RESUMO
Our objective was to determine if methods for preparing total mixed ration [TMR; horizontal paddle mixer with knives (PK) vs. vertical auger (VA) mixer] would alter the physical form of the TMR and affect utilization of diets with increasing amounts of modified wet distillers grains with solubles (MWDGS). Holstein cows (n = 24 with 12 ruminally cannulated; 144 d in milk ± 31 d at start) were used in a split-plot design with mixer type as the whole plot and MWDGS concentrations as subplots in a replicated 3 × 3 Latin square arrangement with 35-d periods. Inclusion rates of MWDGS were 10, 20, and 30% of dietary dry matter, primarily replacing corn, soybean meal, soyhulls, and whole cottonseed. Feed dry matter intake (DMI) was less for PK (23.8 kg/d) than for VA (25.7 kg/d), but was unaffected by MWDGS concentration. Milk production did not differ by concentration of MWDGS or by interaction of MWDGS × mixer. Milk fat percentage declined with increasing MWDGS but the interaction between mixer and MWDGS showed that decreases were larger with VA mixing. Cows fed the diet containing 30% MWDGS mixed with PK averaged 3.45% (1.24 kg/d) milk fat, whereas cows fed the same diet mixed with VA averaged 2.81% (1.10 kg/d) fat. Concentrations of trans-10,cis-12 C18:2 in milk fat likely explain the differences observed in milk fat yield; the concentration of trans-10,cis-12 C18:2 increased as MWDGS was increased and the MWDGS × mixer interaction showed that VA had greater concentrations. Greater mean particle size and increased variation in particle size with VA may partially explain differences in milk fat via increased sorting that allowed for an altered rumen environment and favored alternative biohydrogenation pathways. Feed conversion efficiency (FCE; energy-corrected milk/DMI) decreased linearly as MWDGS increased, but FCE tended to be maintained when higher MWDGS diets were mixed using PK rather than VA. Ruminal pH and ammonia concentration decreased linearly as MWDGS increased. The PK mixer resulted in greater FCE when higher amounts of MWDGS were fed, primarily because milk fat content and yield were not as depressed and DMI was lower at similar milk yields.