Lyophilisation and concentration of chitosan/siRNA polyplexes: Influence of buffer composition, oligonucleotide sequence, and hyaluronic acid coating.

Chitosan (CS)/siRNA polyplexes have great therapeutic potential for treating multiple diseases by gene silencing. However, clinical application of this technology requires the development of concentrated, hemocompatible, pH neutral formulations for safe and efficient administration. In this study we evaluate physicochemical properties of chitosan polyplexes in various buffers at increasing ionic strengths, to identify conditions for freeze-drying and rehydration at higher doses of uncoated or hyaluronic acid (HA)-coated polyplexes while maintaining physiological compatibility. Optimized formulations are used to evaluate the impact of the siRNA/oligonucleotide sequence on polyplex physicochemical properties, and to measure their in vitro silencing efficiency, cytotoxicity, and hemocompatibility. Specific oligonucleotide sequences influence polyplex physical properties at low N:P ratios, as well as their stability during freeze-drying. Nanoparticles display greater stability for oligodeoxynucleotides ODN vs siRNA; AT-rich vs GC-rich; and overhangs vs blunt ends. Using this knowledge, various CS/siRNA polyplexes are prepared with and without HA coating, freeze-dried and rehydrated at increased concentrations using reduced rehydration volumes. These polyplexes are non-cytotoxic and preserve silencing activity even after rehydration to 20-fold their initial concentration, while HA-coated polyplexes at pH∼7 also displayed increased hemocompatibility. These concentrated formulations represent a critical step towards clinical development of chitosan-based oligonucleotide intravenous delivery systems.

Preparation of Concentrated Chitosan/DNA Nanoparticle Formulations by Lyophilization for Gene Delivery at Clinically Relevant Dosages.

Chitosan/DNA polyplexes have been optimized for efficient and safe in vitro and in vivo gene delivery. Clinical application of this technology requires the development of formulations with higher concentrations to reach therapeutic dosages. Polyplexes were prepared using chitosan and EGFPLuc plasmids. Freeze-thawing and freeze-drying studies were performed to identify and optimize lyoprotectant and buffer contents in formulations. Freeze-dried samples were rehydrated in reduced volumes to increase their final DNA dose. Nanoparticle physicochemical properties were analyzed, and their transfection efficiency and cytotoxicity were measured in human embryonic kidney 293 cells. Data showed that 3.5 mM histidine buffer (pH 6.5) combined with one of 0.5% wt/vol sucrose, dextran 5 kDa, or trehalose was required to prevent polyplex aggregation during freeze-drying. Optimal formulations could be concentrated 20-fold, to a clinically desired ∼1 mg of DNA/mL, while maintaining near physiological pH and tonicity. Polyplexes were predominantly spherical, with diameters below 200 nm, polydispersity indexes below 0.32, and zeta potentials above +19 mV. Rehydrated formulations had transfection efficiencies no less than 65% of fresh polyplexes without excipients and had no effect on viability and metabolic activity of human embryonic kidney 293 cells. These concentrated formulations represent an important step toward clinical use of chitosan-based gene delivery systems.

Three-dimensional in situ zonal morphology of viable growth plate chondrocytes: a confocal microscopy study.

Longitudinal growth, occurring in growth plates with structurally distinct zones, has clinical implications in the treatment of progressive skeletal deformities. This study documents the three-dimensional morphology of chondrocytes within histological zones of growth plate using confocal microscopy combined with fluorescent labeling techniques. Three-dimensional reconstruction of Calcein AM-labeled chondrocytes was made from stacks of confocal images recorded in situ from 4-week-old swine growth plates. Three-dimensional quantitative morphological measurements were further performed and compared at both tissue and cell levels. Chondrocyte volume and surface area increased about five- and threefold, respectively, approaching the chondro-osseous junction from the pool of reserve cells. Chondrocytes from the proliferative zone were the most discoidal cells (sphericity of 0.81 ± 0.06) among three histological zones. Minimum and maximum cell/matrix volume ratios were identified in the reserve (11.0 ± 2.2) and proliferative zones (16.8 ± 3.0), respectively. Evaluated parameters revealed the heterogeneous and zone-dependent morphological state of the growth plate. Tissue and cellular morphology may have noteworthy contribution to the growth plate behavior during growth process. The ability to obtain in situ cell morphometry and monitor the changes in the growth direction could improve our understanding of the mechanisms through which abnormal growth is triggered.

Tissue and cellular morphological changes in growth plate explants under compression.

The mechanisms by which mechanical loading may alter bone development within growth plates are still poorly understood. However, several growth plate cell or tissue morphological parameters are associated with both normal and mechanically modulated bone growth rates. The aim of this study was to quantify in situ the three-dimensional morphology of growth plate explants under compression at both cell and tissue levels. Growth plates were dissected from ulnae of immature swine and tested under 15% compressive strain. Confocal microscopy was used to image fluorescently labeled chondrocytes in the three growth plate zones before and after compression. Quantitative morphological analyses at both cell (volume, surface area, sphericity, minor/major radii) and tissue (cell/matrix volume ratio) levels were performed. Greater chondrocyte bulk strains (volume decrease normalized to the initial cell volume) were found in the proliferative (35.4%) and hypertrophic (41.7%) zones, with lower chondrocyte bulk strains (24.7%) in the reserve zone. Following compression, the cell/matrix volume ratio decreased in the reserve and hypertrophic zones by 24.3% and 22.6%, respectively, whereas it increased by 35.9% in the proliferative zone. The 15% strain applied on growth plate explants revealed zone-dependent deformational states at both tissue and cell levels. Variations in the mechanical response of the chondrocytes from different zones could be related to significant inhomogeneities in growth plate zonal mechanical properties. The ability to obtain in situ cell morphometry and monitor the changes under compression will contribute to a better understanding of mechanisms through which abnormal growth can be triggered.