Digestion of waste bananas to generate energy in Australia.

This paper presents results from laboratory studies to measure the methane yield and rate of digestion of reject bananas. These parameters were determined in experiments that took into account the likely configuration of a full-scale plant in the banana growing region of north Queensland. The digestion was conducted in a 200-l reactor using fed-batch operation, relying entirely on the natural microbial consortia on the reject bananas to avoid reliance on external inocula such as sludge, an undesirable material around food packaging facilities. An enrichment culture was first established in a highly buffered 200-l batch digestion unit. The fed-batch digester was then started by exchanging leachate with the mature batch reactor. Under loading conditions of 0.6 kg VS m(-3)d(-1) over 70 days where the average working volume was 160 l, the digester produced 398+/-20 l CH4 kg VS(-1). Increasing the loading rate to 1.6 kg VS m(-3)d(-1) resulted in a reduced methane yield of 210 l CH4 kg VS(-1) over 23 days of operation, with a concomitant accumulation of banana waste in the digester. The leachate at the end of digestion contained over 4000 mg l(-1)K, 200 mg l(-1) N and 75 mg l(-1), levels that exceed acceptable limits for general agricultural irrigation.

Cellulolytic activity in leachate during leach-bed anaerobic digestion of municipal solid waste.

The degradation of municipal solid waste (MSW) under mesophilic conditions can be enhanced by exchanging leachate between fresh waste and stabilised waste. The optimum point in time when leachate from an anaerobically digesting waste bed can be used to initiate degradation of another waste bed might occur when the leachate of the digesting waste bed is highly active with cellulolytic and methanogenic bacteria. In this study, the cellulolytic activity of the leachate was measured using the cellulose-azure assay. As products of hydrolysis are soluble compounds, the rate of generation of these compounds was estimated based on a soluble chemical oxygen demand (SCOD) balance around the fresh waste bed. It was found that once the readily soluble material present in MSW was washed out there was very little generation of SCOD without the production of methane, indicating that flushing leachate from a stabilised waste bed resulted in a balanced inoculation of the fresh waste bed. With the onset of sustained methanogenesis, the rate of SCOD generation equalled the SCOD released from the digester as methane. The experimental findings also showed that cellulolytic activities of the leachate samples closely followed the trend of SCOD generation. reserved.