Air-classified faba bean protein fraction as a substitute to soybean meal in pelleted and extruded broiler diets.

1. The hypothesis that air-classified faba bean protein fraction (FBP) can replace soybean meal (SBM) in pelleted or extruded broiler diets without adverse effect on performance or nutrient digestibility was tested.2. At 17 d of age, male broilers were randomly distriibuted among four dietary treatments consisting of either SBM or FBP (main dietary protein source) and pelleting or extrusion as processing methods. Treatments had 10 replicate pens containing five birds each.3. Compared to SBM, birds fed FBP had significantly lower feed intake, less weight gain and had poorer feed conversion.4. Pellet durability was high (above 92%) for all diets. In pelleted diets, FBP was harder than SBM whereas extruded diets had similar hardness. Pelleting increased water stability compared to extrusion. FBP diets were more water stable than the SBM diets.5. Gizzard content weight was 2.2-fold higher (P = 0.002) for birds given FBP compared to those fed SBM. The weight of the jejunum and ileum with contents was 1.4-fold lower for the FBP diets, and this effect was larger (P < 0.05) for the extruded FBP diet.6. Birds fed FBP diets had significantly higher nitrogen digestibility in the lower jejunum and ileum compared to those given SBM diets, while the starch digestibility coefficient was above 0.980 in all treatments.7. The high nutrient digestibility of FBP diets indicates that the poor performance of the FBP group was due to lower feed intake which was not explained by the differences in pellet durability or hardness. The reduced palatability of the FBP and the longer retention of the FBP diets in the upper gut are more likely to have depressed feed intake.

Interactions between starch source and gelatinisation degree on performance and small intestinal digestion in broiler chickens.

1. A 2 × 2 factorial arrangement was used to test the hypothesis that, in pelleted diets, legume starch is digested less rapidly and to a lesser extent than cereal starch, and that increased gelatinisation through extrusion would eliminate the differences between the starch sources. In addition, the trial examined whether a lower ratio of starch to nitrogen disappearance rate (SNDR) could improve feed conversion ratio (FCR).2. At 17 d of age, male broilers were randomly distributed among four dietary treatments, consisting of either wheat or faba bean starch-rich fraction (FBS) as the sole starch source and pelleting or extrusion as processing methods. Each treatment had 10 replicate pens containing five birds each.3. Extrusion resulted in a more extensive starch gelatinisation compared to pelleting, as expected.4. No difference in weight gain at 29 d of age was observed between birds fed starch sources. However, birds fed wheat tended (P = 0.080) to have better FCR than those fed FBS, while the effect of processing methods was insignificant. Thus, there was no interaction between starch source and processing method on FCR.5. In pelleted diets, FBS had lower and slower starch digestibility compared to wheat in all intestinal segments (P < 0.05). The interaction between starch source and processing method in all intestinal segments (P < 0.001) demonstrated that FBS responded more to gelatinisation through extrusion than did wheat. Thus, differences in starch digestibility between the wheat and FBS were eliminated with extrusion.6. Feeding extruded diets significantly increased the upper jejunal expression of GLUT1, GLUT2 and SGLT1 compared to pelleted diets, which suggested that glucose absorption was less likely to be a limiting factor for starch utilisation.7. Pelleting resulted in a lower ratio (P < 0.001) of SNDR compared to extrusion (on average 1.4-fold) but did not improve FCR.

Varying starch to fat ratios in pelleted diets: I. Effects on nutrient digestibility and production performance in Eimeria-challenged broiler chickens.

1. The hypothesis was that a diet with a high starch to fat ratio (HS) impairs nutrient digestibility and growth performance, as compared to a diet with a low starch to fat ratio (LS) in Eimeria-challenged broilers. From days 10 to 29, 12 replicate pens of birds were given isocaloric and isonitrogenous steam-pelleted diets with either HS or LS, by replacing the wheat starch in one diet by a mixture of rapeseed oil and inert sand in the other. On d 17, a 10-fold dose of live vaccine strains of Eimeria spp. was administered via drinking water. Ileal samples were collected on days 16 and 29. 2. Starch content in the ileum tended to be higher on d 16 and was significantly higher on d 29 in the HS group. 3. The HS diet did not induce exceedingly high levels of starch in the ileum, suggesting there was no starch overload in the gut. Ileal starch digestibility was improved with increasing dietary starch level from 23% to 45%. This demonstrated the capacity of the broiler chicken to digest high levels of starch regardless of Eimeria spp. infection. Ileal energy digestibility was not affected by the treatments. 4. Weight gain did not differ between treatments; however, birds fed the LS diet were less efficient in feed conversion as compared to those fed the HS diet. 5. The use of isolated starch and the unintended higher extent of starch gelatinisation in the HS diet may have contributed to the higher starch digestibility in birds given the HS diet. Thus, the hypothesis that high ratios of starch to fat in pelleted diets may impair starch digestibility and production performance in Eimeria-challenged broiler chickens was not verified. Further work is required to clarify this research question, taking into consideration the physical form of starch source and the potentially confounding role of feed processing on starch availability.

Increasing levels of rapeseed expeller meal in diets for pigs: effects on protein and energy metabolism.

The heavy reliance on imported soybean meal (SBM) as a protein source makes it necessary for the European pig industry to search for alternatives and to develop pigs that perform efficiently when fed such ingredients. Digestion and metabolism are major physiological processes contributing to variation in feed efficiency. Therefore, an experiment was conducted to assess the effects of replacing SBM with increasing levels of rapeseed meal (RSM) in diets for young pigs on apparent total tract digestibility (ATTD) of energy and nutrients, nitrogen (N) balance, energy metabolism and carbohydrate, protein and fat oxidation. Four diets were fed to 32 pigs (22.7±4.1 kg initial BW) for three weeks. The diets consisted of a control cereal grain-SBM basal diet and three test diets where SBM and wheat were partially replaced with 10%, 20%, and 30% of expeller RSM. Increasing level of RSM in the diets linearly reduced ATTD of organic matter, CP, total carbohydrates, dietary fiber and energy. Utilization of digested nitrogen (DN) for N retention and total N excretion were not affected by RSM inclusion, however, RSM inclusion induced a shift in N excretion from urine to feces. Despite a linear increase in liver to metabolic BW ratio, heat production and utilization of metabolizable energy (ME) for retention were not affected by increasing RSM inclusion. In conclusion, replacing SBM with up to 30% of expeller RSM in nutritionally balanced diets for young pigs reduced the ATTD of most nutrients and energy, but did not affect N and energy retention in the body or efficiency of utilization of DN or ME for retention.

Identification of redox imbalance as a prominent metabolic response elicited by rapeseed feeding in swine metabolome.

Rapeseed (RS) is an abundant and inexpensive source of energy and AA in diets for monogastrics and a sustainable alternative to soybean meal. It also contains diverse bioactive phytochemicals that could have antinutritional effects at high dose. When the RS-derived feed ingredients (RSF) are used in swine diets, the uptake of these nutrients and phytochemicals is expected to affect the metabolic system. In this study, 2 groups of young pigs (17.8 ± 2.7 kg initial BW) were equally fed a soybean meal-based control diet and an RSF-based diet, respectively, for 3 wk. Digesta, liver, and serum samples from these pigs were examined by liquid chromatography-mass spectrometry-based metabolomic analysis to determine the metabolic effects of the 2 diets. Analyses of digesta samples revealed that sinapine, sinapic acid, and gluconapin were robust exposure markers of RS. The distribution of free AA along the intestine of RSF pigs was consistent with the reduced apparent ileal digestibility of AA observed in these pigs. Despite its higher fiber content, the RSF diet did not affect microbial metabolites in the digesta, including short-chain fatty acids and secondary bile acids. Analyses of the liver and serum samples revealed that RSF altered the levels of AA metabolites involved in the urea cycle and 1-carbon metabolism. More importantly, RSF increased the levels of multiple oxidized metabolites and aldehydes while decreased the levels of ascorbic acid and docosahexaenoic acid-containing lipids in the liver and serum, suggesting that RSF could disrupt redox balance in young pigs. Overall, the results indicated that RSF elicited diverse metabolic events in young pigs through its influences on nutrient and antioxidant metabolism, which might affect the performance and health in long-term feeding and also provide the venues for nutritional and processing interventions to improve the utilization of RSF in pigs.

Granulomatous enteritis in rainbow trout (Oncorhynchus mykiss) associated with soya bean meal regardless of water dissolved oxygen level.

This study investigated morphological changes associated with soya bean meal-induced enteritis (SBMIE) in distal intestine (DI) of rainbow trout (Oncorhynchus mykiss) fed a soya bean meal (SBM)-based diet and exposed to normoxia or hypoxia created by optimal and low water flow rates, respectively. A 28-day adaption period was followed by a 42-day challenge period where 600 fish were subjected to dietary challenge and/or hypoxia. Twelve tanks each containing 50 juvenile trout were assigned randomly in triplicate to each treatment. Histopathological and immunohistochemical evaluation revealed pathological features that have not previously been described in association with SBMIE. Vacuolar degeneration of epithelial cells mainly at the base of mucosal folds, epithelial cysts, epithelial dysplasia, necrosis, shedding of necrotic cells, and granulomatous inflammation including infiltration of enlarged, sometimes finely vacuolated or "foamy" macrophages, multinucleated giant cells and increased proliferation of fibroblasts were observed. Acid-fast bacteria were not detected in enlarged macrophages; however, these cells contained AB-PAS- and sometimes cytokeratin-positive material, which was interpreted to be of epithelial/goblet cell origin. Hypoxia did not affect the morphological changes in DI. These results suggest that SBM was associated with a granulomatous form of enteritis in DI of rainbow trout regardless of water oxygen level.

Effect of intermittent feeding and oat hulls to improve phytase efficacy and digestive function in broiler chickens.

1. Two trials were carried out to investigate the impact of intermittent feeding and oat hulls as methods to stimulate the anterior digestive tract in broiler chickens. 2. In Trial 1, 7-d-old broilers were placed 4 per cage in 48 cages and fed either ad libitum or intermittently on a diet with 50 g/kg of either oat hulls or cellulose, with or without 1000 FTU phytase, in a 2 × 2 × 2 factorial arrangement. Ad libitum fed birds had two 4-h dark periods with 1-h light in between, while intermittently fed birds in addition had restricted access to feed through four 1 h feeding bouts. 3. In Trial 2, 144 broiler chickens were divided amongst 12 pens which were intermittently fed on the same diets as in Trial 1 in a 2 × 2 factorial arrangement. At 34 d of age, after 16 h feed withdrawal, birds were fed for 1 h, followed by dissection of 4 birds per treatment every hour for 9 h. Contents from different segments of the digestive tract were collected quantitatively to assess dry matter (DM) and starch flow. 4. In Trial 1, phytase improved performance and nutrient availability, while oat hulls and intermittent feeding improved some measures of nutrient availability. Intermittent feeding augmented the effect of phytase on myo-inositol hexakisphosphate (IP6) degradation in the anterior digestive tract. 5. In Trial 2, birds filled up their crop and slowly passed these contents on to lower segments of the digestive tract. Already 1 h after commencement of feeding, the entire length of the small intestine was filled with DM, and no significant changes in DM content were observed before 4-5 h later, when the small intestine gradually became emptied. The tendency for a higher initial load of DM and starch in birds without oat hulls seems to support the hypothesis that one important function of the gizzard is feed-flow regulation. 6. In conclusion, the anterior digestive tract seems to have an important regulative function in broiler chickens when stimulated by intermittent feeding or structural components. More research is needed in order to elucidate the role of the crop and gizzard for phytase function.

Composition of individual nucleobases in diets containing different products from bacterial biomass grown on natural gas, and digestibility in mink (Mustela vison).

The objectives of the present study were to quantify the amount of nucleic acids, to examine the nucleobase composition and to determine the digestibility of individual nucleobases in diets containing various products from bacterial biomass grown on natural gas, including autolytic and hydrolytic fractions, using mink (Mustela vison) as a model animal. The diets consisted of cod fillet (control), commercial basic BioProtein, and five experimentally produced autolytic and hydrolytic fractions of the bacterial protein meal as protein sources. Each diet was assigned to four adult male mink, housed individually in cages equipped for controlled feeding and quantitative collection of faeces. Faeces were collected for 4 days, and the individual nucleobases in diet and faeces were analysed by HPLC after hydrolysis using HClO(4). The content of nucleobases in the diets containing bacterial protein meal was 37% to 205% higher than in the control diet. The nucleobase-nitrogen in the control diet amounted to 4.3% of the total nitrogen content, whereas the experimental bacterial protein diets contained from 7.4% to 17.4% of the total N content in the form of nucleic acids. The various methods used to produce the bacterial protein fractions clearly affected both the amount of nucleic acids and the molar proportions of the individual nucleobases. The average digestibility of the nucleobases was 95%, and all the individual nucleobases were highly digestible. Uracil showed the highest digestibility (on average 96.8%), whereas thymine showed the lowest digestibility (on average 93.6%).

Post-ruminal or intravenous infusions of carbohydrates or amino acids to dairy cows 2. Late lactation.

The objectives of this study were to compare the effects of post-ruminal and intravenous infusions of wheat starch or glucose (CHO) or a mixture of amino acids (AA) on milk protein yield, nitrogen (N) utilisation, plasma metabolites and mammary extraction rate of dairy cows in late lactation. Eight cow, ruminally fistulated, was assigned to two 4 × 4 Latin squares during 14-day periods, where the last 7 days were for infusions. Infusions were: (1) starch in the abomasum (SP), (2) glucose in the blood (GB), (3) AA in the abomasum (AP), and (4) AA in the blood (AB). The experiment started 165 ± 4 days (mean ± s.e.) post partum (milk yield 22.5 ± 1.1 kg) Daily amounts of nutrients infused were 257, 283, 233, and 260 g for SP, GB, AP and AB, respectively. The cows were fed a basal diet consisting of a concentrate mixture and grass silage (55:45 on a dry-matter (DM) basis), where total dry-matter intake (DMI) was 13.3 kg/day. Milk production was affected by site of infusion within substrate, whereas infusion substrates within infusion site (CHO or AA) were of minor importance. Responses to intravenous infusions (GB or AB) were similar to those in early lactation, but more pronounced. Compared with SP infusion, GB infusion increased ( P < 0.05) milk yield, energy-corrected milk (ECM), protein and lactose yield by 1.4 and 0.9 kg, 38 and 59 g, respectively. The AB infusion had 1.4 and 1.3 kg, 51, 52 and 50 g higher ( P < 0.05) milk yield, ECM, protein, fat and lactose yields than the AP infusion, respectively. N balance data indicated higher losses of metabolic faecal nitrogen (MFN) by abomasal than by intravenous infusions, but the catabolism of AA was lower than in early lactation indicated by no difference ( P < 0.05) in urinary N excretion between treatments. Intravenous AA infusion increased plasma glucose and insulin above that of intravenous glucose infusion. The treatment effects on plasma insulin concentrations were higher in late than in early lactation, suggesting a higher sensitivity in late lactation even at similar negative energy balance. Compared with the SP infusion, GB infusion showed lower ( P < 0.05) concentrations of essential AA (EAA) and branched-chain AA (BCAA) resulting in a higher AA utilisation because of a higher milk protein production. AP infusion increased ( P < 0.05) plasma non-essential AA concentration compared with AB infusion, but infusion site of AA had no effect ( P>0.05) on plasma EAA or BCAA. It is concluded that it is the nutrient supply and not the lactation stage per se that is important for the response in milk production. Nevertheless, stage of lactation affects the N metabolism and the response in plasma hormone concentrations even when cows are in negative energy balance in both lactation stages.

Apparent ruminal degradation and rumen escape of soluble nitrogen fractions in grass and grass silage administered intraruminally to lactating dairy cows.

The main objective of this study was to investigate in vivo ruminal degradation and rumen escape of soluble N fractions in grass and grass silage. Soluble protein and long-chain peptides (PLP), small peptides (SP) and free AA (FAA) were obtained from fresh grass and grass silages fertilized with different levels of N. Soluble extracts from the forages were pulse dosed into the rumen of three cannulated lactating dairy cows, and a simple or complex model was used to examine the kinetics of the soluble N fractions in the rumen. When soluble extracts from silage were investigated, pulse dosages of total nonammonia N (NAN) were 21, 27, and 32 g, while for fresh grass only dosages of 20 g were ruminally administered. In the silage extracts, mean proportions of PLP-N, SP-N, and FAA-N in the NAN were 30, 52, and 18%, respectively, whereas in the fresh grass the corresponding values were 67, 20, and 13%. From silage extracts, all three soluble N fractions showed a linear decrease (P < 0.05) in degradation rate and an increase (P < 0.05) in ruminal escape with increasing dosage. In silage, mean degradation rates, parameterized from the complex model, were 230, 214, and 334%/h for PLP-N, SP-N, and FAA-N, respectively, and the ruminal escape was highest (P < 0.05) for SP-N (11.2% of dose) and lowest (P < 0.05) for FAA-N (5.0% of dose). No differences in degradation rate and ruminal escape between fresh grass and silage were observed. However, the proportion of N dose converted to ammonia was only 24% in the fresh grass, whereas for the silages a mean value of 76% was found. From this study, it is concluded that a significant amount of dietary soluble N escapes ruminal degradation, and thus contributes to the intestinal AA supply. Moreover, if the main aim is to study degradation kinetics of individual N fractions, a complex model should be used in the evaluation. This model can also be used to study ruminal synchronization of N and energy for microbial growth.