Behavior of lyophilized biological valves in a chronic animal model.

Glutaraldehyde is used in order to improve the mechanical and immunogenic properties of biological tissues, such as bovine pericardium membranes, used to manufacture heart valve bioprostheses. Lyophilization, also known as freeze-drying, preserves biological material without damage by freezing the water content and removing ice by sublimation. Through this process, dehydrated products of high quality may be obtained; also, the material may be easily handled. The lyophilization process reduces aldehyde residues in biological tissue previously treated with glutaraldehyde, thus promoting reduction of cytotoxicity, increasing resistance to inflammation, and possibly decreasing the potential for tissue calcification. The objective of this study was to chronically evaluate the calcification of bovine pericardium heart valve prostheses, previously lyophilized or not, in an animal model. Six-month-old sheep received implants of lyophilized and unlyophilized heart valve prostheses in the pulmonary position with right bypass. The study followed 16 animals for a period of 90 days. Right ventricle-pulmonary artery (RV/PA) transvalvular pressure gradient was evaluated before and immediately after implantation and before explantation, as were tissue calcium, inflammation intensity, and thrombosis and pannus formation. The t-test was used for statistical analysis. Twelve animals survived to the end of the experiment, but one of the animals in the control group had endocarditis and was excluded from the data. Four animals died early. The mean RV/PA gradient on implantation was 2.0 ± 1.6 mm Hg in the control group and 6.2 ± 4.1 mm Hg in the lyophilized group (P = 0.064). This mean gradient increased at explantation to 7.7 ± 3.9 mm Hg and 8.6 ± 5.8 mm Hg, respectively (P = 0.777). The average calcium content in the tissue leaflets after 3 months was 21.6 ± 39.1 mg Ca(2+)/g dry weight in the control group, compared with an average content of 41.2 ± 46.9 mg Ca(2+)/g dry weight in the lyophilized group (P = 0.478). In this experimental study there was no reduction of calcification after lyophilization. However, histological analysis showed less inflammation over the lyophilized tissue when compared with the control.

Proposição de método simples e barato para o estudo dinâmico da sudorese na pele restaurada pós-queimaduras de segundo grau / Proposal of simple and inexpensive method for the dynamic study of sweating in skin restored after second-degree burns

Introdução: Um sistema integrado para estimular a sudorese e avaliá-la dinâmica e continuadamente com o uso de gravação digital é descrito nesse artigo. Método: Consiste de um pequeno aparelho portátil para estimular a sudorese, funcionando a bateria de 9 volts. As gotas de suor produzidas são monitoradas e podem ser sequencialmente fotografadas ou continuadamente gravadas em vídeo digital por câmera posicionada a certa distância da pele. As imagens são então analisadas por um programa de computador capaz de contar as gotas em momentos específicos, podendo-se acompanhar o desenvolvimento delas até sua confluência. Conclusão: O pequeno tamanho e peso do equipamento fazem-no facilmente transportável. É possível, assim, a gravação continuada e análise dinâmica da sudorese, utilizando um método nacional, simples, barato e pouco trabalhoso.

Introduction: An integrated system to stimulate sweating and evaluate it through dynamic and continuous digital recording is described in this article. Methods: It consists of a small portable device to stimulate sweating, running a 9-volt battery. The drops of sweat produced are monitored and can be photographed sequentially or continuously recorded on digital video by camera positioned at some distance from the skin. The images are then analyzed by software able of countingthe drops at specific time, being able to monitor their development to its confluence. Conclusion: The small size and weight make it easily transportable. It is thus possible to record continuous and dynamic analysis of sweating, using a national method, simple, cheap and not very laborious.

In vitro and in vivo evaluation of lyophilized bioprosthetic valve.

Freeze-drying of biological tissues allows for dry storage and gamma ray sterilization, which may improve their use as a medical prosthesis. The objective of this study was to evaluate the rehydration characteristics and hydrodynamic performance of prosthetic valves before and after lyophilization. Two size 23 bovine pericardium aortic valve prostheses from different manufacturers were evaluated in a Shelhigh (Union, NJ, USA) pulse duplicator (80 ppm, 5 L/min) before and after lyophilization. Flow and transvalvular pressure gradient were registered in vitro and in vivo, and images of opening and closing of the prosthesis were obtained in the pulse duplicator in a digital camera. Rehydration was evaluated by comparison of dry valve weight with valve weight after 15 min, and 1, 24, 48, and 72 h in saline solution, inside the pulse duplicator. In vivo performance was assessed by surgical implantation in Santa Inês young male sheep in the pulmonary position after 30 min rehydration with 0.9% saline. Transvalvular pressure gradient and flow measurements were obtained immediately after implantation and 3 months after surgery when valves were explanted. Captured images showed a change in the profile opening and closing of valve prosthesis after lyophilization. The gradient measured (in vitro) in two valves was 17.08 ± 0.57 and 18.76 ± 0.70 mm Hg before lyophilization, and 34.24 ± 0.59 and 30.40 ± 0.97 mm Hg after lyophilization. Rehydration of both lyophilized valves was approximately 82%. Drying changed the profile of the opening and closing of valve prostheses, and increased on average by 83% the gradient in vitro tests. The result of the in vivo tests suggests maintaining pressure levels of the animal with the lyophilized prostheses within acceptable levels.

A new approach to heart valve tissue engineering: mimicking the heart ventricle with a ventricular assist device in a novel bioreactor.

The 'biomimetic' approach to tissue engineering usually involves the use of a bioreactor mimicking physiological parameters whilst supplying nutrients to the developing tissue. Here we present a new heart valve bioreactor, having as its centrepiece a ventricular assist device (VAD), which exposes the cell-scaffold constructs to a wider array of mechanical forces. The pump of the VAD has two chambers: a blood and a pneumatic chamber, separated by an elastic membrane. Pulsatile air-pressure is generated by a piston-type actuator and delivered to the pneumatic chamber, ejecting the fluid in the blood chamber. Subsequently, applied vacuum to the pneumatic chamber causes the blood chamber to fill. A mechanical heart valve was placed in the VAD's inflow position. The tissue engineered (TE) valve was placed in the outflow position. The VAD was coupled in series with a Windkessel compliance chamber, variable throttle and reservoir, connected by silicone tubings. The reservoir sat on an elevated platform, allowing adjustment of ventricular preload between 0 and 11 mmHg. To allow for sterile gaseous exchange between the circuit interior and exterior, a 0.2 µm filter was placed at the reservoir. Pressure and flow were registered downstream of the TE valve. The circuit was filled with culture medium and fitted in a standard 5% CO(2) incubator set at 37 °C. Pressure and flow waveforms were similar to those obtained under physiological conditions for the pulmonary circulation. The 'cardiomimetic' approach presented here represents a new perspective to conventional biomimetic approaches in TE, with potential advantages.

Natural and prosthetic heart valve calcification: morphology and chemical composition characterization.

Calcification is the most common cause of damage and subsequent failure of heart valves. Although it is a common phenomenon, little is known about it, and less about the inorganic phase obtained from this type of calcification. This article describes the scanning electron microscopy (SEM)/energy dispersive X-ray spectroscopy and Ca K-edge X-ray absorption near edge structure (XANES) characterization performed in natural and bioprosthetic heart valves calcified in vivo (in comparison to in vitro-calcified valves). SEM micrographs indicated the presence of deposits of similar morphology, and XANES results indicate, at a molecular level, that the calcification mechanism of both types of valves are probably similar, resulting in formation of poorly crystalline hydroxyapatite deposits, with Ca/P ratios that increase with time, depending on the maturation state. These findings may contribute to the search for long-term efficient anticalcification treatments.

Effect of freeze-drying on the mechanical, physical and morphological properties of glutaraldehyde-treated bovine pericardium: evaluation of freeze-dried treated bovine pericardium properties.

PURPOSE: Biomaterials have been widely used in the field of regenerative medicine. Bovine pericardium tissue has been successfully used as a bioprosthetic material in manufacturing heart valves, but studies concerning the tissue are ongoing in order to improve its storage, preservation and transportation. This article provides an overview of the characteristics of bovine pericardium tissue chemically treated after the freeze-drying process. These characteristics are essential to evaluate the changes or damage to the tissue during the process. METHODS: The mechanical properties of the tissue were analyzed by three different methods due to its anisotropic characteristics. The physical properties were analyzed by a colorimetric method, while the morphological properties were evaluated by scanning electron microscopy (SEM). RESULTS: The freeze-dried bovine pericardium showed no significant change in its mechanical properties. There was no significant change in the elasticity of the tissue (p>0.05) and no color change. In addition, SEM analysis showed that the freeze-dried samples did not suffer structural collapse. CONCLUSIONS: It was concluded that glutaraldehyde-treated bovine pericardium tissue showed no significant change in its properties after the freeze-drying process.

Prospects in lyophilization of bovine pericardium.

Almost 30 years after the introduction of heart valve prostheses patients worldwide are benefiting from the implant of these devices. Among the various types of heart valves, the ones made of treated bovine pericardium have become a frequently used replacement of the heart's native valve. Lyophilization, also known as freeze-drying, is an extremely useful technique for tissue storage for surgical applications. This article gives a brief overview on the current bovine pericardium lyophilization development, including the chemical modification to improve physical-chemical characteristics and the advanced technologies used to guarantee a high-quality product. It was shown that lyophilization process can be successfully applied as a method of bovine pericardium preservation and also as a technological tool to prepare new materials obtained by chemical modification of native tissues.

Cavopulmonary anastomosis improves left ventricular assist device support in acute biventricular failure.

OBJECTIVE: Right ventricular failure during left ventricular assist device (LVAD) support can result in severe hemodynamic compromise with high mortality. This study investigated the acute effects of cavopulmonary anastomosis on right ventricular loading and LVAD performance in a model of severe biventricular failure. METHODS: LVAD support was performed by means of centrifugal pump implantation in 14 anesthetized dogs (20-30 kg) with severe biventricular failure obtained by ventricular fibrillation induction. Animals were randomized to be submitted to classical cavopulmonary anastomosis (Glenn shunt) or to control group and were maintained under LVAD support for 2h. Left and right atrial, right ventricular and systemic pressures were monitored, while total pulmonary flow was simultaneously recorded by transonic flowmeters located on the superior vena cava and pulmonary trunk. Blood gas and venous lactate determinations were also obtained. RESULTS: Ventricular fibrillation maintenance resulted in acute LVAD performance impairment after 90 min in the control group, while animals with Glenn circuit maintained normal LVAD pump flow (55+/-13 ml kg(-1)min(-1) vs 21+/-4 ml kg(-1)min(-1), p<0.001) and better peripheral perfusion (blood lactate of 29+/-10 pg/ml vs 46+/-9 pg/ml, p<0.001). Left and right atrial pressures did not change significantly, while right ventricular pressure was lower in animals with Glenn circuit (13+/-3 mm Hg vs 22+/-8 mm Hg, p=0.005). Right ventricular unloading with Glenn shunt also resulted in superior total pulmonary flow (59+/-13 ml kg(-1)min(-1) vs 17+/-3 ml kg(-1)min(-1), p<0.001). CONCLUSION: The concomitant use of cavopulmonary anastomosis during LVAD support in a model of severe biventricular failure limited right ventricular overloading and resulted in better hemodynamic performance.

Desempenho hemodinâmico e resposta inflamatória durante o uso do DAV-InCor como ponte para o transplante / Hemodynamic performance and inflammatory response during the use of VAD-InCor as a bridge to transplant

FUNDAMENTO: O transplante cardíaco enfrenta o grave problema da escassez de doadores. Estima-se que entre 20 por cento e 40 por cento dos pacientes falecem na fila de espera. Para esses pacientes, a utilização de dispositivos de assistência circulatória é, muitas vezes, a única possibilidade de sobrevivência durante a espera do doador. No Brasil, não existe nenhum programa regular de utilização desses dispositivos como ponte para transplante. OBJETIVO: Avaliar o desempenho hemodinâmico e a resposta inflamatória durante a utilização do DAV-InCor como ponte para transplante. MÉTODOS: Entre outubro de 2003 e abril de 2006, 11 pacientes, indicados em caráter de prioridade para o transplante cardíaco, evoluíram em choque cardiogênico refratário. O implante do DAV-InCor foi realizado em sete pacientes. O diagnóstico etiológico foi cardiopatia chagásica em cinco pacientes e cardiomiopatia dilatada idiopática em dois. RESULTADOS: A assistência mecânica ao ventrículo esquerdo foi mantida nos sete pacientes por períodos entre 14 e 42 dias (média 26,2). O desempenho hemodinâmico foi adequado, com a normalização do índice cardíaco, dos níveis de saturação venosa de O2 e do lactato. O transplante foi realizado em dois pacientes, os outros cinco faleceram por infecção sistêmica ou falência de múltiplos órgãos. CONCLUSÃO: O desempenho do DAV-Incor, no comportamento hemodinâmico dos pacientes estudados, foi adequado para a manutenção de uma condição circulatória satisfatória durante o período estudado. Houve melhora dos parâmetros de perfusão tecidual e manutenção de sinais de resposta inflamatória sistêmica. Houve alta incidência de complicações; contudo, não foram demonstradas complicações relacionadas ao dispositivo que comprometam a segurança da utilização do mesmo.

BACKGROUND: Cardiac transplantation faces the serious problem of lack of donors and it is estimated that 20 to 40 percent of the patients die while waiting for heart transplantation. For these patients, the use of mechanical circulatory assist devices is the only choice of survival while waiting for a donor. In Brazil, the experience with mechanical circulatory support is limited and there is no regular program regarding the use of these devices as a bridge to heart transplantation. OBJECTIVE: To evaluate the hemodynamic performance and the systemic inflammatory response during the clinical use of the InCor-type ventricular assist device (VAD-InCor) as a bridge to heart transplantation. METHODS: Between October 2003 and April 2006, 11 patients in the waiting list for heart transplantation presented hemodynamic deterioration due to refractory cardiogenic shock. Seven of these patients were submitted to VAD-InCor implantation for left ventricular assistance. The etiologic diagnosis was Chagas' disease in 5 patients and idiopathic dilated cardiomyopathy in 2. RESULTS: The duration of left ventricular assistance ranged from 14 to 42 days (mean 26.2 days). During this period, the hemodynamic performance of the DAV-InCor was adequate to support a normal hemodynamic state. There was normalization of central venous oxygen saturation and serum lactate. Two patients were submitted to heart transplantation, while the other 5 patients died under assistance due to infection and multiple organ failure. CONCLUSION: The performance of the VAD-InCor, in the hemodynamic behavior of the studied patients, was adequate for the maintenance of a satisfactory circulatory state during the studied period. There was improvement in the tissue perfusion parameters and maintenance of systemic inflammatory response signs. There was a high incidence of complications; however, complications related to the device, which could compromise the safety of its use, were not demonstrated.

Histological evaluation of biocompatibility of lyophilized bovine pericardium implanted subcutaneously in rats.

This article aims at investigating in vivo evaluation of lyophilization procedure on the biocompatibility of bovine pericardium treated with glutaraldehyde (GA). The bovine pericardium was fixed with 0.5% glutaraldehyde during 10 days and preserved in 4% formaldehyde (FA). Two groups of samples were prepared from treated membranes: Group 1, nonlyophilized samples and Group 2, lyophilized samples. Male Sprague-Dawley rats (4 weeks after birth) were anesthetized (pentobarbital sodium 25 mg/kg of body weight) and in each one were implanted subcutaneously in the dorsal region a sample from Group 1 and another from Group 2. These samples were explanted after 30 days for histological analysis. No intercurrences took place after the surgery. No differences (P > 0.05) in the calcification, granulomatous reaction, mononuclear infiltration, and granulation tissue development was observed between both groups. The implanted lyophilized samples presented a trend for a reduced inflammatory reaction. Lyophilization of the bovine pericardium does not seem to increase the above listed tissue reaction.

Cytotoxicity and genotoxicity of bovine pericardium preserved in glycerol.

Bovine pericardium is a widely utilized biomaterial. Usually, after harvesting, it is advantageous that the pericardium be immersed in glycerol to improve its shelf life. This can induce some degree of toxicity in the material. The studies were performed in compliance with the rules of ISO 10993 and OECD 487, in the biological evaluation of medical devices. The material was prepared without previous washing. After sterilization by gamma radiation the pericardium was immersed in RPMI 1640 culture medium to fulfill the extraction condition. The same extract was employed in the cytotoxic and genotoxic tests. The procedures were carried out with Chinese hamster ovary cell line and to determine the cytotoxicity, a colorimetric method with the tetrazolium compound MTS was used. For the genotoxicity, following the in vitro micronucleus assay, the test was developed with and without metabolic activation. The Cytotoxicity Index was graphically estimated at the extract concentration of 78%. In the genotoxicity test, the average value of cell proliferation index was found to be 1.62 +/- 0.02 with S9 metabolic activator and 1.91 +/- 0.01 without S9 metabolic activator. Both values are similar to the negative control value in the micronucleus assay. We observed that although the pericardium preserved in glycerol shows a certain level of cytotoxicity, it does not show any genotoxicity.

Hemodynamic performance and inflammatory response during the use of VAD-InCor as a bridge to transplant.

BACKGROUND: Cardiac transplantation faces the serious problem of lack of donors and it is estimated that 20 to 40% of the patients die while waiting for heart transplantation. For these patients, the use of mechanical circulatory assist devices is the only choice of survival while waiting for a donor. In Brazil, the experience with mechanical circulatory support is limited and there is no regular program regarding the use of these devices as a bridge to heart transplantation. OBJECTIVE: To evaluate the hemodynamic performance and the systemic inflammatory response during the clinical use of the InCor-type ventricular assist device (VAD-InCor) as a bridge to heart transplantation. METHODS: Between October 2003 and April 2006, 11 patients in the waiting list for heart transplantation presented hemodynamic deterioration due to refractory cardiogenic shock. Seven of these patients were submitted to VAD-InCor implantation for left ventricular assistance. The etiologic diagnosis was Chagas' disease in 5 patients and idiopathic dilated cardiomyopathy in 2. RESULTS: The duration of left ventricular assistance ranged from 14 to 42 days (mean 26.2 days). During this period, the hemodynamic performance of the DAV-InCor was adequate to support a normal hemodynamic state. There was normalization of central venous oxygen saturation and serum lactate. Two patients were submitted to heart transplantation, while the other 5 patients died under assistance due to infection and multiple organ failure. CONCLUSION: The performance of the VAD-InCor, in the hemodynamic behavior of the studied patients, was adequate for the maintenance of a satisfactory circulatory state during the studied period. There was improvement in the tissue perfusion parameters and maintenance of systemic inflammatory response signs. There was a high incidence of complications; however, complications related to the device, which could compromise the safety of its use, were not demonstrated.

Left ventricular circulatory support as bridge to heart transplantation in Chagas' disease cardiomyopathy.

This study was performed to assess the safety and feasibility of the implantation of ventricular assist devices (VADs) as a bridge to heart transplantation in patients with advanced biventricular failure due to Chagas' disease. Six patients were submitted to paracorporeal left VAD implantation, while right ventricular dysfunction was managed clinically. The mean time of circulatory support was 27 days. Two patients were bridged to heart transplantation successfully, while the other four patients died under assistance with complications that correlated with the final situation of multiple organ failure. Nevertheless, persistent right ventricular dysfunction was observed only in one patient who survived more than 15 days, despite the general significant preoperative compromise of the right ventricle. This paradoxical observation indicates that left VAD implantation may be regarded as a valuable treatment option for patients with Chagas' disease cardiomyopathy who evolve with decompensated heart failure or cardiogenic shock.

Adenoviral expression of calmodulin antisense reduces hypertrophy in cultured cardiomyocytes.

Sustained myocardial hypertrophy is associated with an increased risk of sudden death and progression to heart failure. Multiple signal pathways are involved in cardiac hypertrophy and understanding their interaction may point to new therapeutic targets. In this work, we tested the hypothesis that adenovirus-mediated calmodulin (CaM) antisense expression will reduce the intracellular availability of CaM and inhibit the hypertrophic response. Three recombinant adenoviruses were constructed: AdASCaM, containing the AntiSense sequence of CaM and the enhanced green fluorescent protein (GFP) coding sequence; AdCaM, containing the coding sequence of CaM and the GFP sequence; and the AdGFP, containing the GFP coding sequence. Neonatal rat ventricular cardiomyocytes were infected with AdASCaM, AdCaM, or AdGFP and stimulated with phenylephrine (PE, 50 microM) or angiotensin II (AngII, 10 microM) for 48 h and cell surface area measured with planimetry. After PE treatment, the surface areas of cardiomyocytes infected with AdASCaM or AdGFP were 411 +/- 174.3 micro(2) and 832.6 +/- 372.3 micro(2), respectively (P < 0.01). After AngII treatment, the surface areas of cardiomyocytes infected with AdASCaM or AdGFP were 441.5 +/- 149.2 micro(2) and 726 +/- 328.3 micro(2), respectively (P < 0.01). Adenoviral expression of the CaM antisense (AdASCaM) significantly inhibited PE or AngII-induced cardiomyocyte hypertrophy. Cardiomyocytes infected with the AdCaM showed increased area when compared with those infected with the AdGFP. These results suggest that adenovirus-mediated changes in CaM expression may alter hypertrophy in cardiac myocytes.

Lyophilized bovine pericardium treated with a phenethylamine-diepoxide as an alternative to preventing calcification of cardiovascular bioprosthesis: preliminary calcification results.

This study investigated the calcification process that occurred on chemically treated bovine pericardium substrata through tests with simulated body fluid solutions. The use of bovine pericardium bioprosthetic valves in heart valve surgery has a significant drawback due to the calcification processes. Thus, many routes such as chemical treatments in the substratum or the adoption of systemic therapies are considered in the literature with the intention to inhibit or to decelerate this process. The presented treatment using the two different phenetylamine-diepoxide solutions showed no effects on calcification experiments as showed by the tests. However, the lyophilized bovine pericardium samples, treated with both solutions, did not show any detectable phosphate deposits. The lyophilization of bovine pericardium before chemical treatments with cross-link agents as epoxy compounds may be an alternative to the conventional calcification prevention methods, but further investigations are recommended to check if the same behavior is found in all lyophilized systems.