A NanoDrop-based method for rapid determination of viability decline in suspension cultures of animal cells.

We describe a rapid method for monitoring the cell growth and decline phases in suspension cultures of animal cells. During the cell growth phase, ultraviolet (UV)-absorbing components in the medium are consumed, but at later times as cells begin to die, UV-absorbing molecules such as proteins are released into the medium. Measuring the absorbance at 280nm (A(280)) with a NanoDrop spectrophotometer, an inverse correlation between the onset of the cell decline phase and A(280) was observed. This simple method can be applied to quickly determine the beginning of the decline phase of cultures of mammalian and insect cells in suspension.

k(L)a as a predictor for successful probe-independent mammalian cell bioprocesses in orbitally shaken bioreactors.

The aim of this study was to gain a better understanding of orbitally shaken bioreactors (OSRs) operated without controllers for pH and dissolved oxygen (DO) concentration. We used cylindrical OSRs with working volumes ranging from 250mL to 200L to determine that the volumetric mass transfer coefficient of oxygen (k(L)a) is a good predictor of the performance of OSRs at different scales. We showed that k(L)a values of 7-10hour(-1) were required to avoid DO limitations and to prevent conditions of low pH during the cultivation of CHO cells. Overall, cell cultures in probe-independent OSRs of different nominal volumes ranging from 250mL to 200L achieved similar cell densities, recombinant protein concentrations, and pH and DO profiles when having the same k(L)a. We conclude that k(L)a is a key parameter for probe-independent bioprocesses in OSRs and can be used as a scale-up factor for their operation.

TubeSpin bioreactor 50 for the high-density cultivation of Sf-9 insect cells in suspension.

Here we present the TubeSpin bioreactor 50 (TubeSpins) as a simple and disposable culture system for Sf-9 insect cells in suspension. Sf-9 cells had substantially better growth in TubeSpins than in spinner flasks. After inoculation with 10(6) cells/ml, maximal cell densities of 16×10(6) and 6×10(6) cells/ml were reached in TubeSpins and spinner flasks, respectively. In addition the cell viability in these batch cultures remained above 90% for 10 days in TubeSpins but only for 4 days in spinner flasks. Inoculation at even higher cell densities reduced the duration of the lag phase. After inoculation at 2.5×10(6) cells/ml, the culture reached the maximum cell density within 3 days instead of 7 days as observed for inoculation with 10(6) cells/ml. Infection of Sf-9 cells in TubeSpins or spinner flasks with a recombinant baculovirus coding for green fluorescent protein (GFP) resulted in similar GFP-specific fluorescence levels. TubeSpins are thus an attractive option for the small-scale cultivation of Sf-9 cells in suspension and for baculovirus-mediated recombinant protein production.

Purification and analysis of polyhistidine-tagged human parvovirus B19 VP1 and VP2 expressed in insect cells.

Human parvovirus B19 is an autonomously replicating human pathogen with a specific tropism for human erythroid progenitor cells. There is an interest in producing empty nucleocapsids of B19 as they can be used as tools in molecular biology and diagnostics. Native B19 virus particles are formed from two structural viral proteins, VP1 and VP2. The VP2 protein alone is able to self assemble and consequently form virus-like particles (VLPs) in heterologous expression systems. Purification of recombinant VLPs has been conducted using various traditional methods. These include laborious and time-consuming, e.g. cesium chloride or sucrose gradient ultracentrifugation steps, allowing limited working volumes to be processed. Therefore, an alternative purification method enabling process scale-up was developed and evaluated. Polyhistidine-tagged versions of B19 VP1 and VP2 capsid proteins were engineered and produced using the baculovirus expression system. The recombinant protein products were purified by immobilized metal-ion affinity chromatography (IMAC) and analyzed by SDS-PAGE, immunoblotting, electron microscopy, and enzyme-linked immunosorbent assays. Further, the immunological properties of the recombinant proteins were evaluated. The results showed that the VP2 fusion protein assembled into capsid-like structures and that both VP1 and VP2 following purification by IMAC have potential as antigens for diagnosis of a B19 infection.

Evaluation of a new ELISA for the detection of specific IgG to the Epstein-Barr nuclear antigen 1 (EBNA-1).

Diagnosis of acute primary Epstein-Barr Virus (EBV) infection is predominantly performed by serology. Detection of specific antibodies to defined EBV antigens is considered state of the art. Antibodies to EBNA-1 are not produced early in primary infection and a positive EBNA-1 serology is a sign of past infection. Therefore EBNA-1 serology plays a crucial role for EBV routine diagnosis. In the present study the quantitative EBV EBNA-1-IgG-ELISA PKS medac was evaluated regarding its suitability for routine diagnosis. Using clinically and diagnostically defined serum samples (141 from seronegative, 111 from acute infected, and 52 from individuals with past infection) as well as 100 sera from healthy blood donors the diagnostic performance of the assay was investigated. Furthermore, precision, performance of the single-point quantitation (SPQ), and suitability of the assay for automation were evaluated. Compared to the pre-definition of the serum panel a sensitivity of 100% and a specificity of 99.6% was found. The measurement of the blood donor sera resulted in an anti-EBNA-1 IgG prevalence of 93% and an agreement of 99% with the results of a commercial ELISA used as reference. Regarding intra-assay variation, interassay variation (performed manually and automatically), and person-to-person variation a coefficient of variation < 10% was found with reactive samples. A good dilution linearity (r2 = 0.961), an excellent correlation of SPQ vs. the calibration curve (r2 = 0.997), and between the results of manually vs. automatically performed test runs (r2 > 0.995) was found. The evaluation has shown that the assay meets the demands of routine diagnosis very well.

Monitoring human parvovirus B19 virus-like particles and antibody complexes in solution by fluorescence correlation spectroscopy.

Fluorescence correlation spectroscopy (FCS) was used in monitoring human parvovirus B19 virus-like particle (VLP) antibody complexes from acute phase and past-immunity serum samples. The Oregon Green 488-labeled VLPs gave an average diffusion coefficient of 1.7 x 10(-7) cm2 s(-1) with an apparent hydrodynamic radius of 14 nm. After incubation of the fluorescent VLPs with an acute phase serum sample, the mobility information obtained from the fluorescence intensity fluctuation by autocorrelation analysis showed an average diffusion coefficient of 1.5 x 10(-8) cm2 s(-1), corresponding to an average radius of 157 nm. In contrast, incubation of the fluorescent VLPs with a past-immunity serum sample gave an average diffusion coefficient of 3.5 x 10(-8) cm2 s(-1) and a radius of 69 nm. A control serum devoid of B19 antibodies caused a change in the diffusion coefficient from 1.7 x 10(-7) to 1.6 x 10(-7) cm2 s(-1), which is much smaller than that observed with acute phase or past-immunity sera. Thus, VLP-antibody complexes with different diffusion coefficients could be identified for the acute phase and past-immunity sera. FCS measurement of VLP-immune complexes could be useful in distinguishing between antibodies present in acute phase or past-immunity sera as well as in titration of the VLPs.

Properties of baculovirus particles displaying GFP analyzed by fluorescence correlation spectroscopy.

Recombinant baculovirus particles displaying green fluorescent protein (GFP) fused to the major envelope glycoprotein gp64 of the Autographa californica multicapsid nucleopolyhedrovirus (AcMNPV) were characterized by fluorescence correlation spectroscopy (FCS). FCS detected Brownian motion of single, intact recombinant baculovirus display particles with a diffusion coefficient (D) of (2.89 +/- 0.74) x 10(-8) cm2s(-1) and an apparent hydrodynamic radius of 83.35 +/- 21.22 nm. In the presence of sodium dodecyl sulfate (SDS), Triton X-100, and octylglucoside, the diffusion time was reduced to the 0.2 ms range (D = 7.57 x 10(-7) cm2s(-1)), showing that the fusion proteins were anchored in the viral envelope. This allowed for a calculation of the number of single gp64 fusion proteins incorporated in the viral membrane. A mean value of 3.2 fluorescent proteins per virus particle was obtained. Our results show that FCS is the method of choice for studying enveloped viruses such as a display virus with one component being GFP.