Comparison of the effects of two screw insertion patterns on bone fragment translocation in a 3.5 mm dynamic compression plate and a 3.5 mm limited-contact dynamic compression plate.

OBJECTIVE: To compare the effects of screw insertion pattern, plate type, application of bone reduction forceps, and additional load screw insertion in an 8-hole 3.5 mm dynamic compression plate (DCP) and limited-contact dynamic compression plate (LC-DCP) on bone fragment translocation (BFT) in a fracture gap model. STUDY DESIGN: In vitro mechanical study. METHODS: Two screw insertion patterns were tested in the DCP and newly redesigned LC-DCP using gap model synthetic bone constructs. In Pattern 1, screws were first inserted into the holes at each end of the plate, then screws were inserted into the holes adjacent to the fracture gap. In Pattern 2, screws were only inserted into the holes adjacent to the fracture gap. The effects of tight or loose bone forceps securing the plate, loosening a neutral screw in Pattern 1, and inserting up to 4 additional load screws with each pattern were tested. Changes in the fracture gap were measured after insertion of all neutral screws and after each load screw. RESULTS: Pattern 2 BFT was significantly greater than Pattern 1 BFT when bone forceps were loose with both plates (P < .001). In the DCP, the BFT was significantly increased by loosening the bone forceps with Pattern 2 (P < .001) and by loosening 1 neutral screw in Pattern 1 (P < .001). The BFT for each additional load screw inserted was significantly less than 1.0 mm. CONCLUSIONS: A tight neutral screw in the same bone fragment as the load screw or bone clamps that tightly secure the plate to the bone can limit BFT.

An animal model for interface tissue formation in cemented hip replacements.

OBJECTIVE: To create a model in sheep for investigation of early changes related to the formation of an interface membrane in hip prosthesis. STUDY DESIGN: Experimental study. ANIMALS: Twenty-four female adult Swiss Alpine sheep. METHODS: Sheep were divided into 2 groups of 12 for unilateral cemented total hip arthroplasty. In Group I, the prosthesis was fixed with retrograde cement gun injection to achieve a complete cement mantle, whereas in Group II a primary cement mantle defect was produced. Groups I and II were further divided into 2 sub-groups with study end points of 2 and 8.5 months after surgery. Radiographs were evaluated postoperatively and at euthanasia for migration of the femoral component and bone resorption. Histologic sections were evaluated semiquantitatively for changes in cell types and numbers, and bone reactions; and quantitatively for size of interface membrane and new bone formation. RESULTS: Radiographically, there tended to be an increase in bone resorption and periosteal bone formation throughout the femoral shaft in Group II compared with Group I, but this was only statistically significant at the region of the femoral neck (R5) at both time periods (P<.05). Semiquantitative histologic evaluation revealed significant increases (P<.05) in cellularity, numbers of fibroblasts, giant cells, macrophages, and mononuclear cells, in Group II primarily at 2 months after surgery. This was also true for interface membrane formation and bone remodeling. Quantitative data showed an increased in the size of the interface membrane and area of bone formation at 8.5 months in Group II. CONCLUSIONS: The cement defect model offered controlled and repeatable production of an interface membrane. The results suggest that a primary cement mantle defect could be a possible trigger for implant instability, eliciting a cascade of biomechanical and molecular events in bone tissue leading to aseptic loosening. CLINICAL RELEVANCE: The results show the effect of defects in the cement mantle in promoting interface membrane formation. Long-term and biochemical studies are required to evaluate the relevance of this interface membrane formation.

An experimental animal model of aseptic loosening of hip prostheses in sheep to study early biochemical changes at the interface membrane.

BACKGROUND: Aseptic loosening of hip prosthesis as it occurs in clinical cases in human patients was attributed to wear particles of the implants, the response of the tissue dominated by macrophages and the production of inflammatory mediators and matrix degrading enzymes; however, the cascade of events initiating the process and their interaction regarding the time course is still open and discussed controversially. Therefore, the goal of this study was to establish an experimental animal model in sheep allowing to follow the cascade of early mechanical and biochemical events within the interface membrane and study the sequence of how they contribute to the pathological bone resorption necessary for aseptic loosening of the implant. METHODS: A cemented modular system (Biomedtrix) was used as a hip replacement in 24 adult Swiss Alpine sheep, with one group receiving a complete cement mantle as controls (n = 12), and the other group a cement mantle with a standardized, lateral, primary defect in the cement mantle (n = 12). Animals were followed over time for 2 and 8.5 months (n = 6 each). After sacrifice, samples from the interface membranes were harvested from five different regions of the femur and joint capsule. Explant cell cultures were performed and supernatant of cultures were tested and assayed for nitric oxide, prostaglandin E2, caseinolytic and collagenolytic activity. RNA extraction and quantification were performed for inducible nitric oxide synthase, cyclooxygenase-2, interleukin 1, and interleukin 6. Overall differences between groups and time periods and interactions thereof were calculated using a factorial analysis of variance (ANOVA). RESULTS: The development of an interface membrane was noticed in both groups at both time points. However, in the controls the interface membrane regressed in thickness and biological activity, while both variables increased in the experimental group with the primary cement mantle defect over time. Nitric oxide (NO) and PGE2 concentrations were higher in the 8.5 months group (P < 0.0001) compared to the 2 months group with a tendency for the unstable group to have higher concentrations. The same was true for collagenolytic activity (P = 0.05), but not for caseinolytic activity that decreased over time (P < 0.0001). CONCLUSION: In this study, a primary cement mantle defect of the femoral shaft elicited biomechanical instability and biochemical changes over time in an experimental animal study in sheep, that resembled the changes described at the bone cement-interface in aseptic loosening of total hip prosthesis in humans. The early biochemical changes may well explain the pathologic bone resorption and formation of an interface membrane as is observed in clinical cases. This animal model may aid in future studies aiming at prevention of aseptic loosening of hip prosthesis and reflect some aspects of the pathogenesis involved.

Extraosseous cement granuloma associated with total hip replacement in 6 dogs.

OBJECTIVE: To report the clinical, radiographic, and pathologic features of extraosseous cement granuloma (ECG), a low occurrence, long-term complication of total hip replacement (THR). STUDY DESIGN: Retrospective clinical study. Sample Population-Six client-owned dogs. METHODS: Medical records for 6 dogs that had a cemented modular THR and developed ECG were reviewed for the clinical, radiologic, and histopathologic findings of ECG. Morphologic and elemental analyses of retrieved particles were conducted in 2 dogs using scanning electron microscopy (SEM) and energy-dispersive x-ray spectroscopy (EDS). RESULTS: Three golden retrievers and 3 Labrador retrievers had progressive lameness in the operated limb 4 to 7 years after THR and developed ECG. Other clinical features included an acute deterioration to non-weight bearing associated with pathologic fracture of the proximal femur in 2 dogs, and obstipation in 1 dog. In 5 dogs, there was a large caseous mass surrounding the proximal femur. Obstipation in 1 dog was caused by a similar mass adjacent to bone cement used for fixation of the acetabular cup. Radiographic changes included a multilobular soft tissue mass, containing irregular mineral densities, in the gluteal mass surrounding the proximal femur, THR interface deterioration, osteolysis, new bone formation, and implant subsidence were consistent with chronic aseptic loosening. The histopathologic diagnosis was sterile granuloma associated with a massive heterogeneous particulate burden, which was assumed to have resulted from severe wear of all prosthesis components. CONCLUSIONS: ECG is a manifestation of severe aseptic loosening of cemented total hip replacement, with the generation of wear debris probably responsible for granuloma formation. CLINICAL RELEVANCE: Because revision can offer a good prognosis in early aseptic femoral loosening, yearly radiographic monitoring of the recipients is recommended.

Removal of infected canine cemented total hip prostheses using a femoral window technique.

OBJECTIVE: To evaluate a femoral window technique for retrieval of cemented total hip prostheses. STUDY DESIGN: Retrospective clinical study. ANIMALS: Twelve dogs with infection of a cemented modular total hip prosthesis. METHODS: Implant removal was performed by an extended craniolateral approach to the hip and proximal femur without trochanteric osteotomy. The femoral cement mantle was fragmented and removed with simple orthopedic instrumentation by a lateral femoral window that was repaired using cerclage wires. Surgical technique, intraoperative and postoperative complications, bacterial culture results, histopathologic findings, and completeness of cement removal were recorded. Follow-up radiographs were taken 5 to 9 weeks postoperatively. Long-term follow-up information was obtained by client questionnaire. Functional outcome was assessed by scoring ability to stand, sit, walk, run, play, climb stairs, and get into a car. RESULTS: Prosthesis retrieval was performed 2 to 41 months after implantation (median, 14 months). Complete removal of femoral cement was achieved in 10 dogs. A nondisplaced femoral fissure, extending proximally from the window, was an intraoperative complication in 2 dogs. Staphylococcus spp was most commonly isolated (6 dogs) from interfacial membrane samples. Systemic antibiotic therapy, dependent on susceptibility testing, was administered for 3 to 10 weeks postoperatively. There was radiographic evidence of osteotomy healing at 5- to 9-week reassessment. Recurrence of osteomyelitis was not observed. Long-term functional outcome was considered mildly abnormal. CONCLUSIONS: The lateral window was an effective technique for retrieval of retained femoral cement. CLINICAL RELEVANCE: Removal of an infected prosthesis using this technique generally resulted in a clinical outcome comparable to that with ab initio femoral head and neck excision.