Indicators for lack of systemic availability of organic pigments.

Experimental data of all 143 organic pigments registered with the European Chemicals Agency, of which 88 were listed in a nanomaterial inventory, was retrieved from the registered substance fact sheets. Availability of the data was 93% for solubility, 82% for bacterial mutagenicity, 79% for acute oral toxicity, 75% for irritation, 59% for skin sensitisation, 36% for repeated dose toxicity and 34% for each clastogenicity and mutagenicity in mammalian cells and 23% for toxicity to reproduction. Pigments mostly had a water and octanol solubility of significantly below 0.1 mg/L, but fourteen were found to be of higher solubility. None were irritating to skin and eyes. Except for the metal salt and the ß-naphthol pigments, none of the insoluble pigments showed adverse effects up to limit doses indicating that poor solubility prevents systemic uptake of toxicologically relevant amounts. The few available toxicokinetic data shows absence of metabolism or significant uptake and is in support of this. Occasional effects observed on bacterial mutagenicity and skin sensitisation are attributed to impurities. There is no indication that for organic pigments other particle characteristics such as surface area or morphology have an impact on the investigated toxicological endpoints.

Local tolerance testing under REACH: Accepted non-animal methods are not on equal footing with animal tests.

In general, no single non-animal method can cover the complexity of any given animal test. Therefore, fixed sets of in vitro (and in chemico) methods have been combined into testing strategies for skin and eye irritation and skin sensitisation testing, with pre-defined prediction models for substance classification. Many of these methods have been adopted as OECD test guidelines. Various testing strategies have been successfully validated in extensive in-house and inter-laboratory studies, but they have not yet received formal acceptance for substance classification. Therefore, under the European REACH Regulation, data from testing strategies can, in general, only be used in so-called weight-of-evidence approaches. While animal testing data generated under the specific REACH information requirements are per se sufficient, the sufficiency of weight-of-evidence approaches can be questioned under the REACH system, and further animal testing can be required. This constitutes an imbalance between the regulatory acceptance of data from approved non-animal methods and animal tests that is not justified on scientific grounds. To ensure that testing strategies for local tolerance testing truly serve to replace animal testing for the REACH registration 2018 deadline (when the majority of existing chemicals have to be registered), clarity on their regulatory acceptance as complete replacements is urgently required.

Comparative short-term inhalation toxicity of five organic diketopyrrolopyrrole pigments and two inorganic iron-oxide-based pigments.

Diketopyrrolopyrroles (DPP) are a relatively new class of organic high-performance pigments. The present inhalation and particle characterization studies were performed to compare the effects of five DPP-based pigments (coarse and fine Pigment Red 254, coarse and fine meta-chloro DPP isomer and one form of mixed chlorinated DPP isomers) and compare it to coarse and fine inorganic Pigment Red 101. Wistar rats were exposed head-nose to atmospheres of the respective materials for 6 h/day on 5 consecutive days. Target concentrations were 30 mg/m(3) as high dose for all compounds and selected based occupational exposure limits for respirable nuisance dust. Toxicity was determined after end of exposure and after 3-week recovery using broncho-alveolar lavage fluid (BALF) and microscopic examinations of the entire respiratory tract. Mixed chlorinated DPP isomers and coarse meta-chloro DPP isomer caused marginal changes in BALF, consisting of slight increases of polymorphonuclear neutrophils, and in case of coarse meta-chloro DPP increased MCP-1 and osteopontin levels. Mixed chlorinated DPP isomers, Pigment Red 254, and meta-chloro DPP caused pigment deposits and phagocytosis by alveolar macrophages, slight hypertrophy/hyperplasia of the bronchioles and alveolar ducts, but without evidence of inflammation. In contrast, only pigment deposition and pigment phagocytosis were observed after exposure to Pigment Red 101. All pigments were tolerated well and caused only marginal effects in BALF or no effects at all. Only minor effects were seen on the lung by microscopic examination. There was no evidence of systemic inflammation based on acute-phase protein levels in blood.

Assessment of Pre- and Pro-haptens Using Nonanimal Test Methods for Skin Sensitization.

Because of ethical and regulatory reasons, several nonanimal test methods to assess the skin sensitization potential of chemicals have been developed and validated. In contrast to in vivo methods, they lack or provide limited metabolic capacity. For this reason, identification of pro-haptens but also pre-haptens, which require molecular transformations to gain peptide reactivity, is a challenge for these methods. In this study, 27 pre- and pro-haptens were tested using nonanimal test methods. Of these, 18 provided true positive results in the direct peptide reactivity assay (DPRA; sensitivity of 67%), although lacking structural alerts for direct peptide reactivity. The reaction mechanisms leading to peptide depletion in the DPRA were therefore elucidated using mass spectrometry. Hapten-peptide adducts were identified for 13 of the 18 chemicals indicating that these pre-haptens were activated and that peptide binding occurred. Positive results for five of the 18 chemicals can be explained by dipeptide formations or the oxidation of the sulfhydryl group of the peptide. Nine of the 27 chemicals were tested negative in the DPRA. Of these, four yielded true positive results in the keratinocyte and dendritic cell based assays. Likewise, 16 of the 18 chemicals tested positive in the DPRA were also positive in either one or both of the cell-based assays. A combination of DPRA, KeratinoSens, and h-CLAT used in a 2 out of 3 weight of evidence (WoE) approach identified 22 of the 27 pre- and pro-haptens correctly (sensitivity of 81%), exhibiting a similar sensitivity as for directly acting haptens. This analysis shows that the combination of in chemico and in vitro test methods is suitable to identify pre-haptens and the majority of pro-haptens.

Eye irritation testing of nanomaterials using the EpiOcular™ eye irritation test and the bovine corneal opacity and permeability assay.

BACKGROUND: Assessment of eye irritation hazard has long been a core requirement in any chemical legislation. Nevertheless, publications focussing on the eye damaging potential of nanomaterials are scarce. Traditionally, eye irritation testing was performed using rabbits. The OECD Test Guideline 437 Bovine Corneal Opacity and Permeability (BCOP) test method allows determining severely irritating substances without animals, and the recently adopted OECD Test Guideline 492 Reconstructed human cornea-like epithelium test method allows identifying chemicals that neither induce eye irritation nor serious eye damage. For substances applicable to these tests, huge progress has been made in replacing animal testing. METHODS: The in vitro eye irritation potential of 20 nanosized and 3 non-nanosized materials was investigated in a 2-tier EpiOcular™ Eye Irritation Test (EpiOcular™-EIT) and BCOP testing strategy including histopathology of the bovine corneas. Furthermore, applicability of the testing strategy for nanomaterials was assessed. Test materials encompassed OECD representative nanomaterials (metals (Ag), metal oxides (ZnO, TiO2, CeO2), amorphous SiO2 and MWCNTs), three organic pigments, quartz, and talc. RESULTS: None of the dry-powder nanomaterials elicited eye irritation in either the EpiOcular™-EIT or the BCOP assay. Likewise, an amorphous SiO2 nanomaterial that was supplied as suspension was tested negative in both assays. By contrast, in the EpiOcular™-EIT, the silver nanomaterial that was supplied as dispersion was tested positive, whereas its surfactant-containing dispersant was borderline to negative. In the BCOP assay, the silver nanomaterial elicited highly variable results and dark-brown patches remained on the corneal surface, whereas the results for its dispersant alone were borderline to positive, which was assessed as inconclusive due to high inter-assay variability. CONCLUSION: The present study points to the low eye irritation potential of a spectrum of nanomaterials, which is consistent with available in vivo data for the same test materials or for nanosized or bulk materials of the same composition.

A medical-toxicological view of tattooing.

Long perceived as a form of exotic self-expression in some social fringe groups, tattoos have left their maverick image behind and become mainstream, particularly for young people. Historically, tattoo-related health and safety regulations have focused on rules of hygiene and prevention of infections. Meanwhile, the increasing popularity of tattooing has led to the development of many new colours, allowing tattoos to be more spectacular than ever before. However, little is known about the toxicological risks of the ingredients used. For risk assessment, safe intradermal application of these pigments needs data for toxicity and biokinetics and increased knowledge about the removal of tattoos. Other concerns are the potential for phototoxicity, substance migration, and the possible metabolic conversion of tattoo ink ingredients into toxic substances. Similar considerations apply to cleavage products that are formed during laser-assisted tattoo removal. In this Review, we summarise the issues of concern, putting them into context, and provide perspectives for the assessment of the acute and chronic health effects associated with tattooing.

LuSens: a keratinocyte based ARE reporter gene assay for use in integrated testing strategies for skin sensitization hazard identification.

Allergic contact dermatitis can develop following repeated exposure to allergenic substances. To date, hazard identification is still based on animal studies as non-animal alternatives have not yet gained global regulatory acceptance. Several non-animal methods addressing key-steps of the adverse outcome pathway (OECD, 2012) will most likely be needed to fully address this effect. Among the initial cellular events is the activation of keratinocytes and currently only one method, the KeratinoSens™, has been formally validated to address this event. In this study, a further method, the LuSens assay, that uses a human keratinocyte cell line harbouring a reporter gene construct composed of the antioxidant response element (ARE) of the rat NADPH:quinone oxidoreductase 1 gene and the luciferase gene. The assay was validated in house using a selection of 74 substances which included the LLNA performance standards. The predictivity of the LuSens assay for skin sensitization hazard identification was comparable to other non-animal methods, in particular to the KeratinoSens™. When used as part of a testing battery based on the OECD adverse outcome pathway for skin sensitization, a combination of the LuSens assay, the DPRA and a dendritic cell line activation test attained predictivities similar to that of the LLNA.

Computer models versus reality: how well do in silico models currently predict the sensitization potential of a substance.

National legislations for the assessment of the skin sensitization potential of chemicals are increasingly based on the globally harmonized system (GHS). In this study, experimental data on 55 non-sensitizing and 45 sensitizing chemicals were evaluated according to GHS criteria and used to test the performance of computer (in silico) models for the prediction of skin sensitization. Statistic models (Vega, Case Ultra, TOPKAT), mechanistic models (Toxtree, OECD (Q)SAR toolbox, DEREK) or a hybrid model (TIMES-SS) were evaluated. Between three and nine of the substances evaluated were found in the individual training sets of various models. Mechanism based models performed better than statistical models and gave better predictivities depending on the stringency of the domain definition. Best performance was achieved by TIMES-SS, with a perfect prediction, whereby only 16% of the substances were within its reliability domain. Some models offer modules for potency; however predictions did not correlate well with the GHS sensitization subcategory derived from the experimental data. In conclusion, although mechanistic models can be used to a certain degree under well-defined conditions, at the present, the in silico models are not sufficiently accurate for broad application to predict skin sensitization potentials.

Non-animal test methods for predicting skin sensitization potentials.

Contact allergies are complex diseases, and it is estimated that 15-20 % of the general population suffers from contact allergy, with increasing prevalence. Evaluation of the sensitization potential of a substance is usually carried out in animal models. Nowadays, there is much interest in reducing and ultimately replacing current animal tests. Furthermore, as of 2013, the EU has posed a ban on animal testing of cosmetic ingredients that includes skin sensitization. Therefore, predictive and robust in vitro tests are urgently needed. In order to establish alternatives to animal testing, the in vitro tests must mimic the very complex interactions between the sensitizing chemical and the different parts of the immune system. This review article summarizes recent efforts to develop in vitro tests for predicting skin sensitizers. Cell-based assays, in chemico methods and, to a lesser extent, in silico methods are presented together with a discussion of their current status. With considerable progress having been achieved during the last years, the rationale today is that data from different non-animal test methods will have to be combined in order to obtain reliable hazard and potency information on potential skin sensitizers.

Putting the parts together: combining in vitro methods to test for skin sensitizing potentials.

Allergic contact dermatitis is a common skin disease and is elicited by repeated skin contact with an allergen. In the regulatory context, currently only data from animal experiments are acceptable to assess the skin sensitizing potential of substances. Animal welfare and EU Cosmetic Directive/Regulation call for the implementation of animal-free alternatives for safety assessments. The mechanisms that trigger skin sensitization are complex and various steps are involved. Therefore, a single in vitro method may not be able to accurately assess this endpoint. Non-animal methods are being developed and validated and can be used for testing strategies that ensure a reliable prediction of skin sensitization potentials. In this study, the predictivities of four in vitro assays, one in chemico and one in silico method addressing three different steps in the development of skin sensitization were assessed using 54 test substances of known sensitizing potential. The predictivity of single tests and combinations of these assays were compared. These data were used to develop an in vitro testing scheme and prediction model for the detection of skin sensitizers based on protein reactivity, activation of the Keap-1/Nrf2 signaling pathway and dendritic cell activation.

Identification and localization of soluble sulfotransferases in the human gastrointestinal tract.

Soluble SULTs (sulfotransferases) are important in the regulation of messenger molecules and the elimination of xenobiotics. However, sulfo-conjugation of various substrates can also lead to the formation of reactive metabolites that may induce cancer and cause other damage. The aim of the present study was to identify the SULT forms expressed in the human gastrointestinal tract, especially the colon and rectum (common sites for cancer), and to determine their cellular localization. Normal colonic or rectal tissue, resected with tumours, was obtained from 39 subjects. For comparison, we additionally studied one to four samples from stomach, jejunum, ileum, cecum and liver. SULTs were detected by immunoblotting, immunohistochemistry and measurement of enzyme activities. SULT1A1, 1A3 and 1B1 were found in all parts of the gastrointestinal tract, often exceeding levels in liver (where these forms were present at high, undetectable and low levels respectively). They were predominantly localized in differentiated enterocytes. SULT1E1 and 2A1 were only detected in liver, jejunum, ileum and cecum. SULT1C1 was readily found in stomach, but was negligible elsewhere. SULT1A2 was present at low levels in individual samples. The remaining forms were not detected with the limitation that only high levels could be recognized with the antisera used. In conclusion, SULTs are abundant in the gastrointestinal tract of man. We suspect that they are involved in the presystemic elimination of bioactive food-borne components, including aglycones released by gut microbiota, as well as the bioactivation of some procarcinogens.

Malignant transformation of human colon epithelial cells by benzo[c]phenanthrene dihydrodiolepoxides as well as 2-hydroxyamino-1-methyl-6-phenylimidazo[4,5-b]pyridine.

Polycyclic aromatic hydrocarbons (PAHs) and heterocyclic aromatic amines (HCAs) ingested with food have repeatedly been suggested to be involved in the malignant transformation of colon epithelial cells. In order to test this hypothesis, HCEC cells (SV40 large T antigen-immortalized human colon epithelial cells) were incubated with a racemic mixture of benzo[c]phenanthrene dihydrodiol epoxides (B[c]PhDE), extremely potent carcinogenic PAH metabolites in vivo, or with 2-hydroxyamino-1-methyl-6-phenylimidazo[4,5-b]pyridine (N-OH-PhIP), the N-hydroxylated metabolite of the most abundant HCA in cooked meat. First, it was shown that HCEC cells express sulfotransferase 1A1, which is needed to metabolize N-OH-PhIP to the corresponding N-sulfonyloxy derivative, the direct precursor molecule of genotoxic nitrenium ions. Thereafter, exponentially growing HCEC cells were exposed five times to 0.1 microg (0.37 nmol) B[c]PhDE/ml for 30 min or 0.72 microg (3 nmol) N-OH-PhIP/ml for 24 h. Chemically treated HCEC cells showed an enhanced saturation density and grew faster than the corresponding solvent-treated cell cultures. After five treatment cycles, HCEC(B[c]PhDE) as well as HCEC(N-OH-PhIP) cells lost cell-cell contact inhibition and started piling up and forming foci in the culture flasks. Furthermore, HCEC(B[c]PhDE) and HCEC(N-OH-PhIP) cells were injected i.m. into SCID mice. Within 6 weeks after injection, eight animals out of eight injected with HCEC(B[c]PhDE) or HCEC(N-OH-PhIP) cells developed tumors at the site of injection, thus demonstrating the high tumorigenic potential of the HCEC(B[c]PhDE) and HCEC(N-OH-PhIP) cell cultures. Taken together, we show for the first time that the abovementioned active PAH metabolites as well as N-OH-PhIP are indeed able to malignantly transform human colon epithelial cells in vitro.

Stable expression of rat sulfotransferase 1B1 in V79 cells: activation of benzylic alcohols to mutagens.

We have constructed Chinese hamster V79-derived cell lines (V79-rSULT1B1-A and -B) that express rat sulfotransferase 1B1 (rSULT1B1). Sulfotransferase activity towards 1-naphthol was 1020 +/- 220 pmol/min/mg cytosolic protein in V79-rSULT1B1-A cells and 57 +/- 9 pmol/ min/mg in V79-rSULT1B1-B cells. These activities were similar over 100 population doublings and at varying cell densities. Immunostaining indicated a cytoplasmatic localization of rSULT1B1. Expression usually was homogeneous within colonies but showed some variation between colonies. The level of rSULT1B1 protein in V79-rSULT1B1-B cells was similar to that in rat liver but higher than in colon mucosa. The cytotoxicity of the benzylic alcohols 4H-cyclopenta[def]chrysen-4-ol and 6-hydroxymethylbenzo-[a]pyrene was enhanced >100-fold in V79-rSULT1B1-A cells compared with SULT-deficient cells (V79p). Likewise, these compounds showed mutagenic effects (at the hprt locus) in V79-rSULT1B1-A cells starting at a concentration of 0.02 and 0.01 micro M, respectively, but were inactive in V79p cells even at a concentration of 1 micro M. The cell line with the lower expression level, V79-rSULT1B1-B, showed only marginal toxification of the compounds investigated, indicating an important role of the expression level in the test system. A thoroughly characterized mammalian cell system, including positive controls, is now available for studying rSULT1B1-mediated bioactivation of promutagens and protoxicants.