Mesoporous sol-gel silica supported vanadium oxide as effective catalysts in oxidative dehydrogenation of propane to propylene.

Vanadium oxide incorporated mesoporous silica (V-m-SiO2) were designed and synthesized using a surfactant-modified sol-gel method. Detailed characterization shows that monomeric [VO4] sites containing one terminal V[double bond, length as m-dash]O bond and three V-O-support bonds are dominated until atomic ratio of vanadium to silicon approaches to 5%. It is also confirmed that such V-m-SiO2 catalyst contains high proportion of vanadium oxide species interacting strongly with silica. Compared to vanadium oxide supported mesoporous silica (V/m-SiO2) prepared using a traditional impregnation method, present V-m-SiO2 catalyst exhibits more superior ability to catalyze oxidative dehydrogenation of propane to propylene. By correlation with structural data, superior catalytic performance of present V-m-SiO2 catalyst can be reasonably attributed, in part, to its favorable geometric and electronic properties rendered by the unique preparation method.

High-Yield Preparation of American Oyster Defensin (AOD) via a Small and Acidic Fusion Tag and Its Functional Characterization.

The marine peptide, American oyster defensin (AOD), is derived from Crassostrea virginica and exhibits a potent bactericidal effect. However, recombinant preparation has not been achieved due to the high charge and hydrophobicity. Although the traditional fusion tags such as Trx and SUMO shield the effects of target peptides on the host, their large molecular weight (12-20 kDa) leads to the yields lower than 20% of the fusion protein. In this study, a short and acidic fusion tag was employed with a compact structure of only 1 kDa. Following 72 h of induction in a 5 L fermenter, the supernatant exhibited a total protein concentration of 587 mg/L. The recombinant AOD was subsequently purified through affinity chromatography and enterokinase cleavage, resulting in the final yield of 216 mg/L and a purity exceeding 93%. The minimum inhibitory concentrations (MICs) of AOD against Staphylococcus aureus, Staphylococcus epidermidis, and Streptococcus galactis ranged from 4 to 8 µg/mL. Moreover, time-killing curves indicated that AOD achieved a bactericidal rate of 99.9% against the clinical strain S. epidermidis G-81 within 0.5 h at concentrations of 2× and 4× MIC. Additionally, the activity of AOD was unchanged after treatment with artificial gastric fluid and intestinal fluid for 4 h. Biocompatibility testing demonstrated that AOD, at a concentration of 128 µg/mL, exhibited a hemolysis rate of less than 0.5% and a cell survival rate of over 83%. Furthermore, AOD's in vivo therapeutic efficacy against mouse subcutaneous abscess revealed its capability to restrain bacterial proliferation and reduce bacterial load, surpassing that of antibiotic lincomycin. These findings indicate AOD's potential for clinical usage.

Whole-genome sequencing and functional analysis of a novel chitin-degrading strain Rhodococcus sp. 11-3.

Chitin is the second most abundant polysaccharide in nature. Therefore, how to utilize the resource is an important issue. Rhodococcus sp. 11-3 is a strain with high chitin deacetylase (CDA) activity. In the present study, we used a combined Illumina and PacBio sequencing strategy to assemble the whole genome sequence of this strain. The genome of Rhodococcus sp. 11-3 was 5,627,661 bp in size and contained 5983 coding genes, of which 5983, 4040, 4648, 4914, 4174, 2350, and 173 genes were annotated in the Non-Redundant Protein Database (NR), Swiss-Prot, Pfam, Clusters of Orthologous Groups of proteins (COG), Gene Ontology (GO), Kyoto Encyclopedia of Genes and Genomes (KEGG) and Carbohydrate-active enzymes (CAZymes) databases, respectively. The genome was annotated to a chitin deacetylase gene (RhoCDA) and a chitinase gene (RhoChi). They were not very similar to the previously reported chitin deacetylase and chitinase. This made it possible to investigate the genes associated with chitin degradation and would provide an important reference for subsequent gene cloning, functional research, development and application. Therefore, the Rhodococcus sp. 11-3 strain has great potential in the development of chitin resources.

Catalytic Performance of Li/Mg Composites for the Synthesis of Glycerol Carbonate from Glycerol and Dimethyl Carbonate.

A series of Li/Mg composites were synthesized by the coprecipitation method using magnesium and lithium nitrates, and then used for the synthesis of glycerol carbonate (GC) from glycerol and dimethyl carbonate (DMC). The experimental results indicated that Li/Mg composites were prospective catalysts for GC synthesis. 92.05% glycerol conversion and 90.61% GC yield were obtained after reacting at 80 °C for 2 h in the presence of Li/Mg composites. The structure and properties of Li/Mg composites were characterized by X-ray diffraction (XRD), Fourier transform infrared (FT-IR), Brunauer-Emmett-Teller (BET), and CO2-temperature-programmed desorption (TPD) techniques. It was inferred that the basic strength and basicity of Li/Mg composites were improved with increase in Li content. It was concluded that Li2CO3 was the main reactive species. A too-strong basic strength of Li/Mg composites could facilitate the glycerol conversion but impair GC selectivity.

Food-grade expression of nattokinase in Lactobacillus delbrueckii subsp. bulgaricus and its thrombolytic activity in vitro.

OBJECTIVES: To produce nattokinase in a food-grade expression system and evaluate its thrombolytic activity in vitro. RESULTS: No nattokinase activity from reconstituted strains was observed in simulated gastric juice, but the enzyme was stable in intestinal fluid, the relative activity of which was found to be 60% after 4 h. Due to the nattokinase being produced intracellularly by recombinant bacterial strains, the persistence of the bacteria in gastric juice ensured transmission of the nattokinase into intestinal juice. Because of subsequent disintegration of the bacteria, the highest nattokinase activity was observed after 3 h at approximately 32%, following its carriage within the recombinant strains to the intestinal fluid. CONCLUSIONS: This study demonstrated that nattokinase from recombinant strains exhibited good thrombolytic activity in vitro and may be used by the dairy fermentation industry for the development of novel thrombolytic functional foods.

Probiotics, prebiotics, and synbiotics regulate the intestinal microbiota differentially and restore the relative abundance of specific gut microorganisms.

Fermented milk is an effective carrier for probiotics, the consumption of which improves host health. The beneficial effects of probiotics, prebiotics, and synbiotics on gut dysbiosis have been reported previously. However, the way in which specific probiotics, prebiotics, and synbiotics regulate intestinal microbes remains unclear. Therefore, the probiotics Lactobacillus rhamnosus AS 1.2466 and Lactobacillus delbrueckii ssp. bulgaricus ATCC 11842 and the prebiotics xylooligosaccharide and red ginseng extracts were fed to mice to determine their effects on the intestinal microbiota. Then, mice were administered xylooligosaccharide and L. rhamnosus (synthesis) by gavage, and the number of L. rhamnosus was determined in the intestine at different times. The results show that probiotics and prebiotics can quickly reduce the Firmicutes/Bacteroidetes ratio, inhibit harmful bacteria (such as Klebsiella and Escherichia coli), and accelerate the recovery of beneficial intestinal microorganisms (such as Lactobacillus). In a complex intestinal microecology, different probiotics and prebiotics have different effects on specific intestinal microorganisms that cannot be recovered in the short term. In addition, after 20 d of intragastric xylooligosaccharide addition at 0.12 g/kg of body weight, L. rhamnosus colonization in the mouse ileum was 7.48 log cfu/mL, which was higher than in the low-dose group, prolonging colonization time and increasing the number of probiotics in the intestine. Therefore, this study demonstrated that probiotics and prebiotics can promote the balance of intestinal microbiota by regulating specific microbes in the intestine, and the effects of a suitable combination of synbiotics are beneficial, laying the foundation for the development of new dairy products rich in synbiotics.

Notoginsenoside R1 protects human keratinocytes HaCaT from LPS-induced inflammatory injury by downregulation of Myd88.

Burn injury is a gigantic challenge in public health which brings multiple negative effects to patients both in physical and spiritual aspects. Inflammation plays vital roles in the progression of burn injury, and our study investigated whether notoginsenoside R1 (NGR1) alleviated lipopolysaccharide (LPS)-induced human keratinocyte HaCaT cell inflammatory injury. Inflammatory injury was induced by LPS in HaCaT cells. Stimulated cells were then treated by NGR1 in different concentrations. Cell viability and cell apoptosis were detected by Cell Counting Kit-8 and flow cytometry, respectively. The concentration of tumor necrosis factor α (TNF-α) and interleukin-6 (IL-6) was measured by enzyme-linked immunosorbent assay (ELISA). The accumulated levels of apoptosis-related proteins (caspase-3 and caspase-9), nuclear factor κB (NF-κB), p38 mitogen-activated protein kinase (p38MAPK) signal pathways-related proteins (p65, IκBα, and p38MAPK), and myeloid differentiation primary response 88 (MyD88) were examined by western blot. Transfection was used to alter the expression of MyD88. We found that LPS stimulated HaCaT cells and induced cell inflammation, evidenced by decreasing cell viability, increasing cell apoptosis, and elevating TNF-α and IL-6 expressions. Then, we found that NGR1 reversed the results by enhancing cell viability, inhibiting cell apoptosis, and reducing TNF-α and IL-6 expressions. In addition, NGR1 decreased the phosphorylation of p65, IκBα, and p38MAPK, which increased by LPS. Moreover, NGR1 negatively regulated the expression of MyD88, and transfection with pMyD88 led to the opposite results with what showed by NGR1 in LPS-stimulated HaCaT cells. To sum up, NGR1 alleviates LPS-induced HaCaT cell inflammatory injury by downregulation of MyD88, as well as inactivation of NF-κB and p38MAPK signal pathways.

Adhesion and Colonization of the Probiotic Lactobacillus rhamnosus Labeled by Dsred2 in Mouse Gut.

The health-promoting effects of the probiotic strain Lactobacillus rhamnosus are based on its adherence and colonization ability. However, little is known about its adhesion and colonization rates. Lactobacillus rhamnosus in mouse intestinal mucosa a mutant of the red fluorescence protein (RFP) DSred2 was used to tag L. rhamnosus to observe the adhesion and distribution of L. rhamnosus in mouse intestinal mucosa. A mutant of the red fluorescence protein (RFP) Dsred2 was used to tag L. rhamnosus to allow us to observe and distinguish it in the mouse intestine. Seven-week-old female BALB/c mice were fed once (at day 0) with an oral administration of the labeled L. rhamnosus, and the number of labeled bacteria was detected in different regions of the intestinal tract at 3 h and at day 1, 2, 3, 4, 5, 6, 7, and 15 after administration. The labeling process changed the morphology of L. rhamnosus, as it appeared after observation under the microscope, but did not change its basic probiotic properties in vitro. In vivo, labeled L. rhamnosus reached the colonization peak at the fourth day after gavage. From the distribution point of view, the number of colonization strains increased from the proximal to the distal small intestine (duodenum < jejunum < ileum) and the number of strains in the colon was less than the distal small intestine (ileum). The labeling protocol actually allowed the detection of the distribution and adhesion of this bacterium to the intestine, thus demonstrating that the health-promoting effects of this probiotic are satisfied. This study provides a scientific basis in the use of probiotics such as L. rhamnosus in functional foods.

Constructing Cd0.5Zn0.5S@ZIF-8 nanocomposites through self-assembly strategy to enhance Cr(VI) photocatalytic reduction.

A novel and highly efficient photocatalyst of Cd0.5Zn0.5S@ZIF-8 nanocomposite has been developed by a facile self-assembly strategy. This is the first report on the application of CdxZn1-xS and metal-organic framework (MOF) nanocomposite as photocatalysts for the reduction of Cr(VI). The resulting Cd0.5Zn0.5S@ZIF-8 exhibited higher photocatalytic activity than that of pristine Cd0.5Zn0.5S and ZIF-8. Particularly, the CZS@Z60 composite with 60 wt% of ZIF-8 exhibited a photocatalytic activity that is about 1.6 times as high as that of Cd0.5Zn0.5S. The dominant reason for the improved photocatalytic reduction potential is proved to be the newly-formed interfacial SZn bonds that firmly connect Cd0.5Zn0.5S and ZIF-8 and substantially improve the separation efficiency of photo-excited electrons and holes. The newly-formed chemical bonds are confirmed by XPS analyses, and the prolonged lifetime of photo-excited electrons is evidenced by the electrochemical measurement of photocurrent, which shows that the photocurrent on Cd0.5Zn0.5S@ZIF-8 is much higher than that of Cd0.5Zn0.5S and ZIF-8. This study clearly demonstrates that the MOF-based composite nanomaterials hold great promises for applications in the field of environmental remediation and for design of novel photocatalytic materials.

Novel N-doped ZrO2 with enhanced visible-light photocatalytic activity for hydrogen production and degradation of organic dyes.

Two new types of N-doped ZrO2 photocatalysts ZON and AZON have been synthesized using ethylenediamine as the nitrogen source by a facile and low-cost sol-gel method. The N-doped ZrO2 samples have been characterized using various techniques including X-ray diffraction (XRD), UV-Vis spectroscopy, Fourier transform infrared spectroscopy (FTIR), X-ray photoelectron spectroscopy (XPS), photoluminescence spectroscopy (PL) and N2 adsorption-desorption tests. The XRD analysis shows that the crystallinity of ZON samples calcined at 400-600 °C can be indexed to monoclinic ZrO2; while the AZON samples calcined at 400-550 °C only show amorphous diffraction patterns. The UV-Vis response of both N-doped ZrO2 samples can be extended to the visible light regime. The high resolution XPS spectra indicate that N element has been doped in the lattice of ZrO2. Visible-light photocatalytic reactions using the N-doped ZrO2 photocatalysts (i.e. ZON, AZON) calcined at 450 °C show the highest hydrogen production rate (2.12 mmol g-1 h-1) and best methylene orange degradation performance due to substitutional N-doping of the ZrO2. The novel N-doped ZrO2 materials are demonstrated to be very promising photocatalysts with enhanced visible-light photocatalytic activity. Our results provide useful insights into the development of novel photocatalytic materials for hydrogen production and degradation of organic wastes by narrowing the wide bandgap of semiconductors with high photocatalytic activity under UV-Vis light.

A Novel Glycoside Hydrolase Family 113 Endo-ß-1,4-Mannanase from Alicyclobacillus sp. Strain A4 and Insight into the Substrate Recognition and Catalytic Mechanism of This Family.

Few members of glycoside hydrolase (GH) family 113 have been characterized, and information on substrate recognition by and the catalytic mechanism of this family is extremely limited. In the present study, a novel endo-ß-1,4-mannanase of GH 113, Man113A, was identified in thermoacidophilic Alicyclobacillus sp. strain A4 and found to exhibit both hydrolytic and transglycosylation activities. The enzyme had a broad substrate spectrum, showed higher activities on glucomannan than on galactomannan, and released mannobiose and mannotriose as the main hydrolysis products after an extended incubation. Compared to the only functionally characterized and structure-resolved counter part Alicyclobacillus acidocaldarius ManA (AaManA) of GH 113, Man113A showed much higher catalytic efficiency on mannooligosaccharides, in the order mannohexaose ≈ mannopentaose > mannotetraose > mannotriose, and required at least four sugar units for efficient catalysis. Homology modeling, molecular docking analysis, and site-directed mutagenesis revealed the vital roles of eight residues (Trp13, Asn90, Trp96, Arg97, Tyr196, Trp274, Tyr292, and Cys143) related to substrate recognition by and catalytic mechanism of GH 113. Comparison of the binding pockets and key residues of ß-mannanases of different families indicated that members of GH 113 and GH 5 have more residues serving as stacking platforms to support -4 to -1 subsites than those of GH 26 and that the residues preceding the acid/base catalyst are quite different. Taken as a whole, this study elucidates substrate recognition by and the catalytic mechanism of GH 113 ß-mannanases and distinguishes them from counterparts of other families.

A thermophilic ß-mannanase from Neosartorya fischeri P1 with broad pH stability and significant hydrolysis ability of various mannan polymers.

A new ß-mannanase gene, man5P1, was cloned from the thermophilic fungus Neosartorya fischeri P1, and successfully expressed in Pichia pastoris. The predicted amino acid sequence of man5P1 consists of a putative 19-residue signal peptide at the N-terminus and a catalytic domain of glycoside hydrolase family 5. The purified recombinant Man5P1 (rMan5P1) was optimally active at pH 4.0 and 80 °C, and was acid and alkali tolerant, exhibiting >20% of the maximal activity at pH 2.0 and 9.0. rMan5P1 had better stability over a broad pH range of 2.0-12.0, and was highly thermostable at 60 °C and below. The enzyme was highly active towards galactomannan and glucomannan, and exhibited classic endo-activity producing a mixture of mannooligosaccharides (MOS). Moreover, it had strong resistance to SDS and Ag(+) and proteases. The superior properties make Man5P1 a potential candidate for use in various industrial applications.

A novel thermophilic endo-ß-1,4-mannanase from Aspergillus nidulans XZ3: functional roles of carbohydrate-binding module and Thr/Ser-rich linker region.

The gene man5XZ3 from Aspergillus nidulans XZ3 encodes a multimodular ß-mannanase of glycoside hydrolase family 5 that consists of a family 1 carbohydrate-binding module (CBM1), a Thr/Ser-rich linker region, and a catalytic domain. Recombinant Man5XZ3 and its two truncated derivatives, Man5ΔCBM (removing the CBM1) and Man5ΔCL (removing both the CBM1 and linker region), were produced in Pichia pastoris and showed significant variance in the secondary structure. The three enzymes had similar biochemical properties, such as optimal pH and temperature (pH 5.0 and 80 °C) and excellent pH stability at pH 4.0-10.0. Removal of the CBM1 alone could improve the thermostability of Man5XZ3, but further removal of the linker region resulted in worse thermostability. Man5XZ3 retained greater enzyme activity in the presence of an organic solvent (acetone), two detergents (SDS and Triton X-100), and a chaotropic agent (urea) compared with Man5ΔCBM and Man5ΔCL. This study provides an excellent ß-mannanase candidate favorable for various industries and primarily demonstrates the relationship between enzyme structure and function.

A family 5 ß-mannanase from the thermophilic fungus Thielavia arenaria XZ7 with typical thermophilic enzyme features.

A novel ß-mannanase gene, man5XZ7, was cloned from thermophilic fungus Thielavia arenaria XZ7, and successfully expressed in Pichia pastoris. The gene (1,110 bp) encodes a 369-amino acid polypeptide with a molecular mass of approximately 40.8 kDa. The deduced sequence of Man5XZ7 consists of a putative 17-residue signal peptide and a catalytic module belonging to glycoside hydrolase (GH) family 5, and displays 76 % identity with the experimentally verified GH 5 endo-ß-1,4-mannanase from Podospora anserina. Recombinant Man5XZ7 was optimally active at 75 °C and pH 5.0 and exhibited high activity at a wide temperature range (>50.0 % activity at 50-85 °C). Moreover, it had good adaptability to acidic to basic pH (>74.1 % activity at pH 4.0-7.0 and 25.6 % even at pH 9.0) and good stability from pH 3.0 to 10.0. These enzymatic properties showed that Man5XZ7 was a new thermophilic and alkali-tolerant ß-mannanase. Further amino acid composition analysis indicated that Man5XZ7 has several characteristic features of thermophilic enzymes.