Effects of postchill application of acidified sodium chlorite to control Campylobacter spp. and Escherichia coli on commercial broiler carcasses.

Experiments were performed to assess the reduction of Campylobacter spp. and Escherichia coli in commercial broiler carcasses by postchill dip applications of acidified sodium chlorite. Carcass rinses were collected before the inside-outside-bird washer (IOBW), post-IOBW, postchill, and after the postchill application of acidified sodium chlorite. Prevalence and counts of Campylobacter spp. and E. coli were determined. The mean values for Campylobacter spp. and E. coli counts differed significantly at sampling sites. The IOBW reduced the bacterial counts significantly in only one experiment. The chiller reduced Campylobacter counts significantly in both experiments but failed to significantly reduce the counts of E. coli in one experiment. No major reduction in the prevalence after enrichment for Campylobacter spp. was detected post-IOBW or postchill. However, a significant reduction in Campylobacter spp. and in E. coli counts and Campylobacter spp. prevalence was seen after the postchill application of acidified sodium chlorite. These results demonstrate that the antimicrobial effect of acidified sodium chlorite applied postchill may be used to significantly reduce Campylobacter spp. and E. coli in commercial broiler carcasses. Postchill systems may eventually be used in different applications, such as mist, spray, or bath, which could be applied closer to the final stages in processing.

Efficacy of two acidified chlorite postmilking teat disinfectants with sodium dodecylbenzene sulfonic acid on prevention of contagious mastitis using an experimental challenge protocol.

Two acidified sodium chlorite postmilking teat disinfectants were evaluated for efficacy against Staphylococcus aureus and Streptococcus agalactiae by using National Mastitis Council experimental challenge procedures. The effect of these teat dips on teat skin and teat end condition was also determined. Both dips contained 0.32% sodium chlorite, 1.32% lactic, and 2.5% glycerin. Dips differed in the amount of sodium dodecylbenzene sulfonic acid (0.53 or 0.27%) added as a surfactant. Both dips significantly reduced new intramammary infection (IMI) rates compared with undipped controls. The dip containing 0.53% dodecylbenzene sulfonic acid reduced new IMI by Staph. aureus by 72% and Strep. agalactiae by 75%. The dip containing 0.27% dodecylbenzene sulfonic acid reduced new IMI by Staph. aureus by 100% and by Strep. agalactiae by 88%. Changes in teat skin and teat end condition for treatment and control groups varied in parallel over time. Teats treated with either teat dip had higher mean teat skin and teat end scores than control teats at some weeks. However, teat skin and teat end condition did not tend to change from the start to the completion of the trial. Application of the two new postmilking teat dips was effective in reducing new IMI from contagious mastitis pathogens. (Key words: teat dip, contagious mastitis, chlorous acid)