Effect of cooled perches on the efficacy of an induced molt in White Leghorn laying hens previously exposed to heat stress.

This study examined the effect of water-chilled perches on hen production and physiological responses to induced molt during elevated temperatures. A total of 288White Leghorns at 82 wk of age were housed in 36 cages of 6 banks. Each bank was assigned to 1 of 3 treatments: cooled perches, air perches, and no perches. The hens were subjected to 2 heat episodes during their first laying cycle at week 21 to 35 and week 73 to 80, respectively. The hens were subjected to a 28 D nonfasted molting regimen starting at 85 wk of age. Cyclic heat of 32°C (6:00 am to 6:00 pm) was applied daily during the molting period. After molt, hens were returned to a layer diet and housed under thermoneutral condition. Two birds per cage were monitored for BW change during molt. Egg production was recorded daily. Feed utilization was measured during molt at 86 and 88 wk of age. Egg weight and eggshell traits were examined at 84 wk (pre-molt) and post-molt at 92, 96, and 104 wk of age. Rectal temperature and blood samples were collected from 2 birds per cage at the end of molt. Blood samples were used for determining heterophil/lymphocyte ratio, corticosterone, and thyroid hormones. Plumage condition was examined at 22 wk post-molt. Compared to control and air perch hens, cooled perch hens had higher feed usage and greater BW loss, lower heterophil/lymphocyte ratios (P < 0.05) with no difference in thyroid hormones and corticosterone at the end of molt. Cooled perch hens also had higher egg production beginning at 98 wk of age (Ptreatment*age < 0.0001) than control hens and sometimes the air-perch hens. Cooled perch hens had higher rectal temperature than control but not air perch hens at end of molt. Moreover, cooled perch hens had better breast feather scores than air perch hens but worse vent plumage (P ≤ 0.05) than both control and air perch hens. These results indicate that the provision of cooled perches assists hens with better adaptation to stressors, such as induced molt plus heat exposure, resulting in improved post-molt egg production.

Effect of cooled perches on performance, plumage condition, and foot health of caged White Leghorn hens exposed to cyclic heat.

We examined the effects of water-chilled perches as cooling devices on hen performance during 2 summers using daily cyclic heat. White Leghorns, 17 wk of age, were assigned to 36 cages arranged into 6 banks. The banks were assigned to cooled perches, air perches, and no perches resulting in 2 replicate banks and 12 cages per treatment. Chilled water (10°C) was circulated through the cooled perches during heat episodes. Daily cyclic heat of 35°C was applied from 0600 to1800 h with a lowering of temperature to 28°C from 1800 to 0600 h during the 2014 and 2015 summers when hens were 21 to 35 and 73 to 80 wk of age, respectively. Mortality and egg production were recorded daily. Feed utilization, egg weight, and shell quality traits were measured at 4-wk intervals during the heat episodes and at 8-wk intervals during thermoneutrality. Body weight was determined at 17, 35, 72, and 80 wk of age and physical condition at 80 wk of age. At several ages during the heat episodes, cooled perch hens had increased egg production (P < 0.0001) and feed usage (P < 0.04) as compared to both air perch and control hens. The cooled perch hens had higher BW at 35 and 72 wk of age (Ptreatment*age = 0.03) and lower cumulative mortality (P = 0.02) than control hens but not air perch hens. Eggs from cooled perch hens had overall heavier weights (P < 0.0001) and higher breaking force (P < 0.0001) than eggs from the other two group hens. Greater eggshell percentage (Ptreatment*age = 0.03) and eggshell thickness (Ptreatment*age = 0.01) occurred at some ages during the 2 heat episodes as compared to the other 2 treatments. Nail length, feet hyperkeratosis, and overall feather score were similar among treatments. These results indicate that cooled perch ameliorates the negative effects of heat stress on egg traits and performance without influencing the physical condition of hens.

Effect of cooled perches on physiological parameters of caged White Leghorn hens exposed to cyclic heat.

We assessed the effects of water-chilled perches as a cooling device on the physiological parameters of caged laying hens exposed to 2 cyclic heating episodes. White Leghorns, 17 wk of age, were randomly assigned to 36 cages of 6 banks placed in the same room. Each bank was randomly assigned to 1 of 3 treatments: cooled perch (CP), air perch (AP), and no perch (CTRL) resulting in 2 replicate banks and 12 cages per treatment. Chilled water (10°C) circulated through the CP during heat periods when hens were 21 wk to 35 wk and 73 wk to 80 wk of age, respectively. During the heating episodes, hens were submitted to a daily cyclic temperature regimen of 35°C (0600 h to 1800 h) and 28°C (1800 h to 0600 h). Rectal temperature, packed cell volume, heterophil to lymphocyte (H/L) ratio, and plasma levels of triiodothyronine (T3), thyroxine (T4), interleukin (IL)-6, IL-10, immunoglobulin (Ig) Y, interferon (IFN)-γ, and heat shock protein (HSP) 70 were measured on the last day of the 2 heating episodes. At the end of the first heating episode, CP hens had lower rectal temperature (P = 0.02) than both AP and CTRL hens. The CP hens also had lower HSP 70 (P = 0.04) than CTRL hens but not AP hens. At the end of the second heating episode, the CP hens had lower rectal temperature (P = 0.02) and circulating H/L ratio (P = 0.01) than both AP and CTRL hens. The CP hens also had higher levels of T3 (P = 0.002) and T3/T4 ratio (P = 0.0006) than CTRL hens but not AP hens, with a greater packed cell volume than AP hens (P = 0.02) but not CTRL hens. Cytokines and IgY levels were similar among treatments. These results indicate that CP hens were better able to cope with cyclic heat stress than CTRL and sometimes AP hens as noted by the beneficial effects on rectal temperature, thyroid activity, HSP, and H/L ratio.

Cooled perch effects on performance and well-being traits in caged White Leghorn hens.

We assessed the effects of chilled water cooling perches on hen performance and physiological and behavioral parameters under "natural" high temperatures during the 2013 summer with a 4-hour acute heating episode. White Leghorns at 16 wk of age (N = 162) were randomly assigned to 18 cages (n = 9) arranged into 3 units. Each unit was assigned to one of the 3 treatments through 32 wk of age: 1) cooled perches, 2) air perches, and 3) no perches. Chilled water (10°C) was circulated through the cooled perches when cage ambient temperature exceeded 25°C. At the age of 27.6 wk, hens were subjected to a 4-hour acute heating episode of 33.3°C and plasma corticosterone was determined within 2 hours. Egg production was recorded daily. Feed intake and egg and shell quality were measured at 5-week intervals. Feather condition, foot health, adrenal and liver weights, plasma corticosterone, and heat shock protein 70 mRNA were determined at the end of the study at 32 wk of age. The proportion of hens per cage perching, feeding, drinking, panting, and wing spreading was evaluated over one d every 5 wks and on the d of acute heat stress. There were no treatment effects on the measured physiological and production traits except for nail length. Nails were shorter for cooled perch hens than control (P = 0.002) but not air perch hens. Panting and wing spread were observed only on the day of acute heat stress. The onset of both behaviors was delayed for cooled perch hens, and they perched more than air perch hens following acute heat stress (P = 0.001) and at the age 21.4 wk (P = 0.023). Cooled perch hens drank less than control (P = 0.019) but not air perch hens at the age 21.4 wk. These results indicate that thermally cooled perches reduced thermoregulatory behaviors during acute heat stress, but did not affect their performance and physiological parameters under the ambient temperature imposed during this study.

The ability of White Leghorn hens with trimmed comb and wattles to thermoregulate.

It is estimated that each year over 19 million pullets in the United States have their combs partially trimmed at a young age to improve egg production and feed efficiency. A possible disadvantage of trimming is that the comb and wattles may be essential for thermoregulation during hot weather allowing for conductive cooling of the blood through vasodilation of superficial vessels in these integumentary tissues. The objective of this study was to investigate the effects of partial comb and wattle removal, performed at 21 d of age, on the ability of White Leghorns to thermoregulate before, during, and after an imposed heating episode that averaged 34.6°C for 50.5 h. An increase in mortality at 20 h and body temperature at 48 h post initiation of the heating episode demonstrated that hens with trimmed comb and wattles were not able to cope with heat stress as effectively as controls. The increase in wattle temperature in controls as compared to trimmed hens during the heating episode and following heat stress provides supportive evidence that blood pools to the peripheral surface for conductive heat loss. During high temperatures typical of summer, trimmed hens attempted to compensate for their lack of ability to transfer heat from their comb and wattles to the environment through increased proportion of panting and wing spreading. Under less extreme conditions with lowered ambient temperatures, the trimming of the comb and wattles did not impair the ability of hens to thermoregulate, as body temperatures and behavior were similar to controls with no mortality. Egg weight was the only production parameter adversely affected by the trimming of the comb and wattles as compared to controls. The implication is that hens need their combs and wattles to thermoregulate effectively during periods of high environmental temperature. Pullets should not be subjected to a comb and wattle trim if they are housed in laying facilities that are not appropriately cooled during the summer.

Effects of in ovo injection of organic trace minerals and post-hatch holding time on broiler performance and bone characteristics.

Effects of the in ovo injection of organic Mn, Zn, and Cu in association with post-hatch (POH) feed and water restriction on the performance and physical-chemical bone parameters of male Ross × Ross 708 broilers were examined. On 17 d of incubation, a total of 1,872 eggs were subjected to in ovo injection using a commercial multi-egg injector. Treatments (TRT) includingd non-injected and diluent-injected controls. The respective Zn, Mn, and Cu levels (mg/mL) added to the diluent of the low (LMD) and high mineral (HMD) TRT groups were 0.181, 0.087, and 0.010, and 0.544, 0.260, and 0.030, respectively. The 4 TRT groups were then sub-divided into 2 POH holding time (HT) groups, with 15 birds randomly allocated to each of 6 replicate pens in each of the 8 groups. The first HT group (0HT) had immediate access to water and feed, and the second HT group (24HT) contained birds that were kept in transport baskets for 24 h before being released. Performance was determined and selected birds were subsequently necropsied and their tibiae extracted for analysis. In comparison to birds from 24HT group, those in the 0HT group had a higher BW gain and feed intake, and a lower FCR through 21 d POH. The percentage of bone ash of the birds belonging to the HMD group was higher than all other TRT on d 1 POH and was higher than the non-injection control group on d 21 POH. On d 1, the LMD and HMD groups had higher tibial Mn concentrations than those of the control groups. On d 7, bones from the HMD group had a higher concentration of Mn than did the non-injected control group, and likewise, on d 21 POH, had a higher concentration of Zn than did the control groups. In conclusion, a 24HT negatively affected the performance of the birds during the first 2 wk POH; however, the LMD and HMD TRT had a positive influence on bone mineralization.

Effect of partial comb and wattle trim on pullet behavior and thermoregulation,1.

The wattles and comb of chickens are important for thermoregulation allowing for heat exchange during high temperatures. These integumentary tissues are sometimes trimmed to prevent tears if caught on cage equipment and to also improve feed efficiency; however, the procedure itself could be painful to chicks. Our objective was to determine the effect of trimming the comb and wattles on behavior, BW, feed usage, and the surface temperature of pullets. The wattles and comb of Leghorns were partially trimmed at 21 d age (n = 6 cages, 13 chicks each) with another 6 cages serving as controls. Behaviors were recorded 3 times daily for 1 h starting at 0800, 1200, and 1500 using instantaneous scan sampling observations conducted every 5 min prior to, on the d of, and after the trim. Group BW at 21, 28, and 36 d age and the amount of feed used for 7 d beginning at 21 and 29 d age were measured per cage. At 1300 h on d before and after the trim, thermal images of the pullet's beak, comb, eye, wattle, and shank were randomly taken on 3 pullets/cage. Smaller proportions of trimmed chicks were eating and greater proportions were sitting on the d of the trim as compared to the controls with the opposite trend occurring on 4 d post-trim (treatment by age interaction, P = 0.03 and 0.0001, respectively). Standing behavior differed only on the d of the trim where smaller proportions of trimmed pullets stood as compared to intact controls (treatment by age interaction, P = 0.0002). Trimming the comb and wattles did not affect preening, running, BW, feed utilization, and the surface temperature of the pullet. The indices of behavior suggest that on the d of the trim, pullets may have experienced temporary distress, but they returned to normal behavior by 5 h post-trim with no long-term effect on BW, feed usage, or surface body temperature.

Effects of commercial in ovo injection of 25-hydroxycholecalciferol on bone development and mineralization in male and female broilers.

Improved bone development and mineralization in broilers have been attributed to the use of 25-hydroxylcholecalceiferol [25(OH)D3] as a dietary supplement. In this study, effects of the in ovo injection of 25(OH)D3 delivered in commercial diluent on 18 d of incubation (doi) on subsequent bone development and mineralization in male and female Ross × Ross 708 broilers were investigated. The variables investigated included bone mineral density and breaking strength, bone ash concentration, and calcium and phosphorus bone ash concentrations. In a single-stage incubator, with 6 treatments on each of the 10 tray levels, a total of 2,400 experimental broiler hatching eggs were evenly and randomly set. Eggs were treatment-injected and transferred to corresponding hatching baskets on 18 doi. Experimental treatment groups were those that received 0.2, 0.6, 1.8, or 5.4 µg of 25(OH)D3 that were delivered in 100 µL of commercial diluent. Noninjected and diluent-injected controls were also included. On 21 doi, chicks were pulled and placed in corresponding floor pens, and on each of d 0, 14, and 28 posthatch (poh), 2 birds of each sex from each pen were randomly selected for necropsy and extraction of both of their tibia bones. Bones from the right leg were subjected to mineral density analysis and those from the left leg were used to determine breaking strength and residual bone ash concentration. Furthermore, ash calcium and phosphorus concentrations on d 14 and 28 poh were determined. There was a treatment × sex × age interaction for bone breaking strength. Bone breaking strength in male birds on d 28 poh was higher in the 0.20, 0.60, and 1.80 µg of 25(OH)D3-injected treatment groups than in the diluent-injected control group. In conclusion, although the in ovo injection of 25(OH)D3 had no positive effect on the bone development of Ross × Ross 708 broilers through d 28 poh compared with noninjected controls, it may provide a benefit to those subjected to an injection of commercial vaccine diluent.

The effect of perch availability during pullet rearing and egg laying on the behavior of caged White Leghorn hens.

Enriched cages, compared with conventional cages, allow egg laying strains of chickens to meet some behavioral needs, including a high motivation to perch. The objective of this study was to determine if perch availability during rearing affected perch use as adults and if perch presence affected eating and drinking in caged White Leghorn hens. Chickens were assigned to 14 cages each with and without 2 round metal perches from hatch to 16.9 wk of age. At 17 wk of age, pullets were assigned to laying cages consisting of 1 of 4 treatments. Treatment 1 chickens never had access to perches (controls). Treatment 2 chickens only had access to 2 round metal perches during the laying phase (17 to 71 wk of age). Treatment 3 chickens only had access to 2 round perches during the pullet phase (0 to 16.9 wk of age). Treatment 4 chickens had access to the perches during both the pullet and laying phase. Each treatment during the adult phase consisted of 9 cages with 9 birds/cage for a total of 36 cages. Automatic infrared cameras were used to monitor behavior of hens in each cage for a 24-h period at 19, 24, 29, 34, 39, 44, 49, 54, 59, 64, and 69 wk of age. Behavior was also recorded twice weekly by an observer in the room where the hens were housed during photophase from 25 to 68 wk of age. Behavioral data were analyzed using ANOVA with repeated measures and the MIXED model procedure. A greater proportion of hens without perches as pullets used the rear perch more during both photophase and scotophase than hens with prior pullet perching experience. Eating and drinking activities of caged adult Leghorns were not impaired by their prior experience to perches as pullets or by the presence of perches in laying cages. It is concluded that providing perches in cages to White Leghorns during pullet rearing did not facilitate use of perches as adults.

The effect of perch access during pullet rearing and egg laying on physiological measures of stress in White Leghorns at 71 weeks of age.

Egg laying strains of chickens have a strong motivation to perch. Providing caged chickens with perches allows them to perform their natural perching behavior and also improves their musculoskeletal health due to exercise. Little is known about the effect of perch access for hens on physiological measures of stress. Our hypothesis was that denying chickens access to perches would elicit a stress response. The objective of this study was to determine the effect of perch access during all or part of life cycle on physiological homeostasis in caged 71-wk-old White Leghorn hens. A total of 1,064 chicks were assigned randomly to cages with and without perches (n = 14 pullet cages/perch treatment) on day of hatch. As pullets aged, chicks were removed from cages to provide more space. At 17 wk of age, 324 chickens in total were assigned to laying cages consisting of 4 treatments with 9 replicates per treatment. Treatment 1 chickens never had access to perches during their life cycle. Treatment 2 chickens had access to perches only from 17 to 71 wk of age (laying phase). Treatment 3 chickens had access to perches only from hatch to 16.9 wk of age (pullet phase). Treatment 4 chickens always had access to perches during their life cycle. At 71 wk of age, chickens were sampled for measurement of plasma catecholamines (epinephrine, norepinephrine, and dopamine) and corticosterone; blood serotonin and Trp; fluctuating asymmetry of shank length and width; and adrenal weight. Only shank width differed among treatments. Chickens with previous exposure to perches during the pullet phase had wider shanks than chickens without access to perches (P = 0.006), suggesting that early perching promoted skeletal development. These results suggest that a stress response was not elicited in 71-wk-old White Leghorn hens that always had access to perches compared with hens that never had access to perches during all or part of their life cycle.

Effect of perches on liver health of hens.

Fatty liver is a common energy metabolic disorder in caged laying hens. Considering that the egg industry is shifting from conventional cages to alternative housing systems such as enriched cages, the objective of this study was to determine the effects of perches on fat deposition and liver health in laying hens. Three hundred twenty-four 17-wk-old White Leghorn hens were housed in 1 of 4 treatments with 9 hens per cage. Treatment 1 hens never had access to perches during their life cycle. Treatment 2 hens had access to perches during the pullet phase only. Treatment 3 hens had access to perches during the laying phase only. Treatment 4 hens always had access to perches. Liver weight, abdominal fat pad weight, BW, liver fat, and circulating alanine transaminase, aspartate transaminase, and adiponectin were determined. Provision of perches during either the rearing or laying phase did not affect liver health in 71-wk-old hens. However, perch access compared with no perch access during the egg laying phase reduced relative fat pad weight. These results suggest that providing perches as a means of stimulating activity reduced abdominal fat deposition in caged hens during the laying period. However, perch access in caged hens was ineffective in reducing fat deposition in the liver and altering enzyme activities related to improved liver function.

Effects of perch access and age on physiological measures of stress in caged White Leghorn pullets.

The neuroendocrine system controls animals' adaptability to their environments by releasing psychotropic compounds such as catecholamines [epinephrine (EP), norepinephrine (NE), and dopamine (DA)], corticosterone (CORT), and serotonin (5-hydroxytryptamine or 5-HT). Changes of these neuroendocrine compounds have been used as biomarkers of animals' stress responses associated with their well-being. Assuming that pullets, like laying hens, are highly motivated to perch, we hypothesize that pullets with access to perches will experience less stress than pullets that never have access to perches. The objective of this study was to examine the effects of perch access and age on physiological measurements of stress in White Leghorn pullets housed in conventional cages. Hatchlings (n = 1,064) were randomly assigned to 28 cages. Two parallel metal round perches were installed in each of 14 cages assigned the perch treatment, whereas control cages were without perches. Two birds per cage were bled at wk 4, 6, and 12 wk of age. Plasma levels of CORT, DA, EP, and NE, blood concentrations of 5-HT and Trp, and heterophil to lymphocyte ratios were measured. Data were analyzed using a 2-way ANOVA. The perch treatment or its interaction with age did not affect any parameter measured in the study. The increase in the concentrations of circulating EP, NE, 5-HT (numerical increase at 4 wk), and Trp in 4- and 6-wk-old pullets compared with 12-wk-old pullets is unclear, but may have been due to acute handling stress at younger ages. In contrast, concentrations of DA were less at 4 wk compared with levels at 6 and 12 wk of age. Plasma CORT levels and the heterophil to lymphocyte ratio, indicators of long-term stress, were unaffected by age (P = 0.07 and 0.49, respectively). These results indicated that age, but not perch access, affects neuroendocrine homeostasis in White Leghorn pullets. Pullets that were never exposed to perches showed no evidence of eliciting a stress response.

Development of an enzyme-linked immunosorbent assay for detection of chicken osteocalcin and its use in evaluation of perch effects on bone remodeling in caged White Leghorns.

Osteocalcin (OC) is a sensitive biochemical marker for evaluating bone turnover in mammals. The role of avian OC is less clear because of the need for a chicken assay. Our objectives were to develop an assay using indirect competitive ELISA for detecting chicken serum OC and use the assay to examine the effects of perches on bone remodeling in caged hens. Anti-chicken OC polyclonal antibody was produced by immunization of rabbits with a recombinant OC from Escherichia coli. Chicken OC extracted from bone was used as a coated protein, and purified chicken OC was used for calibration. The limit of detection of the developed OC ELISA was 0.13 ng/mL. The intra- and interassay CV were <7 and <12%, respectively. The sensitivity of the developed OC ELISA was compared with a commercial Rat-Mid OC ELISA in laying hens housed in conventional cages with or without perches. Serum samples were collected from 71-wk-old White Leghorn hens subjected to 4 treatments. Treatment 1 was control chickens that never had access to perches during their life cycle. Treatment 2 chickens had perches during the pullet phase (0 to 16.9 wk of age), whereas treatment 3 chickens had perches only during the egg-laying phase of the life cycle (17 to 71 wk of age). Treatment 4 chickens always had access to perches (0 to 71 wk of age). Correlation between the 2 assays was 0.62 (P < 0.0001). Levels of serum OC using the developed chicken ELISA were higher than that detected using the Rat-Mid ELISA (P < 0.0001). Results from the chicken ELISA assay showed that hens with perch access had higher concentrations of serum OC than hens without perches during egg laying (P = 0.04). Pullet access to perches did not affect serum OC levels in 71-wk-old hens (P = 0.15). In conclusion, a chicken OC ELISA has been validated that is sensitive and accurate with adequate discriminatory power for measuring bone remodeling in chickens.

The effect of perch availability during pullet rearing and egg laying on musculoskeletal health of caged White Leghorn hens.

A major skeletal problem of conventionally caged hens is increased susceptibility to osteoporosis mainly due to lack of exercise. Osteoporosis is characterized by a progressive decrease in mineralized structural bone. Whereas considerable attention has been given to enriching laying cages, little research has been conducted on providing caged pullets with furnishments, in particular perches. The objective of the current study was to determine if metal perches during all or part of the life cycle of White Leghorns affected hen musculoskeletal health, especially at end of lay. Treatments during the pullet phase (hatch to 16.9 wk) entailed cages with and without perches. Four treatments were used during the laying phase (17 to 71 wk of age). Treatment 1 chickens never had access to perches at any point during their life cycle, typical of egg industry practices in the United States for conventional cages. Treatment 2 chickens had access to perches only during the egg-laying phase, which was from 17 to 71 wk of age. Treatment 3 chickens had access to perches only during the pullet phase (0 to 16.9 wk of age). Treatment 4 chickens had perch access throughout their entire life cycle (0 to 71 wk of age). Musculoskeletal health was assessed by measuring muscle weights, bone mineralization, bone fracture incidence, and keel bone deviations. Muscle deposition of 71-wk-old hens increased when given access to perches as pullets. Bone mineralization of 71-wk-old hens also increased if given perch access as adults. However, the disadvantage of the adult perch was the higher incidence of keel deviations and keel fractures at end of lay. The increase in bone mineralization of the keel bone as a result of perch access during the pullet and laying phases was not great enough to prevent a higher incidence of keel bone fractures at end of lay. Perch redesign and placement of perches within the cage to minimize keel fractures and deviations are possible solutions.

The effect of perches in cages during pullet rearing and egg laying on hen performance, foot health, and plumage.

Enrichment of pullet cages with perches has not been studied. Our objective was to determine if access to metal perches during all or part of the life cycle of caged White Leghorns affected egg traits, foot health, and feather condition. Treatment 1 represented control chickens that never had access to perches during their life cycle. Treatment 2 hens had perches only during the egg laying phase of the life cycle (17 to 71 wk of age), whereas treatment 3 chickens had perches during the pullet phase (0 to 16.9 wk of age). Treatment 4 chickens always had access to perches (0 to 71 wk of age). Comparisons between chickens that always had perches with controls that never had perches showed similar performance relative to egg production, cracked eggs, egg weight, shell weight, % shell, and shell thickness. More dirty eggs occurred in laying cages with perches. Feed usage increased resulting in poorer feed efficiency in hens with perch exposure during the pullet phase with no effect during egg laying. Perches did not affect hyperkeratosis of toes and feet. The back claw at 71 wk of age broke less if hens had prior experience with perches during the pullet phase. In contrast, during egg laying, the back claw at 71 wk of age broke more due to the presence of perches in laying cages. Perches in laying cages resulted in shorter trimmed claws and improved back feather scores, but caused poorer breast and tail feather scores. In conclusion, enriching conventional cages with perches during the entire life cycle resulted in similar hen performance compared with controls. Fewer broken back claws but poorer feed efficiency occurred because of prior experience with perches as pullets. Perch presence during egg laying improved back feather scores with more trimmed nails but caused more dirty eggs, broken back claws, and poorer breast and tail feather scores. Although perches allow chickens to express their natural perching instinct, it was not without causing welfare problems.

Early access to perches in caged White Leghorn pullets.

Osteoporosis, a progressive decrease in mineralized structural bone, causes 20 to 35% of all mortalities in caged White Leghorn hens. Previous research has focused on manipulating the egg laying environment to improve skeletal health, with little research on the pullet. The objective of the current study was to determine the effect of perch access on pullet health, bone mineralization, muscle deposition, and stress in caged White Leghorns. From 0 to 17 wk of age, half of the birds were placed in cages with 2 round metal perches, while the other half did not have perches (controls). Bone mineralization and bone size traits were determined in the tibia, femur, sternum, humerus, ulna, radius, and phalange (III carpometacarpal) using dual energy x-ray absorptiometry. Muscle weights were obtained for the breast and left leg (drum and thigh). A sample of pullets from each cage was evaluated for foot health, BW, right adrenal weight, and packed cell volume. Most measurements were taken at 3, 6, and 12 wk of age. Access to perches did not affect breast muscle weight, percentage breast muscle, percentage leg muscle, bone mineral density, bone length, bone width, adrenal weight, packed cell volume, and hyperkeratosis of the foot-pad and toes. There were no differences in BW, bone mineral content, and leg muscle weight at 3 and 6 wk of age. However, at 12 wk of age, BW (P = 0.025), bone mineral content of the tibia, sternum, and humerus (P = 0.015), and the left leg muscle weight (P = 0.006) increased in pullets with access to perches as compared with controls. These results suggest that perch access has beneficial effects on pullet health by stimulating leg muscle deposition and increasing the mineral content of certain bones without causing a concomitant decrease in bone mineral density.

The effect of cage and house design on egg production and egg weight of White Leghorn hens: an epidemiological study.

Hen performance can be affected by many interacting variables related to cage design, such as floor area, height, tier arrangement, and feeder and drinker type and placement within the cage. Likewise, features of house design such as waste management and lighting can also affect hen productivity. The influence of these design aspects on hen performance has not been fully assessed. Determining the effects of numerous, interacting variables is impractical in a traditional experiment; therefore, an epidemiological approach, using variability in cage and house design among and within commercial producers, was employed to identify features that affect egg production and egg weight. A universal cage measurement system was created to calculate cage design variables. A database for recording information on cage design, resource location, waste management, environmental conditions, and hen productivity was developed. Production outcomes were assessed from placement to 60 wk of age in White Leghorns (n = 165-168 houses). Using GLM, a statistical model was identified that best described the variance in egg traits. Eggs/hen-housed increased with greater feeder space allocation (P = 0.031); taller cages (P = 0.029); rear (vs. front) drinker location in vertical cages (P = 0.026); and regular removal of manure from the house (P = 0.005). Case weight of eggs was greater in A-frame houses where manure was removed regularly instead of being left in the house (P < 0.001); with increasing cage floor slope (P = 0.001); in cages where drinkers were placed more toward the front or back of the cage as compared with the middle of the cage (P < 0.001); with more space/hen (P = 0.024); and with higher caloric intake (P < 0.001). Perhaps because of its negative correlation with egg production, case weight of eggs increased with less feeder space allocation (P = 0.004) and shorter cage heights (P < 0.001). These results reveal important effects of feeder space, floor space, cage height, drinker position, and waste management on hen productivity.

Effect of lighting programs during the pullet phase on skeletal integrity of egg-laying strains of chickens.

Egg-laying strains of chickens are highly susceptible to osteoporosis, a noninfectious disease characterized by a decrease in structural bone as hens age. To minimize the onset of osteoporosis, it was hypothesized that a delay in sexual maturity may allow a pullet to develop a stronger skeletal frame before egg laying, leading to improved skeletal mineralization at end of lay. One management tool that can easily be implemented by pullet growers to delay sexual maturity is length of photoperiod. The objective of the current study was to determine whether lighting programs used during the pullet phase of egg-laying strains of chickens can be manipulated to allow for improved skeletal mineralization in laying hens at end of lay. Two experiments were conducted in which 1,000 pullets/experiment were exposed to 1 of 3 varying step-down lighting programs (2 to 17 wk of age), referred to as rapid, moderate, and slow. For both experiments, 2 strains of chickens were used. Experiment 1 compared the Hy-Line W-36 with the Hy-Line W-98, and experiment 2 compared the Hy-Line Brown with the Hy-Line W-98. At 66 wk of age, all hens remaining in the study were weighed individually and the drum stick and wing were retrieved for determination of bone mineralization and bone size traits. Bone data were analyzed using an analysis of covariance with BW as the covariant, and BW was analyzed as an ANOVA. Skeletal frame development was affected by lighting regimen. Pullets exposed to the slow lighting photoperiod had longer bones and more bone area (experiment 2) than those exposed to the rapid photoperiod, most likely because of a delay in bone growth plate closure, which occurs at sexual maturity. However, this delay in sexual maturity, as indicated by longer bones, did not improve bone mineralization at 66 wk of age. It was concluded that pullet lighting regimen had little effect on bone mineralization at end of lay.

Hen welfare in different housing systems.

Egg production systems have become subject to heightened levels of scrutiny. Multiple factors such as disease, skeletal and foot health, pest and parasite load, behavior, stress, affective states, nutrition, and genetics influence the level of welfare hens experience. Although the need to evaluate the influence of these factors on welfare is recognized, research is still in the early stages. We compared conventional cages, furnished cages, noncage systems, and outdoor systems. Specific attributes of each system are shown to affect welfare, and systems that have similar attributes are affected similarly. For instance, environments in which hens are exposed to litter and soil, such as noncage and outdoor systems, provide a greater opportunity for disease and parasites. The more complex the environment, the more difficult it is to clean, and the larger the group size, the more easily disease and parasites are able to spread. Environments such as conventional cages, which limit movement, can lead to osteoporosis, but environments that have increased complexity, such as noncage systems, expose hens to an increased incidence of bone fractures. More space allows for hens to perform a greater repertoire of behaviors, although some deleterious behaviors such as cannibalism and piling, which results in smothering, can occur in large groups. Less is understood about the stress that each system imposes on the hen, but it appears that each system has its unique challenges. Selective breeding for desired traits such as improved bone strength and decreased feather pecking and cannibalism may help to improve welfare. It appears that no single housing system is ideal from a hen welfare perspective. Although environmental complexity increases behavioral opportunities, it also introduces difficulties in terms of disease and pest control. In addition, environmental complexity can create opportunities for the hens to express behaviors that may be detrimental to their welfare. As a result, any attempt to evaluate the sustainability of a switch to an alternative housing system requires careful consideration of the merits and shortcomings of each housing system.

Bone mineralization in male commercial broilers and its relationship to gait score.

Broilers selected for increased body size and breast muscle have imposed stress on the skeletal system, resulting in poorer walking ability. Our objectives were to determine the relationship between bone mineralization and gait score in 4 crosses of commercial broilers and to ascertain if mineralization of the toe is correlated to the tibia. Three chickens per pen each with good (gait score of 0 or 1) or poorer (gait score of 3) walking ability were killed and weighed. The left humerus, the left middle toe, and both drumsticks were collected for determination of bone mineral density (BMD), bone mineral content, and bone size traits using dual-energy x-ray absorptiometry. The BMD and bone size traits were similar among the 4 crosses of commercial broilers at 6 wk of age. However, gait scores differed among genotypes, with cross C having better gait scores than crosses A and B, but did not differ from cross D. The bone mineral content and bone size traits did not differ between birds with good walking ability as compared with those broilers of poorer walking ability. However, birds with poorer walking ability had higher BMD (P<0.05) and BW (P<0.001) than males with good walking ability. Within a cross, the correlation between gait score and BMD was not significant except for cross D birds. Broilers of cross D with better walking ability had decreased bone mineralization (r=0.19, P=0.03). The stronger correlation between gait score and BW for all crosses of commercial broilers (r=0.38, P<0.0001) suggests that the low association between gait score and bone mineralization for cross D was mainly due to BW. The BMD of the left toe was correlated to the BMD of the left tibia (r=0.91, P<0.0001) and right tibia (r=0.87, P<0.0001). In conclusion, bone mineralization was similar among crosses of meat-type chickens, and it had little influence on the gait score of male broilers.