Production of a fermented solid containing lipases from Penicillium roqueforti ATCC 10110 and its direct employment in organic medium in ethyl oleate synthesis.

The production and direct employment in organic medium in the ethyl-oleate synthesis of a fermented solid (FS) containing lipases by Penicillium roqueforti ATCC 10110 (PR10110) was investigated. For the production of this FS, the solid-state fermentation of different agroindustrial waste was used, such as: cocoa shell, sugarcane bagasse, sugarcane bagasse with cocoa shell, and cocoa shell with soybean oil and nutrient solution. The response surface methodology was used to study the effect of independent variables of initial moisture content and inductor concentration, as carbon source and inducer on lipase production. The characterization of the fermented solid in organic medium was also carried out. The highest lipase activity (53 ± 5 U g-1 ) was 16% higher than that obtained with the nonoptimized conditions. The characterization studies observed high stability of the FS in organic solvents for 5 h at 30°C, as well as at different temperatures, and the residual activity was measured against triolein. The FS was also able to catalyze ethyl-oleate synthesis maintaining high relative conversion over five reaction cycles of 96 h at 40°C in n-heptane. These results are promising and highlight the use of the FS containing PR10110 lipases for the first time in biocatalytic processes.

High-throughput screening for distinguishing nitrilases from nitrile hydratases in Aspergillus and application of a Box-Behnken design for the optimization of nitrilase.

Nitrilases and nitrile hydratases/amidases hydrolyze nitriles into carboxylic acids and/or amides, which are used in industrial chemical processes. In the present study, 26 microorganisms, including yeasts and filamentous fungi, in a minimum solid mineral medium supplemented with glucose and phenylacetonitrile were screened to evaluate their biocatalytic potential. Of these microorganisms, five fungi of the genus Aspergillus were selected and subjected to colorimetry studies to evaluate the production and distinction of nitrilase and nitrile hydratase/amidase enzymes. Aspergillus parasiticus Speare 7967 and A. niger Tiegh. 8285 produced nitrilases and nitrile hydratase, respectively. Nitrilase optimization was performed using a Box-Behnken design (BBD) and fungus A. parasiticus Speare 7967 with phenylacetonitrile volume (µl), pH, and carbohydrate source (starch:glucose; g/g) as independent variables and nitrilase activity (U ml-1 ) as dependent variable. Maximum activity (2.97 × 10-3  U ml-1 ) was obtained at pH 5.5, 80 µl of phenylacetonitrile, and 15 g of glucose. A. parasiticus Speare 7967 showed promise in the biotransformation of nitriles to carboxylic acids.

Development of amperometric biosensor in modified carbon paste with enzymatic preparation based on lactase immobilized on carbon nanotubes.

ABSTRACT: The variety of products derived from milk, without or with lactose, encourages the development of more effective analytical techniques that can be applied to the quality control of both the production line and the final products. Thus, in this work an efficient and minimally invasive method for the detection of lactose was proposed, using a biosensor containing the enzyme lactase (LAC) immobilised on carbon nanotubes (CNTs) that, when reacting with lactose, emit an electrochemical signal. This biosensor was connected to a potentiostat, and its electrochemical cell was composed of the following three electrodes: reference electrode (Ag/AgCl), auxiliary electrode (platinum wire), and working electrode (biosensor) on which graphite (carbon) paste (CP), CNTs, and LAC were deposited. The transmission electron microscopy and scanning electron microscopy were used in the characterisation of the composite morphology, indicating excellent interactions between the CNTs and LAC. The sensitivity of the CP/LAC/CNT biosensor was determined as 5.67 µA cm-2.mmol-1 L and detection limits around 100 × 10-6 mol L-1 (electrode area = 0.12 cm2) and an increase in the stability of the system was observed with the introduction of CNTs because, with about 12 h of use, there was no variation in the signal (current). The results indicate that the association between the CNTs and LAC favoured the electrochemical system.

Enzymatic saccharification of lignocellulosic residues using cellulolytic enzyme extract produced by Penicillium roqueforti ATCC 10110 cultivated on residue of yellow mombin fruit.

The aim of this work was to enzymatic saccharification of food waste was performed by crude enzymatic cellulolytic extract produced by P. roqueforti cultivated in yellow mombin residue. The best yield of reducing sugars (259.45mgg-1) was achieved with sugarcane bagasse after 4h; the hydrolysis of corn cob, rice husk and peanut hull resulted in yields around 128-180mgg-1. The addition of 10mmolL-1 of Mn2+ potentiated the saccharification of sugarcane bagasse, in about 86%. The temperature and substrate (sugarcane bagasse) concentration parameters were optimized using a Doehlert Design and, a maximum sugar yield of 662.34±26.72mgg-1 was achieved at 62.40°C, 0.22% (w/v) of substrate, with the addition of Mn2+. Sugar yield was significantly high when compared to previous studies available in scientific literature, suggesting the use of crude cellulolytic supplemented with Mn2+ an alternative and promising process for saccharification of sugarcane bagasse.

Antimicrobial activity of coconut oil-in-water emulsion on Staphylococcus epidermidis and Escherichia coli EPEC associated to Candida kefyr.

Candida kefyr has been considered both a food-spoiling agent and a type of yeast with fermentation properties. In this study, the authors have evaluated the antimicrobial activity of a coconut oil-in-water emulsion associated to the presence of C. kefyr. Fresh coconut kernels were used to obtain the coconut oil-in-water emulsion, the sterile coconut oil-in-water emulsion by decantation, and the coconut oil by means of a heating process. Commercial virgin coconut oil was also used. Agar diffusion, minimal inhibitory concentration and minimal bactericidal concentration (MIC/MBC) techniques were employed to evaluate antimicrobial activity against E. coli and S. epidermidis. The C. kefyr isolate was identified and confirmed. Coconut milk-derived fatty acids were characterized by acid index and thin layer chromatography. Scanning electronic microscopy was performed to evaluate the morphology of the microorganisms. Lipase activity of C. kefyr isolate was also detected. Coconut oil-in-water emulsion associated to C. kefyr was active against both bacteria. Thin layer chromatography confirmed the presence of triglycerides and free fatty acids. The acid index showed higher acidity potential for the coconut oil-in-water emulsion. The microscopic images showed antibacterial action through the formation of membrane holes' and demonstrated yeast shape. All the above show new potentials for C. kefyr and coconut oil-in-water emulsion in food technology.