Efficiency enhancement of electrocoagulation, ion-exchange resin and reverse osmosis (RO) membrane filtration by prior organic precipitation for treatment of anaerobically-treated palm oil mill effluent.

Anaerobically-treated palm oil mill effluent (POME) still has unacceptable properties for water recycling and reuse, with an unpleasant appearance due to the brownish color caused by tannins and phenolic compounds. This study proposes an approach for treating anaerobically-treated POME for water recycling by combining organic precipitation, electrocoagulation (EC), and ion-exchange resin, followed by reverse osmosis (RO) membrane filtration in series. The results indicated that the organic precipitation enhanced the efficiency of EC treatment in reducing the concentrations of tannins, color, and chemical oxygen demand (COD) of the anaerobically-treated POME effluent, with reductions of 95.73%, 96.31%, and 93.96% for tannin, color, and COD, respectively. Moreover, organic precipitation affected the effectiveness of Ca2+ and Mg2+ ion removal using ion exchange resin and RO membrane filtration. Without prior organic precipitation, the ion-exchange resin process required a longer contact time, and the RO membrane filtration treatment was hardly effective in removing total dissolved solids (TDS). The combined process gave a water quality that meets the criteria set by the Thailand Ministry of Industry for industrial boiler use (COD 88 mg/L, TDS <0.001 mg/L, water hardness <5 mg-CaCO3/L, and pH 6.9).

Chemical and biological effects of zero-valent iron (ZVI) concentration on in-situ production of H2 from ZVI and bioconversion of CO2 into CH4 under anaerobic conditions.

The conversion of carbon dioxide (CO2) to methane (CH4) is a strategy for sequestering CO2. Zero-valent iron (ZVI) has been proposed as an alternative electron donor for the CO2 reduction to CH4. In this study, the effects of ZVI concentrations on the abiotic production of H2 (without the action of microorganisms) in the first part and on the biological conversion of CO2 to CH4 using ZVI as a direct electron donor in the second part were examined. In the abiotic H2 production, the increase in the ZVI concentration from 16 to 32, 64, and 96 g/L was found to have positive effects on both the amounts of H2 generated and the rates of H2 production because the extent of ZVI oxidation positively correlates with increasing surface area. Nevertheless, the increase in ZVI concentration from 96 to 224 g/L did not benefit the H2 production because the ZVI dissolution was suppressed by the increasing aqueous pH above 10. In the bioconversion of CO2 to CH4 using ZVI as an electron donor, the main methanogenesis pathway occurred via hydrogenotrophic methanogenesis at pH 8.7-9.5 driven by the genus Methanobacterium of the class Methanobacteria. At ZVI concentrations of 64 g/L and above, the production of volatile fatty acid (VFA) became clear. Acetate was the main VFA, indicating the induction of homoacetogenesis at ZVI concentrations of 64 g/L and above. In addition, the presence of propionate as the second major VFA suggests the production of propionate from CO2 and acetate under conditions with high H2 partial pressure. The results indicated that the pathway for ZVI/CO2 conversion to CH4 was competitive between hydrogenotrophic methanogenesis and homoacetogenesis.

Correction: Chiangnoon et al. Antibacterial Hydrogel Sheet Dressings Composed of Poly(vinyl alcohol) and Silver Nanoparticles by Electron Beam Irradiation. Gels 2023, 9, 80.

In the original publication [...].

Antibacterial Hydrogel Sheet Dressings Composed of Poly(vinyl alcohol) and Silver Nanoparticles by Electron Beam Irradiation.

Advanced wound dressings that can deliver potent antibacterial action are still much in need, especially for treating wound infections caused by drug-resistant bacteria. In this research, we utilized electron beam (EB) irradiation to develop antibacterial hydrogel sheet dressings from poly(vinyl alcohol) (PVA) and silver nanoparticles (AgNPs) in a two-step processing and evaluated their bactericidal efficacy, as well as the AgNP release. The effect of the irradiation dose on the swelling, gel fraction, network parameters, and mechanical properties of the hydrogels was first determined to establish the optimal doses for the two-step processing. The prototypic hydrogel sheets were then formed in the first EB irradiation and served as a matrix for the AgNP synthesis by the reduction of the silver nitrate precursors during the second EB irradiation. The diffusion assay showed that the minimal inhibition concentration (MIC) of the AgNP-load hydrogels was 0.25 and 0.5 mg/cm2 against Escherichia coli and Staphylococcus aureus, respectively. At these MIC levels, the released AgNPs increased sharply before reaching the maximum, ~950 and 1800 ppb, at 24 h as analyzed by atomic absorption. Therefore, we successfully demonstrated that this two-step processing by EB irradiation provides a convenient platform to fabricate AgNP-loaded hydrogel dressings that can be further developed for wound healing.

Effect of freeze-thaw process on physical properties, microbial activities and population structures of anaerobic sludge.

Effects of the freeze-thaw process on physical properties, cell viability, microbial activities and population structures of anaerobic sludge were investigated. It was found that the sludge volume index was greatly reduced from 16.4 mL/g in the original sludge to 4.0 mL/g in the solid fraction of the frozen-thawed sludge. Even though the freeze-thaw process decreased cell viability in the solid fraction of the frozen-thawed sludge, microbial activity tests showed that the freeze-thaw process enhanced acidogenic activity approximately 20%. The enhanced acidogenic activity of the solid fraction was in good agreement with the enrichment of Clostridiaceae, Porphyromonadaceae and Propionibacteriaceae found in the solid fraction. The relative abundances of Proteobacteria families Oxalobacteraceae, Moraxellaceae, and Pseudomonadaceae were found to be highest in the liquid fraction where they form a substantial proportion of the bacterial community (a total of 59%).

Comparative biochemical methane potential of paragrass using an unacclimated and an acclimated microbial consortium.

The effect of inoculum sources on the anaerobic digestion of paragrass was investigated. Two types of sludge were used as the inoculums: an anaerobic sludge obtained from a domestic wastewater treatment plant (OS) and a sludge acclimated to fibrous substrates in raw palm oil mill effluent (AMC). Microbial activity assays showed that the AMC had hydrolytic and acetogenic activities two times greater than the activities of the OS. In addition, the production of methane from acetate by the AMC occurred without a lag phase, while it took 8 days for the OS to start producing methane from the same substrate. The biochemical methane potential after 80 days digestion was 316 ml STP/g VS(added) using the AMC, and 277 ml STP/g VS(added) using the OS. The methane potential of the paragrass was estimated to be 3337 Nm(3) CH4/ha a.

Anaerobic digestion of glycerol and co-digestion of glycerol and pig manure.

The potential of glycerol obtained from transesterification of waste cooking oil as a main carbon source for biogas production was investigated. The glycerol was highly contaminated with oils and fats and was pretreated with sulfuric acid. Using a carbon source of glucose as a control, we compared biogas production from the acid-treated glycerol in a synthetic medium and the acid-treated glycerol mixed with pig manure. The anaerobic digestion of acid-treated glycerol with supplement in a synthetic medium was found to be satisfactory at organic loading rates (OLR) between 1.3, 1.6 and 2.6 g chemical oxygen demand (COD) L(-1) d(-1). The maximum methane yield of 0.32 L at Standard temperature and pressure (STP) g(-1) COD removal was achieved at an OLR of 1.6 g COD L(-1) d(-1) and the methane content was 54% on an average. At a higher organic loading rate of 5.4 g COD L(-1) d(-1), the propionic acid to acetic acid ratio was higher than the critical threshold limit for metabolic imbalance. Anaerobic digestion of acid-treated glycerol with pig manure was also investigated at the COD ratio of 80:20 (glycerol:pig manure). The anaerobic digestion of acid-treated glycerol with pig manure was found to be satisfactory at organic loading rates between 1.3, 1.7, 2.9 and 5.0 g COD L(-1) d(-1) in terms of COD reduction (>80%) and methane content of (62% on an average). However, the biogas production rate was found to significantly decrease at the highest load. The maximum methane yield of 0.24 L STP g(-1) COD removal was achieved at an OLR of 1.3 g COD L(-1) d(-1).