Treatment of swine manure by hydrothermal carbonization: The influential effect and preliminary mechanism of surfactants.

Treatment of swine manure by hydrothermal carbonization (HTC) with the aid of different surfactants was first explored in this study. PEG 400 (polyethylene glycol 400) and Tween 80 facilitated the formation of bio-oil. SLS (sodium lignosulfonate) and SDS (sodium dodecyl sulfate) promoted the formation of water-soluble matters/gases. Span 80 enhanced the formation of hydrochar, which resulted in a 50.19 % mass yield, 92.39 % energy yield, and a caloric value of 28.68 MJ/kg. The hydrochar obtained with Span 80 presented a similar combustion performance to raw swine manure and the best pyrolysis performance. The use of Span 80 promoted the transfer of degradation products to hydrochar, especially hydrophobic ester and ketone compounds. Notedly, Span 80 suppressed the synthesis of PAHs during the HTC process, which was reduced to 0.92 mg/kg. Furthermore, the hydrochar produced with Span 80 contained lower contents of heavy metals. On the whole, Span 80 has shown great potential in enhancing the HTC of swine manure. The acting mechanisms of surfactants in the HTC of swine manure included adsorption, dispersion, and electrostatics repulsion.

Recycling Pomelo Peel Waste in the Form of Hydrochar Obtained by Microwave-Assisted Hydrothermal Carbonization.

Pomelo peel (PP) is a kind of solid waste that is produced in the processing industry of honey pomelo. This study deeply explored the feasibility of recycling PP in the form of hydrochar (HC) by microwave-assisted hydrothermal carbonization (HTC) technology. Under the non-catalytic reaction conditions, the yield of hydrochar initially increased with the rise of reaction temperature (150-210 °C) until it remained relatively stable after 210 °C. Under the CaO-catalytical reaction condition, the yield of hydrochar did not change much at first (150-190 °C) but decreased significantly when the reaction temperature exceeded 190 °C. After the microwave-assisted HTC treatment, the PP-derived HC presented higher aromaticity, carbonization degree, porosity, and caloric value. Compared with raw PP, the nutrients in HC were more stable (conducive to being used as slow-release fertilizer). The application of CaO increased the pH value of HC and effectively promoted the accumulation of phosphorus in HC. The HC produced at 210 °C without any catalyst possessing a high devolatilization ability. Additionally, the HC obtained at 190 °C with CaO as the catalyst presented a high combustion property. In general, PP-derived HC showed great application potential in the field of soil remediation/improvement and solid fuels. This preliminary study would undoubtedly provide some important fundamental understanding of the microwave-assisted HTC of PP.

Efficient conversion of sewage sludge into hydrochar by microwave-assisted hydrothermal carbonization.

The treatment of sewage sludge (SS) is an environmental problem worldwide. In recent years, hydrothermal carbonization (HTC) of SS for hydrochar (HC) has attracted extensive attention. This study preliminarily explored the microwave-assisted HTC of SS for the first time. Increasing the reaction temperature (150-250 °C) and reaction time (0-120 min) resulted in a decrease in the HC yield, and it gradually increased with the rising solid-liquid ratio (0.03-0.25 g/mL). Compared with raw SS, the HC products possessed higher aromaticity, carbonization degree, porosity, and polarity, and lower content of soluble nutrients (N/P/K) and leachable heavy metals (Cu, Zn, Pb, Cd, Cr, and Ni), indicating a lower risk of nutrient and heavy metal loss. Attention should be paid to the total contents of Zn and Cd in HC exceeded the permitted value for use in cultivated land with edible crops. The use of CaO as a catalyst improved the yield of HC, made the HC and process water (PW) weakly alkaline, and further passivated the heavy metals in the HC. In the case of H3PO4, although the conversion of SS was enhanced (lower content of volatile organic matter in HC), the contents of soluble nutrients (N/P/K) in HC/PW increased, and the migration of Zn and Cd into process water was enhanced. The HCs obtained in this study had poor combustion properties, but higher ignition temperatures than raw SS. PW must be properly treated or recycled because it still contained high contents of organic matter and nutrients. This fundamental study provides basic insights into the microwave-assisted HTC of SS.