Bioconversion of Fish Discards through the Production of Lactic Acid Bacteria and Metabolites: Sustainable Application of Fish Peptones in Nutritive Fermentation Media.

In the current work, we study the capacity of 30 peptones obtained by enzyme proteolysis of ten discarded fish species (hake, megrim, red scorpionfish, pouting, mackerel, gurnard, blue whiting, Atlantic horse mackerel, grenadier, and boarfish) to support the growth and metabolite production of four lactic acid bacteria (LAB) of probiotic and technological importance. Batch fermentations of Lactobacillus plantarum, L. brevis, L. casei, and Leuconostoc mesenteroides in most of the media formulated with fish peptones (87% of the cases) led to similar growths (quantified as dry-weight biomass and viable cells) and metabolites (mainly lactic acid) than in commercial control broth (MRS). Comparisons among cultures were performed by means of the parameters obtained from the mathematical fittings of experimental kinetics to the logistic equation. Modelling among experimental and predicted data from each bioproduction was generally accurate. A simple economic assessment demonstrated the profitability achieved when MRS is substituted by media formulated with fish discards: a 3-4-fold reduction of costs for LAB biomass, viable cells formation, and lactic and acetic acid production. Thus, these fish peptones are promising alternatives to the expensive commercial peptones as well as a possible solution to valorize discarded fish biomasses and by-products.

Optimal Production of Protein Hydrolysates from Monkfish By-Products: Chemical Features and Associated Biological Activities.

The aim of this work was the recovery of protein substrates from monkfish waste (heads and viscera) generated in the on-board processing of this species. Initially, the effect of pH, temperature, and protease concentration was studied on mixtures of a 1:1 ratio (w/v) of monkfish heads/water. The optimal conditions of proteolytic digestion were established at 57.4 °C, pH 8.31, [Alcalase] = 0.05% (v/w) for 3 h of hydrolysis. Later on, a set of hydrolysis at 5L-pH-stat reactor were run under the aforementioned conditions, confirming the validity of the optimization studies for the head and viscera of monkfish. Regarding the chemical properties of the fish protein hydrolysates (FPH), the yield of digestion was higher than 90% in both cases and the degrees of hydrolysis and the soluble protein content were not especially large (<20% and <45 g/L, respectively). In vitro digestibility was higher than 90% and the percentage of essential amino acids ranged from 40 to 42%. Antioxidant activities were higher in viscera FPH, and antihypertensive ability was superior in head FPH. The values of number average molecular weights (Mn) of monkfish hydrolysates were 600 Da in the viscera and 947 Da in the head. The peptide size distribution, obtained by size-exclusion chromatography, indicated that the largest presence of peptides below 1000 Da and 200 Da was observed in the viscera FPH.

Biotechnological Valorization of Food Marine Wastes: Microbial Productions on Peptones Obtained from Aquaculture By-Products.

Based on a biotechnological strategy, in the present work several peptones are produced from the Alcalase hydrolysis (0.1-0.2% v/w, 56-64 °C, pH 8.27-8.98, 3 h) and thermal processing (105 °C, 60 min) of wastes generated from the industrial processing of turbot, salmon, trout, seabream and seabass. These peptones were included (in the range of 2.6-11 g/L of soluble protein) as main source of organic nitrogen (protein substrates) in low-cost media for the culture of lactic acid bacteria (LAB), marine probiotic bacteria (MPB) and ubiquitous Gram+ bacteria. In most cases, batch fermentations conducted in aquaculture peptone media led to the best growth, metabolic productions and yields. Nevertheless, no significant differences between aquaculture peptones and commercial media were generally observed. Kinetic parameters from a logistic equation and used for cultures modeling were applied with the purpose of comparing the bioproduction outcomes. In economical terms, the validity of the aquaculture peptones as substitutives of the peptones (meat extract, casitone, etc.) from commercial media was also compared. The decreasing of the costs for LAB bioproductions ranged between 3-4 times and the growth costs of MPB and Gram+ bacteria were improved more than 70 and 15 times, respectively, in relation to those found in control commercial media.

Production of Marine Probiotic Bacteria in a Cost-Effective Marine Media Based on Peptones Obtained from Discarded Fish By-Products.

The industrial production of marine bacteria with probiotic properties is limited by the excessive cost of the culture media adequate for their growth. The present work aimed to study the suitability of 30 marine media formulated with nitrogen sources (fish peptones) from different fish discards and seawater, for the growth of two marine probiotic bacteria (MPB), namely Phaeobacter sp. and Pseudomonas fluorescens. These fish peptones were produced from several discarded fish and by-products (heads, skins, and whole individuals of megrim, mackerel, gurnard, hake, etc.). In all cultivations, no significant differences were found on cell viability when the microorganism grew on commercial or alternative media. In relation to the biomass production, the growth of Phaeobacter sp. on waste media was commonly similar or a 20% lower than observed in the control cultures. For P. fluorescens, various peptones (skin peptones of pouting and blue whiting) showed even higher productive ability than commercial peptones. An initial economical evaluation revealed that low-cost media reduced until 120 times the cost of production of MPB.

Production of Valuable Compounds and Bioactive Metabolites from By-Products of Fish Discards Using Chemical Processing, Enzymatic Hydrolysis, and Bacterial Fermentation.

The objective of this report was to investigate the isolation and recovery of different biocompounds and bioproducts from wastes (skins and heads) that were obtained from five species discarded by fishing fleets (megrim, hake, boarfish, grenadier, and Atlantic horse mackerel). Based on chemical treatments, enzymatic hydrolysis, and bacterial fermentation, we have isolated and produced gelatinous solutions, oils that are rich in omega-3, fish protein hydrolysates (FPHs) with antioxidant and antihypertensive activities, and peptones. FPHs showed degrees of hydrolysis higher than 13%, with soluble protein concentrations greater than 27 g/L and in vitro digestibilities superior to 90%. Additionally, amino acids compositions were always valuable and bioactivities were, in some cases, remarkable. Peptones that were obtained from FPHs of skin and the heads were demonstrated to be a viable alternative to expensive commercial ones indicated for the production of biomass, lactic acid, and pediocin SA-1 from Pediococcus acidilactici.