Evaluation of sorbent materials for the sampling and analysis of phosphine, sulfuryl fluoride and methyl bromide in air.

Phosphine (PH3), sulfuryl fluoride (SO2F2) and methyl bromide (CH3Br) are highly toxic chemical substances commonly used for fumigation, i.e., pest control with gaseous pesticides. Residues of fumigation agents constitute a health risk for workers affected, and therefore accurate methods for air sampling and analysis are needed. In this study, three commercial adsorbent tubes; Carbosieve SIII™, Air Toxics™ and Tenax TA™, were evaluated for sampling these highly volatile chemicals in air and their subsequent analysis by thermal desorption-gas chromatography-mass spectrometry (TD-GC-MS). The breakthrough volume (BTV) of each fumigant was experimentally determined on the different adsorbents at concentrations at or above their permissible exposure limits, using a method based on frontal chromatography of generated fumigant atmospheres. Carbosieve SIII™, a molecular sieve possessing a very high specific area, proved to be a better adsorbent than both Air Toxics™ and Tenax TA™, resulting in at least a 4-fold increase of the BTV50%. BTV50% for Carbosieve SIII™ at 20°C was measured as 4.7L/g, 5.5L/g and 126L/g for phosphine, sulfuryl fluoride and methyl bromide, respectively, implying safe sampling volumes of 1.9L, 2.2L and 50L, respectively, for a commercial tube packed with 800mg Carbosieve SIII™. The temperature dependence of BTV was strong for Carbosieve SIII™, showing a reduction of 3-5%/°C in breakthrough volume within the range -20 to 40°C. Furthermore, although Carbosieve SIII™ reportedly has a higher affinity for water than most other adsorbents, relative humidity had only a moderate influence on the retention capacity of phosphine. Overall, the applicability of Carbosieve SIII™ adsorbent sampling in combination with TD-GC-MS analysis was demonstrated for highly volatile fumigants.

Determination of vapor pressure of low-volatility compounds using a method to obtain saturated vapor with coated capillary columns.

The vapor pressures of O-ethyl S-2-diisopropylaminoethyl methylphosphonothiolate (VX), O-isobutyl S-2-diethylaminoethyl methylphosphonothiolate (RVX), and 2,4-dinitrotoluene (2,4-DNT) were determined with the gas saturation method in temperatures ranging from -12 to 103 degrees C. The saturated vapor was generated using a fused-silica column coated with the compound. This column was placed in a gas chromatograph, and the vapor pressure was determined directly from the detector signal or by sampling on Tenax tubes that were subsequently analyzed. From the linear relationships obtained by plotting log P vs 1/T, the enthalpies of vaporization (deltaHvap) and the vapor pressures at selected temperatures were determined. The vapor pressure of VX at 25 degrees C was 0.110 Pa and the deltaHvap 77.9 kJ x mol(-1). The corresponding results for RVX were 0.082 Pa and 76.6 kJ x mol(-1). The vapor pressure of 2,4-DNT at 72 degrees C (melting point) was determined to 6.0 Pa, and the enthalpies of the solid and the liquid state were 94.2 and 75.3 kJ x mol(-1), respectively. Using capillary columns to generate saturated vapors has three major advantages: short equilibrium time, low consumption of sample, and safe handling of toxic compounds.

Personal decontamination after exposure to stimulated liquid phase contaminants: functional assessment of a new unit.

OBJECTIVE: To evaluate the efficacy of a decontamination station following exposure of volunteers to liquids with physical characteristics comparable to sarin and mustard gas. DESIGN: Twenty-four volunteers participated in the experiment which was performed with all staff wearing personal protective equipment including respiratory protection. The clothes, skin, and hair of the volunteers were contaminated with the simulated liquid phase contaminants, ethyl lactate and methyl salicylate. Sulphur hexafluoride gas was used to confirm the ventilation efficacy. Decontamination followed guidelines using a two-stage procedure. In the first chamber, all volunteers received a 3-minute shower with water at 30 degrees C, and their clothes but not their respiratory masks were removed. In the second, they were twice washed thoroughly with soap and water. After decontamination, the volunteers entered a third chamber for first aid measures. RESULTS: The air concentration of sulphur hexafluoride was reduced by 1:10,000 between the first and the third chambers. Ethyl lactate and methyl salicylate were measured in low concentrations in the third chamber. The capacity was 16 volunteers per hour with two-thirds on stretchers. After self-decontamination of the staff, the concentration of ethyl lactate increased significantly in the third chamber, consistent with residual ethyl lactate adsorbed by their underwear. This observation revealed a deficiency in the guidelines for self-decontamination. CONCLUSION: The capacity of the decontamination unit was found to be 16 volunteers per hour. The ventilation system and guidelines of the decontamination unit were demonstrated to be effective under the conditions examined. The self-decontamination of the staff was not optimal.

Mutagenicity testing of condensates of smoke from titanium dioxide/hexachloroethane and zinc/hexachloroethane pyrotechnic mixtures.

Condensates of smoke from titanium dioxide/hexachloroethane and zinc/hexachloroethane pyrotechnic mixtures were investigated for their potential to produce genetic damage in the tester strains TA98, TA100, TA1535 and TA1537 of Salmonella typhimurium and in the mouse bone marrow micronucleus assay. Both smoke condensates contained several chlorinated hydrocarbons among which tetrachloroethylene, hexachloroethane, hexachlorobutadiene and hexachlorobenzene were identified by GC/MS. Condensate of smoke from titanium dioxide/hexachloroethane showed a dose-related positive response in the Salmonella assay with strains TA98 and TA100 in the absence of metabolic activation from rat liver S9 fraction. Both smoke condensates were negative in the micronucleus assay but produced a small but significant depression of erythropoietic activity. The results indicate that smoke condensate from titanium dioxide/hexachloroethane mixtures contains unidentified compound(s) that may be considered mutagenic in the Salmonella assay.