Physico-chemical properties of quartz from industrial manufacturing and its cytotoxic effects on alveolar macrophages: The case of green sand mould casting for iron production.

Industrial processing of materials containing quartz induces physico-chemical modifications that contribute to the variability of quartz hazard in different plants. Here, modifications affecting a quartz-rich sand during cast iron production, have been investigated. Composition, morphology, presence of radicals associated to quartz and reactivity in free radical generation were studied on a raw sand and on a dust recovered after mould dismantling. Additionally, cytotoxicity of the processed dust and ROS and NO generation were evaluated on MH-S macrophages. Particle morphology and size were marginally affected by casting processing, which caused only a slight increase of the amount of respirable fraction. The raw sand was able to catalyze OH and CO2(-) generation in cell-free test, even if in a lesser extent than the reference quartz (Min-U-Sil), and shows hAl radicals, conventionally found in any quartz-bearing raw materials. Enrichment in iron and extensive coverage with amorphous carbon were observed during processing. They likely contributed, respectively, to increasing the ability of processed dust to release CO2- and to suppressing OH generation respect to the raw sand. Carbon coverage and repeated thermal treatments during industrial processing also caused annealing of radiogenic hAl defects. Finally, no cellular responses were observed with the respirable fraction of the processed powder.

Effects of clopidogrel on horses with experimentally induced endotoxemia.

OBJECTIVE: To evaluate the effects of clopidogrel on clinical and clinicopathologic variables in healthy horses with experimentally induced endotoxemia. ANIMALS: 12 adult mares. Procedures-Horses were assigned with a randomization procedure to receive clopidogrel (4 mg/kg, once, then 2 mg/kg, q 24 h; n = 6) or a placebo (6) through a nasogastric tube. After 72 hours of treatment, horses received lipopolysaccharide (LPS; 30 ng/kg, IV). Heart rate, respiratory rate, rectal temperature, CBC variables, plasma fibrinogen concentration, serum tumor necrosis factor-α concentration, plasma von Willebrand factor concentration, and measures of platelet activation (including ADP- and collagen-induced platelet aggregation and closure times, thrombelastography variables, and results of flow cytometric detection of platelet membrane P-selectin, phosphatidylserine, and microparticles) were determined at various times before and after LPS administration by investigators unaware of the treatment groups. Statistical analyses were performed with repeated-measures ANOVA. RESULTS: 4 of 6 clopidogrel-treated horses had significant decreases in ADP-induced platelet aggregation before and after LPS administration. Heart rate increased significantly after LPS administration only for the placebo group. No significant differences were detected between groups for CBC variables, closure time, and plasma concentration of fibrinogen or serum concentration of tumor necrosis factor-α, and no clinically relevant differences were detected for other hemostatic variables. CONCLUSIONS AND CLINICAL RELEVANCE: In this study, administration of LPS did not induce platelet hyperreactivity in horses on the basis of measures of platelet adhesion, aggregation, degranulation, and procoagulant activity. Administration of clopidogrel was associated with variable platelet antiaggregatory activity and attenuated some clinical signs of endotoxemia.

Imogolite: an aluminosilicate nanotube endowed with low cytotoxicity and genotoxicity.

High-aspect-ratio nanomaterials (HARN) (typically, single-walled carbon nanotubes (SWCNT) or multiwalled carbon nanotubes (MWCNT)) impair airway barrier function and are toxic to macrophages. Here, we assess the biological effects of nanotubes of imogolite (INT), a hydrated alumino-silicate [(OH)3Al2O3SiOH] occurring as single-walled NT, on murine macrophages and human airway epithelial cells. Cell viability was assessed with resazurin. RT-PCR was used to study the expression of Nos2 and Arg1, markers of classical or alternative macrophage activation, respectively, and nitrite concentration in the medium was determined to assess NO production. Epithelial barrier integrity was evaluated from the trans-epithelial electrical resistance (TEER). Potential genotoxicity of INT was assessed with comet and cytokinesis-block micronucleus cytome assays. Compared to MWCNT and SWCNT, INT caused much smaller effects on RAW264.7 and MH-S macrophage viability. The incubation of macrophages with INT at doses as high as 120 µg/cm(2) for 72 h did not alter either Nos2 or Arg1 expression nor did it increase NO production, whereas IL6 was induced in RAW264.7 cells but not in MH-S cells. INT did not show any genotoxic effect in RAW264.7 and A549 cells except for a decrease in DNA integrity observed in epithelial A549 cells after treatment with the highest dose (80 µg/cm(2)). No significant change in permeability was recorded in Calu-3 epithelial cell monolayers exposed to INT, whereas comparable doses of both SWCNT and MWCNT lowered TEER. Thus, in spite of their fibrous nature, INT appear not to be markedly toxic for in vitro models of lung-blood barrier cells.

Effects of clopidogrel on the platelet activation response in horses.

OBJECTIVE: To evaluate the platelet activation response before and after treatment with clopidogrel in horses. ANIMALS: 12 healthy adult mares. PROCEDURES: In a masked study, horses (6/group) were randomly allocated to alternately receive placebo or clopidogrel via nasogastric tube at a loading dose of 4 mg/kg followed by 2 mg/kg every 24 hours. Blood samples were collected before and 72 hours after initiation of treatment for ADP- and collagen-induced light transmission aggregometry; determination of closure time in collagen-ADP cartridges; modified thrombelastography for comparison of maximal amplitudes generated by kaolin, reptilase, and reptilase plus ADP activation; and flow cytometric tests to detect platelet fibrinogen binding, P-selectin expression, and phosphatidylserine externalization before and after ex vivo stimulation with thrombin, convulxin, thrombin with convulxin, and calcium ionophore. RESULTS: Clopidogrel administration induced a significant decrease in mean aggregation response to 5 µM and 10 µM ADP stimulation; however, 2 horses had resistance to clopidogrel's inhibitory action. Significant differences after clopidogrel treatment were not found in any other tests of platelet function. CONCLUSIONS AND CLINICAL RELEVANCE: Assays using commercially available reagents were configured to measure different variables of the platelet activation response; however, clopidogrel's platelet inhibitory action was only detected by ADP-induced light transmission aggregometry. Results also suggested that horses, like humans, have interindividual variability in response to clopidogrel that may influence the drug's clinical efficacy as an antiplatelet agent.

Carbon in intimate contact with quartz reduces the biological activity of crystalline silica dusts.

To evaluate the effect of carbonaceous materials on the pathogenic activity of quartz dusts, mixtures of carbon soot (1 and 10%) and quartz (Min-U-Sil) were prepared and then milled so to attain an intimate association of carbon and the quartz surface. Both cellular and cell-free tests show that carbon associated to quartz completely inhibits the typical free radical generation of quartz dusts (through Fenton activity and homolytic cleavage of a C-H bond) and suppresses the oxidative stress and inflammation induced by quartz alone on MH-S murine macrophage cells (lipid peroxidation, nitric oxide release, and tumor necrosis factor-α synthesis). The cytotoxic response to quartz is also largely reduced. An extremely pure quartz milled with 10% of soot showed inactivating effects on the adverse reactions to quartz similar to Min-U-Sil quartz. None of these effects takes place when the same experiments are carried out with mechanically mixed samples, which suggests that carbon acts not just as a radical quencher but because of its association to the quartz surface.

Hematite nanoparticles larger than 90 nm show no sign of toxicity in terms of lactate dehydrogenase release, nitric oxide generation, apoptosis, and comet assay in murine alveolar macrophages and human lung epithelial cells.

Three hematite samples were synthesized by precipitation from a FeCl3 solution under controlled pH and temperature conditions in different morphology and dimensions: (i) microsized (average diameter 1.2 µm); (ii) submicrosized (250 nm); and (iii) nanosized (90 nm). To gain insight into reactions potentially occurring in vivo at the particle-lung interface following dust inhalation, several physicochemical features relevant to pathogenicity were measured (free radical generation in cell-free tests, metal release, and antioxidant depletion), and cellular toxicity assays on human lung epithelial cells (A549) and murine alveolar macrophages (MH-S) were carried out (LDH release, apoptosis detection, DNA damage, and nitric oxide synthesis). The decrease in particles size, from 1.2 µm to 90 nm, only caused a slight increase in structural defects (disorder of the hematite phase and the presence of surface ferrous ions) without enhancing surface reactivity or cellular responses in the concentration range between 20 and 100 µg cm⁻².

Thickness of multiwalled carbon nanotubes affects their lung toxicity.

Two samples of highly pure multiwalled carbon nanotubes (MWCNTs) similar in hydrophobicity and surface reactivity were prepared with similar length, <5 µm, but markedly different diameter (9.4 vs 70 nm). The samples were compared for their cytotoxic activity, uptake, and ability to induce oxidative stress (ROS production and intracellular GSH depletion) in vitro in murine alveolar macrophages (MH-S). The in vivo toxicity was evaluated by measuring biochemical (LDH activity and total proteins) and cellular responses in bronchoalveolar lavage (BAL) after intratracheal instillation in rats. Both samples were internalized in MH-S cells. However, thin MWCNTs appeared significantly more toxic than the thicker ones, both in vitro and in vivo, when compared on a mass-dose basis. The data reported herein suggest that the nanotube diameter is an important parameter to be considered in the toxicological assessment of CNTs.

Does vitreous silica contradict the toxicity of the crystalline silica paradigm?

"Vitreous silica" is a particular form of amorphous silica, much neglected in experimental studies on silica toxicity. In spite of the incorrect term "quartz glass", often employed, this material is fully amorphous. When reduced in powdered form by grinding, the particulate appears most close to workplace quartz dust but, opposite to quartz, is not crystalline. As silicosis and lung cancer are also found among workers exposed to "quartz glass", the question arises of whether crystallinity is the prerequisite feature that makes a silica dust toxic. We compare here the behavior of comminuted quartz, vitreous silica, and monodispersed silica spheres, as it concerns surface reactivity and cellular responses involved in the accepted mechanisms of silica toxicity. Care was taken to choose samples of extreme purity, to avoid any effect due to trace contaminants. Quartz and vitreous silica, opposite to silica spheres, show irregular particles with sharp edges, stable surface radicals, and sustained release of HO(*) radicals via a Fenton-like mechanism. The evolution of the heat of adsorption of water as a function of coverage shows with quartz and vitreous silica a similar pattern of strong hydrophilic sites, nearly absent on the other silica specimen. When tested on a macrophage cell line (MH-S), vitreous silica and pure quartz, but not the monodispersed silica spheres, showed a remarkable potency in cytotoxicity, nitric oxide synthase activation and release of nitrite, and tumor necrosis factor-alpha production, suggesting a common behavior in inducing an oxidative stress. All of the above features appear to indicate that crystallinity might not be a necessary prerequisite to make a silica particle toxic.

Formation of a vitreous phase at the surface of some commercial diatomaceous earth prevents the onset of oxidative stress effects.

To understand the effect of the commercial processing of diatomaceous earths (DEs) on their ultimate surface structure and potential toxicity, we investigated the influence of the industrial processing and the nature of the deposit. Two flux calcined specimens from different deposits, DE/1-FC and DE/2-FC, and the simply calcined sample DE/1-C, from the same deposit as DE/1-FC, were compared in both their bulk and their surface properties. X-ray diffraction (XRD) analysis in a heating chamber revealed the presence of cristobalite in all samples, more abundant on the flux calcined ones. The crystal lattice is probably imperfect, as the alpha-beta transition, visible by XRD in DE/1-FC and DE/2-FC, is not detected by differential scanning calorimetry. Progressive etching with HF solutions suggests that most of the crystalline phase is at the core and not at the outer region of the samples. The combined use of spectroscopic (UV-vis and IR) and calorimetric techniques (heat of adsorption of water as a measure of hydrophilicity) reveals that DE/1-FC and DE/2-FC particles have an external layer of glass, absent in DE/1-C, where iron impurities act as network-forming and sodium ions as modifier species, with few patches of a hydrophobic phase, the latter relatable to a heated pure silica phase. When tested on a macrophage cell line (MH-S) in comparison with appropriate positive and negative controls (an active and an inactive quartz dust, respectively), only DE/1-C exhibited a cell damage and activation similar to that of active quartz (measured by lactate dehydrogenase release, peroxidation of membrane lipids and synthesis of NO). It is likely that the presence of a vitreous phase mitigates or even eliminates the cellular responses of silica in DE.

The oxidation of glutathione by cobalt/tungsten carbide contributes to hard metal-induced oxidative stress.

The occupational exposure to cobalt/tungsten carbide (Co/WC) dusts causes asthma and interstitial fibrosis. The International Agency for Research on Cancer (IARC) recently classified the mixture Co/WC as probably carcinogenic to humans (group 2A). The mechanism of action of Co/WC involves particle driven generation of Reactive Oxygen Species (ROS) with consequent oxidative damage. The present study evaluates the reactivity of Co/WC dust toward glutathione (GSH) and cysteine (Cys). Co/WC oxidized thiols through a mechanism involving the generation of sulphur-centred radicals. The results are consistent with the oxidation taking place at surface active sites, a part of which is accessible only to Cys S-H groups, but not to GSH ones. Such a reaction, with consequent irreversible depletion of antioxidant defenses of cells, will potentiate the oxidative stress caused by particle and cell generated ROS.

Quartz inhibits glucose 6-phosphate dehydrogenase in murine alveolar macrophages.

Crystalline silica is well-known to induce oxidative stress as a consequence of both surface-derived generation of free radicals and intracellular production of reactive oxygen species upon phagocytosis; the mechanism of the latter is still partially unknown. In this study, we report that in murine alveolar MH-S macrophages, a 24 h incubation with quartz particles (80 microg/cm(2)) inhibits the glucose 6-phosphate dehydrogenase (G6PD) (1) activity by 70% and the pentose phosphate pathway by 30%. Such effects are accompanied by a 50% decrease of intracellular glutathione, a 35% increase of thiobarbituric acid reactive products (index of lipoperoxidation), and a 5-fold increase of leakage of lactate dehydrogenase in the extracellular medium (index of cytotoxicity). Quartz inhibits G6PD but not other oxidoreductases, and such inhibition is fully prevented by glutathione, suggesting that silica exerts on G6PD an oxidative damage. Our data provide a new additional mechanism by which silica may induce oxidative stress, that is, by inhibiting the pentose phosphate pathway, one of the main antioxidant metabolic pathways of the cell.

Endocytosis, oxidative stress and IL-8 expression in human lung epithelial cells upon treatment with fine and ultrafine TiO2: role of the specific surface area and of surface methylation of the particles.

Inhaled ultrafine particles show considerably stronger pulmonary inflammatory effects when tested at equal mass dose with their fine counterparts. However, the responsible mechanisms are not yet fully understood. We investigated the role of particle size and surface chemistry in initiating pro-inflammatory effects in vitro in A549 human lung epithelial cells on treatment with different model TiO(2) particles. Two samples of TiO(2), i.e. fine (40-300 nm) and ultrafine (20-80 nm) were tested in their native forms as well as upon surface methylation, as was confirmed by Fourier transformed infrared spectroscopy. Radical generation during cell treatment was determined by electron paramagnetic resonance with 5,5-dimethyl-1-pyrroline-N-oxide or 4-hydroxy-2,2,6,6-tetramethylpiperidine-1-oxyl. Interleukin-8 mRNA expression/release was determined by RT-PCR and ELISA, whereas particle uptake was evaluated by transmission electron microscopy. TiO(2) particles were rapidly taken up by the cells, generally as membrane bound aggregates and large intracellular aggregates in vesicles, vacuoles and lamellar bodies. Aggregate size tended to be smaller for the ultrafine samples and was also smaller for methylated fine TiO(2) when compared to non-methylated fine TiO(2). No particles were observed inside nuclei or any other vital organelle. Both ultrafine TiO(2) samples but not their fine counterparts elicited significantly stronger oxidant generation and IL-8 release, despite their aggregation state and irrespective of their methylation. The present data indicate that ultrafine TiO(2), even as aggregates/agglomerates, can trigger inflammatory responses that appear to be driven by their large surface area. Furthermore, our results indicate that these effects result from oxidants generated during particle-cell interactions through a yet to be elucidated mechanism(s).

Reaction of cysteine and glutathione (GSH) at the freshly fractured quartz surface: a possible role in silica-related diseases?

The reactivity of quartz dusts towards glutathione (GSH) and cysteine (Cys) has been investigated. Cys and GSH react, without being adsorbed (UV-Vis spectroscopy), with commercial quartz dusts in an exposed surface-dependent way, but not with amorphous silica. GSH and Cys have been contacted with freshly ground quartz (agate jar QZg-a and steel jar QZg-s) and quartz heated in air at 500 degrees C (QZs-500) and with a dust generated from a purified quartz (99.9999%) to detect the nature of the reacting surface sites. With both GSH and Cys, the highest reactivity was found on the particles ground in a steel jar, while pure quartz was fully inactive. Detection of the radical GS* (spin trapping) suggests a radical mechanism of oxidation to disulphide onto surface-bound iron traces, more abundant on QZg-s and absent on the pure quartz. Oxidation of thiol groups occurs at surface sites different from those involved in the homolytic rupture of a C-H bond. Both reactions are more pronounced on freshly ground samples, but the C-H rupture takes place at silicon-based surface radicals and Fe2+ centers, while oxidation of GSH and Cys requires Fe3+ centers. As all commercial quartz dusts contain surface iron as an impurity, depletion of extracellular or intracellular GSH may contribute to the oxidative damage caused by particle-derived and cell-derived reactive oxygen species.

Concurrent abomasal displacement and perforating ulceration in cattle: 21 cases (1985-1996).

OBJECTIVE: To evaluate the association of physical examination and clinicopathologic findings with surgical findings in cattle with concurrent abomasal displacement and perforating ulceration, to determine short- and long-term survival rates in these cattle, and to determine whether degree of peritonitis (focal vs diffuse) influences survival rates. DESIGN: Retrospective study. ANIMALS: 21 cattle with concurrent abomasal displacement and perforating ulceration and 42 cattle with uncomplicated abomasal displacement. PROCEDURE: Information on signalment, stage of lactation, physical examination findings, clinicopathologic data, surgical diagnosis, procedure(s) performed, and necropsy findings were retrieved from medical records of all cattle included in this study. Differences between physical examination findings of cattle with concurrent disease and those of cattle with uncomplicated displacements were evaluated, as were differences between survival rates in cattle with focal versus diffuse peritonitis. RESULTS: Cattle with concurrent disease had a greater probability of having pneumoperitoneum and signs of abdominal pain identified on physical examination than did cattle with uncomplicated diseases. There was no relationship between clinicopathologic data and survival time. Short-term survival rate was 38%, and degree of peritonitis significantly influenced survival time in cattle with concurrent abomasal displacement and perforating ulceration. Long-term survival rate in these cattle was 14%. CLINICAL IMPLICATIONS: Cattle with concurrent displaced abomasum and perforating ulceration have a poor chance for survival. In addition to detection of displaced abomasum, physical examination findings that can help lead to a presurgical diagnosis of this syndrome are pneumoperitoneum and signs of abdominal pain.

Effects of human FLT3 ligand on myeloid leukemia cell growth: heterogeneity in response and synergy with other hematopoietic growth factors.

A novel hematopoietic growth factor for primitive hematopoietic progenitor cells, the ligand for the flt3/flk2 receptor, (FL), has been recently purified and its gene has been cloned. In the present study, we investigated the effects of FL on the proliferation and differentiation of normal and leukemic myeloid progenitor cells. We demonstrate that FL is a potent stimulator of the in vitro growth of granulocyte-macrophage colony-stimulating factor (GM-CSF), interleukin-3 (IL-3), or G-CSF-dependent granulocyte-macrophage committed precursors from Lin- CD34+ bone marrow cells of normal donors. By contrast, FL does not affect the growth of erythroid-committed progenitors even in the presence of erythropoietin. The effect of FL on the proliferation and on the in vitro growth of clonogenic leukemic precursor cells was studied in 54 acute myeloid leukemia (AML) cases. Fresh leukemia blasts from 36 of 45 patients with AML significantly responded to FL without any relation to the French-American-British (FAB) subtype. FL stimulated the proliferation of leukemic blasts in a dose-dependent fashion. Synergistic activities were seen when FL was combined with G-CSF, GM-CSF, IL-3, or stem cell factor (SCF). FL as a single factor induced or increased significantly colony formation by clonogenic precursor cells from 21 of 24 patients with AML. In the presence of suboptimal and optimal concentrations of G-CSF, GM-CSF, IL3, SCF, or a combination of all factors, FL strongly enhanced the number of leukemic colonies (up to 18-fold). We also evaluated the induction of tyrosine phosphorylated protein on FL stimulation in fresh AML cells. We demonstrate that, on FL stimulation, a band of phosphorylated protein(s) of about 90 kD can be detected in FL-responsive, but not in FL-unresponsive cases. This study suggests that FL may be an important factor for the growth of myeloid leukemia cells, either as a direct stimulus or as a synergistic factor with other cytokines.

Interleukin-3 in vivo: kinetic of response of target cells.

Human recombinant interleukin-3 (IL-3; Sandoz AG, Basel, Switzerland) was administered for 7 days to patients with neoplastic disease and normal hematopoiesis. The purpose of the study was to assess IL-3 toxicity, to identify target cells, to define their kinetics of response at different dose levels, and to determine if IL-3 in vivo increased the sensitivity of bone marrow (BM) progenitors to the action of other hematopoietic growth factors. A total of 21 patients entered the study; the dosage ranged from 0.25 to 10 micrograms/kg/d. The effect on peripheral blood cells during treatment showed no significant changes in the number of platelets, erythrocytes, neutrophils, or lymphocytes (and their subsets). A mild monocytosis and basophilia occurred. Eosinopenia, present in the first hours of treatment, was followed by a dose-and time-dependent eosinophilia. IL-3 treatment affected BM cell proliferation by increasing the percentage of BM progenitors engaged in the S-phase of the cell cycle. The effect was dose dependent, with the various progenitors showing different degrees of sensitivity. The most sensitive progenitors were the megakaryocyte progenitors (colony-forming unit-megakaryocyte), then the erythroid progenitors (burst-forming unit-erythroid), and finally the granulo-monocyte progenitors (colony-forming unit-granulocyte-macrophage) whose proliferative activity was stimulated at the higher doses of IL-3. Only a slight increase in the proliferative activity of myeloblasts, promyelocytes, and myelocytes was observed, whereas the activity of erythroblasts was unchanged. The priming effect was such that BM progenitors, purified from patients treated with IL-3, produced more colonies in vitro in the presence of granulocyte colony-stimulating factor (G-CSF; granulocyte colonies), IL-5 (eosinophil colonies), and granulocyte-macrophage CSF (GM-CSF; predominantly eosinophil colonies). These data indicate that even in vivo IL-3 acts essentially as a primer for the action of other cytokines. Therefore, optimum stimulus of myelopoiesis will require either endogenous or exogenous late-acting cytokines such as G-CSF, erythropoietin, GM-CSF, and IL-6 for achieving fully mature cells in peripheral blood. If exogenous cytokines are used with IL-3, it is likely that G-CSF will yield more neutrophils, whereas GM-CSF may enhance eosinophils, monocytes, and neutrophils. Attention to the clinical relevance of each cell type will be necessary and should determine the selection of the combination of cytokines.