Cell surface staining of recombinant factor VIII is reduced in apoptosis resistant BHK-21 cells.

We have recently demonstrated an increase in recombinant factor VIII (rFVIII) secretion from BHK-21 cells (rBHK-21(host)) following an over-expression of the chaperone protein heat shock protein 70 (Hsp70) (rBHK-21(Hsp70)) due to an inhibition of apoptotic cell death and an increased cellular expression of rFVIII [Ishaque, A., Thrift, J., Murphy, J.E., Konstantin, K., 2007. Over-expression of Hsp70 in BHK-21 cells engineered to produce recombinant factor VIII promotes resistance to apoptosis and enhances secretion. Biotechnol. Bioeng. Biotech. Bioeng. 97, 144-155]. In the present study we investigated the difference in adherence of rFVIII to the cell membrane surface by comparing changes in cell viability and extent of phosphatidylersine (PS) exposure in apoptosis between rBHK-21(host), rBHK-21(Hsp70), and parental BHK-21 cells devoid of rFVIII expression (BHK-21(native)) during batch cell culture experiments. The Zenon technique was used to double stain for cell surface and intracellular rFVIII using flow cytometric Guava PCA analysis. By this quantitative analysis intracellular rFVIII was shown to decrease in rBHK-21(host) cells as the cell viability declined while the rFVIII cell surface staining increased. Conversely, rBHK-21(Hsp70) cell cultures displayed higher cell viability and intracellular rFVIII with less cell surface rFVIII staining. Time dependent increases of rFVIII adherence to the surface of rBHK-21(host) cells and its reduction on the surface of rBHK-21(Hsp70) cells was also confirmed by fluorescence microscopy. Furthermore, greater rFVIII cell surface staining correlated with an increase in detectable PS exposure on the surface of BHK-21(native) batch cell cultures. However, PS exposure could not be identified to the same extent on rBHK-21(host) cells despite a similar decline in cell viability between rBHK-21(host) and BHK-21(native) batch cultures. Any exposed PS on rBHK-21(host) cells was most likely masked by secreted rFVIII, mimicking the effect on activated platelets where the externalization of PS also occurs, and serves as a ligand for FVIII activation in the blood coagulation cascade. Taken together we have identified that rFVIII sequestration on the membrane surface is another potential limitation to rFVIII productivity and one which can also be alleviated by reduction of apoptosis in a clone expressing human HSP70.

Anti-apoptotic genes Aven and E1B-19K enhance performance of BHK cells engineered to express recombinant factor VIII in batch and low perfusion cell culture.

The engineering of production cell lines to express anti-apoptotic genes has been pursued in recent years due to potential process benefits, including enhanced cell survival, increased protein expression, and improved product quality. In this study, a baby hamster kidney cell line secreting recombinant factor VIII (BHK-FVIII) was engineered to express the anti-apoptotic genes Aven and E1B-19K. In high cell density shake flask culture evaluation, 11 clonal cell lines expressing either E1B-19K or a combination of Aven and E1B-19K showed improved survival compared to both parental and blank vector cell line controls. These cell lines exhibited lower caspase-3 activation and reduced Annexin-V binding compared to the controls. Parental and blank vector cell lines were less than 50% viable after 48 h of exposure to thapsigargin while cell lines expressing E1B-19K with or without Aven maintained viabilities approaching 90%. Subsequently, the best Aven-E1B-19K candidate cell line was compared to the parental cell line in 12-L perfusion bioreactor studies. Choosing the appropriate perfusion rates in bioreactors is a bioprocess optimization issue, so the bioreactors were operated at sequentially lower specific perfusion rates, while maintaining a cell density of 2 x 10(7) viable cells/mL. The viability of the parental cell line declined from nearly 100% at a perfusion rate of 0.5 nL/cell/day to below 80% viability, with caspase-3 activity exceeding 15%, at its lower perfusion limit of 0.15 nL/cell/day. In contrast, the Aven-E1B-19K cell line maintained an average viability of 94% and a maximum caspase-3 activity of 2.5% even when subjected to a lower perfusion minimum of 0.1 nL/cell/day. Factor VIII productivity, specific growth rate, and cell size decreased for both cell lines at lower perfusion rates, but the drop in all cases was larger for the parental cell line. Specific consumption of glucose and glutamine and production of lactate were consistently lower for the Aven-E1B-19K culture. Furthermore, the yield of ammonia from glutamine increased for the Aven-E1B-19K cell line relative to the parent to suggest altered metabolic pathways following anti-apoptosis engineering. These results demonstrate that expression of anti-apoptotic genes Aven and E1B-19K can increase the stability and robustness of an industrially relevant BHK-FVIII mammalian cell line over a wide range of perfusion rates.

Over-expression of Hsp70 in BHK-21 cells engineered to produce recombinant factor VIII promotes resistance to apoptosis and enhances secretion.

Production of coagulation factor VIII (FVIII) by recombinant cell lines is limited by its failure to reach or maintain the native conformation in the endoplasmic reticulum. This results in significant cytoplasmic degradation and/or aggregation of the misfolded product. The molecular chaperone Hsp70 was overexpressed in an attempt to increase the recombinant FVIII (rFVIII) secretion. The characteristics of increased Hsp70 expression were investigated by comparing a clone of BHK-21 cells expressing rFVIII (rBHK-21(host)) to a chaperone clone derived by transfection of the host clone with human Hsp70 (rBHK-21(Hsp70)) in small-scale batch cell cultures. To aid this investigation a number of fluorescence based cellular apoptosis assays were developed and optimized. These assays demonstrated sub-populations of rBHK-21(host) cells that were apoptotic in nature and were identified prior to the loss in plasma membrane integrity. Dual staining for intracellular rFVIII and caspase-3 activation showed a reduction in intracellular rFVIII in rBHK-21(host) cells that correlated with a significant increase in active caspase-3, suggesting that apoptosis was a factor limiting rFVIII secretion. In sharp contrast there was more intracellular rFVIII and less active caspase-3 in rBHK-21(Hsp70) cell cultures. Moreover when grown in batch culture, rBHK-21(Hsp70) cells released rFVIII of higher specific activity (active FVIII protein/total FVIII protein), suggesting improved product quality. Thus, increased expression of HSP70 led to an increased yield of a secreted recombinant protein by inhibition of apoptosis and promoting proper conformational maturation of rFVIII in sub-optimal bioreactor conditions.

Cyclooxygenase-2 inhibits tumor necrosis factor alpha-mediated apoptosis in renal glomerular mesangial cells.

Renal mesangial cell apoptosis is a crucial repair mechanism in glomerular nephritis (GN). These cells express receptors to tumor necrosis factor alpha (TNFalpha), a cytokine with proapoptotic properties implicated in the resolution of GN. Progression to proliferative GN is accompanied by cyclooxygenase-mediated formation of prostaglandins and inefficient apoptosis of mesangial cells. The aims of this study were to quantify TNFalpha-mediated apoptosis in renal mesangial cells and to determine whether expression of the inducible form of cyclooxygenase, cylooxygenase-2 (COX-2), inhibits this apoptosis. By 24 h significant levels of apoptosis were induced by TNFalpha (100 ng/ml) or etoposide control (100 microm), as shown by phosphatidylserine externalization, caspase-3 activation, development of a sub-G(0)/G(1) region, and distinct chromatin condensation. Using adenoviral-mediated delivery of the COX-2 gene (AdCOX-2) apoptotic features were prevented from appearing in AdCOX-2 cells treated with TNFalpha, whereas etoposide-treated AdCOX-2 cells were not protected. Furthermore, COX-2 expression, induced by the vasoconstrictor peptide ET-1 or the cytokine interleukin-1beta also inhibited TNFalpha-mediated but not etoposide-mediated apoptosis, to an extent, similar to adenoviral COX-2 infection. Selective COX-2 inhibition by NS-398 restored TNFalpha-mediated apoptosis. Prostaglandin (PG) E(2) and PGI(2) were shown to be the major prostaglandin metabolites in AdCOX-2 cells. The addition of PGE(2) and PGI(2) protected against TNFalpha-mediated apoptosis. These results demonstrate COX-2 anti-apoptotic activity via a death receptor route and suggest that selective COX-2 inhibition may augment TNFalpha apoptosis in chronic inflammatory conditions.