RESUMO
The first step in downstream processing of mammalian cell culture includes the separation of the cells without cell damage to avoid the release of intracellular enzymes, which could potentially cause proteolytic degradation of the target protein and may increase the impurities for further chromatographic steps. This especially includes the reduction of host DNA for therapeutic proteins. The aim of this investigation was to examine the extent of cell damage at the bench and pilot scale using a stabilized fluidized bed (expanded bed) for direct recovery of IgG from cell culture broth. For this purpose, Streamline-25 and -200 columns containing 75 mL and 5 L of rProtein A matrix, respectively, were used. The repeated batch cultivations resulted in high cell viabilities of about 90% prior purification. The pH was gently adjusted to pH 8 before the broth was applied to the gel. In bench scale, 1 to 6 L of unclarified feed was applied to the Streamline-25 column. In pilot scale, up to 95 L was processed using the Streamline-200 column. The antibodies from 95 L of unclarified feed were recovered after approximately 1.5 h. The possible cell damage, caused either by the equipment or by the cells' passage through the expanded bed, was detected by the following assays: microscopic count of the cells using trypan blue dye exclusion to determine viability; monitoring of intracellular components (i.e., DNA concentration); activity of lactate dehydrogenase (LDH); and, finally, the particle load in the flow through and the eluate. Despite the sensitivity of hybridoma cells to shear forces, neither the high flow rate (300 to 450 cm/h) nor the passage of the cells through the expanded bed caused any relevant cell damage or clogging of the gel. Excellent DNA depletion was observed.
Assuntos
Anticorpos Monoclonais/isolamento & purificação , Cromatografia de Afinidade/métodos , Animais , Biotecnologia , Separação Celular/métodos , Sobrevivência Celular , DNA/isolamento & purificação , Hibridomas/citologia , Hibridomas/imunologia , Concentração de Íons de Hidrogênio , Imunoglobulina G/isolamento & purificação , Ligantes , Camundongos , Projetos Piloto , Proteínas Recombinantes , Proteína Estafilocócica ARESUMO
The non-destructive removal of hybridoma cells from fermentation broth with an improved disc stack centrifuge (CSA1, Westfalia Separator AG, Oelde, Germany) was investigated. The centrifuge was equipped with a hydrohermetic feed system, which allowed a gentle, shearless acceleration of the cells inside the bowl. No significant cell damage was observed during the separation of hybridoma cells from repeated batch fermentation in 100 liter scale. In the clarified liquid phase there was no increase in Lactate-Dehydrogenase (LDH) activity. Consequently, there was no increased exposure of the product to intracellular components.Due to continuous operation with a periodic and automatic discharge of sediment, a high throughput was achieved without any considerable loss of product. The clarification for mammalian cells was in the range of 99% to 99.9%, depending on the operating conditions. The content of cell debris and other small particles decreased about 30 to 50%, depending on the particle load in the feed stream. The centrifuge was fully contained; cleaning and sterilizing in place possible. Therefore, the decice could be integrated easily into the fermentation process.
RESUMO
For monitoring of recombinant human antithrombin III during cell culture processes and subsequent purification steps a rapid method for quantitative determination was developed. The need for the introduction of this rapid method came from the limited availability of a quantitative enzyme-linked immunosorbent assay (ELISA) and the very time-consuming ELISA procedure. The developed method is based on reversed-phase high-performance liquid chromatography using a C4 column. The separation by gradient elution using water and acetonitrile takes less than 20 min even when complex samples, such as serum containing cell culture samples, have to be analyzed. Automation and a high sample throughput are possible with this reliable method. If necessary, insulin, transferrin and albumin can also be quantified with minor changes of the elution profile.