Novel free nitrous acid and ultrasonication pretreatment enhanced sludge biodegradability.

The main goal of this study was to investigate the novel combined Ultrasonication and Free Nitrous Acid (FNA) pretreatment on biodegradability and kinetics of thickened waste-activated sludge (TWAS). Partial factorial design with four levels of (0, 600, 1500, and 3000 KJ/Kg) for ultrasonication and 0, 0.7, 1.4, and 2.8  mg HNO2-N/L for FNA dose were examined creating 16 different combinations. Results revealed that combined pretreatment could significantly improve solubilization and solid destruction compared to solo pretreatments. The highest organic matter solubilization of 25.6% and volatile suspended solids destruction of 21.7% were observed when 2.8  mg HNO2-N/L and 1500 KJ/Kg were combined. Moreover, combining the pretreatments further enhanced biodegradability up to the highest percentage of 50.3% when pretreatment of 3000 KJ/Kg and 2.8  mg HNO2-N/L was applied. Also, the experimental data from a biochemical methane potential test was fitted well into First Order Kinetic and Modified Gompertz models, given that the coefficients of determination, R2, for models at all treatment levels were above 99%.

Vacuum-enhanced anaerobic fermentation: Achieving process intensification, thickening and improved hydrolysis and VFA yields in a single treatment step.

This study assessed the feasibility of a novel vacuum-enhanced anaerobic digestion technology, referred to as IntensiCarbTM (IC), under mild vacuum pressure (110 mbar), compared to a control (conventional fermenter), and evaluated the impact of the vacuum on the activities of various microbial groups. Both fermenters (test and control) were operated with mixed (50% v/v) municipal sludge at solids concentrations of 2-2.5%, pH of 7.8-8.1, 40-45 °C, a theoretical solids retention time (SRT) of 3 days with different hydraulic retention times (HRT). The intensification factor (IF) of the IC, defined as SRT/HRT, was controlled at 1.3 and 2.0. Simultaneous thickening and fermentation intensification were achieved. Compared with the control, the IC, despite the shorter HRTs, achieved 29.5 to 90.2% increase in the VFA yield (79 to 116 mg ΔVFA/ g VSS vs 61 mg ΔVFA/ g VSS), and 16.2% to 56.4% increase (280 to 377 mg ΔsCOD/ g VSS vs 241 mg ΔsCOD/ g VSS), in the hydrolysis yield. Fermentate from the IC exhibited comparable specific denitrification rates to acetate. Further, the solids-free condensate contained low nutrient concentrations, and thus was far superior to a typical centrates from dewatering as a carbon source. No adverse effects of vacuum on the activity of fermentative bacteria and methanogens were observed. This study demonstrated that the IC can be deployed as an intensification technology for both fermentation and anaerobic digestion of biosolids with the additional significant advantage, i.e. elimination of sidestream ammonia treatment requirements.

A proof-of-concept experimental study for vacuum-driven anaerobic biosolids fermentation using the IntensiCarb technology.

This study demonstrates the potential of an innovative anaerobic treatment technology for municipal biosolids (IntensiCarb), which relies on vacuum evaporation to decouple solids and hydraulic retention times (SRT and HRT). We present proof-of-concept experiments using primary sludge and thickened waste activated sludge (50-50 v/v mixture) as feed for fermentation and carbon upgrading with the IntensiCarb unit. IntensiCarb fully decoupled the HRT and SRT in continuously stirred anaerobic reactors (CSAR) to achieve two intensification factors, that is, 1.3 and 2, while keeping the SRT constant at 3 days (including in the control fermenter). The intensified CSARs were compared to a conventional control system to determine the yields of particulate hydrolysis, VFA production, and nitrogen partitioning between fermentate and condensate. The intensified CSAR operating at an intensification factor 2 achieved a 65% improvement in particulate solubilization. Almost 50% of total ammonia was extracted without pH adjustment, while carbon was retained in the fermentate. Based on these results, the IntensiCarb technology allows water resource recovery facilities to achieve a high degree of plant-wide intensification while partitioning nutrients into different streams and thickening solids. PRACTITIONER POINTS: The IntensiCarb reactor can decouple hydraulic (HRT) and solids (SRT) retention times in anaerobic systems while also increasing particulate hydrolysis and overall plant capacity. Using vacuum as driving force of the IntensiCarb technology, the system could achieve thickening, digestion, and partial dewatering in the same unit-thus eliminating the complexity of multi-stage biosolids treatment lines. The ability to partition nutrients between particulate, fermentate, and condensate assigns to the IntensiCarb unit a key role in recovery strategies for value-added products such as nitrogen, phosphorus, and carbon, which can be recovered separately and independently.

Combined hydrothermal and free nitrous acid, alkali and acid pretreatment for biomethane recovery from municipal sludge.

This study focused on investigating the effect of combined chemical and hydrothermal pretreatment (HTP) on the anaerobic digestibility of thickened waste activated sludge (TWAS). Three different combined pretreatment conditions of HTP + free nitrous acid (FNA), HTP + Acid, and HTP + Alkaline were applied to TWAS. To control and compare the effect of combined pretreatments and a single pretreatment, Acid, Alkaline, FNA and HTP pretreatments were applied done prior to AD. The results of this study revealed that combined pretreatments have higher potential to improve methane production yield and rate but not in the solubilization of COD. The highest methane yield of 275 mL CH4/g TCOD added was achieved for the combined pretreatment with FNA and HTP. HTP + FNA pretreatment was found to produce higher methane yields compared to the combination of other typical acid and alkaline reagents with hydrothermal pretreatment. Methane yields of 594, 527, and 544 L CH4/g VSS added, were achieved for HTP + FNA, HTP + ALK, and HTP + ACID pretreatments, respectively. The preliminary economic analysis showed that out of the combined pretreatment, only combining HTP with FNA is economically feasible.

Traditional Consumption of the Fruit Pulp of Chrysophyllum albidum (Sapotaceae) in Pregnancy may be Serving as an Intermittent Preventive Therapy against Malaria Infection.

BACKGROUND: The bark of Chrysophyllum albidum is reported to possess antimalarial property. The fruit pulp of C. albidum consumed by pregnant women of south eastern Nigeria may also possess antimalarial activity. The present preliminary study investigated the antimalarial potential of the pulp juice and seed of C. albidum. METHODS: Schizonticidal activity was evaluated using the Peter's 4-day suppressive test. The prophylactic and curative antimalarial activities of the extracts were evaluated in Albino mice inoculated with Plasmodium berghei. RESULTS: The oral acute toxic dose of the pulp extract is beyond 5000 mg/kg. The seed and pulp possess both suppressive and curative properties. The seed extract suppressed early infection by 72.97% and 97.30%, at 500 and 1000 mg/kg, respectively. The pulp juice recorded 72.97% and 81.08%, at 500 and 1000 mg/kg, respectively. At 500 mg/kg dose, the level of parasite control on Day 7 was the same (96.10%) for both seed and pulp. CONCLUSION: This study demonstrates the presence of antimalarial constituents in the chemically uncharacterized samples (fruit pulp and seed) of C. albidum. Its ethnomedicinal use may be valuable in pregnancy where it may possibly serve as an intermittent preventive therapy against malaria.