Immobilization of Candida rugosa lipase on magnetized Dacron: kinetic study.

Candida rugosa lipase has been covalently immobilized on ferromagnetic azide polyethyleneterepthalate (Dacron) with specific activity retention of 16% for 4-nitrophenyl palmitate and 24% for hydrolysis of triolein in hexane. The immobilized enzyme was more thermal stable than the soluble one, retaining 78.8% of the activity after 1 h at 60 degrees C. Also, this immobilized derivative was stable at the storage at 4 degrees C. It has been used 5 cycles for pNPP hydrolysis without loss of activity. Soluble and immobilized Candida rugosa lipase showed a Michaelian behavior for fatty acid 4-nitrophenyl esters and different apparent K(M) values: 0.110 mM and 0.124 mM (4-nitrophenyl palmitate - C16); 0.193 mM and 0.235 mM (4-nitrophenyl laurate - C12) and 0.206 mM and 0.119 mM (4-nitrophenyl butyrate - C4), respectively. The immobilized lipase was more efficient for catalyzing the hydrolysis of 4-nitrophenyl esters with short chain length fatty acid (4-NPB - C4) than soluble enzyme. The ferromagnetic Dacron-lipase derivative was able to catalyze the synthesis of triolein from glycerol and oleic acid with 50% of conversion after 72 h at 40 degrees C.

Effect of culture conditions on lipase production by Fusarium solani in batch fermentation.

Lipase (Glycerol ester hydrolase EC 3.1.1.3.) from a Brazilian strain of Fusarium solani FSI has been investigated. The effect of different carbon sources and trace elements added to basal medium was observed with the aim of improving enzyme production. Lipase specific activity was highest (0.45 U mg(-1)) for sesame oil. When this medium was supplemented with trace elements using olive oil, corn oil and sesame oil the lipase specific activity increased to 0.86, 1.89 and 1.64 U mg(-1), respectively, after 96 h cultivation without any considerable biomass increase. The Km of this lipase using pNPP (p-nitrophenylpalmitate) as substrate, was 1.8 mM with a Vmax of 1.7 micromol min(-1) mg protein(-1). Lipase activity increased in the presence of increasing concentrations of hexane and toluene. In contrast, incubation of this enzyme with water-soluble solvents decreased its activity after 10% concentration (v/v) of the solvent. The lipase activity was stable below 35 degrees C but above this temperature activity losses were observed.

Immobilization of pneumococcal polysaccharide vaccine on silicon oxide wafer for an acoustical biosensor.

One the most important aspects of a biosensor is related to immobilization and maintenance of specific reference compounds on sensing surfaces. A method for the immobilization of polysaccharides to a silicon oxide surface intended for Surface Acoustical Waves (SAW) sensors is described. Silicon oxide is a hydrophobic inorganic support used for the fabrication of many electronic devices. The pneumococcal polysaccharide (PPS) vaccine is immobilized via Protein A after pre-treatment of the surface with hydrochloric acid. The effects of non-specific binding are discussed. The results indicate that the immobilization of PPS via Protein A increases the sensitivity of detecting Streptococcus pneumoniae antibodies in human sera and offers greater reproducibility of response compared with ELISA methods. The principles of this technique are simple and are applicable to the immobilization of many capsular polysaccharides.

Production of lipase free of citrinin by Penicillium citrinum.

Lipase (Glycerol ester hydrolase E.G. 3.1.1.3) from a Brazilian strain of Penicillium citrinum free of the mycotoxin citrinin has been investigated. Citrinin production was inhibited by using culture medium containing olive oil, soybean oil and corn oil as carbon sources. Potassium concentration and pH play an important role in citrinin production. Potassium concentration lower than 30 mM and pH below 4.5 inhibited the mycotoxin production. P. citrinum produced lipase free of extraneous proteins and citrinin when cultured using, as nitrogen source, ammonium sulphate (lipase activity of 7.88 U/mg) and yeast extract (lipase activity of 4.95 U/mg) with olive oil as carbon source. This data is relevant to the larger scale production of lipases for food technology applications, from Penicillium citrinum.

Action of immobilized xanthine oxidase on purines.

Xanthine oxidase was covalently immobilized on polyacrylamide gel beads, polyamide-11 and dacron. Hypoxanthine (15 ml of 200 microM), prepared in 0.1 M phosphate buffer, pH 8.0, was circulated through a column containing 1.0 g derivatized enzyme at a flow rate of 1.0 ml/min at 28 degrees C. Specific activities of 0.660, 0.072 and 0.016 Units/mg of protein were demonstrable for the polyacrylamide gel beads, dacron and polyamide-11 derivatives, respectively. The action of these water insoluble enzyme derivatives on 6-mercaptopurine (15 ml of 660 microM) was also investigated, under the same experimental conditions, showing specific activities of 0.063 Units/mg, 0.574 muUnits/mg and 0.118 muUnits/mg, respectively. The 6-mercaptopurine oxidative pathway catalyzed by immobilized xanthine oxidase on dacron stopped at the intermediate compound, 6-mercapto-8-hydroxypurine, so that no 6-thiouric acid was produced, whereas the immobilized preparations using polyacrylamide gel beads and polyamide-11 behaved like the soluble enzyme, namely, 6-thiouric acid was the final product. The behavior of dacron-xanthine oxidase compound was similar to that previously described for the derivatives obtained with carboxymethylcellulose and chitosan. The hypoxanthine oxidative pathway catalyzed by xanthine oxidase immobilized on these three supports was similar to the soluble enzyme.(ABSTRACT TRUNCATED AT 250 WORDS)

Action of immobilized xanthine oxidase on purines

Xanthine oxidase was covalently immbolized on polyacrylamide gel beads, polyamide- 11 and dacron. Hypoxanthine (15 ml of 200 µM), prepared in 0.1 M phosphate buffer, pH 8.0, was circulated through a column containing 1.0g derivatized enzyme at a flow rate of 1.0 ml/min at 28§C. Specific activities of 0.660, 0.072 and 0.016 Units/mg of protein were demonstrable for the polyacrylamide gel beads, dacron and polyamide-11 derivatives, respectively. The action of these water insoluble enzyme derivatives on 6 mercaptopurine (15 ml of 660 µM) was also investigated, under the same experimental conditions, showing specific activites of 0.063 Units/mg, 0.574 µUnits/mg and 0.118 µUnitis/mg, respectively. The 6-mercaptopurine oxidative pathway catalyzed by immobilized xanthine oxidase on dacron stopped at the intermediate compound 6-mercaptopurine oxidative on dracon stopped at the intermediate compound, 6-mercapto-8-hydroxypurine, so that no 6-thiouric acid was produced, whereas the immobilized preparations using polyacrylamide gel beads and polyamide-11 behaved like the soluble enzyme, namely, 6-thiouric acid was the final product. The behavior of dracon-xanthine oxidase immobilized on these three supports was similar to the soluble enzyme. However, although its oxidation is stoichiometric for polyacrylamide gel beads and polyamide- 11 derivatives, and no xanthine formation is observed (steady-state equilibrium), under the action of the enzymedacron derivative the xanthine formation rate (0.164 µUnits/mg) is higher than the uric acid formation rate (0.017 µUnits/mg) compared to the hypoxanthine consumption (0.072 µUnits/mg). These findings suggest again that xanthine oxidase-dacron derivative is limited to the catalysis of oxidation of hypoxanthine carbon atom number 2 as in 6-mercaptopurine

Lipase from a Brazilian strain of Penicillium citrinum.

A lipases (glycerol ester hydrolases E. C. 3.1.1.3) from a brazilian strain of Penicillium citrinum has been investigated. When the microorganism was cultured in the simple medium (1.0% olive oil and 0.5% yeast extract), using olive oil in as carbon source in the inocula, the enzyme extracted showed maximum activity (409 IU/mL). In addition, decrease of yeast extract concentration also reduces the lipase activity. Nevertheless, when yeast extract was replaced by ammonium sulfate, no activity was detected. Purification by precipitation with ammonium sulfate showed best activity in the 40-60% fraction. The optimum temperature for enzyme activity was found in the range of 34-37 degrees C. However, after 30 min at 60 degrees C, the enzyme was completely inactivated. The enzyme showed optimum at pH 8.0. The dried concentrated fraction (after dialysis and lyophilization) maintained its lipase activity at room temperature (28 degrees C) for 8 mo. This result in lipase stability suggests an application of lipases from P. citrinum in detergents and other products that require a high stability at room temperature.

Glucose biosensor using glucose oxidase immobilized in polyaniline.

A biosensor for glucose utilizing kinetics of glucose oxidase (EC 1.1.3.4.) was developed. The enzyme was immobilized on polyaniline by covalent bonding, using glutaraldehyde as a bifunctional agent. The system showed a linear response up to 2.2 mM of glucose with a response time of 2.5-4.0 min. In addition, the immobilized enzyme had a higher activity between pH 6.5 and 7.5. The system retained 50% of its activity after 30 d of daily use. The optical absorption spectra of the polyaniline/glucose oxidase electrode after glucose had been added to the buffer solution showed that the absorption band around 800 nm had changed considerably when glucose was allowed to react with the electrode. This optical variation makes polyaniline a very promising polymer for use as a support in optical sensor for clinical application.

Effects of potassium on the ethanol production rate of Saccharomyces cerevisiae carrying the plasmid pCYG4 related with ammonia assimilation.

The influence of potassium on ethanol production by Saccharomyces cerevisiae wild type and AR5 cells carrying the plasmid pCYG4 was investigated. This plasmid carries the glutamate dehydrogenase gene conferring an 11-fold higher level of expressed enzyme activity over the wild type cells. All experiments were carried out in batch culture with medium supplemented to different potassium concentrations up to 180 mM. Maximum ethanol production rate was observed in the AR5 cells grown in medium supplemented with 3.5 mM of potassium ions. Glucose uptake rate increased with increasing potassium up to 60 mM, but higher concentrations depressed glucose uptake rate in both strains. Furthermore, the wild type cells showed higher growth rate, ethanol production, and glucose consumption rate than the AR5 cells. These lower rates in the AR5 cells could be explained by repression of potassium uptake by an enhancement of ammonium feeding, and greater energy requirements by these cells due the presence of the plasmid.

Activity of immobilized alpha-amylase.

1. alpha-Amylase immobilized on polyamide 11 showed higher specific activity and retention of activity than the derivatives employing polyacrylamide and polyethyleneterephthalate as supports. 2. Polyamide 11 and polyethyleneterephthalate alpha-amylase derivatives exhibited a higher extent of multiple attacks on starch than the water-soluble enzyme whereas the polyacrylamide derivative presented less. 3. The polyamide 11 alpha-amylase derivative acted on amylose-azure in the same way as the water-soluble alpha-amylase.

Limited adrenal reserve in paracoccidioidomycosis: cortisol and aldosterone responses to 1-24 ACTH.

Adrenal function in twenty-three patients with paracoccidioidomycosis (South American Blastomycosis) has been assessed by measuring the response to adrenocortical stimulation with 1-24 ACTH. Two patients with overt Addison's disease showed very low basal levels and the complete absence of an increase in either cortisol or aldosterone secretion. Six patients showed probable diminished adrenal reserve in terms of cortisol and three patients showed diminished reserve in terms of aldosterone function. These findings indicate an incidence of significant hypoadrenalism in 44% of hospitalized patients with disseminated paracoccidioidomycosis.