The toxicological effects of heavy fuel oil category substances.

Heavy fuel oil (HFO) category substances are used to manufacture HFO, a product used in industrial boilers and marine diesel engines. Commercial HFOs and blending stream components are substances of complex and variable composition, composed of C20 to >C50 hydrocarbons, although lower molecular weight material may be added to reduce viscosity and improve flow characteristics. An HFO blending stream (catalytically cracked clarified oil [CCCO]) was tested for target organ and developmental toxicity in rats following repeated dermal administration at doses of 5, 25, or 50 mg/kg/d. In the repeated dose study, there was evidence of increased liver weights, reduced thymus weights, and reductions in hematological parameters with an overall no observed adverse effect level (NOAEL) of 5 mg/kg/d. In the developmental toxicity test, there were significant reductions in fetal survival, significant increases in resorption frequency, and significantly reduced fetal weights with an overall NOAEL of 5 mg/kg/d. These target organ and developmental effects are associated with the types and levels of aromatic constituents in these substances. Among HFO blending streams, CCCOs have the highest levels of aromatics and, because they produce the characteristic toxicological effects at the lowest levels, are considered as "reasonable worst-case examples" for this group of substances. Other HFO category members with lower levels of aromatics produce similar effects but have higher NOAELs. The potential for target organ and developmental effects of other HFO category members can be predicted from information on the types and levels of the aromatic constituents present in these substances.

Characterization of the noncancer hazards of gas oils.

Gas oils, used to manufacture diesel fuel and residential heating oil, are complex hydrocarbon substances with carbon numbers of C9-C30 and boiling ranges of approximately 150 °C to 450 °C. Target organ (liver enlargement, reduced thymus weights, and reductions in hematological parameters) and developmental (reduced fetal viability, increased resorption frequency, and reduced fetal weights) effects are associated with aromatic constituents present in some gas oils. Two types of gas oils were tested for repeated-dose and developmental toxicity following repeated dermal administration. A blend of commercial diesel fuels containing 26% aromatics, primarily single-ring compounds, did not cause either target organ or developmental effects at levels up to 600 mg/kg/d. "Cracked" gas oils containing higher levels of aromatic constituents were also tested. Because of limited sample availability, 2 cracked gas oil samples were tested, one for systemic effects and the other for developmental toxicity. The sample tested in the repeated-dose toxicity study (81% aromatics including approximately 10% 3-ring compounds) produced increased liver weights, reduced thymus weights, and reductions in hematological parameters. The overall no observed adverse effect level (NOAEL) was 100 mg/kg/d. The sample tested for developmental toxicity (65% aromatics including approximately 5% 3-ring compounds) resulted in significant reductions in fetal survival, significant increases in resorption frequency, and significant reductions in fetal weights with an overall NOAEL of 100 mg/kg/d. In summary, gas oils may or may not cause target organ and/or developmental effects depending on the levels and types of aromatic constituents that they contain.

Spontaneous hibernomas in Sprague-Dawley rats.

Hibernomas are rare neoplasms originating in brown adipose tissue of humans and other animal species, including laboratory animals. Background incidence values for these tumors in all common strains of laboratory rats are generally accepted as being <0.1%. Between April 2000 and April 2007, however, sixty-two hibernomas (an overall prevalence of 3.52%) were observed in a total of 1760 Sprague-Dawley rats assigned to three carcinogenesis bioassays at two separate research laboratories. All rats were obtained from Charles River's breeding facilities in either Portage, Michigan, or Raleigh, North Carolina. Tumors (twenty-nine benign and thirty-three malignant) were randomly distributed among test article-treated and control groups and were considered to be spontaneous. Most tumors originated in the thoracic cavity, and they were usually described as soft, mottled to tan masses with nodular to lobulated profiles. Immunohistochemical procedures for uncoupling protein 1 (UCP1) confirmed brown adipose tissue as the site of origin rather than white fat. The marked increase in hibernomas in our studies suggests that greater numbers of spontaneous hibernomas may be sporadically encountered in future carcinogenesis studies with Sprague-Dawley rats. The increased potential for hibernomas to arise as spontaneous neoplasms has important implications in studies involving peroxisome proliferators-activated receptor (PPAR) drugs, lipophilic environmental chemicals (e.g., polychlorinated biphenyls), and other molecules or physiologic processes (e.g., beta-adrenergic stimulation) that may target brown fat adipocytes.