RESUMO
The objective of this research was to find out the potential of bioscouring using xylano-pectinolytic enzymes, for degumming of aloe fibers. Bioscouring was optimized with 1 : 20 fiber to buffer ratio, using 10 IU xylanase and 3.2 IU pectinase in 50 mM buffer (pH 8.5), EDTA (3 mM), and Tween 80 (1%), at 50°C temperature with agitation rate of 50 rpm and treatment period of 60 min. Enzymatic treatment of aloe fibers increased brightness and whiteness by 55.67% and 24.88%, respectively and decreased yellowness by 44.11% as compared to alkaline fiber scouring, thereby replacing chemical scouring completely. Additionally, the pretreatment of aloe fibers with enzymes resulted in a 50% less consumption of bleaching chemicals with similar optical properties as obtained by 100% bleaching. This is the first report showing the eco-friendly bioscouring approach of aloe fibers, using enzymes produced concurrently from a bacterial isolate.
Assuntos
Aloe , Conservação dos Recursos Naturais , Poligalacturonase , Tecnologia , Temperatura , Estados UnidosRESUMO
This study was undertaken to investigate the potential of bioscouring in the processing of undegummed sisal fibers, using xylano-pectinolytic enzymes. Optimum bioscouring was obtained at pH 8.5 and 50 mM buffer molarity, using xylanase (10 IU) and pectinase (8 IU), with a material to liquor proportion of 1:25 (g:ml), EDTA (2 mM) and Tween 80 (0.5%), at 50 °C temperature with agitation rate of 55 rpm and treatment period of 60 min. Enzymatic treatment of sisal fibers enhanced the brightness and whiteness by 11.52 and 6.83%, respectively, and reduced the yellowness by 7.14% in comparison to control. The use of xylanase and pectinase enzymes completely replaced the chemical scouring method for removing non-cellulosic impurities. Thus, enzymatic scouring is energy saving and ecofriendly, since it completely eliminated the use of toxic chemicals used in alkaline scouring. An increase of 23.75% and 11.58% in brightness and whiteness of enzymatically scoured cum bleached fibers, as compared to chemically scoured cum bleached fibers was finally obtained, along with reduction in yellowness by 27.99%. This is the first report demonstrating environmentally sustainable enzymatic approach for scouring of undegummed sisal fibers, using enzymes, simultaneously produced from a bacterial isolate.
Assuntos
Bacillus pumilus/enzimologia , Proteínas de Bactérias/química , Endo-1,4-beta-Xilanases/química , Pectinas/química , Poligalacturonase/química , Concentração de Íons de HidrogênioRESUMO
In this study, the efficacy of xylano-pectinolytic enzymes in scouring of banana fibers has been reported. Maximum efficiency of bioscouring was recorded using xylanase and pectinase doses of 15 and 4.8 IU, respectively (produced by a bacterial isolate) at a material-to-liquor proportion of 1:25 having 8.5 pH, treatment time of 1 h, speed of 50 rpm, temperature 50 °C, 3 mM EDTA and 1% Tween-80, with maximum sugar release, enhanced fiber water absorbing power and the finest optical characteristics. Enzymatic treatment resulted in 13.27% increase in whiteness, 16.14% increase in brightness and 8.63% decrease in yellowness as compared to raw banana fibers. The bioscouring also resulted in 50% reduction in scouring chemicals, in order to achieve the similar optical characteristics as obtained by the chemically treated fibers with 100% scouring and bleaching. It decreased the consumption of environment polluting chemicals and energy. Therefore, this has proven to be an environment safe method for removing the non-cellulosic impurities. This is the first report mentioning the scouring of banana fibers using xylano-pectinolytic enzymes.
Assuntos
Proteínas de Bactérias/química , Endo-1,4-beta-Xilanases/química , Musa/química , Poligalacturonase/química , Têxteis , Bacillus pumilus/enzimologia , Química VerdeRESUMO
This study was carried out to demonstrate the biotechnological potential of xylano-pectinolytic enzymes on scouring of ramie fibers. Optimization of bioscouring process showed a maximum effect of enzymes with 50-mM strength of buffer, pH 8.5, fibers to liquid ratio of 1 : 20 (g:ml). Xylanase and pectinase dosage of 7.5 and 3.0 IU, respectively, was found to be best for removal of xylan and pectin impurities, after treatment time of 1.5 h, at 50 °C temperature and 55 rpm agitation rate. EDTA and Tween 80 at concentration of 1.5 mM and 1.25 %, respectively, were found to be the best for effective removal of impurities, in order to improve hydrophilicity of the fibers. After bioscouring, brightness and whiteness values of bioscoured fibers were increased by 9.72 and 7.10% in comparison with control fibers. After enzymatic scouring, a reduction of 14.45 % in yellowness was also seen in ramie fibers. Enzymatic treatment resulted in 6.97% increased brightness, 10.64% increased whiteness, and 4.11% decreased yellowness as compared with scoured ramie fibers. The results indicated that scouring using xylanase and pectinase enzymes could be a substitute for chemical scouring technique. Enzymatic scouring is, therefore, environmentally sustainable and saves energy, also decreases the consumption of harmful chemicals used in alkaline scouring. This is the first report showing the effect of xylanase and pectinase enzymes, produced by a bacterial isolate, on physico-chemical and various optical properties of ramie fibers.
Assuntos
Modelos Químicos , Têxteis , Boehmeria , Pectinas , Poligalacturonase , TemperaturaRESUMO
In this study, screening and isolation of xylano-cellulolytic enzymes producing positive microbes from termitarium and termite gut microbiome were done using cost-effective agricultural wastes. The enrichment of xylano-cellulolytic microbes was done in three steps using wheat bran and waste paper. The qualitative screening of xylanase and cellulase producing micro-organisms was done on nutrient agar plates containing wheat bran and waste paper, respectively. Xylanase and cellulase positive colonies were analysed by observing the zone of substrate (wheat bran and waste paper) hydrolysis around the colonies. A total of 30 bacterial isolates were obtained from termite gut and termitarium, respectively. Xylan and cellulose degrading potential of the positive isolates was also quantitatively estimated using agro-wastes-based medium. All the bacterial isolates displayed cellulase and xylanase activities in the range of 0.45-6.80 and 51-380 IU/ml, respectively. This is the first report mentioning the isolation of xylano-cellulolytic microbes from termite gut and termitarium using very simple cost-effective methodology.
RESUMO
This article documents the addition of 268 microsatellite marker loci to the Molecular Ecology Resources Database. Loci were developed for the following species: Alburnoides bipunctatus, Chamaerops humilis, Chlidonias hybrida, Cyperus papyrus, Fusarium graminearum, Loxigilla barbadensis, Macrobrachium rosenbergii, Odontesthes bonariensis, Pelteobagrus vachelli, Posidonia oceanica, Potamotrygon motoro, Rhamdia quelen, Sarotherodon melanotheron heudelotii, Sibiraea angustata, Takifugu rubripes, Tarentola mauritanica, Trimmatostroma sp. and Wallago attu. These loci were cross-tested on the following species: Alburnoides fasciatus, Alburnoides kubanicus, Alburnoides maculatus, Alburnoides ohridanus, Alburnoides prespensis, Alburnoides rossicus, Alburnoides strymonicus, Alburnoides thessalicus, Alburnoides tzanevi, Carassius carassius, Fusarium asiaticum, Leucaspius delineatus, Loxigilla noctis dominica, Pelecus cultratus, Phoenix canariensis, Potamotrygon falkneri, Trachycarpus fortune and Vimba vimba.
Assuntos
Bases de Dados Genéticas/estatística & dados numéricos , Repetições de Microssatélites/genética , Primers do DNA/genética , Especificidade da EspécieRESUMO
A very high level of alkalophilic and thermostable pectinase and xylanase has been produced from newly isolated strains of Bacillus subtilis and Bacillus pumilus respectively. Enzyme production for pectinase was carried out under SSF using combinations of cheap agricultural residues while xylanase was produced under submerged fermentation using wheat bran as substrate to minimize the cost of production of these enzymes Among the various substrates tested, the highest yield of pectinase production was observed by using combination of WB + CW (6592 U/g of dry substrate) supplemented with 4% yeast extract when incubated at 37 degrees C for 72 h using deionized water of pH 7.0 as moistening agent. The biobleaching effect of these cellulase free enzymes on kraft pulp was determined. Both xylanase and pectinase showed stability over a broad range of pH from 6 to 10 and temperature from 55 to 70 degrees C. The bleaching efficiency of the pectinase and xylanase on kraft pulp was maximum after 150 min at 60 degrees C using enzyme dosage of 5 IU/ml of each enzyme at 10% pulp consistency with about 16% reduction in kappa number and 84% reduction in permanganate number. Enzyme treated pulp when subjected to CDED(1)D(2) steps, 25% reduction in chlorine consumption and upto 19% reduction in consumption of chlorine dioxide was observed for obtaining the same %ISO brightness. Also an increase of 22 and 84% in whiteness and fluorescence respectively and a decrease of approximately 19% in the yellowness of the biotreated pulp were observed by pretreatment of the pulp with our enzymatic mixture.