Male adolescent exposure to endocrine-disrupting pesticides: vinclozolin exposure in peripubertal rabbits.

Adolescence is a time of dramatic neuroendocrine changes that are required for sexual maturation. Hormonal mimicking or inhibiting chemicals can cause significant impairment during this critical period. Vinclozolin (Vin) has been shown to be an anti-androgen affecting male offspring in rats in utero, and its mechanism of action may be mediated by inhibition of androgenic receptor action. The majority of teenagers working on farms are male, and therefore a systemic fungicide, vinclozolin, was selected for study. The rabbit has proved to be an excellent species for modelling reproductive toxicant effects in the male and was selected as the test species. The peripubertal phase for the rabbit was determined to be between the 3rd and 4th months. A 2-month dosing period was therefore initiated at 3 months of age and carried through to the 4th month. Vin was administered by dermal application (100 mg kg(-1) in 100 microl of dimethylsulphoxide) daily. Body weights were determined weekly. The rabbits were then held until fully mature (6 months of age). Semen was collected and evaluated from sexually mature males on a weekly schedule for 5 weeks to maximize sperm output. An automated solid phase extraction procedure for monitoring exposures through isolation and quantification of Vin and its metabolic products was developed. Increased plasma levels of Vin and M2 were found throughout the experimental period. The exposed rabbits had a smaller weight gain during pubertal growth (approaching significance; P=0.059). At maturity, the accessory sex glands of the exposed animals weighed less than those of the controls (P=0.016). Surprisingly, the pooled sperm count of the exposed animals was significantly higher (P=0.017) than that of the unexposed animals. The anti-androgenic effects of Vin may have blocked the negative feedback mechanism of testosterone on the hypothalamus or pituitary gland, allowing for an increase in gonadotrophin release, and consequently increasing sperm production at puberty.

Prioritization of NTP reproductive toxicants for field studies.

Population studies that evaluate human reproductive impairment are time consuming, expensive, logistically difficult, and with limited resources must be prioritized to effectively prevent the adverse health effects in humans. Interactions among health scientists, unions, and industry can serve to identify populations exposed to potential hazards and develop strategies to evaluate and apply appropriate controls. This report describes a systematic method for prioritizing chemicals that may need human reproductive health field studies. Rodent reproductive toxicants identified from the National Toxicology Program (NTP) Reproductive Assessment by Continuous Breeding (RACB) protocol were prioritized on the basis of potency of toxic effect and population at risk. This model for prioritization links NTP findings with data from the National Occupational Exposure Survey (NOES) and the Hazardous Substance Data Base (HSDB) or the High Production Volume Chemical Database (HPVC) to prioritize chemicals for their potential impact on worker populations. The chemicals with the highest priority for field study were: dibutyl phthalate, boric acid, tricresyl phosphate, and N, N-dimethylformamide.

Alterations in rabbit kidney protein expression following lead exposure as analyzed by two-dimensional gel electrophoresis.

It was recently reported that low blood lead levels impaired kidney function in men. To develop a set of molecular markers of renal lead exposure and effect, we investigated changes in renal protein expression while approximating occupational lead exposure at subchronic, low blood levels. Lead was administered to male Dutch Belted rabbits as a lead acetate solution adjusted weekly to achieve and maintain the target blood lead levels of 0, 20, 40, and 80 microg/dL for 15 weeks. Lead exposure did not affect kidney or body weights. The effect of increasing blood lead on protein expression was evaluated in rabbit kidney by large-scale two-dimensional electrophoresis (2-DE). Significant quantitative changes (p < 0.05) occurred in a dose-related manner in 12 proteins at 20 microg/dL exposure, 25 at 40 microg/dL, and 102 at 80 microg/dL. At a higher level of significance (p < 0.001), 40 microg/dL blood lead resulted in one protein alteration and 80 microg/dL affected 14 proteins. A set of quantitatively altered charge variants was tentatively identified as glutathione-S-transferase (GST), based on similar observations in rodents subjected to short-term, very high lead exposure. The significance of the protein alterations observed as markers of toxicity awaits their conclusive identification. Investigation of the kidney 2-DE profile in lead-exposed rabbit may be useful in understanding the mechanism of lead nephrotoxicity in humans.

Male reproductive effects of lead, including species extrapolation for the rabbit model.

The effects of elevated blood lead on semen quality were evaluated in the rabbit model and compared to published effects in humans. Mature, male rabbits were given lead acetate by subcutaneous injection in the dose range of 0 to 3.85 mg/kg on a Monday-Wednesday-Friday basis. In each of eight treatment groups, a dosing regimen was developed to produce blood lead levels of 0, 20, 40, 50, 70, 80, 90, and 110 microg/dL. A 5-week pre-exposure period was followed by a 15-week exposure testing period allowing for response through six cycles of the seminiferous epithelium. Semen analyses revealed that increased blood lead levels were associated with adverse changes in the sperm count, ejaculate volume, percent motile sperm, swimming velocities, and morphology. Hormonal responses were minimal. Testicular pathology revealed a dose-dependent inhibition of spermiation. For six measures of semen quality, threshold estimates ranged from 16 to 24 microg/dL. Using the species extrapolation factor derived in this study, a rabbit dose would have to be divided by 1.56 to obtain the equivalent human dose for an equal percentage decrease in sperm concentration; however, rabbits are 3.75 more sensitive in terms of absolute decrease in sperm count for a given blood lead level.

Paternal exposure of rabbits to lead: behavioral deficits in offspring.

Paternal exposures to exogenous agents have been reported to produce a variety of developmental defects in the offspring. In experimental animals, these effects include decreased litter size and weight, increased stillbirth and neonatal death, birth defects, tumors, and functional/behavioral abnormalities-some of these effects being transmitted to the second and third generations. The majority of experimental studies assessing nervous system function of offspring following paternal exposures have utilized rats as the experimental animal, but other species can be used. The National Toxicology Program (NTP) has initiated studies to validate the rabbit as an animal model for human reproductive toxicity, because rabbits are the smallest laboratory animal from which ejaculates can be collected repeatedly. An important part of reproductive toxicology is assessment of the reproductive ability of males following exposure, as well as developmental and functional assessment of their offspring. This article describes a pilot study and a main study to investigate the feasibility of using rabbits to assess the functional effects of paternal exposure to lead. The pilot study included seven male rabbits per group exposed for 15 weeks to lead acetate sufficient to produce 0, 50, or 110 micrograms/dl blood lead. The main study included 15 male rabbits per group exposed for 15 weeks to lead acetate to produce 0, 20, 40, and 80 micrograms/dl blood lead. At the conclusion of the exposure, male rabbits were mated with unexposed females. These females carried their litters to term, delivered, and reared their own offspring. The offspring were weighed at 5, 10, 15, 20, 25, 30, and some at 35 days of age. They were also tested for exploratory activity in a standard figure-eight "maze" for 30 min/day on days 15, 20, 25, and 30. A second assessment of exploratory behavior, along with a simple test of aversive conditioning, was attempted in the pilot study, but was judged not to be suitable for the main study. Of the 21 male rabbits that were mated in the pilot study, 16 produced viable litters (6/7, 6/7, and 4/7 in control, low- and high-lead groups, respectively), with a mean number of 6 live births/litter in each treatment group (range 2-8). Of the 60 rabbits mated in the main study, 57 produced litters, and two rabbits died giving birth. Significant postnatal deaths were observed in all groups, with about one half of the offspring dying before testing was initiated at day 15. There were no treatment-related effects on offspring weight gain through wearing. The data suggest that paternal lead exposure of rabbits may reduce figure-eight activity on day 25, the time of peak activity in the offspring.

Review of experimental male-mediated behavioral and neurochemical disorders.

Paternal exposures to exogenous agents have been reported to produce a variety of developmental defects in the offspring. In experimental animals, these effects include decreased litter size and weight, increased stillbirth and neonatal death, birth defects, tumors, and functional/behavioral abnormalities-some of these effects being transmitted to the second and third generations. This article reviews the exogenous agents that have reportedly caused behavioral or neurochemical alterations in offspring of experimental animals following paternal exposures, including advanced age, alcohols, cyclophosphamide, ethylene dibromide, lead, opiates, and a few miscellaneous chemicals. Based upon the consistency of effects in several of these agents in a variety of studies in experimental animals, the conclusion is that paternal exposures may contribute to the incidence of neurobehavioral disorders in humans.

Fibrogenic potentials of coal slags used as abrasive blasting substitutes.

This study was designed to examine the fibrogenic potentials of four coal slags that are being used as substitutes for silica sand in abrasive blasting. Six groups of 100 male Sprague-Dawley rats, including four coal slag groups, a vehicle control, and a positive control for fibrosis (Minusil quartz), were used. Each dust treatment group was given a single 40-mg dose of test agent via intratracheal instillation. Interim sacrifices of 15 animals per group were performed at 2 d, 3 mo, and 6 mo posttreatment, with the terminal sacrifice conducted at 12 mo. Hematoxylin and eosin stained histologic sections were prepared from designated formalin-fixed tissues collected at each necropsy and examined microscopically. Pulmonary silicon analyses were performed for each group at the 2-d and 12-mo sacrifices. Pulmonary function analyses were conducted for each group at the 3-, 6-, and 12-mo sacrifices. Lung hydroxyproline analyses were conducted for 15 animals in each group at the terminal sacrifice. The pulmonary fibrogenic potentials of the four coal slag groups were compared histologically with the Minusil and vehicle controls. A mild to moderate interstitial fibrosis, which was progressive with time, was noted in each of the coal slag groups. However, the coal slag-induced lung fibrosis was much less than that produced by Minusil. Differences in fibrosis among the individual coal slags were relatively minor and certainly not as striking as those between the slags and Minusil. Other data derived from this study, such as lung hydroxyproline content, pulmonary particulate burdens, pulmonary function, and animal body weights, provided further evidence of a reduced toxicity for the coal slags compared to Minusil.

Pulmonary reactivity to vanadium pentoxide following subchronic inhalation exposure in a non-human primate animal model.

An experimental study was conducted to evaluate changes in pulmonary reactivity resulting from repeated vanadium pentoxide (V2O5) dust inhalation. The study assessed pulmonary reactivity to V2O5 through the use of provocation challenges, and compared V2O5 reactivity before and after subchronic V2O5 exposure. A total of 24 adult, male cynomolgus monkeys (Macaca fascicularis) were exposed by inhalation for 6 h per day, 5 days per week, for 26 weeks. Two V2O5-exposed groups (n = 8 each) received equal weekly V2O5 exposures (concentration x time) with different exposure profiles. One V2O5-exposed group received 0.1 mg V2O5 m-3 on Mondays, Wednesday and Fridays, with a twice-weekly peak exposure of 1.1 mg V2O5 m-3 on Tuesdays and Thursdays, and was included to investigate the influence of an exposure regimen with peaks on the development of pulmonary hyper-reactivity. The other V2O5-exposed group received a constant daily concentration of 0.5 mg V2O5 m-3. A control group (n = 8) received filtered, conditioned air. Pre-exposure challenges with V2O5 produced a concentration-dependent impairment in pulmonary function, characterized by airway obstructive changes (increased resistance and decreased flow). Analysis of respiratory cells recovered from the lung by bronchoalveolar lavage demonstrated that airway obstruction was accompanied by a significant influx of inflammatory cells into the lung. Subchronic V2O5 inhalation did not produce an increase in V2O5 reactivity in comparison to the control group, and cytological, immunological and skin test results indicate the absence of allergic sensitization. Instead, a trend toward decreased pulmonary reactivity was found following subchronic V2O5 inhalation.(ABSTRACT TRUNCATED AT 250 WORDS)

Evaluation of the onset and duration of response to cold air inhalation challenge in cynomolgus monkeys (Macaca fascicularis).

Cold air inhalation challenge (CAIC) for the evaluation of bronchial reactivity has been proposed as a physical agent alternative to chemical agent challenges (methacholine or histamine), especially suitable for the occupational environment. The present investigation describes and evaluates a method for performing cold air inhalation challenge in Cynomolgus monkeys (Macaca fascicularis), a species shown to be useful in animal modeling studies of occupational asthma. Six adult male anesthetized monkeys were ventilated by changes in external pressure while breathing cold air (-25 degrees C to -30 degrees C). Pulmonary function testing was performed at 10, 25, 40 and 55 min post-challenge. Significant increases (P less than 0.05) in average pulmonary flow resistance (RL) and decreases in dynamic compliance (CL dyn) were observed, with maximum impairment occurring at 25 min post-challenge, with a trend towards a return to baseline values at 55 min post-challenge. Peak expiratory flow rate (PEFR), forced expiratory volume in 0.5 s/forced vital capacity (FEV0.5/FVC) and forced expiratory flow at 50% forced vital capacity (FEF50) showed the same general pattern of reduction as seen with RL; however, these results were not statistically significant, most probably owing to individual monkey variability and the small number of monkeys (N = 6) used. A repeat challenge at 25 min after a primary challenge yielded increased RL in one monkey, suggesting that no absolute refractory period is present from CAIC. Results of these studies demonstrate that CAIC causes bronchoconstriction in monkeys and may be useful in further animal modeling studies designed to determine the asthmogenic/airway irritant potential of occupational toxicants.

Subchronic inhalation of triethylamine vapor in Fischer-344 rats: organ system toxicity.

Male and female F-344 rats were exposed at 0, 25, or 247 ppm triethylamine (TEA) vapor, 6 hr per day, 5 days per week for up to 28 weeks in order to characterize the subchronic organ system toxicity. Rats were weighed biweekly and scheduled sacrifices were performed following about 30, 60, and 120 days of exposure. No statistically significant treatment-related effects on organ weights, hematology, clinical chemistry, or electrocardiographic indices were observed. Body weight gain was not affected by TEA treatment. No physiologic or pathologic evidence of cardiotoxicity was seen in rats exposed to either TEA concentration for up to 28 weeks. No gross or histopathologic lesions attributable to TEA exposure were noted in any of the organs examined, including the nasal passages. This latter finding is in marked contrast to previously reported findings from this laboratory in which squamous metaplasia, suppurative rhinitis, and lymphoid hyperplasia were found in the respiratory epithelium of F-344 rats exposed to the structurally related chemical, diethylamine, under the same conditions as this study (Lynch et al., 1986).

Acute airway narrowing in monkeys from challenge with 2.5 ppm formaldehyde generated from formalin.

Nine adult male Cynomolgus monkeys (Macaca fascicularis) were exposed for 10 min to 2.55 +/- 0.03 ppm formaldehyde (HCHO; mean +/- standard error of the mean, SEM) generated from formalin with a newly developed HCHO challenge system. The generation system was capable of producing highly stable HCHO vapor concentrations with fluctuations of HCHO concentrations of less than +/- 5%. The experimental design included pre-exposure methacholine challenge to determine if responses to HCHO were associated with pre-existing bronchial hyperreactivity. Significant changes in average pulmonary flow resistance (RL) were observed (compared to control RL values) at 2 (p less than 0.01), 5 (p less than 0.01), and 10 min (p less than 0.005) post-HCHO challenge. Pre-challenge RL values (mean +/- SEM) were 11.3 +/- 1.4 cm H2O.l/s, while at 2, 5, and 10 min after HCHO challenge, values were 16.1 +/- 2.1, 16.9 +/- 2.8 and 20.0 +/- 3.4 cm H2O.l/s, respectively. Methacholine challenge data suggest that reactions to HCHO tend to be greater in monkeys hyperreactive to methacholine, but the relationship does not reach statistical significance in this small series of animals. These data indicate that significant pulmonary function deficits occur immediately after challenge with 2.55 ppm HCHO vapor in monkeys.

Immune responses of cynomolgus monkeys to phthalic anhydride.

Four groups of four Macaca fascicularis monkeys were administered 10 consecutive weekly subcutaneous injections of 2 mg aluminum hydroxide plus one of the following: 200 micrograms of phthalic anhydride (PA)-monkey serum albumin (PA-MSA, group 1); 200 micrograms of PA dissolved in ethanol-saline (EtOH-sal, group 2); 200 micrograms of MSA (group 3); or EtOH-sal alone (group 4). Direct intracutaneous tests to PA-MSA, PA-EtOH-sal, MSA, and EtOH-sal were applied at biweekly intervals throughout the course of the immunization. Serum-specific IgG to PA-MSA and specific IgE to PA-MSA were determined at 2-week intervals according to the ELISA and RAST methods, respectively. The prevalence of cutaneous sensitivity to PA-MSA in the PA-MSA-immunized group (group 1) was significantly greater after 4 and 6 (p less than 0.01) and 8 and 10 (p less than 0.05) weeks, compared with the other treatment groups. Significantly elevated (p less than 0.01) PA-MSA-specific IgG was also observed in monkeys in group 1 compared with the other treatment groups. No significant changes in PA-MSA RAST or total IgE were observed in any group during the study. These results indicate that parenteral sensitization to PA in subhuman primates requires the presence of new antigenic determinants formed by PA on protein carriers.

Ozone enhancement of platinum asthma in a primate model.

Three groups of adult male cynomolgus monkeys (Macaca fascicularis) were exposed to either 200 micrograms/m3 ammonium hexachloroplatinate [(NH4)2PtCl6], 200 micrograms (NH4)2PtCl6 concurrently with 1 ppm ozone (O3), or to 1 ppm O3 only. The animals were exposed by inhalation for 6 h per day, 5 days per week for 12 wk. The experimental design included methacholine preexposure and Na2PtCl6 bronchoprovocation challenge evaluations, Na2PtCl6 threshold skin tests, and sera for analyses of antibodies. Two weeks after the 12-wk exposures, these same indices were reevaluated. Baseline pulmonary function was not significantly affected by the exposure regimens; however, the combination of exposure to O3 and (NH4)2PtCl6 significantly reduced the concentration of platinum (Pt) salt and methacholine necessary to increase average pulmonary flow resistance (RL) 200% (EC200 RL). Ozone or Pt exposure alone had no significant effect on these parameters. Platinum and methacholine EC200 RL values were highly correlated for both Pt-exposed groups after exposure. These data indicated that combined O3 and Pt exposure significantly increased specific (Pt) and nonspecific (methacholine) bronchial hyperreactivity more often than did exposure to either O3 or the Pt salt alone. Combined O3 plus Pt exposure also significantly increases the incidence of positive Pt skin tests when compared with the other exposure groups. Similar to the human experience, radioallergosorbent testing (RAST) for Pt-specific antibodies was not as sensitive as direct skin testing in identifying allergic persons.

Pulmonary function analysis in the rabbit following bronchochallenge to causative agents and mediators of the acute byssinotic response.

New Zealand White rabbits were acutely bronchochallenged for 5 min to ascertain airway responsiveness with six potential byssinogenic agents and mediators: 0.1 g/mL cotton dust extract (CDE), 0.1 g/mL cotton bract extract (CBE), 1 mg/mL endotoxin, 1 mg/mL n-formyl methionyl peptide (n-fMet), 10 mg/mL 5-hydroxytryptamine (5-HT), and 1 mg/mL prostaglandin F2 alpha (PGF2 alpha). Methacholine (MC), 10 mg/mL, was used as a control bronchoconstrictor. Clinically objective criteria were established using increases in resistance values compared to those obtained with saline controls. Animals were classified as: mild responders (Mi) = 125-149%; moderate responders (Mo) = 150-199%; or severe responders (S) = greater than 200%. Three of five (2Mo, 1S) rabbits showed increased pulmonary resistance to CDE bronchochallenge, 3/5 (1Mi, 1Mo, 1S) to CBE, 1/5 (Mo) to purified endotoxin, 4/5 (1Mo, 3S) to n-fMet, 3/5 (1Mi, 1Mo, 1S) to 5-HT, and 2/5 (1Mo, 1S) to PGF2 alpha. All five rabbits (1Mo, 4S) responded to MC bronchochallenge. Rabbits responded minimally to saline, the common solvent of all test agents; however, when challenged with methacholine, a known bronchoconstrictor, rabbits showed significant overt symptoms of acute respiratory distress with immediate and substantial increases in resistance over saline controls. CDE, CBE, and n-fMet inhalation challenge resulted in a majority or all animals showing increased resistance. 5-HT contained in CDE and CBE, exhibited similar resistance increases; however, endotoxin, also found in cotton dust, showed little airway reactivity. The rabbit is useful for characterizing changes in pulmonary function parameters seen in the acute byssinotic reaction. This study has demonstrated that bronchochallenge in the rabbit with potential byssinogenic agents (CDE, CBE, endotoxin, and n-fMet) and mediators (5-HT and PGF2 alpha) result in measurable changes in airway function, particularly increased resistance. Since bronchoconstriction is the major clinical manifestation of the acute byssinotic reaction in man and animals, it is likely that bronchoconstriction observed in cotton mill workers may be in part or totally the result of inherent dust constrictor substances or secondarily released mediators.

Subchronic inhalation of diethylamine vapor in Fischer-344 rats: organ system toxicity.

Male and female Fischer 344 (F-344) rats were exposed at 0,25 or 250 ppm diethylamine (DEA) vapor, 6.5 hr per day, 5 days per week, for 24 weeks in order to assess cardiac and other organ system toxicity. Scheduled sacrifices were performed following 30, 60, and 120 days of exposure. During the first 2 weeks of exposure, the rats exposed at 250 ppm DEA did not gain weight. After 2 weeks, however, the rate of weight gain of these rats was greater than that of controls. Nevertheless, mean body weights for both sexes of rats exposed at 250 ppm DEA remained depressed compared to controls throughout the study. Sneezing, tearing, and reddened noses were seen in rats exposed at 250 ppm DEA. Histopathologic examinations revealed lesions of the nasal mucosa of rats exposed at 250 ppm DEA (rats exposed at 25 ppm were not evaluated). These lesions of the respiratory epithelium consisted of squamous metaplasia, suppurative rhinitis, and lymphoid hyperplasia. There were no pronounced treatment-related effects on organ weights, hematology, or clinical chemistry indices except for blood urea nitrogen which was evaluated in rats of both sexes exposed at 250 ppm DEA for 24 weeks. In contrast to the high-dose animals, no treatment-related effects were observed in rats intermittently exposed at 25 ppm DEA for up to 24 weeks. No evidence of cardiotoxicity was seen in rats exposed to either DEA concentration for up to 24 weeks.

Pulmonary effects of acute vanadium pentoxide inhalation in monkeys.

An experimental study was conducted to investigate the hypothesis that changes in pulmonary function induced by vanadium pentoxide (V2O5) inhalation would be accompanied by evidence of pulmonary inflammation. Sixteen adult, male cynomolgus monkeys were acutely exposed by whole-body inhalation of V2O5 dust at aerosol concentrations of 0.5 mg V2O5/m3 and 5.0 mg V2O5/m3, conducted at a 1-wk interval. Comprehensive pulmonary function tests were performed 1 day after each inhalation exposure to detect functional changes in the airways and pulmonary parenchyma. Pulmonary inflammation was assessed by cytologic analysis of respiratory cells recovered from the lower respiratory tract by bronchoalveolar lavage (BAL). Postexposure values for pulmonary function and BAL were compared with the baseline values determined for each monkey prior to V2O5 exposure. Acute V2O5 dust inhalation produced significant air-flow limitation in both central and peripheral airways without producing any detectable changes in parenchymal function. These functional changes were accompanied by a significant increase in the total cell counts recovered from the lungs by BAL. The increase in total cell count occurred through a dramatic increase in absolute number and relative percentage of polymorphonuclear leukocytes (PMN). These findings suggest that pulmonary inflammatory changes involving PMN may play an important role in the occurrence of air-flow limitation after acute inhalation of V2O5 dust.

The diversity of reaginic immune responses to platinum and palladium metallic salts.

As part of a National Institute for Occupational Safety and Health health hazards evaluation, workers employed in a precious metal refinery exposed to platinum (Pt), palladium (Pd), and other group VIII metallic salts were evaluated for direct skin test sensitivity to Pt. Current (107) and former (30) workers who quit or were discharged because of Pt-related health problems were prick tested with ammonium hexachloroplatinate ([NH4]2 PtCl6). Of the 107 currently exposed workers, 15 (14%) exhibited positive skin tests, as indexed by immediate reactivity at a dose of 10(-3) gm/ml or less. Eight (27%) of the 30 former workers no longer exposed to Pt also demonstrated positive Pt skin tests. Sera obtained from the workers were assessed for transferable antibodies to Pt and Pd salts by monkey passive cutaneous anaphylaxis. In addition, Pt-specific antibodies were evaluated by RAST. Results of these studies suggested that short- and long-term passive cutaneous anaphylaxis immune responses occur after exposure to both Pt and Pd compounds. Results of RAST analysis for Pt-specific antibodies indicated that significantly higher (p less than 0.001) levels were present in the sera of skin test-positive workers as compared to control sera from Pt-exposed, skin test-negative workers or nonexposed control subjects. Evidence was also obtained that Pt or Pt-protein adducts present in the sera of exposed workers may compete for IgE-binding sites in the RAST assay. The specificity of the Pt-specific RAST system was proved by inhibition experiments.

Analysis of emissions collected from four types of iron casting molds.

The levels of polycyclic aromatic hydrocarbons (PAH) and related compounds, phenols and particulates were determined in emissions collected from iron casting molds composed of four different types of chemical binders: furan, urethane, green sand with sea coal and phenol-formaldehyde resins in shell molds. The shell sample, with 50% particulates, contained the most water-soluble material; green sand, 25% particulates; furan, 10% particulates; and urethane, less than 2% particulate material. The portion of the particulate fraction soluble in cyclohexane varies from 16 to 36% between mold types; emissions from urethane and furan molds contained the lowest quantities of cyclohexane-soluble components and of PAH and related compounds. Phenol, which was found in all four foundry samples, was present in the highest concentration in emissions from urethane molds. Shell mold emissions contained the highest levels of 2- and 4-nitrophenol.