Synergistic effect of hydrothermal sludge and food waste in the anaerobic co-digestion process: microbial shift and dewaterability.

While thermal hydrolysis technology is commonly employed for sewage sludge treatment in extensive wastewater treatment facilities, persistent challenges remain, including issues such as ammonia-induced digestive inhibition and reduced productivity stemming from nutrient deficiency within the hydrothermal sludge. In this study, the effects of hydrothermal sludge-to-food waste mixing ratios and fermentation temperatures on anaerobic co-digestion were systematically investigated through a semi-continuous experiment lasting approximately 100 days. The results indicated that anaerobic co-digestion of hydrothermal sludge and food waste proceeded synergistically at any mixing ratio, and the synergistic effect is mainly attributed to the improvement of carbohydrate removal and digestive system stability. However, thermophilic digestion did not improve the anaerobic performance and methane yield. On the contrary, mesophilic digestion performed better in terms of organic matter removal, especially in the utilization of soluble carbohydrates, soluble proteins, and VFAs. Microbial community analysis revealed that the transition from mesophilic to thermophilic anaerobic co-digestion prompts changes in the methane-producing pathways. Specifically, the transition entails a gradual shift from pathways involving acetoclastic and hydrogenotrophic methanogenesis to a singular hydrogenotrophic methanogenesis pathway. This shift is driven by thermodynamic tendencies, as reflected in Gibbs free energy, as well as environmental factors like ammonia nitrogen and volatile fatty acids. Lastly, it is worth noting that the introduction of food waste did lead to a reduction in cake solids following dewatering. Nevertheless, it was observed that thermophilic digestion had a positive impact on dewatering performance.

Optimal deployment of thermal hydrolysis and anaerobic digestion to maximize net energy output based on sewage sludge characteristics.

Thermal hydrolysis (TH) is widely employed in combination with anaerobic digestion (AD) to efficiently treat primary sludge and waste-activated sludge in municipal wastewater treatment plants. In this study, four different scenarios-conventional AD (S1), TH-AD (S2), AD-TH-AD (S3), and characteristics-based AD-TH-AD (S4, primary AD only for primary sludge)-were evaluated to determine the optimal deployment of TH and AD for treating primary sludge and waste-activated sludge to maximize net energy output. The maximum net energy output of 4899 MJ/t-TSfed (per ton total solids of sludge fed) was achieved in S4 when assuming the recovered heat was only used for AD heating and surplus heat was wasted, and the net energy output of S4 was 70.8 % higher than that of S1 and 48.6 % higher than that of S2. This remarkable improvement was attributed to a reduction of > 15.2 % in refractory compounds, resulting in a 17 % increase in methane yield. Importantly, this study provides the first comparison of refractory compounds between inter-thermal hydrolysis (inter-TH) and pre-thermal hydrolysis (pre-TH) using a simulated A2O process. Overall, this study provides innovative insights and strategies for enhancing the TH and AD process performance based on the specific characteristics of sewage sludge derived from wastewater treatment plants.

Hotspots and future trends of phosphorus recycling from livestock manure: A bibliometric review.

In recent decades, the importance of managing the earth's dwindling phosphorus (P) has grown exponentially, as have efforts to develop a circular economy. Livestock manure represents a P-rich waste product, so recycling P from livestock manure has garnered the attention of scholars worldwide. Based on a global database from 1978 to 2021, this study presents the current status of recycling P from livestock manure and proposes strategies for efficient P utilization. Unlike traditional review articles, this work establishes a visual collaborative network on P recycling from livestock manure of research areas, countries, institutions, and authors through a bibliometric analysis using Citespace and VOSviewer software. The co-citation analysis of literature revealed the development of the main research content in this field, and further clustering analysis illustrated the current key research directions. Keyword co-occurrence analysis identified the hotspots and new frontiers of research in this field. According to the results, the United States was the most influential and actively contributing nation, and China was the country with the tightest international ties. The most popular research area was environmental science, and the Bioresource Technology published the largest number of papers in this area. The research priority was the technologies development of P recycling from livestock manure, of which the most used method was struvite precipitation and biochar adsorption. Subsequently, evaluation is also essential, including the economic benefits and environmental impacts of the recycling process by life cycle assessment and substance flow analysis, as well as the agronomic efficiency of the recycled products. New directions for technological innovation in recycling P from livestock manure and potential risks in the recycling process are explored. The results of this study may provide a framework for understanding the mechanisms of P utilization in livestock manure, and support the overall popularization of P recycling technology from livestock manure.

Comparison of phosphorus species in livestock manure and digestate by different detection techniques.

Phosphorus (P) species characterize the effectiveness of the P fertilizer. In this study, the P species and distribution in different manures (pig manure, dairy manure and chicken manure) and their digestate were systematically investigated through combined characterization methods of Hedley fractionation (H2OP, NaHCO3-P, NaOH-P, HCl-P, and Residual), X-ray diffraction (XRD) and nuclear magnetic resonance (NMR) techniques. The results from Hedley fractionation showed that >80 % of P in the digestate was inorganic and the HCl-P content in manure increased significantly during anaerobic digestion (AD). XRD manifested that insoluble hydroxyapatite and struvite belonging to HCl-P were presented during AD, which was in agreement with the result of Hedley fractionation. 31P NMR spectral analysis revealed that some orthophosphate monoesters were hydrolyzed during AD, meanwhile the orthophosphate diester organic phosphorus like DNA and phospholipids content has increased. After characterizing P species by combining these methods, it was found that chemical sequential extraction could be an effective way to fully understand the P in livestock manure and digestate, with other methods used as auxiliary tool depending on the purpose of studies. Meanwhile, this study provided a basic knowledge of utilizing digestate as P fertilizer and minimizing the risk of P loss from livestock manure. Overall, applying digestates can minimize the risk of P loss from directly applied livestock manure while satisfying plant demands, and is an environmentally friendly P fertilizer.

Response of phosphorus speciation to organic loading rates and temperatures during anaerobic co-digestion of animal manures and wheat straw.

The world is facing huge phosphate (P) shortage and anaerobic digestion (AD) is a recognized technology to promote nutrient (N and P) recycling. The composition of P speciation in the digestate is essential for the fertilizing effect. However, how P speciation in the digestates interacts with the AD process conditions is unknown. Therefore, interaction of P speciation in digestates with AD process conditions was investigated by using a chemical sequential extraction method (Hedley fractionation) and X-ray diffraction; specifically, the effects of organic loading rate (OLR), temperature, and substrate composition were investigated. The results showed that OLR and feedstock affected P speciation in the digestate significantly due to different ion species and ionic strengths. The H2O-P concentration in chicken manure with straw (CMS) and dairy manure with straw (DMS) digestates decreased by 44.04-48.76% and 48.88-50.49%, respectively, as the OLR increased from 2 to 4 kg VS m-3 d-1. Simultaneously, HCl-P increased by 38.02-44.01% in the CMS digestates due to Ca-P and Mg-P formation, indicating that Ca-P and Mg-P formation was positively correlated with OLR, whereas P mobility decreased. Further, thermophilic temperature conditions were more conducive for the formation of insoluble P than mesophilic temperature conditions in the digestates due to the thermodynamic driving force of the reactions. The results would facilitate the understanding of P transformation in the AD process under the influence of feedstock, OLR, and temperature. From the viewpoint of nutrient management, lower OLR and temperature are more beneficial for a fast P availability, whereas higher OLR and temperature are more helpful for storage and export because of P precipitated into solid phase of digestate.

Effects of sodium selenite spray on apple production, quality, and sucrose metabolism-related enzyme activity.

Selenium is an essential trace element that improves fruit quality and nutritional value. However, the effect of sodium selenite on apple quality and its relative sucrose metabolism activity remains unclear. In this study, we investigated the roles of selenite spraying, in improving Fuji apple quality and sucrose metabolism-related enzyme activity. Results showed that foliar spraying of sodium selenite significantly (P < 0.05) increased apple fruit yield and internal quality, but no significant effects on external quality. The apple yield, vitamin C content, sugar-acid ratio and total soluble sugar increased 4.4% to 11.7%, 4.68% to 20.86%, 3.07% to 31.57%, and 4.53% to 18.89%, respectively. Se content is 9.5-fold compared to the control. Significant correlations were observed between neutral invertase, sucrose synthase activity and sucrose phosphate synthase enzymes, and sucrose phosphate synthase enzyme was most crucial. Spraying sodium selenite of 100-150 mg/L could be appropriate for improving Fuji apple yield and quality.