RESUMO
In this study, biosurfactant-producing bacteria was evaluated for biosurfactant production by using banana peel as a sole carbon source. From the 71 strains screened, Halobacteriaceae archaeon AS65 produced the highest biosurfactant activity. The highest biosurfactant production (5.30 g/l) was obtained when the cells were grown on a minimal salt medium containing 35 % (w/v) banana peel and 1 g/l commercial monosodium glutamate at 30 °C and 200 rpm after 54 h of cultivation. The biosurfactant obtained by extraction with ethyl acetate showed high surface tension reduction (25.5 mN/m), a small critical micelle concentration value (10 mg/l), thermal and pH stability with respect to surface tension reduction and emulsification activity, and a high level of salt tolerance. The biosurfactant obtained was confirmed as a lipopeptide by using a biochemical test FT-IR, NMR, and mass spectrometry. The crude biosurfactant showed a broad spectrum of antimicrobial activity and had the ability to emulsify oil, enhance PAHs solubility, and oil bioremediation.
Assuntos
Biotecnologia/métodos , Halobacteriaceae/metabolismo , Musa/química , Tensoativos/metabolismo , Anti-Infecciosos/química , Anti-Infecciosos/isolamento & purificação , Anti-Infecciosos/metabolismo , Anti-Infecciosos/farmacologia , Carbono/metabolismo , Fenômenos Químicos , Poluentes Ambientais/química , Poluentes Ambientais/isolamento & purificação , Lubrificantes/química , Lubrificantes/isolamento & purificação , Metais/química , Metais/isolamento & purificação , Nitrogênio/metabolismo , Hidrocarbonetos Policíclicos Aromáticos/química , Hidrocarbonetos Policíclicos Aromáticos/isolamento & purificação , Tensoativos/química , Tensoativos/isolamento & purificação , Tensoativos/farmacologia , Fatores de Tempo , Água/químicaRESUMO
This study aimed at investigating the application of biosurfactant from Sphingobacterium spiritivorum AS43 using molasses as a substrate and fertilizer to enhance the biodegradation of used lubricating oil (ULO). The cell surface hydrophobicity of bacteria, the emulsification activity, and the biodegradation efficiency of ULO were measured. The bacterial adhesion in the hydrocarbon test was used to denote the cell surface hydrophobicity of the used bacterial species. The results indicate a strong correlation between cell surface hydrophobicity, emulsification activity, and the degree of ULO biodegradation. The maximum degradation of ULO (62 %) was observed when either 1.5 % (w/v) of biosurfactant or fertilizer was added. The results also revealed that biosurfactants alone are capable of promoting biodegradation to a large extent without added fertilizer. The data indicate the potential for biosurfactant production by using low-cost substrate for application in the bioremediation of soils contaminated with petroleum hydrocarbons or oils.
Assuntos
Lubrificantes/metabolismo , Petróleo/microbiologia , Sphingobacterium/metabolismo , Tensoativos/metabolismo , Biodegradação Ambiental , Emulsões , Hidrocarbonetos/metabolismo , Concentração de Íons de Hidrogênio , Melaço/microbiologia , Salinidade , Sphingobacterium/citologia , Tensoativos/química , TemperaturaRESUMO
A biosurfactant-producing bacterium, isolate 2/3, was isolated from mangrove sediment in the south of Thailand. It was evaluated as a potential biosurfactant producer. The highest biosurfactant production (4.52 g/l) was obtained when the cells were grown on a minimal salt medium containing 25 % (v/v) palm oil decanter cake and 1 % (w/v) commercial monosodium glutamate as carbon and nitrogen sources, respectively. After microbial cultivation at 30 °C in an optimized medium for 96 h, the biosurfactant produced was found to reduce the surface tension of pure water to 25.0 mN/m with critical micelle concentrations of 8.0 mg/l. The stability of the biosurfactant at different salinities, pH and temperature and also its emulsifying activity was investigated. It is an effective surfactant at very low concentrations over a wide range of temperatures, pH and salt concentrations. The biosurfactant obtained was confirmed as a glycolipid type biosurfactant by using a biochemical test, fourier-transform infrared spectroscopy, MNR and mass spectrometry. The crude biosurfactant showed a broad spectrum of antimicrobial activity and also had the ability to emulsify oil and enhance polyaromatic hydrocarbons solubility.
Assuntos
Meios de Cultura/química , Resíduos Industriais , Ochrobactrum anthropi/crescimento & desenvolvimento , Ochrobactrum anthropi/metabolismo , Tensoativos/metabolismo , Anti-Infecciosos/química , Anti-Infecciosos/metabolismo , Carbono/metabolismo , DNA Bacteriano/química , DNA Bacteriano/genética , DNA Ribossômico/química , DNA Ribossômico/genética , Microbiologia Ambiental , Glicolipídeos/química , Glicolipídeos/metabolismo , Dados de Sequência Molecular , Nitrogênio/metabolismo , Ochrobactrum anthropi/isolamento & purificação , Óleo de Palmeira , Óleos de Plantas , RNA Ribossômico 16S/genética , Análise de Sequência de DNA , Tensão Superficial/efeitos dos fármacos , Tensoativos/química , Temperatura , Tailândia , Tempo , Água/químicaRESUMO
Biosurfactant-producing bacteria, isolate CT2, was isolated from mangrove sediment in the south of Thailand. The sequence of the 16S rRNA gene from isolate CT2 showed 100 % similarity with Selenomonas ruminantium. The highest biosurfactant production (5.02 g/l) was obtained when the cells were grown on minimal salt medium containing 15 g/l molasses and 1 g/l commercial monosodium glutamate supplemented with 1 g/l NaCl, 0.1 g/l leucine, 5 % (v/v) inoculum size at 30 °C and 150 rpm after 54 h of cultivation. The biosurfactant obtained by extraction with ethyl acetate showed high surface tension reduction (25.5 mN/m), a small CMC value (8 mg/l), thermal and pH stability with respect to surface tension reduction and emulsification activity and a high level of salt tolerance. The biosurfactant obtained was confirmed as a lipopeptide by using a biochemical test, FT-IR, MNR and mass spectrometry. The crude biosurfactant showed a broad spectrum of antimicrobial activity and also had the ability to emulsify oil and enhance PAHs solubility.
Assuntos
Sedimentos Geológicos/microbiologia , Selenomonas/isolamento & purificação , Selenomonas/metabolismo , Tensoativos/química , Aminoácidos/metabolismo , Meios de Cultura/metabolismo , Emulsões/química , Concentração de Íons de Hidrogênio , Micelas , Óleos , RNA Ribossômico 16S/genética , Selenomonas/genética , Cloreto de Sódio/metabolismo , Tensão Superficial , Temperatura , TailândiaRESUMO
Microbial surface active compounds (SACs) were isolated from various environmental sources in Thailand. Isolates were screened for SACs production in different carbon sources (crude glycerol, commercial sugar, decanter, glucose, molasses, used palm oil, and used lubricating oil) by using drop-collapsing test and emulsification activity. Molasses produced the highest number of positive results (23 of 25 isolates). Twenty-one isolate strains produced emulsions with xylene, and 15 exhibited high emulsion-stabilizing capacity, maintaining more than 50 % of the original emulsion volume for 24 h, and six isolate strains reduced the growth medium surface tension to 40 mN/m. The phylogenetic position of these 25 isolates was evaluated by 16S rRNA gene sequence analysis. The production of microbial SACs was determined for strains representative of 16 different bacterial genera, in which ten genera (Blastococcus, Erysipelothrix, Humicoccus, Methylophilus, Microlunatus, Nevskia, Pectinatus, Rubrimonas, Selenomonas, and Stenotrophomonas) were firstly reported as SAC-producing strains. Overall, the new SAC-producing strains isolated in this study display promising features for the future development and use in economically efficient industrial-scale biotechnological processes.
Assuntos
Bactérias , Filogenia , RNA Ribossômico 16S/genética , Microbiologia do Solo , Bactérias/classificação , Bactérias/genética , Bactérias/isolamento & purificação , Carbono/química , Carbono/metabolismo , Emulsões , Melaço , TailândiaRESUMO
Biosurfactant-producing bacteria were isolated from mangrove sediment in southern Thailand. Isolates were screened for biosurfactant production by using the surface tension test. The highest reduction of surface tension was achieved with a bacterial strain which was identified by 16S rRNA gene sequencing as Oleomonas sagaranensis AT18. It has also been investigated using different carbon and nitrogen sources. It showed that the strain was able to grow and reduce the surface tension of the culture supernatant to 25 mN/m. In all 5.30 g of biosurfactant yield was obtained after 54 h of cultivation by using molasses and NaNO3 as carbon and nitrogen sources, respectively. The biosurfactant recovery by chloroform:methanol extraction showed a small critical micelle concentration value (8 mg/l), thermal and pH stability with respect to surface tension reduction. It also showed emulsification activity and a high level of salt concentration. The biosurfactant obtained was confirmed as a glycolipid by using a biochemical test, FT-IR and mass spectra. The crude biosurfactant showed a broad spectrum of antimicrobial activity and also had the ability to emulsify oil and enhance PAHs solubility.
Assuntos
Acetobacteraceae/isolamento & purificação , Acetobacteraceae/metabolismo , Glicolipídeos/biossíntese , Tensoativos/metabolismo , Acetobacteraceae/genética , Carbono/metabolismo , DNA Bacteriano/genética , Sedimentos Geológicos/microbiologia , Concentração de Íons de Hidrogênio , Micelas , Melaço/microbiologia , Nitrogênio/metabolismo , Hidrocarbonetos Policíclicos Aromáticos/química , RNA Ribossômico 16S/genética , Análise de Sequência de DNA , Solubilidade , Espectroscopia de Infravermelho com Transformada de Fourier , Tensão Superficial , Temperatura , TailândiaRESUMO
Two types of biosurfactant (BS)-producing bacteria, Bacillus licheniformis TR7 and Bacillus subtilis SA9, were isolated from mangrove sediment in the south of Thailand. The BS production was done by using only molasses as a whole medium for growth and production. Under optimized conditions, the yields of TR7 and SA9 BS were found to be 3.30 and 3.78 g/l, respectively. It could reduce the surface tension of pure water to 28.5 and 29.5 mN/m, with the critical micelle concentrations of about 10 and 30 mg/l, respectively. Good thermal, pH, and salt stability were exhibited. Both BSs could recover oil more effectively than the two synthetic surfactants. In addition, TR7 and SA9 BS could enhance the solubility of polyaromatic hydrocarbons (PAHs). Thus, these BSs have the potential for the removal of oil and PAHs from the combined contaminated environment and facilitate its bioremediation. These studies indicate that molasses, as a renewable, relatively inexpensive and easily available resource, can be used for important biotechnological processes.