Beyond Mechanical Recycling: Giving New Life to Plastic Waste.

Increasing the stream of recycled plastic necessitates an approach beyond the traditional recycling via melting and re-extrusion. Various chemical recycling processes have great potential to enhance recycling rates. In this Review, a summary of the various chemical recycling routes and assessment via life-cycle analysis is complemented by an extensive list of processes developed by companies active in chemical recycling. We show that each of the currently available processes is applicable for specific plastic waste streams. Thus, only a combination of different technologies can address the plastic waste problem. Research should focus on more realistic, more contaminated and mixed waste streams, while collection and sorting infrastructure will need to be improved, that is, by stricter regulation. This Review aims to inspire both science and innovation for the production of higher value and quality products from plastic recycling suitable for reuse or valorization to create the necessary economic and environmental push for a circular economy.

Characterization of Water Solubility in n-Octacosane Using Raman Spectroscopy.

In this study, we demonstrate the ability of polarization-difference Raman spectroscopy (PDRS) to detect dissolved free water molecules in a n-octacosane (n-C28H58) liquid-rich phase, and thus to determine its solubility, at temperatures and pressures relevant to the Fischer-Tropsch synthesis. Our results for the pure alkane reveal thermal decomposition above a temperature of 500 K as well as an increase of gauche conformers of the alkane chains with an increase in temperature. For binary homogeneous mixtures, raw spectra obtained from two different polarization scattering geometries did not show a relevant signal in the OH stretching frequency range. In contrast, isotropic spectra obtained from the PDRS technique reveal a narrow and tiny peak associated with the dangling OH bonds. Over the complete range of temperatures and pressures, no signature of hydrogen-bonded water molecules was observed in the isotropic Raman scattering intensities. A thorough investigation covering a large range of temperatures and pressures using PDRS signals showed that the higher the fraction of gauche conformers of hydrocarbon, the higher the solubility of water. The proportion of gauche and trans conformers was found to be water-concentration-independent, and the intensity of the OH-dangling peak increased linearly with increasing the vapor partial pressure of water. Therefore, we established a relation between a relevant intensity ratio and the concentration of water obtained from SAFT calculations. Contrary to the results from relevant literature, the calibration factor was found to be temperature-independent between 424 and 572 K. The isotropic Raman scattering intensities are corrected in order to provide a better representation of the vibrational density of states. The influence of correction of the isotropic scattering intensities on the solubility measurements as well as on the analysis of the molecular arrangement is discussed.

Simultaneous Analysis of Equilibrium Fluctuations at the Surface and in the Bulk of a Binary Liquid Mixture by Dynamic Light Scattering.

For the first time, we demonstrate that it is possible to simultaneously analyze microscopic fluctuations at the surface and in the bulk of a binary liquid mixture by dynamic light scattering in macroscopic thermodynamic equilibrium. For a model system containing n-octacosane and ethanol, three individual signals distinguishable in the time-resolved analysis of the scattered light intensity appear on different time scales. One oscillatory signal from surface fluctuations at the vapor-liquid interface in the short-time range and two exponential Rayleigh signals from fluctuations in temperature and concentration in the bulk of fluid in the long-time range could be associated with hydrodynamic modes. This microscopic information allows for a simultaneous determination of the macroscopic properties interfacial tension, kinematic viscosity, thermal diffusivity, and mutual diffusivity within a single experimental run. The presented approach represents a worthwhile strategy, for example, in the context of sensor development for an effective multiproperty determination of fluid systems.

Diffusivities of Ternary Mixtures of n-Alkanes with Dissolved Gases by Dynamic Light Scattering.

Theoretical approaches suggest that dynamic light scattering (DLS) signals from low-molecular-weight ternary mixtures are governed by fluctuations in temperature as well as two individual contributions from fluctuations in concentration that are related to the eigenvalues of the Fick diffusion matrix. Until now, this could not be proven experimentally in a conclusive way. In the present study, a detailed analysis of DLS signals in ternary mixtures consisting of n-dodecane (n-C12H26) and n-octacosane (n-C28H58) with dissolved hydrogen (H2), carbon monoxide (CO), or water (H2O) as well as of n-C12H26 or n-C28H58 with dissolved H2 and CO is given for temperatures up to 523 K and pressures up to 4.1 MPa. Thermal diffusivities of pure n-C12H26 and n-C28H58 as well as thermal and mutual diffusivities of their binary mixtures being the basis for the ternary mixtures with dissolved gas were studied for comparison purposes. For the investigated ternary mixtures, three individual signals could be distinguished in the time-resolved analysis of scattered light intensity by using photon correlation spectroscopy (PCS). For the first time, it could be evidenced that these signals are clearly associated with hydrodynamic modes. In most cases, the fastest mode observable for ternary mixtures is associated with the thermal diffusivity. The two further modes obviously related to the molecular mass transport are observable on different time scales and comparable to the modes associated with the concentration fluctuations in the respective binary mixtures. Comparison of the experimental data with results from molecular dynamics simulations revealed very good agreement.

Simultaneous determination of thermal and mutual diffusivity of binary mixtures of n-octacosane with carbon monoxide, hydrogen, and water by dynamic light scattering.

It is demonstrated that thermal and mutual diffusivities of binary mixtures of n-octacosane (n-C28H58) with carbon monoxide (CO), hydrogen (H2), and water (H2O) are simultaneously accessible by dynamic light scattering (DLS). As the light-scattering signals originating from thermal and concentration fluctuations appear in similar time scales, different data evaluation strategies were tested to achieve minimum uncertainties in the resulting transport properties. To test the agreement of the respective theoretical model with the DLS signals in the regression, an improved multifit procedure is introduced. With the selected data evaluation strategy, uncertainties of 4 to 15% and 4 to 30% in the thermal and mutual diffusivities, respectively, could be obtained for the binary mixtures. The mutual diffusivities for the mixtures measured at temperatures ranging from 398 to 523 K and pressures of 5 to 30 bar at saturation conditions are in good agreement with molecular dynamics simulations and data from the literature.