite sharing 28 % sequence identity with its closest structural homologues, including ß-alanine:pyruvate and γ-aminobutyrate:α-ketoglutarate TAs, A1RDF1 displayed no TA activity. Activity screening revealed that the enzyme possesses phospholyase (E.C. 4.2.3.2) activity towards O-phosphoethanolamine (PEtN), an activity described previously for vertebrate enzymes such as human AGXT2L1, enzymes for which no structure has yet been reported. In order to shed light on the distinctive features of PLP-dependent phospholyases, structures of A1RDF1 in complex with PLP (internal aldimine) and PLP⋅PEtN (external aldimine) were determined, revealing the basis of substrate binding and the structural factors that distinguish the enzyme from class III homologues that display TA activity.

A NADH-accepting imine reductase variant: Immobilization and cofactor regeneration by oxidative deamination.

Engineering cofactor specificity of enzymes is a promising approach that can expand the application of enzymes for biocatalytic production of industrially relevant chemicals. Until now, only NADPH-dependent imine reductases (IREDs) are known. This limits their applications to reactions employing whole cells as a cost-efficient cofactor regeneration system. For applications of IREDs as cell-free catalysts, (i) we created an IRED variant showing an improved activity for NADH. With rational design we were able to identify four residues in the (R)-selective IRED from Streptomyces GF3587 (IR-Sgf3587), which coordinate the 2'-phosphate moiety of the NADPH cofactor. From a set of 15 variants, the highest NADH activity was caused by the single amino acid exchange K40A resulting in a 3-fold increased acceptance of NADH. (ii) We showed its applicability using an immobilisate obtained either from purified enzyme or from lysate using the EziG(™) carriers. Applying the variant and NADH, we reached 88% conversion in a preparative scale biotransformation when employing 4% (w/v) 2-methylpyrroline. (iii) We demonstrated a one-enzyme cofactor regeneration approach using the achiral amine N-methyl-3-aminopentanone as a hydrogen donor co-substrate.

Bacillus anthracis ω-amino acid:pyruvate transaminase employs a different mechanism for dual substrate recognition than other amine transaminases.

Understanding the metabolic potential of organisms or a bacterial community based on their (meta) genome requires the reliable prediction of an enzyme's function from its amino acid sequence. Besides a remarkable development in prediction algorithms, the substrate scope of sequences with low identity to well-characterized enzymes remains often very elusive. From a recently conducted structure function analysis study of PLP-dependent enzymes, we identified a putative transaminase from Bacillus anthracis (Ban-TA) with the crystal structure 3N5M (deposited in the protein data bank in 2011, but not yet published). The active site residues of Ban-TA differ from those in related (class III) transaminases, which thereby have prevented function predictions. By investigating 50 substrate combinations its amine and ω-amino acid:pyruvate transaminase activity was revealed. Even though Ban-TA showed a relatively narrow amine substrate scope within the tested substrates, it accepts 2-propylamine, which is a prerequisite for industrial asymmetric amine synthesis. Structural information implied that the so-called dual substrate recognition of chemically different substrates (i.e. amines and amino acids) differs from that in formerly known enzymes. It lacks the normally conserved 'flipping' arginine, which enables dual substrate recognition by its side chain flexibility in other ω-amino acid:pyruvate transaminases. Molecular dynamics studies suggested that another arginine (R162) binds ω-amino acids in Ban-TA, but no side chain movements are required for amine and amino acid binding. These results, supported by mutagenesis studies, provide functional insights for the B. anthracis enzyme, enable function predictions of related proteins, and broadened the knowledge regarding ω-amino acid and amine converting transaminases.

Alteration of the Donor/Acceptor Spectrum of the (S)-Amine Transaminase from Vibrio fluvialis.

To alter the amine donor/acceptor spectrum of an (S)-selective amine transaminase (ATA), a library based on the Vibrio fluvialis ATA targeting four residues close to the active site (L56, W57, R415 and L417) was created. A 3DM-derived alignment comprising fold class I pyridoxal-5'-phosphate (PLP)-dependent enzymes allowed identification of positions, which were assumed to determine substrate specificity. These positions were targeted for mutagenesis with a focused alphabet of hydrophobic amino acids to convert an amine:α-keto acid transferase into an amine:aldehyde transferase. Screening of 1200 variants revealed three hits, which showed a shifted amine donor/acceptor spectrum towards aliphatic aldehydes (mainly pentanal), as well as an altered pH profile. Interestingly, all three hits, although found independently, contained the same mutation R415L and additional W57F and L417V substitutions.

Arteriosclerosis and vascular calcification: causes, clinical assessment and therapy.

BACKGROUND: Arteriosclerosis is a pathological, structural (media vascular calcification) and physiological (modified vascular smooth vessel cells; increased arterial stiffness) alteration of the vessel wall. Through improved assessment methods (functional and imaging), it has become a well-known phenomenon in recent decades. However, its clinical importance was underestimated until recently. MATERIALS AND METHODS: Currently available English-speaking data about conditions/diseases associated with arteriosclerosis, its clinical sequels, available diagnostic procedures and therapeutic modalities were reviewed and summarized. RESULTS: In recent decades, emerging data have brought about a better understanding of causes and consequences of arteriosclerosis and highlight its growing clinical impact. CONCLUSION: Although arteriosclerosis showed an independent clinical impact on cardiovascular morbidity and mortality, especially in patients with chronic kidney disease/end-stage renal disease (CKD/ESRD) and diabetes mellitus, convincing clinical therapy concepts are not available until now. The establishment of novel therapeutic strategies derived from basic research is strongly needed.