Presence of Acetamide in Milk and Beef from Cattle Consuming AFEX-Treated Crop Residues.

AFEX treatment of crop residues can greatly increase their nutrient availability for ruminants. This study investigated the concentration of acetamide, an ammoniation byproduct, in AFEX-treated crop residues and in milk and meat from ruminants fed these residues. Acetamide concentrations in four AFEX-treated cereal crop residues were comparable and reproducible (4-7 mg/g dry matter). A transient acetamide peak in milk was detected following introduction of AFEX-treated residues to the diet, but an alternative regimen showed the peak can be effectively mitigated. Milk acetamide concentration following this transition was 6 and 10 ppm for cattle and buffalo, respectively, but also decreased over time for cattle while tending to decrease (p = 0.08) for buffalo. There was no difference in acetamide concentration in the meat of cattle consuming AFEX-treated residues for 160 days compared to controls. Further investigation is necessary to determine the metabolism of acetamide in ruminants and a maximum acceptable daily intake for humans.

Exposure Assessment of Acetamide in Milk, Beef, and Coffee Using Xanthydrol Derivatization and Gas Chromatography/Mass Spectrometry.

Acetamide has been classified as a possible human carcinogen, but uncertainties exist about its levels in foods. This report presents evidence that thermal decomposition of N-acetylated sugars and amino acids in heated gas chromatograph injectors contributes to artifactual acetamide in milk and beef. An alternative gas chromatography/mass spectrometry protocol based on derivatization of acetamide with 9-xanthydrol was optimized and shown to be free of artifactual acetamide formation. The protocol was validated using a surrogate analyte approach based on d3-acetamide and applied to analyze 23 pasteurized whole milk, 44 raw sirloin beef, and raw milk samples from 14 different cows, and yielded levels about 10-fold lower than those obtained by direct injection without derivatization. The xanthydrol derivatization procedure detected acetamide in every food sample tested at 390 ± 60 ppb in milk, 400 ± 80 ppb in beef, and 39 000 ± 9000 ppb in roasted coffee beans.

Probing the nature of AFEX-pretreated corn stover derived decomposition products that inhibit cellulase activity.

Sequential fractionation of AFEX-pretreated corn stover extracts was carried out using ultra-centrifugation, ultra-filtration, and solid phase extraction to isolate various classes of pretreatment products to evaluate their inhibitory effect on cellulases. Ultra-centrifugation removed dark brown precipitates that caused no appreciable enzyme inhibition. Ultra-filtration of ultra-centrifuged AFEX-pretreated corn stover extractives using a 10 kDa molecular weight cutoff (MWCO) membrane removed additional high molecular weight components that accounted for 24-28% of the total observed enzyme inhibition while a 3 kDa MWCO membrane removed 60-65%, suggesting significant inhibition is caused by oligomeric materials. Solid phase extraction (SPE) of AFEX-pretreated corn stover extractives after ultra-centrifugation removed 34-43% of the inhibition; ultra-filtration with a 5 kDa membrane removed 44-56% of the inhibition and when this ultra-filtrate was subjected to SPE a total of 69-70% of the inhibition were removed. Mass spectrometry found several phenolic compounds among the hydrophobic inhibition removed by SPE adsorption.

Whole-body tissue distribution study of drugs in neonate mice using desorption electrospray ionization mass spectrometry imaging.

RATIONALE: Although Desorption Electrospray Ionization (DESI) Mass Spectrometry Imaging (MSI) is uniquely suited for whole-body (WB) tissue distribution study of drugs, success in this area has been difficult. Here, we present WB tissue distribution studies using DESI-MSI and a new histological tissue-friendly solvent system. METHODS: Neonate pups were dosed subcutaneously (SC) with clozapine, compound 1, compound 2, or compound 3. Following euthanization by hypothermia, neonates underwent a transcardiac perfusion (saline) to remove blood. After cryosectioning, DESI-MSI was conducted for the WB tissue slides, followed sequentially by histological staining. RESULTS: Whole-body tissue imaging showed that clozapine and its N-oxide metabolite were distributed in significant amounts in the brain, spinal cord, liver, heart (ventricle), and lungs. Compound 1 was distributed mainly in the liver and muscle, and its mono-oxygenated metabolite was detected by DESI-MSI exclusively in the liver. Compound 2 was distributed mainly in the muscle and fatty tissue. Compound 3 was distributed mainly in fatty tissue and its metabolites were also mainly detected in the same tissue. CONCLUSIONS: The results demonstrate the successful application of DESI-MSI in whole-body tissue distribution studies of drugs and metabolites in combination with sequential histology staining for anatomy. The results also identified lipophilicity as the driving force in the tissue distribution of the three Amgen compounds.

Profiling of diferulates (plant cell wall cross-linkers) using ultrahigh-performance liquid chromatography-tandem mass spectrometry.

Recalcitrance of grasses to enzymatic digestion arises to a significant degree from a complex array of phenolic crosslinks between cell wall polysaccharide chains that inhibit their conversion to biofuels and lower their nutritive value for animal feed applications. Polysaccharide esters of ferulic acid are abundant in plant cell walls. Crosslinks between polysaccharides are formed through oxidative dehydrodimerization of ferulates, producing dehydrodiferulates (henceforth termed diferulates). Such ferulates and diferulates further crosslink plant cell walls by radical coupling cross-reactions during lignification. Although cell wall digestibility can be improved by cell wall metabolic engineering, or post-harvest by various pretreatment processes, a more comprehensive understanding of the role and impact of ferulate crosslinking on polysaccharide hydrolysis would be accelerated by availability of analytical methods that can distinguish the various diferulates released during biomass pretreatments, many of which are isomers. In this report, we present an ultrahigh-performance liquid chromatography/tandem mass spectrometry (UHPLC/MS/MS) strategy for comprehensive separation and identification of diferulate isomers. Collision-induced dissociation (CID) mass spectra of [M + H](+) ions distinguished various isomers without requiring derivatization. Characteristic product ions for 8-O-4-, 8-8-non-cyclic, 8-8-cyclic, 8-5-cyclic, 8-5-non-cyclic, and 5-5-linked isomers were identified. All diferulates were identified either as di-acids in extracts of NaOH-hydrolyzed corn stover, or as a diverse group of diferulate mono- and di-amides in extracts of Ammonia Fiber Expansion (AFEX™)-treated corn stover. This approach allows for direct analysis of released diferulates with minimal sample preparation, and can serve as the foundation for high-throughput profiling and correlating pretreatment conditions with biomass digestibility in biorefineries producing biofuels and biochemicals.

Profiling of soluble neutral oligosaccharides from treated biomass using solid phase extraction and LC-TOF MS.

Thermochemical pretreatments of cellulosic biomass are known to improve cell wall enzymatic digestibility, while simultaneously releasing substantial amounts of soluble oligosaccharides. Profiling of oligosaccharides released during pretreatment yields information essential for choosing glycosyl hydrolases necessary for cost-effective conversion of cellulosic biomass to desired biofuel/biochemical end-products. In this report we present a methodology for profiling of soluble neutral oligosaccharides released from ammonia fiber expansion (AFEX™)-pretreated corn stover. Our methodology employs solid phase extraction (SPE) enrichment of oligosaccharides using porous graphitized carbon (PGC), followed by high performance liquid chromatography (HPLC) separation using a polymeric amine based column and electrospray ionization time-of-flight mass spectrometry (ESI-TOF-MS). For structural elucidation on the chromatographic time scale, nonselective multiplexed collision-induced dissociation was performed for quasi-simultaneous acquisition of oligosaccharide molecular and fragment masses in a single analysis. These analyses revealed glucans up to degree of polymerization (DP) 22 without modifications. Additionally, arabinoxylans up to DP=6 were detected in pretreated biomass extracts (post-enzymatic digestion). Cross-ring fragment ion abundances were consistent with assignment of linkages between sugar units in glucans and also xylose backbone in arabinoxylans as 1-4 linkages. Comprehensive profiling of soluble oligosaccharides also demonstrated decreases in levels of acetate esters of arabinoxylan oligosaccharides with concomitant increases in nonacetylated oligosaccharides that were consistent with earlier observations of 85% release of acetate esters by AFEX™ pretreatment.

Localization and quantification of drugs in animal tissues by use of desorption electrospray ionization mass spectrometry imaging.

Mass spectrometric imaging (MSI) has emerged as a powerful technique to obtain spatial arrangement of individual molecular ions in animal tissues. Ambient desorption electrospray ionization (DESI) technique is uniquely suited for such imaging experiments, as it can be performed on animal tissues in their native environment without prior treatments. Although MSI has become a rapid growing technique for localization of proteins, lipids, drugs, and endogenous compounds in different tissues, quantification of imaged targets has not been explored extensively. Here we present a novel MSI approach for localization and quantification of drugs in animal thin tissue sections. DESI-MSI using an Orbitrap mass analyzer in full scan mode was performed on 6 µm coronal brain sections from rats that were administered 2.5 mg/kg clozapine. Clozapine was localized and quantified in individual brain sections 45 min postdose. External calibration curves were prepared by micropipetting standards with internal standard (IS) on top of the tissues, and average response factors were calculated for the scans in which both clozapine and IS were detected. All response factors were normalized to area units. Quantifications from DESI-MSI revealed 0.2-1.2 ng of clozapine in individual brain sections, results that were further confirmed by extraction and liquid chromatography/tandem mass spectrometry (LC/MS/MS) analysis.

Large-scale profiling of diterpenoid glycosides from Stevia rebaudiana using ultrahigh performance liquid chromatography/tandem mass spectrometry.

The plant Stevia rebaudiana accumulates a suite of diterpenoid metabolites that are natural sweeteners finding increased use as sugar substitutes. To guide breeding of stevia plants that accumulate substances with desirable flavor in high yield, rapid and accurate methods are needed to profile these substances in plant populations. This report describes an 8-min ultrahigh performance liquid chromatography-tandem mass spectrometry method for separation and quantification of seven stevia glycosides including steviolbioside; stevioside; rebaudiosides A, B, and C; rubusoside; and dulcoside as well as aglycones steviol and isosteviol. This negative mode electrospray ionization/multiple reaction monitoring method yielded low limits of detection <1 ng/mL for steviol, 6 ng/mL for isosteviol, and <15 ng/mL for all stevia glycosides. Stevioside and Reb A, B, and C were quantified in more than 1,100 extracts from stevia leaves as part of a large-scale profiling exercise. Leaf tissue levels in this population spanned about two orders of magnitude for stevioside (2-125 mg/g dry weight), Reb A (2.5-164 mg/g), Reb B (0.5-50 mg/g), and Reb C (1.5-125 mg/g), but levels of individual metabolites exhibited independent variation. The wide spread of metabolite levels highlights the utility and importance of performing targeted metabolic profiling for large plant populations.

Rapid quantification of major reaction products formed during thermochemical pretreatment of lignocellulosic biomass using GC-MS.

Accurate quantification of reaction products formed during thermochemical pretreatment of lignocellulosic biomass would lead to a better understanding of plant cell wall deconstruction for production of cellulosic biofuels and biochemicals. However, quantification of some process byproducts, most notably acetamide, acetic acid and furfural, present several analytical challenges using conventional liquid chromatography methods. Therefore, we have developed a high-throughput gas chromatography based mass spectrometric (GC-MS) method in order to quantify relevant compounds without requiring time-consuming sample derivatization prior to analysis. Solvent extracts of untreated, ammonia fiber expansion (AFEX) treated and dilute-acid treated corn stover were analyzed by this method. Biomass samples were extracted with acetone using an automated solvent extractor, serially diluted and directly analyzed using the proposed GC-MS method. Acetone was the only solvent amongst water, methanol and acetonitrile that did not contain detectable background levels of the target compounds or facilitate a buildup of plant-derived residues in the GC injector, which decreased analytical reproducibility. Quantitative results were based on the method of standard addition and external standard calibration curves.

Multifaceted characterization of cell wall decomposition products formed during ammonia fiber expansion (AFEX) and dilute acid based pretreatments.

Decomposition products formed/released during ammonia fiber expansion (AFEX) and dilute acid (DA) pretreatment of corn stover (CS) were quantified using robust mass spectrometry based analytical platforms. Ammonolytic cleavage of cell wall ester linkages during AFEX resulted in the formation of acetamide (25mg/g AFEX CS) and various phenolic amides (15mg/g AFEX CS) that are effective nutrients for downstream fermentation. After ammonolysis, Maillard reactions with carbonyl-containing intermediates represent the second largest sink for ammonia during AFEX. On the other hand, several carboxylic acids were formed (e.g. 35mg acetic acid/g DA CS) during DA pretreatment. Formation of furans was 36-fold lower for AFEX compared to DA treatment; while carboxylic acids (e.g. lactic and succinic acids) yield was 100-1000-fold lower during AFEX compared to previous reports using sodium hydroxide as pretreatment reagent.

Mushroom spent straw: a potential substrate for an ethanol-based biorefinery.

Rice straw (RS) is an important lignocellulosic biomass with nearly 800 million dry tons produced annually worldwide. RS has immense potential as a lignocellulosic feedstock for making renewable fuels and chemicals in a biorefinery. However, because of its natural recalcitrance, RS needs thermochemical treatment prior to further biological processing. Ammonia fiber expansion (AFEX) is a leading biomass pretreatment process utilizing concentrated/liquefied ammonia to pretreat lignocellulosic biomass at moderate temperatures (70-140 degrees C). Previous research has shown improved cellulose and hemicellulose conversions upon AFEX treatment of RS at 2:1 ammonia to biomass (w/w) loading, 40% moisture (dwb) and 90 degrees C. However, there is still scope for further improvement. Fungal pretreatment of lignocellulosics is an important biological pretreatment method that has not received much attention in the past. A few reasons for ignoring fungal-based pretreatments are substantial loss in cellulose and hemicellulose content and longer pretreatment times that reduce overall productivity. However, the sugar loss can be minimized through use of white-rot fungi (e.g. Pleutorus ostreatus) over a much shorter duration of pretreatment time. It was found that mushroom spent RS prior to AFEX allowed reduction in thermochemical treatment severity, while resulting in 15% higher glucan conversions than RS pretreated with AFEX alone. In this work, we report the effect of fungal conditioning of RS followed by AFEX pretreatment and enzymatic hydrolysis. The recovery of other byproducts from the fungal conditioning process such as fungal enzymes and mushrooms are also discussed.