Acute Inhalation Toxicity After Inhalation of ZnO Nanoparticles: Lung Surfactant Function Inhibition In Vitro Correlates With Reduced Tidal Volume in Mice.

People can be exposed to zinc oxide (ZnO) by inhalation of consumer products or during industrial processes. Zinc oxide nanoparticle (NP) exposure can induce acute inhalation toxicity. The toxicological mechanisms underlying the acute effects on the lungs have long focused on the phagolysosomal dissolution of ZnO NPs in macrophages followed by the release of free Zn2+ ions. However, we postulate an alternative mechanism based on the direct interaction of ZnO NPs with the lung surfactant (LS) layer covering the inside of the alveoli. Therefore, we tested the effect of ZnO NPs and Zn2+ ions on the function of LS in vitro using the constrained drop surfactometer. We found that the ZnO NPs inhibited the LS function, whereas Zn2+ ions did not. To examine the role of lung macrophages in the acute toxicity of inhaled ZnO NPs, mice were treated with Clodrosome, a drug that depletes alveolar macrophages, or Encapsome, the empty carrier of the drug. After macrophage depletion, the mice were exposed to an aerosol of ZnO NPs in whole body plethysmographs recording breathing patterns continuously. Mice in both groups developed shallow breathing (reduced tidal volume) shortly after the onset of exposure to ZnO NPs. This suggests a macrophage-independent mechanism of induction. This study shows that acute inhalation toxicity is caused by ZnO NP interaction with LS, independently of NP dissolution in macrophages.

Pre-conceptional exposure to multiwalled carbon nanotubes suppresses antibody production in mouse offspring.

Prenatal particle exposure has been shown to increase allergic responses in offspring. Carbon nanotubes (CNTs) possess immunomodulatory properties, but it is unknown whether maternal exposure to CNTs interferes with offspring immune development. Here, C57Bl/6J female mice were intratracheally instilled with 67 of µg multiwalled CNTs on the day prior to mating. After weaning, tolerance and allergy responses were assessed in the offspring. Offspring of CNT-exposed (CNT offspring) and of sham-exposed dams (CTRL offspring) were intranasally exposed to ovalbumin (OVA) once weekly for 5 weeks to induce airway mucosal tolerance. Subsequent OVA sensitization and aerosol inhalation caused low or no OVA-specific IgE production and no inflammation. However, the CNT offspring presented with significantly lower OVA-specific IgG1 levels than CTRL offspring. In other groups of 5-week-old offspring, low-dose sensitization with OVA and subsequent OVA aerosol inhalation led to significantly lower OVA-specific IgG1 production in CNT compared to CTRL offspring. OVA-specific IgE and airway inflammation were non-significantly reduced in CNT offspring. The immunomodulatory effects of pre-gestational exposure to multiwalled CNTs were unexpected, but very consistent. The observations of suppressed antigen-specific IgG1 production may be of importance for infection or vaccination responses and warrant further investigation.

Prediction of acute inhalation toxicity using in vitro lung surfactant inhibition.

Private consumers and professionals may experience acute inhalation toxicity after inhaling aerosolized impregnation products. The distinction between toxic and non-toxic products is difficult to make for producers and product users alike, as there is no clearly described relationship between the chemical composition of the products and induction of toxicity. The currently accepted method for determination of acute inhalation toxicity is based on experiments on animals; it is time-consuming, expensive and causes stress for the animals. Impregnation products are present on the market in large numbers and amounts and exhibit great variety. Therefore, an alternative method to screen for acute inhalation toxicity is needed. The aim of our study was to determine if inhibition of lung surfactant by impregnation products in vitro could accurately predict toxicity in vivo in mice. We tested 21 impregnation products using the constant flow through set-up of the constrained drop surfactometer to determine if the products inhibited surfactant function or not. The same products were tested in a mouse inhalation bioassay to determine their toxicity in vivo. The sensitivity was 100%, i.e., the in vitro method predicted all the products that were toxic for mice to inhale. The specificity of the in vitro test was 63%, i.e., the in vitro method found three false positives in the 21 tested products. Six of the products had been involved in accidental human inhalation where they caused acute inhalation toxicity. All of these six products inhibited lung surfactant function in vitro and were toxic to mice.

Limonene and its ozone-initiated reaction products attenuate allergic lung inflammation in mice.

Inhalation of indoor air pollutants may cause airway irritation and inflammation and is suspected to worsen allergic reactions. Inflammation may be due to mucosal damage, upper (sensory) and lower (pulmonary) airway irritation due to activation of the trigeminal and vagal nerves, respectively, and to neurogenic inflammation. The terpene, d-limonene, is used as a fragrance in numerous consumer products. When limonene reacts with the pulmonary irritant ozone, a complex mixture of gas and particle phase products is formed, which causes sensory irritation. This study investigated whether limonene, ozone or the reaction mixture can exacerbate allergic lung inflammation and whether airway irritation is enhanced in allergic BALB/cJ mice. Naïve and allergic (ovalbumin sensitized) mice were exposed via inhalation for three consecutive days to clean air, ozone, limonene or an ozone-limonene reaction mixture. Sensory and pulmonary irritation was investigated in addition to ovalbumin-specific antibodies, inflammatory cells, total protein and surfactant protein D in bronchoalveolar lavage fluid and hemeoxygenase-1 and cytokines in lung tissue. Overall, airway allergy was not exacerbated by any of the exposures. In contrast, it was found that limonene and the ozone-limonene reaction mixture reduced allergic inflammation possibly due to antioxidant properties. Ozone induced sensory irritation in both naïve and allergic mice. However, allergic but not naïve mice were protected from pulmonary irritation induced by ozone. This study showed that irritation responses might be modulated by airway allergy. However, aggravation of allergic symptoms was observed by neither exposure to ozone nor exposure to ozone-initiated limonene reaction products. In contrast, anti-inflammatory properties of the tested limonene-containing pollutants might attenuate airway allergy.

An in vitro method for predicting inhalation toxicity of impregnation spray products.

Impregnation spray products are used for making surfaces water and dirt repellent. The products are composed of one or more active film-forming components dissolved or suspended in an appropriate solvent mixture. Exposure to impregnation spray products may cause respiratory distress and new cases are reported frequently. The toxicity appears to be driven by a disruption of the pulmonary surfactant film, which coats the inside of the lungs. Due to the complex chemistry of impregnation spray products, it is impossible to predict if inhalation of an aerosolized product is toxic in vivo. The aim of this study was to evaluate whether disruption of the pulmonary surfactant film can be used as a predictor of the toxic effects in vivo. Nine impregnation products with various chemical compositions were selected for testing and the main constituents of each product, e.g., solvents, co-solvents and film-forming compounds, were identified by mass spectrometry. We used a capillary surfactometry method to assess disruption of pulmonary surfactant function in vitro and a mouse model to evaluate acute respiratory toxicity during inhalation. Concentration-response relationships were successfully determined both in vitro and in vivo. The true positive rate of the in vitro method was 100%, i.e. the test could correctly identify all products with toxic effects in vivo, the true negative rate was 40%. Investigation of inhibition of the pulmonary surfactant system, e.g. by capillary surfactometry, was found useful for evaluation of the inhalation toxicity of impregnation spray products and thus may reduce the need for animal testing.

Mechanism of action of lung damage caused by a nanofilm spray product.

Inhalation of waterproofing spray products has on several occasions caused lung damage, which in some cases was fatal. The present study aims to elucidate the mechanism of action of a nanofilm spray product, which has been shown to possess unusual toxic effects, including an extremely steep concentration-effect curve. The nanofilm product is intended for application on non-absorbing flooring materials and contains perfluorosiloxane as the active film-forming component. The toxicological effects and their underlying mechanisms of this product were studied using a mouse inhalation model, by in vitro techniques and by identification of the binding interaction. Inhalation of the aerosolized product gave rise to increased airway resistance in the mice, as evident from the decreased expiratory flow rate. The toxic effect of the waterproofing spray product included interaction with the pulmonary surfactants. More specifically, the active film-forming components in the spray product, perfluorinated siloxanes, inhibited the function of the lung surfactant due to non-covalent interaction with surfactant protein B, a component which is crucial for the stability and persistence of the lung surfactant film during respiration. The active film-forming component used in the present spray product is also found in several other products on the market. Hence, it may be expected that these products may have a toxicity similar to the waterproofing product studied here. Elucidation of the toxicological mechanism and identification of toxicological targets are important to perform rational and cost-effective toxicological studies. Thus, because the pulmonary surfactant system appears to be an important toxicological target for waterproofing spray products, study of surfactant inhibition could be included in toxicological assessment of this group of consumer products.

Pulmonary toxicity of perfluorinated silane-based nanofilm spray products: solvent dependency.

A number of cases of pulmonary injury by use of aerosolized surface coating products have been reported worldwide. The aerosol from a commercial alcohol-based nanofilm product (NFP) for coating of nonabsorbing surfaces was found to induce severe lung damage in a recent mouse bioassay. The NFP contained a 1H,1H,2H,2H-perfluorooctyl trialkoxysilane (POTS) and the effects were associated with the hydrolyzed forms of the silane; increase in hydrolyzation resulted in faster induction of compromised breathing and induction of lung damage. In this study, the impact of the solvent on the toxicity of POTS has been investigated. BALB/cA mice were exposed to aerosolized water-based NFPs containing POTS, and solutions of hydrolyzed POTS in methanol, ethanol, and 2-propanol, respectively. No acute respiratory effect was observed at exposure concentrations up to 110 mg/m³ with an aqueous solution of POTS. However, exposure to POTS in methanol resulted in a decrease of the tidal volume--an effect that did not resolve within the recovery period. After 27 min of exposure, the tidal volume had decreased by 25%, indicating partial alveolar collapse. For POTS in ethanol and 2-propanol, a 25% reduction of the tidal volume was observed after 13 and 9 min, respectively; thus, the tidal volume was affected by increase of the chain length. This was confirmed in vitro by investigating lung surfactant function after addition of POTS in different solvents. The addition of vaporized methanol, 2-propanol, or acetone to aerosolized POTS in methanol further exacerbated the tidal volume reduction, demonstrating that the concentration of vaporized solvent participated in the toxicity of POTS.

Offspring IgE responses are influenced by levels of maternal IgG transferred in early life.

PROBLEM: Maternal immune responses may interfere with offspring allergy development as maternal immunization may suppress IgE development, while maternal allergy may promote allergy. Therefore, we investigated the effect of two different maternal treatments on airway allergy in female and male offspring. METHOD OF STUDY: Pregnant mice were immunized (IMM) with ovalbumin (OVA) or immunized and airway-challenged (IMM+AI). At different ages, airway allergy to OVA was induced in offspring by intranasal sensitization. RESULTS: Maternal IgG1 was found at higher levels in IMM+AI than in IMM offspring. After sensitization, the suppression of OVA-specific IgE and IgG1 was complete in juvenile offspring but waned with age concurrently with maternal IgG1 levels. Cytokine secretion, lung inflammation, and B cell priming were not suppressed although IgE responses were. CONCLUSIONS: High compared with low levels of maternal IgG1 were associated with lower TH 2 antibody production after adult offspring were re-exposed to OVA. Thus, offspring allergy-related responses appeared to be shaped by maternal antibody levels.

Experiences from occupational exposure limits set on aerosols containing allergenic proteins.

Occupational exposure limits (OELs) together with determined airborne exposures are used in risk assessment based managements of occupational exposures to prevent occupational diseases. In most countries, OELs have only been set for few protein-containing aerosols causing IgE-mediated allergies. They comprise aerosols of flour dust, grain dust, wood dust, natural rubber latex, and the subtilisins, which are proteolytic enzymes. These aerosols show dose-dependent effects and levels have been established, where nearly all workers may be exposed without adverse health effects, which are required for setting OELs. Our aim is to analyse prerequisites for setting OELs for the allergenic protein-containing aerosols. Opposite to the key effect of toxicological reactions, two thresholds, one for the sensitization phase and one for elicitation of IgE-mediated symptoms in sensitized individuals, are used in the OEL settings. For example, this was the case for flour dust, where OELs were based on dust levels due to linearity between flour dust and its allergen levels. The critical effects for flour and grain dust OELs were different, which indicates that conclusion by analogy (read-across) must be scientifically well founded. Except for subtilisins, no OEL have been set for other industrial enzymes, where many of which are high volume chemicals. For several of these, OELs have been proposed in the scientific literature during the last two decades. It is apparent that the scientific methodology is available for setting OELs for proteins and protein-containing aerosols where the critical effect is IgE sensitization and IgE-mediated airway diseases.

Early life interventions to prevent allergy in the offspring: the role of maternal immunization and postnatal mucosal allergen exposure.

BACKGROUND: Childhood allergy is influenced by maternal factors and allergen exposure in early life, but the factors that determine the development of allergy and tolerance are unknown. Therefore, we compared the effects of two early life interventions, i.e. maternal allergen immunization and postnatal intranasal allergen exposure, as well as a combination of both treatments on allergic responses in the offspring. METHODS: Female mice were immunized with ovalbumin (OVA) or vehicle during pregnancy. After birth, half the offspring from each group were exposed intranasally to low doses of OVA or vehicle weekly for 5 weeks before intraperitoneal immunization with OVA. RESULTS: Maternal immunization reduced OVA-specific IgE and IgG1, but increased IgG2a and T(H)2 cytokine responses in the offspring after immunization. Postnatal intranasal OVA exposure similarly reduced both IgE and IgG1, but also spleen cell numbers and cytokine secretion. Following airway challenges of the offspring, IgE and airway inflammation were suppressed only by intranasal exposure, but not by maternal immunization, the effect of which also waned with age. Differential gene expression in the spleen of offspring supported that IgE suppression by the two interventions was caused by different mechanisms. Despite this, tolerance development after mucosal exposure was obtained in the offspring of immunized dams. CONCLUSIONS: The study suggests that prevention of allergy is possible if initiated in early life, and early mucosal allergen exposure may play a protective role independent of the maternal immune responses.

Single-walled and multi-walled carbon nanotubes promote allergic immune responses in mice.

The adjuvant effect of particles on allergic immune responses has been shown to increase with decreasing particle size and increasing particle surface area. Like ultrafine particles, carbon nanotubes (CNTs) have nano-sized dimensions and a large relative surface area and might thus increase allergic responses. Therefore, we examined whether single-walled (sw) and multi-walled (mw) CNTs have the capacity to promote allergic responses in mice, first in an sc injection model and thereafter in an intranasal model. Balb/cA mice were exposed to three doses of swCNT, mwCNT, as well as ultrafine carbon black particles (ufCBPs, Printex90) during sensitization with the allergen ovalbumin (OVA). Five days after an OVA booster, OVA-specific IgE, IgG1, and IgG2a antibodies in serum and the numbers of inflammatory cells and cytokine levels in bronchoalveolar lavage fluid (BALF) were determined. Furthermore, ex vivo OVA-induced cytokine release from mediastinal lymph node (MLN) cells was measured. In separate experiments, differential cell counts were determined in BALF 24 h after a single intranasal exposure to the particles in the absence of allergen. We demonstrate that both swCNT and mwCNT together with OVA strongly increased serum levels of OVA-specific IgE, the number of eosinophils in BALF, and the secretion of Th2-associated cytokines in the MLN. On the other hand, only mwCNT and ufCBP with OVA increased IgG2a levels, neutrophil cell numbers, and tumor necrosis factor-alpha and monocyte chemoattractant protein-1 levels in BALF, as well as the acute influx of neutrophils after exposure to the particles alone. This study demonstrates that CNTs promote allergic responses in mice.

IgE-mediated asthma and rhinitis I: a role of allergen exposure?

Exposures to airborne protein antigens, aeroallergens, may cause sensitization with production of Th2-dependent antibodies, including IgE. The IgE antibodies and associated cellular responses are responsible for the allergic airway diseases, allergic rhinitis and allergic asthma, which are increasing in societies with Western life style. Aeroallergens may have different potential to sensitize exposed subjects. Thus, there are only a limited number of important groups of aeroallergens, which are those from house dust mites, cockroaches, pets, pollens, and moulds. Allergy follows to a certain extent the pharmacological/toxicological paradigm of dose-response relationship. Unlike effects of pharmacologically and toxicologically active substances, allergens elicit their adverse effects in a two-stage process. In the first stage the immunologically naïve individual is sensitized to the allergen. In the second stage renewed exposure to the allergen elicits the disease response. Also, high concentrations of aeroallergens may induce immunological tolerance. The scientific literature suggests that many environmental factors contribute to the increase in sensitization and development of airway allergies. Nevertheless, the dose-response relationships apply (within certain limits) both to the sensitization itself and to the exacerbation of the diseases. This suggest that exposure reduction may be one of the methods for reduction of risk, in relation to control of the allergic airway diseases.