Readministration of high-dose adeno-associated virus gene therapy vectors enabled by ImmTOR nanoparticles combined with B cell-targeted agents.

Tolerogenic ImmTOR nanoparticles encapsulating rapamycin have been demonstrated to mitigate immunogenicity of adeno-associated virus (AAV) gene therapy vectors, enhance levels of transgene expression, and enable redosing of AAV at moderate vector doses of 2 to 5E12 vg/kg. However, recent clinical trials have often pushed AAV vector doses 10-fold to 50-fold higher, with serious adverse events observed at the upper range. Here, we assessed combination therapy of ImmTOR with B cell-targeting drugs for the ability to increase the efficiency of redosing at high vector doses. The combination of ImmTOR with a monoclonal antibody against B cell activation factor (aBAFF) exhibited strong synergy leading to more than a 5-fold to 10-fold reduction of splenic mature B cells and plasmablasts while increasing the fraction of pre-/pro-B cells. In addition, this combination dramatically reduced anti-AAV IgM and IgG antibodies, thus enabling four successive AAV administrations at doses up to 5E12 vg/kg and at least two AAV doses at 5E13 vg/kg, with the transgene expression level in the latter case being equal to that observed in control animals receiving a single vector dose of 1E14 vg/kg. Similar synergistic effects were seen with a combination of ImmTOR and a Bruton's tyrosine kinase inhibitor, ibrutinib. These results suggest that ImmTOR could be combined with B cell-targeting agents to enable repeated vector administrations as a potential strategy to avoid toxicities associated with vector doses above 1E14 vg/kg.

Rapamycin nanoparticles increase the therapeutic window of engineered interleukin-2 and drive expansion of antigen-specific regulatory T cells for protection against autoimmune disease.

Interleukin-2 (IL-2) therapies targeting the high affinity IL-2 receptor expressed on regulatory T cells (Tregs) have shown promising therapeutic benefit in autoimmune diseases through nonselective expansion of pre-existing Treg populations, but are potentially limited by the inability to induce antigen-specific Tregs, as well as by dose-limiting activation of effector immune cells in settings of inflammation. We recently developed biodegradable nanoparticles encapsulating rapamycin, called ImmTOR, which induce selective immune tolerance to co-administered antigens but do not increase total Treg numbers. Here we demonstrate that the combination of ImmTOR and an engineered Treg-selective IL-2 variant (termed IL-2 mutein) increases the number and durability of total Tregs, as well as inducing a profound synergistic increase in antigen-specific Tregs when combined with a target antigen. We demonstrate that the combination of ImmTOR and an IL-2 mutein leads to durable inhibition of antibody responses to co-administered AAV gene therapy capsid, even at sub-optimal doses of ImmTOR, and provides protection in autoimmune models of type 1 diabetes and primary biliary cholangitis. Importantly, ImmTOR also increases the therapeutic window of engineered IL-2 molecules by mitigating effector immune cell expansion and preventing exacerbation of disease in a model of graft-versus-host-disease. At the same time, IL-2 mutein shows potential for dose-sparing of ImmTOR. Overall, these results establish that the combination of ImmTOR and an IL-2 mutein show synergistic benefit on both safety and efficacy to provide durable antigen-specific immune tolerance to mitigate drug immunogenicity and to treat autoimmune diseases.

Phase 2 Dose-Finding Study in Patients with Gout Using SEL-212, a Novel PEGylated Uricase (SEL-037) Combined with Tolerogenic Nanoparticles (SEL-110).

INTRODUCTION: SEL-212 is a developmental treatment for uncontrolled gout characterized by serum uric acid (sUA) levels ≥ 6 mg/dl despite treatment. It comprises a novel PEGylated uricase (SEL-037; also called pegadricase) co-administered with tolerogenic nanoparticles containing sirolimus (rapamycin) (SEL-110; also called ImmTOR®), which mitigates the formation of anti-drug antibodies (ADAs) against uricase and SEL-037 (PEGylated uricase), thereby enabling sustained sUA control (sUA < 6 mg/dl). The aim of this study was to identify appropriate dosing for SEL-037 and SEL-110 for use in phase 3 clinical trials. METHODS: This open-label phase 2 study was conducted in adults with symptomatic gout and sUA ≥ 6 mg/dl. Participants received five monthly infusions of SEL-037 (0.2 or 0.4 mg/kg) alone or in combination with three or five monthly infusions of SEL-110 (0.05-0.15 mg/kg). Safety, tolerability, sUA, ADAs, and tophi were monitored for 6 months. RESULTS: A total of 152 adults completed the study. SEL-037 alone resulted in rapid sUA reductions that were not sustained beyond 30 days in most participants due to ADA formation and loss of uricase activity. Levels of ADAs decreased with increasing doses of SEL-110 up to 0.1 mg/kg, with anti-uricase titers < 1080 correlating with sustained sUA control and reductions in tophi. Overall, 66% of evaluable participants achieved sUA control at week 20 following five monthly doses of SEL-037 0.2 mg/kg + SEL-110 0.1-0.15 mg/kg, whereas only 26% achieved sUA control at week 20 when SEL-110 was withdrawn after week 12. Compared to other dose combinations, SEL-037 0.2 mg/kg + SEL-110 0.15 mg/kg achieved the greatest sUA control at week 12 and was well-tolerated with no safety concerns. CONCLUSION: Results provide continued support for the use of multiple monthly administrations of SEL-037 0.2 mg/kg + SEL-110 0.1-0.15 mg/kg in clinical trials for SEL-212. TRIAL REGISTRATION: ClinicalTrials.gov identifier, NCT02959918.

Tolerogenic nanoparticles mitigate the formation of anti-drug antibodies against pegylated uricase in patients with hyperuricemia.

Biologic drugs have transformed the standard of care for many diseases. However, many biologics induce the formation of anti-drug antibodies (ADAs), which can compromise their safety and efficacy. Preclinical studies demonstrate that biodegradable nanoparticles-encapsulating rapamycin (ImmTOR), but not free rapamycin, mitigate the immunogenicity of co-administered biologic drugs. Here we report the outcomes from two clinical trials for ImmTOR. In the first ascending dose, open-label study (NCT02464605), pegadricase, an immunogenic, pegylated uricase enzyme derived from Candida utilis, is assessed for safety and tolerability (primary endpoint) as well as activity and immunogenicity (secondary endpoint); in the second single ascending dose Phase 1b trial (NCT02648269) composed of both a double-blind and open-label parts, we evaluate the safety of ImmTOR (primary endpoint) and its ability to prevent the formation of anti-drug antibodies against pegadricase and enhance its pharmacodynamic activity (secondary endpoint) in patients with hyperuricemia. The combination of ImmTOR and pegadricase is well tolerated. ImmTOR inhibits the development of uricase-specific ADAs in a dose-dependent manner, thus enabling sustained enzyme activity and reduction in serum uric acid levels. ImmTOR may thus represent a feasible approach for preventing the formation of ADAs to a broad range of immunogenic biologic therapies.

ImmTOR nanoparticles enhance AAV transgene expression after initial and repeat dosing in a mouse model of methylmalonic acidemia.

A major barrier to adeno-associated virus (AAV) gene therapy is the inability to re-dose patients due to formation of vector-induced neutralizing antibodies (Nabs). Tolerogenic nanoparticles encapsulating rapamycin (ImmTOR) provide long-term and specific suppression of adaptive immune responses, allowing for vector re-dosing. Moreover, co-administration of hepatotropic AAV vectors and ImmTOR leads to an increase of transgene expression even after the first dose. ImmTOR and AAV Anc80 encoding the methylmalonyl-coenzyme A (CoA) mutase (MMUT) combination was tested in a mouse model of methylmalonic acidemia, a disease caused by mutations in the MMUT gene. Repeated co-administration of Anc80 and ImmTOR was well tolerated and led to nearly complete inhibition of immunoglobulin (Ig)G antibodies to the Anc80 capsid. A more profound decrease of plasma levels of the key toxic metabolite, plasma methylmalonic acid (pMMA), and disease biomarker, fibroblast growth factor 21 (FGF21), was observed after treatment with the ImmTOR and Anc80-MMUT combination. In addition, there were higher numbers of viral genomes per cell (vg/cell) and increased transgene expression when ImmTOR was co-administered with Anc80-MMUT. These effects were dose-dependent, with the higher doses of ImmTOR providing higher vg/cell and mRNA levels, and an improved biomarker response. Combining of ImmTOR and AAV can not only block the IgG response against capsid, but it also appears to potentiate transduction and enhance therapeutic transgene expression in the mouse model.

Enhancement of liver-directed transgene expression at initial and repeat doses of AAV vectors admixed with ImmTOR nanoparticles.

Systemic AAV (adeno-associated virus) gene therapy is a promising approach for the treatment of inborn errors of metabolism, but questions remain regarding its potency and durability. Tolerogenic ImmTOR nanoparticles encapsulating rapamycin have been shown to block the formation of neutralizing anti-capsid antibodies, thereby enabling vector re-administration. Here, we further demonstrate that ImmTOR admixed with AAV vectors also enhances hepatic transgene expression at the initial dose of AAV vector, independent of its effects on adaptive immunity. ImmTOR enhances AAV trafficking to the liver, resulting in increased hepatic vector copy numbers and transgene mRNA expression. Enhanced transgene expression occurs through a mechanism independent of the AAV receptor and cannot be replicated in vivo with free rapamycin or empty nanoparticles. The multipronged mechanism of ImmTOR action makes it an attractive candidate to enable more efficient transgene expression at first dose while simultaneously inhibiting adaptive responses against AAV to enable repeat dosing.

One mouse, one pharmacokinetic profile: quantitative whole blood serial sampling for biotherapeutics.

PURPOSE: The purpose of this study was to validate the approach of serial sampling from one mouse through ligand binding assay (LBA) quantification of dosed biotherapeutic in diluted whole blood to derive a pharmacokinetic (PK) profile. METHODS: This investigation compared PK parameters obtained using serial and composite sampling methods following administration of human IgG monoclonal antibody. The serial sampling technique was established by collecting 10 µL of blood via tail vein at each time point following drug administration. Blood was immediately diluted into buffer followed by analyte quantitation using Gyrolab to derive plasma concentrations. Additional studies were conducted to understand matrix and sampling site effects on drug concentrations. RESULTS: The drug concentration profiles, irrespective of biological matrix, and PK parameters using both sampling methods were not significantly different. There were no sampling site effects on drug concentration measurements except that concentrations were slightly lower in sodium citrated plasma than other matrices. CONCLUSIONS: We recommend the application of mouse serial sampling, particularly with limiting drug supply or specialized animal models. Overall the efficiencies gained by serial sampling were 40-80% savings in study cost, animal usage, study length and drug conservation while inter-subject variability across PK parameters was less than 30%.

Pharmacokinetics of anti-IL17A and anti-IL22 peptide-antibody bispecific genetic fusions in mice.

The peptide-antibody (Ab) genetic fusion is a promising technology for targeting multiple antigens in a single Ab-like molecule. We have recently described generation and in vitro characterization of several such genetic fusions, using an interleukin (IL)-17A binding peptide and an anti-IL-22 Ab as a model system. In this study we assessed pharmacokinetic profiles of these model genetic fusions in mice. Specifically an IL-17A binding peptide was fused to either the heavy chain or both the heavy and the light chains of an anti-IL22 human IgG1 (referred to Compounds 1 or 2, respectively). Swiss Webster mice were given a single 10 mg/kg IV dose of Compound 1 or Compound 2 and serum concentrations were measured by a fused molecule immunoassay, in which IL-17A was used as a capture and anti-human IgG was used as a detector. In addition, serum samples were assayed using a total human IgG immunoassay. PK parameters were calculated by non-compartmental modeling. The two genetic fusions had similar PK profiles, with total body clearance of ~0.9-1.0 mL/h/kg, volume of distribution at steady-state of ~63-65 mL/kg, and elimination half-life of ~40 h. Our study provides the first characterization of the PK properties of peptide-Ab genetic fusions and suggests that although these genetic fusions appear to be eliminated faster than a typical Ab, the PK profile may be suitable for preclinical and clinical testing.

Automate it: ligand-binding assay productivity in a discovery bioanalytical setting.

In multiple industries, including the biopharmaceutical industry, automation is synonymous with increased productivity. Environments with high-throughput needs commonly employ automation for efficiency. However, in a discovery bioanalytical ligand-binding assay laboratory setting where the focus is not necessarily on sample analysis throughput, but instead on assay development and characterization, is automation applicable? Can automation enhance productivity when tasks are more customized than routine? In this Perspective we review the different categories of automation with ligand-binding assays with these questions in mind. In considering whether automation technology has progressed far enough to result in a positive return in investment in the discovery setting, the resource investment required to operate in this space was contrasted with the gain in productivity. In our opinion, technology advancements in automated technology platforms, and especially personal automation, have allowed these categories to strike the right balance for investment in the discovery laboratory setting.

Use of response surface methods and path of steepest ascent to optimize ligand-binding assay sensitivity.

Response surface methods (RSM) combined with a steepest ascent approach is a powerful technique to optimize assay performance. In this case, a ligand-binding assay (LBA) to quantitate a peptide biotherapeutic was optimized for improved sensitivity using this technique. Conditions were elucidated to enable pg/mL quantitation of the peptide in human plasma using steepest ascent to efficiently optimize assay factors. Instead of relying solely on assay development experience and intuition to improve assay sensitivity, this systematic approach takes advantage of a predictive mathematical model generated through response surface methods that defines a specific path towards greater predicted assay sensitivity. The actual response observed along the steepest ascent path was in good agreement with the model for several steps, until reagent concentrations moved beyond the physical limits of the system, and model breakdown occurred. RSM combined with steepest ascent method proved a useful tool for sensitivity optimization in three ways: (1) The required LBA sensitivity performance (approximately 200 pg/mL), measured as a signal-to-noise ratio (SNR) at the targeted lower limit of quantitation (LLOQ), was efficiently achieved in only two optimization experiments; (2) Steepest ascent confirmed that the desired sensitivity was found within the initial RSM design space, and no further gain in sensitivity was found venturing beyond this design space along the steepest ascent path; (3) The desired assay sensitivity was maintained over a reasonable range of reagent concentrations along the steepest ascent path, indicating assay robustness for this parameter.