Survey of Meat Collected from Commercial Broiler Processing Plants Suggests Low Levels of Semicarbazide Can Be Created during Immersion Chilling.

ABSTRACT: Semicarbazide (SEM) is routinely employed as an indicator for the use of nitrofurazone, a banned antimicrobial. The validity of SEM as a nitrofurazone marker has been scrutinized because of other possible sources of the compound. Nonetheless, a U.S. trade partner rejected skin-on chicken thighs because of SEM detection and suspected nitrofurazone use. Because nitrofurazone has been banned in U.S. broiler production since 2003, we hypothesized that incidental de novo SEM formation occurs during broiler processing. To assess this possibility, raw leg quarters were collected from 23 commercial broiler processing plants across the United States and shipped frozen to our laboratory, where liquid chromatography-mass spectrometry was used to quantitatively assess for SEM. Leg quarter samples were collected at four points along the processing line: hot rehang (transfer from the kill line to the evisceration line), prechill (before the chilling process), postchill (immediately following chilling), and at the point of pack. Thigh meat with skin attached was removed from 535 leg quarters and analyzed in triplicate for SEM concentrations. The concentrations ranged from 0 to 2.67 ppb, with 462 (86.4%) of 535 samples below the regulatory decision level of 0.5 ppb of SEM. The 73 samples over the 0.5-ppb limit came from 21 plants; 53 (72.6%) of positive samples were in meat collected after chilling (postchill or point of pack). The difference in both prevalence and concentration of SEM detected before and after chilling was highly significant (P < 0.0001). These data support our hypothesis that SEM detection in raw broiler meat is related to de novo creation of the chemical during processing.

Pyrrocidine, a molecular off switch for fumonisin biosynthesis.

Sarocladium zeae is a fungal endophyte of maize and can be found co-inhabiting a single seed with Fusarium verticillioides, a major mycotoxigenic food safety threat. S. zeae produces pyrrocidines A and B that inhibit the growth of F. verticillioides and may limit its spread within the seed to locations lacking S. zeae. Although coinhabiting single seeds, the fungi are generally segregated in separate tissues. To understand F. verticillioides' protective physiological response to pyrrocidines we sequenced the F. verticillioides transcriptome upon exposure to purified pyrrocidine A or B at sub-inhibitory concentrations. Through this work we identified a F. verticillioides locus FvABC3 (FVEG_11089) encoding a transporter critical for resistance to pyrrocidine. We also identified FvZBD1 (FVEG_00314), a gene directly adjacent to the fumonisin biosynthetic gene cluster that was induced several thousand-fold in response to pyrrocidines. FvZBD1 is postulated to act as a genetic repressor of fumonisin production since deletion of the gene resulted in orders of magnitude increase in fumonisin. Further, pyrrocidine acts, likely through FvZBD1, to shut off fumonisin biosynthesis. This suggests that S. zeae is able to hack the secondary metabolic program of a competitor fungus, perhaps as preemptive self-protection, in this case impacting a mycotoxin of central concern for food safety.

Adjusting Suicide Rates in a Military Population: Methods to Determine the Appropriate Standard Population.

The choice of the standard population is important when calculating adjusted rates for a military population: results can influence policies and funding allocations for programs and initiatives for suicide prevention. We describe the methodological considerations and decision-making process used in choosing a standard population for adjusting rates to compare suicide among US Army soldiers and the general US population. We examined 5 different standard populations, using the direct method to adjust annual suicide rates for the Army and the US population, 2004 to 2015, for age and for age and sex. The pattern of the Army and US population age- and sex-adjusted rates remained consistent with crude rates when adjusted to any of the Army standard population distributions. Using an Army distribution as the standard population produces suicide rates consistent with routine messaging about suicide trends among Army soldiers.

Is Quorum Signaling by Mycotoxins a New Risk-Mitigating Strategy for Bacterial Biocontrol of Fusarium verticillioides and Other Endophytic Fungal Species?

Bacterial endophytes are used as biocontrol organisms for plant pathogens such as the maize endophyte Fusarium verticillioides and its production of fumonisin mycotoxins. However, such applications are not always predictable and efficient. In this work, we hypothesize and review work that quorum sensing inhibitors are produced either by fungi or by pathogenic bacteria for competitive purposes, altering the efficiency of the biocontrol organisms. Recently, quorum sensing inhibitors have been isolated from several fungi, including Fusarium species, three of which are mycotoxins. Thus, we further postulate that other mycotoxins are inhibitors or quenching metabolites that prevent the protective abilities and activities of endophytic biocontrol bacteria within intercellular spaces. To test the aforementioned suppositions, we review work detailing the use of bioassay bacteria for several mycotoxins for quorum activity. We specifically focus on the quorum use of endophytic bacteria as biocontrols for mycotoxic fungal endophytes, such as the Fusarium species and the fumonisin mycotoxins.

Two Horizontally Transferred Xenobiotic Resistance Gene Clusters Associated with Detoxification of Benzoxazolinones by Fusarium Species.

Microbes encounter a broad spectrum of antimicrobial compounds in their environments and often possess metabolic strategies to detoxify such xenobiotics. We have previously shown that Fusarium verticillioides, a fungal pathogen of maize known for its production of fumonisin mycotoxins, possesses two unlinked loci, FDB1 and FDB2, necessary for detoxification of antimicrobial compounds produced by maize, including the γ-lactam 2-benzoxazolinone (BOA). In support of these earlier studies, microarray analysis of F. verticillioides exposed to BOA identified the induction of multiple genes at FDB1 and FDB2, indicating the loci consist of gene clusters. One of the FDB1 cluster genes encoded a protein having domain homology to the metallo-ß-lactamase (MBL) superfamily. Deletion of this gene (MBL1) rendered F. verticillioides incapable of metabolizing BOA and thus unable to grow on BOA-amended media. Deletion of other FDB1 cluster genes, in particular AMD1 and DLH1, did not affect BOA degradation. Phylogenetic analyses and topology testing of the FDB1 and FDB2 cluster genes suggested two horizontal transfer events among fungi, one being transfer of FDB1 from Fusarium to Colletotrichum, and the second being transfer of the FDB2 cluster from Fusarium to Aspergillus. Together, the results suggest that plant-derived xenobiotics have exerted evolutionary pressure on these fungi, leading to horizontal transfer of genes that enhance fitness or virulence.

Evidence for fumonisin inhibition of ceramide synthase in humans consuming maize-based foods and living in high exposure communities in Guatemala.

SCOPE: Fumonisin (FB) occurs in maize and is an inhibitor of ceramide synthase (CerS). We determined the urinary FB1 (UFB1 ) and sphingoid base 1-phosphate levels in blood from women consuming maize in high and low FB exposure communities in Guatemala. METHODS AND RESULTS: FB1 intake was estimated using the UFB1 . Sphinganine 1-phosphate (Sa 1-P), sphingosine 1-phosphate (So 1-P), and the Sa 1-P/So 1-P ratio were determined in blood spots collected on absorbent paper at the same time as urine collection. In the first study, blood spots and urine were collected every 3 months (March 2011 to February 2012) from women living in low (Chimaltenango and Escuintla) and high (Jutiapa) FB exposure communities (1240 total recruits). The UFB1 , Sa 1-P/So 1-P ratio, and Sa 1-P/mL in blood spots were significantly higher in the high FB1 intake community compared to the low FB1 intake communities. The results were confirmed in a follow-up study (February 2013) involving 299 women living in low (Sacatepéquez) and high (Santa Rosa and Chiquimula) FB exposure communities. CONCLUSIONS: High levels of FB1 intake are correlated with changes in Sa 1-P and the Sa 1-P/So 1-P ratio in human blood in a manner consistent with FB1 inhibition of CerS.

A blood spot method for detecting fumonisin-induced changes in putative sphingolipid biomarkers in LM/Bc mice and humans.

Fumonisins (FB) are mycotoxins found in maize. They are hypothesised risk factors for neural tube defects (NTDs) in humans living where maize is a dietary staple. In LM/Bc mice, FB1-treatment of pregnant dams induces NTDs and results in increased levels of sphingoid base 1-phosphates in blood and tissues. The increased level of sphingoid base 1-phosphates in blood is a putative biomarker for FB1 inhibition of ceramide synthase in humans. Collection of blood spots on paper from finger sticks is a relatively non-invasive way to obtain blood for biomarker analysis. The objective of this study was to develop and validate in an animal model, and ultimately in humans, a method to estimate the volume of blood collected as blood spots on absorbent paper so as to allow quantification of the molar concentration of sphingoid base 1-phosphates in blood. To accomplish this objective, blood was collected from unexposed male LM/Bc and FB1-exposed pregnant LM/Bc mice and humans and applied to two types of absorbent paper. The sphingoid base 1-phosphates, absorbance at 270 nm (A270), and total protein content (Bradford) were determined in the acetonitrile:water 5% formic acid extracts from the dried blood spots. The results show that in both mouse and human the A270, total protein, and blood volume were closely correlated and the volume of blood spotted was accurately estimated using only the A270 of the extracts. In mouse blood spots, as in tissues and embryos, the FB1-induced changes in sphingolipids were correlated with urinary FB1. The half-life of FB1 in the urine was short (<24 h) and the elevation in sphingoid base 1-phosphates in blood was also short, although more persistent than the urinary FB1.

Analyses of black Aspergillus species of peanut and maize for ochratoxins and fumonisins.

The genus Aspergillus section Nigri, or the black aspergilli, represents genetically closely related species that produce the mycotoxins, ochratoxins and the fumonisins. Fumonisin B1 (FB1) is of an added concern because it is also a virulence factor for maize. Our preliminary data indicated that black aspergilli could develop asymptomatic infections with maize and peanuts plants. Symptomless infections are potential problems, because under favorable conditions, there is a potential for accumulation of ochratoxins and the fumonisins in contaminated postharvest crops. In the present report, the ability of black aspergilli from peanuts and maize to produce ochratoxin A and FB1 on maize kernels was assessed. One hundred fifty strains from peanuts and maize were isolated from several southeastern and midwestern states. Aspergillus nigri (A. nigri var. nigri) was the dominant species (87%), while Aspergillus foetidus, Aspergillus japonicus, Aspergillus tubingensis, and Aspergillus carbonarius were infrequently isolated. None of the wild isolates produced detectable amounts of ochratoxins. However, we do report the occurrence of the fumonisins B1, B2, and B3. Of 54 field isolates, 30% (n = 16) produced FB1, 61% (n = 33) produced FB2, and 44% (n = 24) produced FB3. The amounts of fumonisins produced during the test period of 30 days suggest that these strains might be weak to moderate producers of fumonisin on maize. To our knowledge, this is a first report of FB1 and FB3 production by isolates of black aspergilli from an American cereal and legume.

Maize seedling blight induced by Fusarium verticillioides: accumulation of fumonisin B1 in leaves without colonization of the leaves.

Fusarium verticillioides produces fumonisin mycotoxins during the colonization of maize, and fumonisin B1 (FB1) production is necessary for manifestation of maize seedling blight disease. The objective of this study was to address FB1 mobility and accumulation in seedlings to determine if proximal infection by F. verticillioides is necessary for FB1 accumulation. Taking advantage of an aconidial mutant known to have limited capability for seedling infection, tissue and soil samples were analyzed to compare wild-type F. verticillioides against the mutant. Inoculation with either strain caused accumulation of FB1 in the first and second leaves, but the mutants were unable to colonize aerial tissues. FB1, FB2, and FB3 were detected in the soil and seedling roots, but only FB1 was detected in the leaves of any treatment. These data suggest root infection by F. verticillioides is necessary for accumulation of FB1 in leaves, but the mechanism for accumulation does not require colonization of the leaf.

Ceramide synthase inhibition by fumonisin B1 causes accumulation of 1-deoxysphinganine: a novel category of bioactive 1-deoxysphingoid bases and 1-deoxydihydroceramides biosynthesized by mammalian cell lines and animals.

Fumonisin B(1) (FB(1)) is a mycotoxin that inhibits ceramide synthases (CerS) and causes kidney and liver toxicity and other disease. Inhibition of CerS by FB(1) increases sphinganine (Sa), Sa 1-phosphate, and a previously unidentified metabolite. Analysis of the latter by quadrupole-time-of-flight mass spectrometry assigned an m/z = 286.3123 in positive ionization mode, consistent with the molecular formula for deoxysphinganine (C(18)H(40)NO). Comparison with a synthetic standard using liquid chromatography, electrospray tandem mass spectrometry identified the metabolite as 1-deoxysphinganine (1-deoxySa) based on LC mobility and production of a distinctive fragment ion (m/z 44, CH(3)CH=NH (+)(2)) upon collision-induced dissociation. This novel sphingoid base arises from condensation of alanine with palmitoyl-CoA via serine palmitoyltransferase (SPT), as indicated by incorporation of l-[U-(13)C]alanine into 1-deoxySa by Vero cells; inhibition of its production in LLC-PK(1) cells by myriocin, an SPT inhibitor; and the absence of incorporation of [U-(13)C]palmitate into 1-[(13)C]deoxySa in LY-B cells, which lack SPT activity. LY-B-LCB1 cells, in which SPT has been restored by stable transfection, however, produce large amounts of 1-[(13)C]deoxySa. 1-DeoxySa was elevated in FB(1)-treated cells and mouse liver and kidney, and its cytotoxicity was greater than or equal to that of Sa for LLC-PK(1) and DU-145 cells. Therefore, this compound is likely to contribute to pathologies associated with fumonisins. In the absence of FB(1), substantial amounts of 1-deoxySa are made and acylated to N-acyl-1-deoxySa (i.e. 1-deoxydihydroceramides). Thus, these compounds are an underappreciated category of bioactive sphingoid bases and "ceramides" that might play important roles in cell regulation.