Novel gels and films to mask boar taint in entire male pork.

Boar taint masking strategies were developed using hydrocolloids and spices to produce edible gels and films. Carrageenan (G1) and agar-agar (G2) were used for the gels and gelatin (F1) and alginate+maltodextrin (F2) for the films. The strategies were applied to both castrated (control) and entire male pork with high levels of androstenone and skatole. The samples were evaluated sensorially by a trained tasting panel through quantitative descriptive analysis (QDA). Lower hardness and chewiness of entire male pork, with high levels of boar taint compounds object of study, were found with the carrageenan gel, due to the better carrageenan gel adherence to the loin. The films showed that the gelatin strategy tended to have a certain "sweet" taste, and a higher overall masking than the alginate+maltodextrin film. In conclusion, a trained tasting panel found that gelatin film masked boar taint the most, followed by the alginate+maltodextrin film and the carrageenan-based gel.

Spanish Fuet Sausages Fat-Reduced to Diminish Boar Taint: Sensory and Technological Quality.

Reduced-fat cured sausages were evaluated as a strategy to reduce boar taint in entire male pork products with high levels of androstenone and skatole, both lipophilic. Three fuet-type sausages (two replicates each) were developed: the control (C) (60% lean, 33.69% fat), and two reduced-fat (60% lean 21.19% fat) products; R1, 6% inulin, 0.5% ß-glucan and R2, 3% inulin, 0.5% grape skin and 1% ß-glucan. All of them were prepared from entire male pork with an androstenone concentration of 6.887 µg/g and 0.520 µg/g of skatole. Significant differences (p ≤ 0.001) in the moisture content were described between the fuet R1 and the C and R2, which obtained the highest percentage. Regarding the CIELAB, the C samples had the highest L* value, while the R2 sausages were the darkest. Boar taint was reduced in both R1 and R2, with a greater reduction in R2 (p ≤ 0.000). The addition of inulin and ß-glucan in fuet R1 provided a similar technological and sensory profile to C. However, both strategies provided a reduction of sexual odour, which was higher when grape skins were included. In addition, R2 gave a characteristic sausage with more odour and flavour, dark colour and overall rating than C and R1.

Can sensory boar taint levels be explained by fatty acid composition and emitted volatile organic compounds in addition to androstenone and skatole content?

This study aimed at understanding which molecules were responsible for the differences existing in boar taint sensory evaluation. The latter was therefore linked to the results of skatole and androstenone chemical analyses, fatty acid composition and VOC profiles of heated backfat. This study confirmed that some discrepancy exists between chemical analysis and sensory evaluation of tainted backfats. Significant correlations between human nose scores and fatty acid composition were not revealed. Strong correlations between emissions and contents in skatole and androstenone were found. Oxidation products of polyunsaturated fatty acids, with fatty odor descriptors, were found to be more present in the VOC profiles of boar fat considered untainted through the human nose methodology. Weak coefficient of determination for partial least square regression indicates that other factors, yet unknown, are responsible for sensory evaluation outcomes. These findings hence support the idea that high human nose score is mainly due to boar taint compounds rather than general differences in VOC profiles.

Use of Mediterranean By-Products to Produce Entire Male Large White Pig: Meat and Fat Quality.

A total of 70 male growing non-castrated pigs (Large White), with a 23.07 ± 2.87 kg average body weight (BW), were randomly allocated to three treatments in a 103 day trial: a CONTROL diet and two experimental diets, ALLIUM (5 g/kg of Allium spp. extract) and OLIVE (100 g/kg of olive pulp). Animals were slaughtered at 115 kg live body weight. Meat and fat quality were analyzed. Animals fed ALLIUM and OLIVE had higher water holding capacity (WHC) than those fed the control diet. No significant differences were observed between groups for cooking loss, drip losses and color CIELab. No antioxidant effect was observed on an oxygen radical absorbance capacity (ORAC) test. Animals fed OLIVE presented a more unsaturated fatty acid profile than CONTROL and ALLIUM. Meat from ALLIUM group and OLIVE showed her values of brightness and meat odor than CONTROL. Mean scores of sensory analyses (color, odor, flavor and juiciness) of cooked samples were similar for the three treatments, with the meat samples from the ALLIUM and OLIVE treatments being less hard. Consumers did not reflect a preference for any of the treatments. Both by-products could be used for pork production.

Effects of Dietary Rosemary Extract Supplementation on Pork Quality of Chato Murciano Breed during Storage.

(1) Background: The effect of Rosmarinus officinalis L. dietary supplementation on the pork meat quality of the Chato Murciano breed of pigs was evaluated during 21 days of storage. (2) Methods: Twenty-one castrated male pigs were divided into two groups. One group was fed a control diet (group C), and the other group consumed the same diet plus a 1000 ppm supplement of deodorized rosemary extract (group R). (3) Results: While the inclusion of rosemary extract in the pig diet did not produce notable changes in the technological parameters analysed in the meat, the lower microbiological count obtained in meat pointed to the antimicrobial effect of the extract. The storage time had a significant effect on all the parameters studied in both groups (C and R). Thus, lipid oxidation increased and the colour of the meat deteriorated, at the same time as the microbial counts and the deterioration of the sensory attributes increased. (4) Conclusions: Therefore, a certain antimicrobial effect of rosemary was observed in the meat of Chato Murciano.

Chemical analysis and sensory evaluation of honey produced by honeybee colonies fed with different sugar pastes.

Supplemental feeding of honeybee (Apis mellifera L.) colonies is essential for colony buildup. Honey samples obtained from feeding honey bee colonies with different commercial sugars, including sugar paste, sugar paste + vitamins +amino acids, and sugar paste + vitamins +protein as pollen substitute, were studied to determine the effects of feeding bees on the physicochemical and sensory characteristics of honey, compared with the honey produced by a control group (no supplemental feeding). Analyzed honey samples from the different groups were in accordance with the criteria described in Council directive 2001/110/CE, 2002. Elsewhere, significant differences (p > .05) were detected in color, free acidity, diastase activity, hydroxymethylfurfural, sugar profile, and conductivity between all honey. In terms of mineral content, the honey from hives faded with sugar paste + vitamins +protein and control group had higher values for Na, Mg, P, K, Ca, Mn, Fe, Cu, and Zn. Related to sensory analyses, no differences in flavor and basic taste were found in all analyzed honey (p > .05) independently the type of feeding. For the visual attributes, only differences were found for the color. Supplementary feeding with different sugar pastes and proteins does not affect the physicochemical characteristics of honey. For the sensory analyses, control sample presented significant differences only for color and chemical odor attributes compared with honey from bees receiving supplementation.

Nutritional Attributes and Sensory Quality during Storage Time of Spiced Lamb Burgers from Manchego Spanish Breed.

The aim of this study was to determine the effect of the addition of spices (garlic, rosemary, thyme, sage or clove) on the chemical and sensory characteristics of burgers elaborated with lamb meat from different locations (L: only leg; LNB 2/3 leg + 1/3 neck and breast). Formulation type (L vs. LNB) modified the chemical composition. L burgers showed lower values of fat, saturated fatty acids, monounsaturated fatty acids and higher moisture and polyunsaturated fatty acids content than LNB samples, with both types of burgers maintaining the nutritional indexes (P/S and n6/n3) within the recommended amounts. Nevertheless, the type of formula did not influence the sensory properties of lamb burgers. By contrast, the spice addition affected these characteristics over the period of time considered in this study. At the end of storage their global quality could be listed in the following order, from major to minor rate: Sage > Rosemary > Garlic > Thyme > Clove burgers.

Fat Replacement by Vegetal Fibres to Improve the Quality of Sausages Elaborated with Non-Castrated Male Pork.

Based on the need to find alternatives for the use of meat from non-castrated male pigs that contains high levels of androstenone and skatole, the production of meat products (raw and Frankfurt sausages) with reduced fat content was proposed, as these compounds are lipophilic. For this purpose, three batches of each product (total six) were produced. These included a control batch (1); normal fat content and two fat-reduced batches, where (2) fat was replaced with inulin and ß-glucan, or (3) fat was replaced with inulin and ß-glucan in addition to a skin grape by-product. These groups used meat from non-castrated male pigs that contained 6.25 µg/g androstenone and 0.4451 µg/g skatole. In general, fat-reduced sausages exhibited less brightness than did the controls. The texture results in Frankfurt were similar to those of the control, while Spanish sausage supplemented with grape skin exhibited reduced hardness. Both strategies resulted in a reduction in boar taint, and this reduction was up to 87.3% in raw sausages with grape by-products. Fat reduction could provide an interesting strategy to allow for the use of tainted meat from non-castrated male pigs.

The Use of Pork from Entire Male and Immunocastrated Pigs for Meat Products-An Overview with Recommendations.

Due to the strong public initiative in Europe and increased regulator focus to mitigate pain, surgical castration of pigs is being gradually abandoned, while the importance of other sex categories like entire males (EM) and immunocastrates (IC) increases. Although beneficial for animal welfare and economics, their use also brings forward several quality problems. Besides the occurrence of boar taint in EM, these include excessive carcass leanness, softer fat, meat color and pH deviations, inferior water holding capacity and increased meat toughness. In this paper, the raw material differences between the male sex categories and their influence on product quality are reviewed, and possible solutions are presented. Using EM for dried or thermally processed products may result in lower processing yields and inferior sensory quality, which may partially be prevented by applying specific processing adaptations. Immunocastration is a viable solution, especially when prolonging the vaccination to slaughter interval. Low to medium levels of boar taint can be effectively managed in most of the meat products, applying procedures like cooking, microbial inoculation or masking (by spices and especially smoking), while highly tainted material can be valorized only by combining various methods and/or with dilution of the tainted meat.

Reduction of androstenone perception in pan-fried boar meat by different masking strategies.

BACKGROUND: Consumers highly sensitive to androstenone María (AND) will probably reject meat from entire male pigs, which tends to have high levels of this hormone. To avoid this, the effect of different masking strategies (sprinkling with mixed spices or fennel, marinating and breading with garlic-parsley or curry) on the sensory parameters of pork loin chops obtained from entire animals with high levels of AND (1.0-2.9 mg kg-1 AND in fat) and castrated animals (<0.4 mg kg-1 AND in fat), both with low levels of skatole (<0.1 mg kg-1 skatole in fat) was investigated. RESULTS: The garlic-parsley breadcrumbs led to the highest reduction in the perception of AND compared with the other masking strategies used, and preserved the juiciness of the product. There was a negative correlation between AND and fat content. CONCLUSION: AND odor and flavor can be reduced in meat from entire male pigs by using suitable strategies, the best strategy being the garlic-parsley breadcrumbs. © 2017 Society of Chemical Industry.

A comparative study of the characteristics of French fries produced by deep fat frying and air frying.

Air frying is being projected as an alternative to deep fat frying for producing snacks such as French fries. In air frying, the raw potato sections are essentially heated in hot air containing fine oil droplets, which dehydrates the potato and attempts to impart the characteristics of traditionally produced French fries, but with a substantially lower level of fat absorbed in the product. The aim of this research is to compare: (1) the process dynamics of air frying with conventional deep fat frying under otherwise similar operating conditions, and (2) the products formed by the 2 processes in terms of color, texture, microstructure, calorimetric properties, and sensory characteristics. Although, air frying produced products with a substantially lower fat content but with similar moisture contents and color characteristics, it required much longer processing times, typically 21 min in relation to 9 min in the case of deep fat frying. The slower evolution of temperature also resulted in lower rates of moisture loss and color development reactions. Differential scanning calorimetry (DSC) studies revealed that the extent of starch gelatinization was also lower in the case of air fried product. In addition, the 2 types of frying also resulted in products having significantly different texture and sensory characteristics.

Efficacies of garlic and L. sakei in wine-based marinades for controlling Listeria monocytogenes and Salmonella spp. in Chouriço de Vinho, a dry sausage made from wine-marinated pork.

Chouriço de vinho is made from roughly minced (10 to 30 mm) pork and fat, seasoned with a marinade made from wine, salt, garlic, and other facultative seasonings used according to the recipe of each producer. The batter is maintained at 4 to 7 ºC for 24 to 48 h. It is then stuffed into natural thin pork gut, cold smoked and matured at a low temperature for 1 to 4 wk. The effect of garlic used in wine-based marinade and a starter culture of indigenous Lactobacillus sakei on the behavior of Listeria monocytogenes and Salmonella spp. in the processing of chouriço was investigated. The garlic (as powder and fresh juice) was found to contribute (P < 0.05) to the control of both pathogens in broth. Garlic dose, as tested within the usual limits used for seasoning, did not impact the reduction of pathogens. Garlic-wine-based marinade and a starter culture of indigenous L. sakei contribute to controlling L. monocytogenes and Salmonella spp. in the processing of chouriço. Their presence was responsible for the loss of viability of L. monocytogenes and Salmonella spp. following 5 d of drying, even sooner than situations where no garlic was used. The results of the present work show that the use of a wine-based marinade with garlic has an important role in ensuring the safety of the product.

Systems stunning with CO(2) gas on Manchego light lambs: Physiologic responses and stunning effectiveness.

Effect of four stunning treatments using different CO(2) concentrations and exposure times (G1: 80%90s; G2: 90%90s; G3: 90%60s; G4: 80%60s) on hormonal, haematological and biochemical parameters in Manchego breed light lambs and their stunning effectiveness (% animals correctly stunned) was studied. An electrically stunned control treatment (G5) was used. G1 showed the highest plasmatic hormonal, red cell distribution (RDW) and lactate levels. Haemoglobin, mean corpuscular volume (MCV), mean cell haemoglobin (HbCM), glucose, lactate deshydrogenase (LDH), sodium, potassium and creatine kinase (CK) were highest in G5. Stunning effectiveness was maximum (100%) in G3 and G5, only 50% in G1 and G2 and minimum (30%) in G4. A discriminant analysis showed a function for discriminating between G5 and the gas stunned groups, and another one for discriminating between gas stunned groups. Only potassium and adrenaline variables marked the difference among groups.