Utilization of Whey for Eco-Friendly Bio-Preservation of Mexican-Style Fresh Cheeses: Antimicrobial Activity of Lactobacillus casei 21/1 Cell-Free Supernatants (CFS).

Using whey, a by-product of the cheese-making process, is important for maximizing resource efficiency and promoting sustainable practices in the food industry. Reusing whey can help minimize environmental impact and produce bio-preservatives for foods with high bacterial loads, such as Mexican-style fresh cheeses. This research aims to evaluate the antimicrobial and physicochemical effect of CFS from Lactobacillus casei 21/1 produced in a conventional culture medium (MRS broth) and another medium using whey (WB medium) when applied in Mexican-style fresh cheese inoculated with several indicator bacteria (Escherichia coli, Salmonella enterica serovar Typhimurium, Staphylococcus aureus, and Listeria monocytogenes). The CFSs (MRS or WB) were characterized for organic acids concentration, pH, and titratable acidity. By surface spreading, CFSs were tested on indicator bacteria inoculated in fresh cheese. Microbial counts were performed on inoculated cheeses during and after seven days of storage at 4 ± 1.0 °C. Moreover, pH and color were determined in cheeses with CFS treatment. Lactic and acetic acid were identified as the primary antimicrobial metabolites produced by the Lb. casei 21/1 fermentation in the food application. A longer storage time (7 days) led to significant reductions (p < 0.05) in the microbial population of the indicator bacteria inoculated in the cheese when it was treated with the CFSs (MRS or WB). S. enterica serovar Typhimurium was the most sensitive bacteria, decreasing 1.60 ± 0.04 log10 CFU/g with MRS-CFS, whereas WB-CFS reduced the microbial population of L. monocytogenes to 1.67 log10 CFU/g. E. coli and S. aureus were the most resistant at the end of storage. The cheese's pH with CFSs (MRS or WB) showed a significant reduction (p < 0.05) after CFS treatment, while the application of WB-CFS did not show greater differences in color (ΔE) compared with MRS-CFS. This study highlights the potential of CFS from Lb. casei 21/1 in the WB medium as an ecological bio-preservative for Mexican-style fresh cheese, aligning with the objectives of sustainable food production and guaranteeing food safety.

Nutritional composition and techno-functionality of non-defatted and defatted flour of edible insect Arsenura armida.

Edible insects are traditional foods worldwide, and in Mexico, is a prehispanic practice. Nowadays, edible insects can be a food source for the increasing population. This research aimed to evaluate the nutritional profile, physical and techno-functional characteristics of non-defatted (NDF) and defatted (DF) flour of the edible insect Arsenura armida to use as a functional ingredient. The lipid content in NDF was 24.18%. Both flours are high in protein, 20.36% in NDF and 46.89% in DF; their soluble proteins from A. armida were classified according to their molecular weight, which ranged from 12 to 94 kDa. The physical properties suggest that both flours have good flow characteristics. Regarding techno-functional properties, DF had the highest water (275.6%) and oil (121%) holding capacity values. The viscosity values indicate that they behave as a non-Newtonian shear-thinning fluid at a high concentration (20%). Emulsion capacity values range between 78.3 and 100% in both flours, with stability between 92.4 and 100%. These flours could be a good source of nutrients, and their techno-functional properties make them a good option for animal protein substitutes.

Changes in phenolics and flavonoids in amaranth and soybean sprouts after UV-C treatment.

Sprouts, mainly from cereals, legumes, and some pseudo-cereals, are rich in nutrients and contain biocompounds, making them attractive for consumption. This research study aimed to develop treatments with UV-C light in soybean and amaranth sprouts and evaluate their effect on biocompounds content, compared with chlorine treatments. UV-C treatments were applied at distances of 3 and 5 cm and times of 2.5, 5, 10, 15, 20, and 30 min, whereas chlorine treatments were applied as immersion in solutions at 100 and 200 ppm for 15 min. Phenolics and flavonoid content were higher in UV-C-treated sprouts than in those treated with chlorine solutions. Ten biocompounds were identified in soybean sprouts, with increasing in apigenin C-glucoside-rhamnoside (105%), apigenin 7-O-glucosylglucoside (237%), and apigenin C-glucoside malonylated (70%) due to UV-C application (3 cm, 15 min); for amaranth sprouts, five biocompounds were identified, with higher contents of p-coumaroylquinic acid (17.7%) after UV-C treatment (3 cm, 15 min). The best treatment to achieve the highest bioactive compounds concentration was UV-C at a distance of 3 cm for 15 min, without significant modification on the color parameters, Hue and chroma. PRACTICAL APPLICATION: UV-C can be used to increase the biocompound content in amaranth and soybean sprouts. Nowadays, there is UV-C equipment available for industrial applications. In this way, sprouts may be maintained as fresh through this physical technology, and they will retain or increase the concentration of health-related compounds.

Health Benefits of Consuming Foods with Bacterial Probiotics, Postbiotics, and Their Metabolites: A Review.

Over the years, probiotics have been extensively studied within the medical, pharmaceutical, and food fields, as it has been revealed that these microorganisms can provide health benefits from their consumption. Bacterial probiotics comprise species derived from lactic acid bacteria (LAB) (genus Lactobacillus, Leuconostoc, and Streptococcus), the genus Bifidobacterium, and strains of Bacillus and Escherichia coli, among others. The consumption of probiotic products is increasing due to the current situation derived from the pandemic caused by COVID-19. Foods with bacterial probiotics and postbiotics are premised on being healthier than those not incorporated with them. This review aims to present a bibliographic compilation related to the incorporation of bacterial probiotics in food and to demonstrate through in vitro and in vivo studies or clinical trials the health benefits obtained with their metabolites and the consumption of foods with bacterial probiotics/postbiotics. The health benefits that have been reported include effects on the digestive tract, metabolism, antioxidant, anti-inflammatory, anticancer, and psychobiotic properties, among others. Therefore, developing food products with bacterial probiotics and postbiotics is a great opportunity for research in food science, medicine, and nutrition, as well as in the food industry.

Thermal and pH stability of Justicia spicigera (Mexican honeysuckle) pigments: Application of mathematical probabilistic models to predict pigments stability.

Kinetic and probabilistic (Time-to-Failure, TTF) models were used to predict the color (L*, a*, b* total color differences (ΔE), Hue and Chroma) stability of Justicia spicigera leaves pigments subjected to different temperatures (40 - 80 °C) and pHs (2 - 12). The change in pH caused different hues (from 60° = orange red to 268° = deep-blue) due to the shift effect of anthocyanins in the extract. Temperatures higher than 60 °C increased the color degradation. High heat sensitivity was observed at pH 4 (Ea = 90.27) and 10 (Ea = 154.99 kJ/mol). The Time-to-Failure model for both ΔE and Hue describes the effect of pH and temperature in the J. spicigera extracts. High pHs and temperatures applied to the extracts increased the probability of showing ΔEs > 4 or Hue changes over 20 %. Nearby the neutral region of pH, pigments of J. spicigera were more stable. The TTF model might be a useful tool to describe and predict the behavior of pigments added to foods.

Antifungal Capacity of Poolish-Type Sourdough Supplemented with Lactiplantibacillus plantarum and Its Aqueous Extracts In Vitro and Bread.

This study aimed to evaluate the antifungal capacity of the aqueous extracts (AE) of poolish-type sourdoughs fermented with Lactiplantibacillus plantarum NRRL B-4496 on broth, agar, and bread. The aqueous extracts were obtained by centrifugation and separating the supernatant from the poolish sourdoughs once the fermentation time had ended. The aqueous extracts inhibited 80% of the growth of Penicillium chrysogenum and Penicillium corylophilum and <20% of Aspergillus niger in broth. The AEs delayed the radial growth rate and increased the lag time for the three molds tested. The addition of poolish-type sourdoughs inhibited fungal growth in bread for ten days. The extracts' fungistatic capacity was primarily attributed to lactic and acetic acids and probably the antifungal peptides occurring in the AE. The L. plantarum sourdough is an alternative to calcium propionate as an organic antifungal agent.

Insights on the effectiveness of pneumatic and ultrasonic atomization in combination with UVC light for processing of fruit juices.

This study evaluated the effectiveness of spraying juices, during shortwave ultraviolet irradiation (UVC) treatments as an alternative to promote more contact area, by means of ultrasonic atomization (UA) and pneumatic atomization (PA). Four juices with dissimilar physical characteristics were processed to assess the effect of suspended solids and turbidity. Antioxidant activity, anthocyanins, ascorbic acid, and inactivation of Saccharomyces cerevisiae inoculated in the juices were evaluated. Five decimal reduction cycles were reached after two passes of orange or grapefruit juice through the UVC + UA arrangement. On the other hand, five decimal reduction cycles were achieved after three passes in the UVC + PA arrangement. Losses of 11% and 14% of ascorbic acid were observed in orange and grapefruit juice, respectively, while anthocyanin content presented losses of 50% and antioxidant activity decreased by 40% for pomegranate and blueberry juice, correspondingly.

Fungal inactivation on Mexican corn tortillas by means of thyme essential oil in vapor-phase.

Antifungal activity of thyme (Thymus vulgaris) essential oil (EO) in vapor-phase was tested against representative fungi in corn tortillas. The chemical composition of studied EO was analyzed by gas chromatography-mass spectroscopy, and its major components were linalool, thymol, and p-cymene. The antifungal activity was evaluated by determining the growth of Aspergillus niger or Penicillium expansum after exposure to EO vapors. The in vitro minimum inhibitory concentration (MIC) of the EO was determined by the inverted lid technique, while in situ MIC was determined on the corn tortillas inside an airtight container. The MICs obtained ranged from 160 to 200 µL of thyme EO/Lof air for in vitro conditions and 550-850 µL of the EO/Lof air in corn tortillas. The modified Gompertz model adequately described in vitro mold growth curves. Thyme EO was effective in preventing or significantly delaying growth of the contaminating molds on corn tortillas.

The impacts of antimicrobial and antifungal activity of cell-free supernatants from lactic acid bacteria in vitro and foods.

Lactic acid bacteria (LAB) are distinguished by their ability to produce lactic acid, among other interesting metabolites with antimicrobial activity. A cell-free supernatant (CFS) is a liquid containing the metabolites resulting from microbial growth and the residual nutrients of the medium used. CFS from LAB can have antimicrobial activity due to organic acids, fatty acids, and proteinaceous compounds, among other compounds. This review aims to summarize the information about CFS production, CFS composition, and the antimicrobial (antibacterial and antifungal) activity of CFS from LAB in vitro, on foods, and in active packaging. In addition, the mechanisms of action of CFS on cells, the stability of CFS during storage, CFS cytotoxicity, and the safety of CFS are reviewed. The main findings are that CFS's antibacterial and antifungal activity in vitro has been widely studied, particularly in members of the genus Lactobacillus. CFS has produced strong inhibition of bacteria and molds on foods when applied directly or in active packaging. In most studies, the compounds responsible for antimicrobial activity are identified. A few studies indicate that CFSs are stable for 1 to 5 months at temperatures ranging from 4 to 35°C. The cytotoxicity of CFS on human cells has not been well studied. However, the studies that have been performed reported no toxicity of CFS. Therefore, it is necessary to investigate novel growth mediums for CFS preparation that are compatible with food sensory properties. More studies into CFS stability and cytotoxic effects are also needed.

Effect of process variables on heating profiles and extraction mechanisms during hydrodistillation of eucalyptus essential oil.

The effect of different process variables, such as solid/liquid ratio (1: 1, 1: 3, or 1: 5 g/ml) and stirring speeds (0, 200, or 400 rpm), was studied on the extraction mechanisms of eucalyptus essential oil obtained by hydrodistillation (HD). Different performance parameters such as obtained yield, energy requirements, and environmental impact were compared to those obtained by steam distillation (SD). Two different mathematical models were used to describe the process behavior. The obtained results indicate that the system with a solid/liquid ratio of 1:5 g/ml using a stirring speed of 400 rpm yielded maximum for HD (1.19% ± 0.01%). The environmental impact expressed as Ecopoints (EI99) ranged between 50.87 ± 13.18 and 78.17 ± 13.82 mPT/g essential oil (EO) for systems with steam injection, whereas for HD took values between 16.9 ± 0.3 and 19.24 ± 1.4 mPT/g EO at optimal operating conditions. The model parameters allowed us to identify that large amounts of steam at lower heating velocities induce a high accumulation of EO in the aqueous layer (vapor-liquid equilibrium at the interface), favoring the extraction process.

Postharvest heat treatments to inhibit Penicillium digitatum growth and maintain quality of Mandarin (Citrus reticulata blanco).

Use of fungicides is a common practice as a postharvest treatment to control fruit decay. Nowadays, environment friendly technologies, such as heat treatments, are viable replacements. This study evaluated the effects of post-harvest heat treatments (traditional and microwave-assisted) on mandarins intentionally inoculated with Penicillium digitatum. For the studied heat treatments, the target temperature was 50 °C, which was held for 2.5 min. After heating, mandarins were cooled and stored at 25 °C for 13 days. MW treatments effectively prevented mold growth during storage, while HW only delayed it. Control mandarins (without treatment) showed the highest significant weight loss. Neither thermal treatment nor storage affected fruit juice pH (p > 0.05). Treated mandarins had a significantly lower vitamin C content than control fruits throughout storage, and all mandarins lost firmness by the 13th day (p < 0.05). Control and MW-treated mandarins had lower citric acid content; however, they retained color, total soluble solids (TSS) and had a higher maturity index. While HW mandarins did not have changes in citric acid content, they had higher TSS, and lower maturity index. MW-assisted treatments were effective at inactivating molds and helped retain some nutritional and physical-chemical characteristics of mandarins. However, juice of MW-treated mandarins was not preferred by judges in the sensory tests, the juice was rated lower than that obtained from the other treatment. Postharvest heat treatments may constitute a helpful application to control mandarin' fungal decay.

Essential oils in vapor phase as alternative antimicrobials: A review.

The antimicrobial effectiveness of essential oils (EOs) against many foodborne microorganisms when applied by direct contact has been extensively demonstrated. However, the vapor phase and volatile components present in EOs have not been thoroughly investigated; there are a small number of published reports on the antimicrobial activity of some EOs and a few of their components against selected microorganisms. It is well known that the antimicrobial activity of EOs depends mainly on their chemical composition. It is also important; however, to understand the volatility of these compounds as well as the methodologies used to evaluate the antimicrobial effectiveness of their vapor phase. This review focuses on recent research regarding the chemical composition of EOs, their biological activity and mechanisms of action, the antimicrobial activity of EOs in the vapor phase, the different techniques that have been proposed to evaluate the antimicrobial effects of EOs in the vapor phase, and actual and potential applications of EOs in the vapor phase. Although there is still no standard methodology for determining the activity of EOs in the vapor phase, results reported thus far are encouraging and suggest possible applications in food preservation.

High-Intensity Light Pulses To Inactivate Salmonella Typhimurium on Mexican Chia (Salvia hispanica L.) Seeds.

Chia seeds provide a suitable environment for microorganisms. However, it is difficult to disinfect these seeds with water and/or chemical disinfectant solutions because the mucilage in the seeds can absorb water and consequently form gels. High-intensity light pulses (HILP) is one of the most promising emerging technologies for inactivating microorganisms on surfaces, in clear liquids and beverages, and on solid foods. The aim of this work was to evaluate the effect of HILP on Salmonella Typhimurium in culture medium (in vitro tests) and inoculated onto chia seeds (in vivo tests). HILP was effective against Salmonella Typhimurium under both conditions: 8 s of treatment (10.32 J/cm2) resulted in a 9-log reduction during in vitro tests, and 15 s of treatment (19.35 J/cm2) resulted in a 4-log reduction on the inoculated chia seeds. Salmonella Typhimurium inactivation kinetics were accurately described using the Weibull model (R2 > 0.939). These results indicate that the use of HILP for microbial inactivation on seeds could generate products suitable for human consumption.

Antimicrobial, Cytotoxic, and Anti-Inflammatory Activities of Pimenta dioica and Rosmarinus officinalis Essential Oils.

Essential oils (EOs) are natural products composed of a mixture of volatile and aromatic compounds extracted from different parts of plants that have shown antimicrobial activities against pathogens. In this study, EOs extracted from Pimenta dioica (Myrtaceae) and Rosmarinus officinalis (Lamiaceae) were assessed for their antimicrobial activities using a panel of pathogenic Gram-positive, Gram-negative, and fungal strains. The antimicrobial activity was measured by the minimal inhibitory concentration required for the growth inhibition of the microorganisms. The cytotoxicity of the EOs was tested ex vivo using the model of human-derived macrophage THP-1 cells. In addition, an inflammatory response was evaluated using the anti-inflammatory cytokine IL-10 and the proinflammatory cytokines IL-6 and TNF-α. Results showed that both EOs had antimicrobial activity and different pathogens were exposed to concentrations ranging between 600 and 2000 µg/mL. In addition, the EOs showed no inflammatory activity when exposed to human macrophages, but a potent anti-inflammatory activity was measured when the oil from Rosmarinus officinalis was exposed to macrophages. This study demonstrates that the use of EOs is an effective alternative for pathogenic bacterial and fungal control, alone or in combination with antibiotic therapy. Moreover, the oil extracted from Rosmarinus officinalis could be used as potent anti-inflammatory agent.

Complex Coacervation Between Gelatin and Chia Mucilage as an Alternative of Encapsulating Agents.

Complex coacervation between gelatin type B (GE) and chia mucilage (ChM) was studied. GE-ChM were mixed at mass ratios of 1:1, 2:1, 3:1, 4:1, and 1:2 in a pH range of 1.50 to 5.00, maintaining a total solid concentration of 0.2% (w/w), using turbidity and viscosity tests to obtain the highest yield of complex coacervates. To characterize the complex coacervates, morphology and Fourier-transform infrared spectroscopy (FTIR) were determined. The optimum yield for complex coacervation was achieved with a GE-ChM mass ratio of 2:1 and pH value of 3.6. The critical pH values associated with the formation of soluble (pHc ) and insoluble (pHɸ1 ) complexes, and complete dissociation (pHɸ2 ) at the optimum GE-ChM ratio were found to be 4.50, 4.10, and 2.00, respectively. It was observed that increasing the mass ratio of GE or ChM, the yield of complex coacervates decreased; the higher yields were obtained with the proportions of 2:1 and 1:1 with values of 68.25 ± 0.05% and 61.04 ± 0.05%, respectively. Capsules formed at mass ratios of 1:1, 2:1, and 3:1, had the characteristic grape agglomerate shape for complex coacervates. Further characterization with scanning electron microscopy (SEM) showed a spherical shape for capsules. FTIR spectrum of complex coacervates at optimum conditions had a combination of bands corresponding to GE and ChM, suggesting an interaction between GE-ChM during the formation of complex coacervates. Therefore, complex coacervates between GE-ChM can be formed, and could be used as an alternative as encapsulating agents to be applied in the food industry. PRACTICAL APPLICATION: Complex coacervation is a technique that is being studied in several applications in the food industry. However, studies are still being made to explore different possibilities of natural sources to be used in complex coacervation. This study showed that the combination of gelatin and chia mucilage may be an alternative as encapsulating agents for complex coacervation to be applied in the food industry.

Evaluation of the efficiency of allspice, thyme and rosemary essential oils on two foodborne pathogens in in-vitro and on alfalfa seeds, and their effect on sensory characteristics of the sprouts.

Seeds are usual source of contamination and their sprouts are commonly associated foodborne illness. Therefore, the aim of this study was to evaluate the antibacterial vapor phase efficiency of allspice, thyme and rosemary essential oils on two foodborne pathogens in in vitro and on alfalfa seeds, including the chemical profile of the tested EOs and their effect on the sensory characteristics of the sprouts. Antibacterial activity was determined through the minimal inhibitory concentration (MIC) of EOs in vapor phase to inhibit the growth of Listeria monocytogenes and Salmonella Typhimurium in culture media and on alfalfa seeds. Also, the germination and the effect on sensory characteristics of the sprouts were determined. Thyme EO was the most effective of the tested EOs on culture media and on alfalfa seeds, against both bacteria. When rosemary EO was tested against L. monocytogenes in alfalfa seeds, the MIC (4.0 mL/Lair) was higher, compared to the one obtained in culture media (2.7 mL/Lair). But when this EO was tested against S. Typhimurium, the MIC in alfalfa seeds was lower than in culture media (11.7 vs 13.3 mL/Lair). Allspice EO resulted more effective against both bacteria in alfalfa seeds (6.0 mL/Lair for L. monocytogenes and 6.7 mL/Lair for S. Typhimurium), compared to culture media (12.0 mL/Lair for L. monocytogenes and 13.3 mL/Lair for S. Typhimurium). Vapor phase EOs MICs resulted in significant (p ≤ 0.05) decreases of L. monocytogenes and S. Typhimurium counts compared to the control. There also was a significant (p ≤ 0.05) difference between systems (in vitro or on alfalfa seeds) despite the microorganism or the evaluated EO. Treatment alfalfa seed with vapor phase EOs, did not affect the seed germination. Sensory acceptability of the sprouts, obtained of treated seeds, did not were significant (p ≥ 0.05) different of the sprouts obtained from the non-treated seeds.

Penicillium expansum Inhibition on Bread by Lemongrass Essential Oil in Vapor Phase.

The antimicrobial activity of lemongrass (Cymbopogon citratus) essential oil (EO) in the vapor phase on the growth of Penicillium expansum inoculated on bread was evaluated, followed by a sensory evaluation of the bread's attributes after EO exposure. The lemongrass EO was extracted from dry leaves of lemongrass by microwave-assisted steam distillation. The chemical composition of the lemongrass EO was determined using a gas chromatograph coupled to a mass spectrometer. The refractive index and specific gravity of the EO were also determined. Bread was prepared and baked to reach two water activity levels, 0.86 or 0.94, and then 10 µL of P. expansum spore (106 spores per mL) suspension was inoculated on the bread surface. Concentrations of lemongrass EO were tested from 125 to 4,000 µL/Lair, whereas mold radial growth was measured for 21 days. For sensory evaluation, breads were treated with lemongrass EO vapor at 0, 500, or 1,000 µL/Lair for 48 h and tested by 25 untrained panelists. The EO yield was 1.8%, with similar physical properties to those reported previously. Thirteen compounds were the main components in the EO, with citral being the major compound. P. expansum was inhibited for 21 days at 20°C with 750 µL of EO/Lair, and its inhibition increased with increasing concentrations of EO. Sensory acceptance of bread exposed to vapor concentrations of 500 or 1,000 µL of EO/Lair or without EO was favorable; similar and no significant differences (P > 0.05) were observed among them.

Effects of microwave-assisted hot water treatments designed against Mexican fruit fly (Anastrepha ludens) on grapefruit (Citrus paradisi) quality.

BACKGROUND: Hot water treatment (HWT) against Anastrepha ludens was developed achieving 48 °C in the core of grapefruits and holding it for 6 min. After heating, the grapefruits were hydro-cooled and stored at 23 °C and analyzed for 16 days. The effect of microwave-assisted HWT (MW-HWT) on grapefruit quality was analyzed and compared with the quality of fruits treated with HWT and control fruits (without treatment). The physicochemical properties and chemical composition of essential oil were analyzed. RESULTS: MW-HWT was equivalent to HWT according to accumulated heat calculations, with the advantage of being shorter. Treatments significantly affected the weight, color, maturity index, juice content, firmness, titratable acidity, pH, and ascorbic acid content of the grapefruits (P < 0.05), but had no effect on the total soluble solids (P > 0.05). The major components identified in the essential oil were d-limonene and ß-myrcene, compounds responsible of the scent of the grapefruits. CONCLUSION: MW-HWT was shorter (130 min) and had a lesser effect on the quality of the grapefruit when compared with fruits under HWT (188 min duration). Thus, this treatment could be considered as an alternative method against the Mexican fruit fly in grapefruit. © 2017 Society of Chemical Industry.

Description of Aspergillus flavus growth under the influence of different factors (water activity, incubation temperature, protein and fat concentration, pH, and cinnamon essential oil concentration) by kinetic, probability of growth, and time-to-detection models.

A Box-Behnken design was used to determine the effect of protein concentration (0, 5, or 10g of casein/100g), fat (0, 3, or 6g of corn oil/100g), aw (0.900, 0.945, or 0.990), pH (3.5, 5.0, or 6.5), concentration of cinnamon essential oil (CEO, 0, 200, or 400µL/kg) and incubation temperature (15, 25, or 35°C) on the growth of Aspergillus flavus during 50days of incubation. Mold response under the evaluated conditions was modeled by the modified Gompertz equation, logistic regression, and time-to-detection model. The obtained polynomial regression models allow the significant coefficients (p<0.05) for linear, quadratic and interaction effects for the Gompertz equation's parameters to be identified, which adequately described (R2>0.967) the studied mold responses. After 50days of incubation, every tested model system was classified according to the observed response as 1 (growth) or 0 (no growth), then a binary logistic regression was utilized to model A. flavus growth interface, allowing to predict the probability of mold growth under selected combinations of tested factors. The time-to-detection model was utilized to estimate the time at which A. flavus visible growth begins. Water activity, temperature, and CEO concentration were the most important factors affecting fungal growth. It was observed that there is a range of possible combinations that may induce growth, such that incubation conditions and the amount of essential oil necessary for fungal growth inhibition strongly depend on protein and fat concentrations as well as on the pH of studied model systems. The probabilistic model and the time-to-detection models constitute another option to determine appropriate storage/processing conditions and accurately predict the probability and/or the time at which A. flavus growth occurs.

Antimicrobial activity of whey protein films supplemented with Lactobacillus sakei cell-free supernatant on fresh beef.

The aim of this work was to evaluate the antimicrobial activity of whey protein isolate (WPI) films supplemented with Lactobacillus sakei NRRL B-1917 cell-free supernatant on beef inoculated with Escherichia coli ATCC 25922 or Listeria monocytogenes Scott A; additionally, sensory evaluation was performed on wrapped beef cubes. Supernatant concentrates were obtained from Lb. sakei cultures in MRS broth after centrifugation, filtering, and freeze-drying. Films were prepared with WPI (3% w/w), alginate (0.625% w/w), rehydrated supernatant (18 mg/ml), and glycerol. Films were used to wrap beef cubes inoculated with ≈103 CFU/g E. coli or L. monocytogenes. Sensory evaluation was carried out on grilled beef wrapped or not with the studied antimicrobial films. During refrigerated storage, antimicrobial films reduced 1.4 log10 CFU/g of L. monocytogenes after 120 h, while E. coli decreased 2.3 log10 CFU/g after 36 h. Grilled beef wrapped with antimicrobial film was well accepted by panelists, besides scores evidenced no significant differences (p > 0.05) between wrapped and unwrapped beef.