Factors influencing fumonisin B1 contamination in maize: insights from two production regions in Costa Rica.

Maize (Zea mays L.) is an important cereal crop worldwide. Contaminated maize kernels pose a significant mycotoxin exposure risk for humans in Latin America. Fumonisins, the most prevalent mycotoxin in maize, typically occur during pre-harvest conditions leading to significant economic losses. Various factors, including weather conditions, may influence this contamination. This study aimed to determine the association between fumonisin B1 (FB1) contamination, prevalence of Fusarium verticillioides, weather conditions and kernel quality in the two primary maize production areas in Costa Rica (Brunca and Chorotega). All maize samples (100%) showed FB1 contamination, with higher concentrations in samples from Brunca region, consistent with the presence of F. verticilliodes. Weather conditions appeared to play an important role in this contamination, since Brunca region had the highest mean temperature and relative humidity after maize silking (R1) and the total monthly rainfall in this region was significantly higher during the last two months of maize cultivation (grain-filling and physiological maturity stages R3 to R6). Interestingly, this study found a negative correlation between grain damage and kernel contamination with FB1 and F. verticillioides. The concentration of mineral nutrients in kernels from both regions was largely similar. Most nutrients in kernels exhibited a negative correlation with FB1, particularly nitrogen. Zinc and phosphorus were the only nutrients in kernels showing a positive correlation with FB1 in samples from the Brunca region. The results highlight elevated levels of FB1 contamination in maize and contribute to a better understanding of pre-harvest factors influencing FB1 contamination in tropical conditions.

Mycotoxin Exposure in Children through Breakfast Cereal Consumption in Chile.

Mycotoxins are unavoidable contaminants produced by fungi in food, especially grains. This study aimed to measure the occurrence and levels of total aflatoxins (AFs); ochratoxin A (OTA); zearalenone (ZEN); fumonisins B1, B2, and B3 (FUM); deoxynivalenol (DON); and T-2/HT-2 toxins in the four most commonly consumed breakfast cereals in Chile and to assess mycotoxin exposure and risk in children aged 2 to 13 years due to cereal consumption. In this study, a total of 110 batches with three subsamples of the four brands were sampled in supermarkets from November 2019 to June 2021. Samples were analyzed by Veratox® ELISA (Neogen). Exposure was assessed by estimated daily intake (EDI) considering the levels found in a modified lower bound (mLB) and upper bound (UB). Risk was estimated by margin of exposure (MOE) in the case of OTA and AFs and hazard quotient (HQ) for the rest of the mycotoxins. No T2/HT2 toxins were detected. Few samples had quantifiable levels of ZEN, FUM, and DON except for brand 1, with a mean (standard deviation, SD) of 54 (20), 1552 (351), and 706 (218) ng/g, respectively. In addition, three FUM samples and one DON sample had values over the Chilean regulation. Brands 2, 3, and 4 had quantifiable levels of AFs, with mean (SD) values of 1.3 (0.1), 2.1 (0.6), and 1.9 (0.4) ng/g, respectively. Brand 3 had quantifiable levels of OTA, with a mean (SD) of 2.3 (0.4) ng/g. Estimated exposure indicated a risk of AFs in all scenarios, and of FUM for brand 1 consumption, OTA and DON for brand 3 consumption, and OTA for brand 4 consumption in the mLB worst-case scenario. In general, mycotoxin levels were below the Chilean regulatory limits, but most of them were above the EU regulation for processed cereal-based food in young children. Because the risk was higher in the 2- to 5-year-old children, we recommend special regulations for this group in Chile.

Prediction of fumonisins B1 and B2 in corn distiller's dried grains with solubles through near-infrared reflectance spectroscopy.

BACKGROUND: Distiller's dried grains with solubles (DDGS) are coproducts of the biofuel industries that use corn as raw material. This cereal is commonly contaminated by mycotoxins, including fumonisins (FBs), which can pose a serious health threat to humans and animals. Corn DDGS are typically used as a protein-rich animal feed. As mycotoxins from the original cereal grains become concentrated in DDGS, mycotoxicological monitoring is highly required before their use as ingredient in the industry. RESULTS: This work aimed to develop a methodology for predicting fumonisins B1 (FB1 ) and B2 (FB2 ) in corn DDGS using near-infrared reflectance spectroscopy (NIRS) technology associated with chemometric methods. One hundred and ninety corn DDGS samples originating from Brazilian ethanol plants and feed mills were included in this assessment. Two datasets were created: one for calibration (132 samples) and another for external validation (58 samples). Partial least squares regression and a cross-validation approach were applied to build the models. Liquid chromatography coupled to tandem mass spectrometry was used as the reference methodology. Calibration results of correlation coefficient and residual prediction deviation for FB1 and FB2 were, respectively, 0.90 and 0.88; and 2.16 and 2.06. CONCLUSION: Values of the external validation dataset were compared and no statistical difference was found between groups, indicating a satisfactory predictive ability and confirming the potential of NIRS to predict fumonisins in corn DDGS. © 2022 Society of Chemical Industry.

Fumonisin-containing diets decrease the metabolic activity of myenteric neurons in rats.

Fumonisins are naturally occurring mycotoxins that contaminate food for human and animal consumption. They have neurotoxic effects, but the mechanisms by which these toxins affect the nervous system are not fully known. In the present study, male Wistar rats were fed between 21 and 63 days of age with diets that contained fumonisins B1+B2 at 0, 1, and 4 mg/kg. The following variables were assessed: food consumption, growth, body weight gain, and blood parameters. Morphoquantitave analyses of the most metabolically active myenteric neurons were performed, detected by NADH-diaphorase activity. Nitrergic neurons were detected by NADPH-diaphorase activity. The fumonisin-containing diets did not significantly alter food consumption or the body or plasma parameters. These diets decreased the metabolic activity of jejunal myenteric neurons, reducing neuronal density of the most metabolic active neurons by 30.8% and the cell body area by 4.3%. The diets also decreased the cell body area of nitrergic neurons by 22.1%. The effects of fumonisin B1 on the respiratory metabolism of isolated mitochondria in the brain and liver were also assessed. A decrease in oxygen consumption up to a 29% in the brain and 38% in the liver was observed in mitochondrial isolates to which 50 µM fumonisin B1 was added. The decrease in respiratory activity that was triggered by exposure to fumonisins was related to the lower metabolic activity of myenteric neurons, which had a negative impact on neuroplasticity of the enteric nervous system.

Carbon sources to enhance the biosynthesis of useful secondary metabolites in Fusarium verticillioides submerged cultures.

Fusarium verticillioides is a prolific producer of useful secondary metabolites such as naphthoquinone pigments, monoterpenes, and sesquiterpenes, as well as the harmful mycotoxins fumonisins. A strategy to increase their production includes creating a proper nutritional environment that enables the fungus to produce the compounds of interest. The aim of the present work was to study the effect of different carbon sources (glucose, fructose, xylose, sucrose, and lactose) on secondary metabolites biosynthesis in F. verticillioides submerged cultures. The production of volatile terpenes was evaluated through gas chromatography coupled to mass spectrometry. The quantification and identification of pigments was conducted using a UV/VIS spectrophotometer and NMR spectrometer, respectively. The quantification of fumonisin B1 and fumonisin B2 was performed by high-performance liquid chromatography. Our results showed that the biosynthesis of naphthoquinone pigments, monoterpenes, and sesquiterpenes was highest in cultures with fructose (13.00 ± 0.71 mmol/g), lactose [564.52 × 10-11 ± 11.50 × 10-11 µg/g dry weight (DW)], and xylose (54.41 × 10-11 ± 1.55 × 10-11 µg/g DW), respectively, with fumonisin being absent or present in trace amounts in the presence of these carbon sources. The highest biosynthesis of fumonisins occurred in sucrose-containing medium (fumonisin B1: 7.85 × 103 ± 0.25 × 103 µg/g DW and fumonisin B2: 0.38 × 103 ± 0.03 × 103 µg/g DW). These results are encouraging since we were able to enhance the production of useful fungal metabolites without co-production with harmful mycotoxins by controlling the carbon source provided in the culture medium.

Natural Occurrence of Mycotoxin-Producing Fusaria in Market-Bought Peruvian Cereals: A Food Safety Threat for Andean Populations.

Consumption of cereals contaminated by mycotoxins poses health risks. For instance, Fumonisins B, mainly produced by Fusarium verticillioides and Fusariumproliferatum, and the type B trichothecene deoxynivalenol, typically produced by Fusarium graminearum, are highly prevalent on cereal grains that are staples of many cultural diets and known to represent a toxic risk hazard. In Peru, corn and other cereals are frequently consumed on a daily basis under various forms, the majority of food grains being sold through traditional markets for direct consumption. Here, we surveyed mycotoxin contents of market-bought grain samples in order to assess the threat these mycotoxins might represent to Peruvian population, with a focus on corn. We found that nearly one sample of Peruvian corn out of six was contaminated with very high levels of Fumonisins, levels mostly ascribed to the presence of F. verticillioides. Extensive profiling of Peruvian corn kernels for fungal contaminants could provide elements to refine the potential risk associated with Fusarium toxins and help define adapted food safety standards.

Effect of fungicides commonly used for Fusarium head blight management on growth and fumonisin production by Fusarium proliferatum.

Fumonisin occurrence was reported in wheat grains and F. proliferatum has been suggested to be the main contributor to its presence in wheat. Thus, a survey was performed in order to study the impact of four commercial fungicides used in Argentina for controlling Fusarium head blight disease (epoxiconazole+metconazole, tebuconazole, pyraclostrobin+epoxiconazole, and prothioconazole) on growth and fumonisin production of two F. proliferatum strains in relation to water activity (aW; 0.99, 0.97, 0.95) and temperature (15°C and 25°C). Most fungicides reduced growth rates when compared to the control (reduction increased as fungicide concentration increased), and reduced fumonisin production when they were used at high doses; however, most fungicides enhanced fumonisin production at sublethal doses, with the exception of prothioconazole. Thus, fungicides used for FHB management could enhance fumonisin production by F. proliferatum strains present in wheat grains.

Occurrence and Probabilistic Risk Assessment of Fumonisin B1, Fumonisin B2 and Deoxynivalenol in Nixtamalized Maize in Mexico City.

Fumonisins (FB1+FB2) and deoxynivalenol (DON) are mycotoxins produced by Fusarium species that might be present in maize and maize products. Knowledge on their occurrence in nixtamalized maize from Mexico together with an accompanying risk assessment are scarce, while nixtamalized maize is an important food in Mexico. This study presents the occurrence of FB1 + FB2 and DON in nixtamalized maize samples collected in Mexico City and analyses their distribution and resulting estimated daily intake for Mexican consumers by a probabilistic approach using a two-dimensional Monte-Carlo simulation. The results obtained reveal that for FB1 + FB2, 47% of the Mexican men and 30% of the Mexican women might exceed the provisional tolerable daily intake (PMTDI) of 2 µg/kg bw/day for fumonisins and for DON, 9% of men and 5% of women would be exceeding the PMTDI of 1 µg/kg bw/day, corresponding to the high consumers. The results raise a flag for risk managers in Mexico, to consider regulations and interventions that lower mycotoxin levels in nixtamalized maize for human consumption.

The Role of Fumonisins in the Biological Interaction between Fusarium verticillioides and Sitophilus zeamais.

The aim of the current study was to investigate the entomopathogenic capacity of the mold Fusarium verticillioides and the effect of its mycotoxins fumonisins, on the grain beetle Sitophilus zeamais. We evaluated the capacity of this fungus to infect live insects, the antifungal activity of constituents of the insect's epicuticle, and the effect of a fumonisin extract on the fitness of the insects. We found that F. verticillioides could not penetrate the cuticle of S. zeamais and that the fumonisin extract had no negative effects on the fitness of the insects. However, the progeny of the insects increased, and the fumonisin extract had repellent effects. This is the first report about the effects of fumonisins on the relationship between F. verticillioides and S. zeamais, which may provide useful information about interactions between pathogenic microorganisms and insects, especially on stored product pests.

Fumonisin and Beauvericin Chemotypes and Genotypes of the Sister Species Fusarium subglutinans and Fusarium temperatum.

Fusarium subglutinans and Fusarium temperatum are common maize pathogens that produce mycotoxins and cause plant disease. The ability of these species to produce beauvericin and fumonisin mycotoxins is not settled, as reports of toxin production are not concordant. Our objective was to clarify this situation by determining both the chemotypes and genotypes for strains from both species. We analyzed 25 strains from Argentina, 13 F. subglutinans and 12 F. temperatum strains, for toxin production by ultraperformance liquid chromatography mass spectrometry (UPLC-MS). We used new genome sequences from two strains of F. subglutinans and one strain of F. temperatum, plus genomes of other Fusarium species, to determine the presence of functional gene clusters for the synthesis of these toxins. None of the strains examined from either species produced fumonisins. These strains also lack Fum biosynthetic genes but retain homologs of some genes that flank the Fum cluster in Fusarium verticillioides None of the F. subglutinans strains we examined produced beauvericin although 9 of 12 F. temperatum strains did. A complete beauvericin (Bea) gene cluster was present in all three new genome sequences. The Bea1 gene was presumably functional in F. temperatum but was not functional in F. subglutinans due to a large insertion and multiple mutations that resulted in premature stop codons. The accumulation of only a few mutations expected to disrupt Bea1 suggests that the process of its inactivation is relatively recent. Thus, none of the strains of F. subglutinans or F. temperatum we examined produce fumonisins, and the strains of F. subglutinans examined also cannot produce beauvericin. Variation in the ability of strains of F. temperatum to produce beauvericin requires further study and could reflect the recent shared ancestry of these two species.IMPORTANCEFusarium subglutinans and F. temperatum are sister species and maize pathogens commonly isolated worldwide that can produce several mycotoxins and cause seedling disease, stalk rot, and ear rot. The ability of these species to produce beauvericin and fumonisin mycotoxins is not settled, as reports of toxin production are not concordant at the species level. Our results are consistent with previous reports that strains of F. subglutinans produce neither fumonisins nor beauvericin. The status of toxin production by F. temperatum needs further work. Our strains of F. temperatum did not produce fumonisins, while some strains produced beauvericin and others did not. These results enable more accurate risk assessments of potential mycotoxin contamination if strains of these species are present. The nature of the genetic inactivation of BEA1 is consistent with its relatively recent occurrence and the close phylogenetic relationship of the two sister species.

Mycotoxin-contaminated diets and an adsorbent affect the performance of Nellore bulls finished in feedlots.

Mycotoxins are present in almost all feedstuffs used in animal nutrition but are often ignored in beef cattle systems, even though they can affect animal performance. The objective of this study was to evaluate the effects of mycotoxins and a mycotoxin adsorbent (ADS) on performance of Nellore cattle finished in a feedlot. One hundred Nellore cattle (430 ± 13 kg) were used in a randomized complete block design with a 2 × 2 factorial arrangement of treatments. The factors consisted of two diets with either natural contamination (NC) or exogenous contamination (EC) and the presence (1 g/kg of DM; ADS) or absence of a mycotoxin adsorbent. The NC and EC diets had the following contaminations, respectively: 0.00 and 10.0 µg/kg aflatoxins, 5114 and 5754 µg/kg fumonisins, 0.00 and 42.1 µg/kg trichothecenes B, 0.00 and 22.1 µg/kg trichothecenes A and 42.9 and 42.9 µg/kg fusaric acid. At the beginning of the experiment, all animals were weighed, and four randomly selected animals were slaughtered to evaluate the initial carcass weight. After 97 days of treatment, all animals were weighed and slaughtered. There was no interaction among factors for the DM intake (DMI; P = 0.92); however, there was a tendency for the EC diets to decrease the DMI by 650 g/day compared to animals fed NC diets (P = 0.09). There was a trend for interaction among factors (P = 0.08) for the average daily gain (ADG), where the greatest ADG was observed for cattle fed the NC diet (1.77 kg), and the lowest was observed for those fed the EC diet (1.51 kg). The NC + ADS and EC + ADS treatments presented intermediate values for ADG. The animals fed the NC diet had a greater final BW (596 kg) than animals fed the EC treatment (582 kg; P = 0.04). There was a tendency for interaction among factors for carcass gain (P = 0.08). Similarly to ADG, the highest carcass gain was observed for animals fed the NC diet (1.20 kg), and the lowest was observed for those fed the EC diet (1.05 kg). The NC + ADS and EC + ADS treatments presented intermediate values. The natural contamination groups had greater carcass gain than that of the EC groups, and the use of the ADS recovered part of the weight gain in animals fed the EC diet. In conclusion, mycotoxins at the levels evaluated affected the performance of beef cattle, and adsorbents may mitigate their impact.

Influência da qualidade micotoxicológica e nutricional de híbridos de milho no custo da ração de frangos de corte / Influence of mycotoxicological and nutritional quality of maize hybrids on broiler chickens feed cost

Objetivou-se avaliar as variáveis micotoxicológicas e nutricionais de híbridos de milho com diferentes características que influenciam no custo da ração para frangos de corte. Foram avaliados 26 híbridos de milho geneticamente modificados nas safrinhas de 2016 e 2017, com diferentes germoplasmas, textura de endosperma e duração do ciclo. Nos híbridos, foram avaliados grãos avariados, fumonisinas (B1+B2) (FUM), aflatoxinas (B1+B2+G1+G2) (AFLA), zearalenona (ZEA), deoxinivalenol (DON), umidade, proteína bruta (PB), energia metabolizável aparente corrigida para balanço de nitrogênio (EMAn), aminoácidos digestíveis para aves (lisina, metionina, cistina e treonina) e o respectivo custo da ração inicial para frangos de corte, que foi calculada pelo custo mínimo. A prevalência de FUM, AFLA, ZEA e DON foi de 90, 17, 33 e 0%, com médias de 3067, 1, 38 e 0µg/kg nos dois anos, respectivamente. A média de EMAn e PB foi de 3264kcal/kg e 8,02%, respectivamente, e diferiu (P<0,05) nos dois anos. O custo da ração foi influenciado significativamente (P<0,05) por FUM, PB, EMAn nos dois anos. Híbridos com tecnologia Viptera apresentam menor concentração por FUM e menor custo da ração. Híbridos de ciclo precoce têm menor concentração de FUM, maiores percentuais de PB e de aminoácidos digestíveis e menor custo da ração.(AU)

The objective of this study was to evaluate the mycotoxicological and nutritional variables of maize hybrids with different characteristics that influence the broiler chicken's feed costs. In 2016 and 2017 winter crops, 26 genetically modified hybrids of maize with different germplasm, endosperm texture and cycle duration were evaluated. The analyzed variables were damaged grains, fumonisins (B 1 +B 2 ) (FUM), aflatoxins (B 1 +B 2 +G 1 +G 2 ) (AFLA), zearalenone (ZEA), deoxynivalenol (DON), moisture, crude protein (CP), apparent metabolizable energy corrected for nitrogen balance (AMEn), digestible amino acids for poultry (lysine, methionine, cystine and threonine) and the respective cost of the initial feed for broiler chickens calculated at the minimum cost. The prevalence of FUM, AFLA, ZEA and DON was 90, 17, 33 and 0%, with means of 3067, 1, 38 and 0µg/kg in the two years, respectively. The mean of AMEn and CP was 3264kcal/kg and 8.02%, respectively, and differed (P< 0.05) in the two years. The feed cost was significantly influenced (P<0.05) by FUM, PB, AMEn in two years. Hybrids with Viptera technology show lower concentration per FUM and lower feed cost. Early cycle hybrids have lower concentrations of FUM, higher percentages of CP and digestible amino acids, and lower feed costs.(AU)

Influência da qualidade micotoxicológica e nutricional de híbridos de milho no custo da ração de frangos de corte / Influence of mycotoxicological and nutritional quality of maize hybrids on broiler chickens feed cost

Objetivou-se avaliar as variáveis micotoxicológicas e nutricionais de híbridos de milho com diferentes características que influenciam no custo da ração para frangos de corte. Foram avaliados 26 híbridos de milho geneticamente modificados nas safrinhas de 2016 e 2017, com diferentes germoplasmas, textura de endosperma e duração do ciclo. Nos híbridos, foram avaliados grãos avariados, fumonisinas (B1+B2) (FUM), aflatoxinas (B1+B2+G1+G2) (AFLA), zearalenona (ZEA), deoxinivalenol (DON), umidade, proteína bruta (PB), energia metabolizável aparente corrigida para balanço de nitrogênio (EMAn), aminoácidos digestíveis para aves (lisina, metionina, cistina e treonina) e o respectivo custo da ração inicial para frangos de corte, que foi calculada pelo custo mínimo. A prevalência de FUM, AFLA, ZEA e DON foi de 90, 17, 33 e 0%, com médias de 3067, 1, 38 e 0µg/kg nos dois anos, respectivamente. A média de EMAn e PB foi de 3264kcal/kg e 8,02%, respectivamente, e diferiu (P<0,05) nos dois anos. O custo da ração foi influenciado significativamente (P<0,05) por FUM, PB, EMAn nos dois anos. Híbridos com tecnologia Viptera apresentam menor concentração por FUM e menor custo da ração. Híbridos de ciclo precoce têm menor concentração de FUM, maiores percentuais de PB e de aminoácidos digestíveis e menor custo da ração.(AU)

The objective of this study was to evaluate the mycotoxicological and nutritional variables of maize hybrids with different characteristics that influence the broiler chicken's feed costs. In 2016 and 2017 winter crops, 26 genetically modified hybrids of maize with different germplasm, endosperm texture and cycle duration were evaluated. The analyzed variables were damaged grains, fumonisins (B 1 +B 2 ) (FUM), aflatoxins (B 1 +B 2 +G 1 +G 2 ) (AFLA), zearalenone (ZEA), deoxynivalenol (DON), moisture, crude protein (CP), apparent metabolizable energy corrected for nitrogen balance (AMEn), digestible amino acids for poultry (lysine, methionine, cystine and threonine) and the respective cost of the initial feed for broiler chickens calculated at the minimum cost. The prevalence of FUM, AFLA, ZEA and DON was 90, 17, 33 and 0%, with means of 3067, 1, 38 and 0µg/kg in the two years, respectively. The mean of AMEn and CP was 3264kcal/kg and 8.02%, respectively, and differed (P< 0.05) in the two years. The feed cost was significantly influenced (P<0.05) by FUM, PB, AMEn in two years. Hybrids with Viptera technology show lower concentration per FUM and lower feed cost. Early cycle hybrids have lower concentrations of FUM, higher percentages of CP and digestible amino acids, and lower feed costs.(AU)

Fumonisin occurrence in wheat-based products from Argentina.

In Argentina, wheat is the most consumed cereal by the human population. Since fumonisins occurence in wheat grains and wheat-based products have been reported worldwide, a survey was conducted in order to determine fumonisin contamination in 91 wheat-based products (white wheat flour samples, wheat flour used at bakery products and whole-wheat flour samples) collected from different retail stores of Rio Cuarto city in Argentina using HPLC-MS/MS. Sixty-seven samples (74%) showed contamination by fumonisins. From these samples, 16 showed fumonisin levels between LOD and LOQ (between 0.01 to 0.05 ng/g), while fumonisins (FB1 + FB2) in quantifiable samples ranged from 0.05 ng/g to 18.9 ng/g. Although FB1 was more prevalent, FB2 was foun3d in higher levels than FB1. Overall, fumonisin prevalence was high, but concentrations were far below EU or USA limits set for maize and maize-based products.

Fumonisins and their analogues in contaminated corn and its processed foods - a review.

One of the food security problems faced worldwide is the occurrence of mycotoxins in grains and their foods. Fumonisins (FBs) are mycotoxins which are prevalent in corn (Zea mays L.) and its based foods. Their intake and exposure have been epidemiologically and inconclusively associated with oesophageal cancer and neural tube defects in humans, and other harmful health effects in animals. The toxic effects of FBs can be acute or chronic and these metabolites bioaccumulate mainly in liver and kidney tissues. Among FBs, fumonisin B1 (FB1) is the most relevant moiety although the 'hidden' forms produced after food thermal processes are becoming relevant. Corn is the grain most susceptible to Fusarium and FBs contamination and the mould growth is affected both by abiotic and biotic factors during grain maturation and storage. Mould counts are mainly affected by the grain water activity, the environmental temperature during grain maturation and insect damage. The abiotic factors affected by climatic change patterns have increased their incidence in other regions of the world. Among FBs, the hidden forms are the most difficult to detect and quantify. Single or combined physical, chemical and biological methods are emerging to significantly reduce FBs in processed foods and therefore diminish their toxicological effects.

Creatine kinase and ATPase activities in piglets fed a fungal mycotoxin co-contaminated diet: Consequences in the pathogenesis of subclinical intoxication.

Creatine kinase (CK) activity, through the creatine-kinase-phosphocreatine (CK/PCr) system, provides a temporal and spatial energy buffer to maintain cellular energetic homeostasis, being responsible to provide adenosine triphosphate (ATP) to the proper function of ATPases enzymes, such as the sodium-potassium (Na+, K+-ATPase) and hydrogen (H+-ATPase) pumps. Thus, the aim of this study was to evaluate the involvement of CK/PCr system in the impairment of energetic homeostasis in piglets fed with a diet co-contaminated with mycotoxins, as well as the effects on ATPases enzymes. Animals were randomly divided in two groups (eight repetitions with two animals each): CON (basal diet) and MYC (mycotoxin diet; 9300 µg/kg of aflatoxins and 8000 µg/kg of fumonisins) which were feed during 15 days. Piglets that received a diet containing 300 µg/kg of aflatoxins and 8000 µg/kg of fumonisins (MYC group) presented lower body weight on days 10 and 15 of experiment when compared to control (CON group). Serum CK activity was lower on days 5, 10 and 15 of experiment in the MYC group. The same occurred for serum Na+, K+-ATPase and H+-ATPase activities on days 10 and 15 when compared to CON group. Moreover, serum calcium levels were superior on day 15 of experiment in the MYC group, while serum potassium and sodium levels were lower in comparison to CON group. Based on these evidences, a diet co-contaminated by aflatoxins and fumonisins inhibits serum CK activity, impairing the energetic homeostasis. This inhibition alters the activities of ATPases (Na+, K+-ATPase and H+-ATPase), contributing to the imbalance of Na+, K+ and Ca+ ionic levels. In summary, the cascade of alterations contributes directly to disease pathogenesis of piglets intoxicated by mycotoxins.

Post-weaning piglets fed with different levels of fungal mycotoxins and spray-dried porcine plasma have improved weight gain, feed intake and reduced diarrhea incidence.

Mycotoxins are responsible for economic losses in the swine production industry, especially during post-weaning, when piglets are physiologically immature. Spray-dried porcine plasma (SDPP), added to pig diets, may help reduce losses due to mycotoxins. This work investigates the effects of SDPP in post-weaning piglets fed with diets containing natural contaminants or with more contaminants (co-contamination by mycotoxins). Fifty-six castrated weaned piglets were used in a randomized 2 (0 and 6% of SDPP) x 2 (natural contamination or co-contamination with mycotoxin) factorial design, with seven experimental units of two piglets each. The natural contaminants were 0.95 µg/kg aflatoxins +450 µg/kg fumonisins. The co-contaminated diet contained 300 µg/kg aflatoxins +8000 µg/kg fumonisins. Animals were fed 15 days with experimental diets. Feed intake, weight gain, feed efficiency, diarrhea incidence, and economic feasibility of SDPP treatement were evaluated in three periods of five days each. There was no interaction (P < 0.05) between mycotoxins levels and SDPP. Feed intake, weight gain and feed efficiency were higher (P < 0.05) in diets supplemented with SDPP. Animals fed with SDPP showed lower (P < 0.05) diarrhea incidence in the 1-10 day and 1-15 day periods. The experimental dose of mycotoxins reduced (P < 0.05) weight gain at 11-15 days. SDPP proved to be economical feasible over the total experimental period (1-15 days). Spray-dried plasma improved weight gain, feed intake and reduced diarrhea incidence in piglets post-weaning, but did not correlate with various levels of mycotoxins.

Quality and safety of maize (Zea mays L.) from Rondônia state storage units, Northern Brazil.

The quality and safety of maize (Zea mays L.) from different grain storage units (GSUs), located in the main producing region of Rondônia State, Northern Brazil, were evaluated. Maize grains (n = 76) stored in four GSUs were collected from July to November 2014 and evaluated for grain damages, humidity, fungi and fumonisins (FBs) content. The climate conditions data were also obtained from plant growing to storage periods. Regarding the moisture content and water activity (aw), these varied from 10.0% to 16.1% and 0.5 to 0.8, respectively. As expected, fungi spores were present in 94.8% of the samples, prevailing Fusarium genera, with a fungi colony maximum of 2.2 × 104 CFU g-1. Regarding FBs, 60.5% of the samples were contaminated, below Brazilian and United States maximum limits, but 9.2% had levels higher than the European legislation.

Influence of water activity and temperature on growth and fumonisin production by Fusarium proliferatum strains on irradiated wheat grains.

Wheat is the most important cereal consumed by the Argentine population. In previous studies performed in durum and common wheat grains in this country it has been observed fumonisin contamination as well as high incidence of Fusarium proliferatum. Fumonisins are toxic fungal metabolites, and consumption of fumonisin-contaminated maize has been epidemiologically associated with oesophageal cancer and neural tube defects in some human populations. Using irradiated wheat-grains, the effects of abiotic factors, temperature (15, 25, and 30°C) and water activity (aW; 0.995, 0.98, 0.96, 0.94, 0.92, and 0.88), on mycelial growth and fumonisin biosynthesis were compared for three F. proliferatum strains isolated from wheat grains in Argentina. Although all isolates showed similar profiles of growth, the fumonisin production profiles were slightly different. Maximum growth rates were obtained at the highest aW (0.995) and 25°C, with growth decreasing as the aW of the medium was reduced. Maximum amounts of total fumonisins (FB1, FB2 and FB3) were produced at 0.995 aW and 15°C for 2 strains, and at 25°C and 0.995 aW for the third one. Fumonisins concentrations varied considerably depending on the aW and temperature interactions assayed. Studied strains showed different fumonisin production profiles. Two-dimensional profiles of aW by temperature interactions were developed from these data to identify areas where conditions indicate a significant risk of fumonisins accumulation on wheat. As a result, temperature and aW conditions that resulted in fumonisins production are those found during wheat grain development (especially milk and dough stages) in the field. This is the first study made using irradiated wheat grains and provides useful baseline data on conditions representing a low or a high risk for fumonisins contamination of wheat grains which is of concern because this cereal is destined mainly for human consumption.

Intoxicação por antibióticos ionóforos e leucoencefalomalácia concomitantes pelo consumo de ração comercial contaminada em equinos / Concurrent ionophore poisoning and leukoencephalomalacia by consumption of contaminated commercial ration in horses

Background: Equidae nutritional change increased the frequency of diseases due to inappropriate administration and storage of rations. Although there are reports of ionophore poisoning (IP) and leukoencephalomalacia (LEM) in equidae from Brazil, the concurrent occurrence of both diseases by the same contaminated commercial ration is unprecedented. Therefore, the present paper aims to describe the epidemiological, clinical, laboratorial and pathological findings of concurrent IP and LEM outbreaks in horses.Cases: Eleven farmers from seven different locations in Distrito Federal, Midwestern Brazil, reported sudden clinical signs in 27 horses after the ingestion of commercial pelleted ration. During the farm visits, it was found that the ration brand and batches were identical, and macroscopic evaluation revealed no abnormalities. Eight horses were clinically evaluated and presented hyporexia, apathy, hypermetria, ataxia, dehydration, dyspnea, tongue hypotonia, muscle tremors, tachycardia, facial hypoalgesia, dysphagia, and sporadic or permanent recumbence. Laboratorial changes were restricted to creatine phosphokinase (mean: 1,573.4 ± 16.9 IU/L) and gammaglutamyl transferase (mean: 34.85 ± 29.14 IU/L) serum increases. Pathological evaluation has performed in eight horses presenting pallor and whitish striations in the gluteal, longissimus dorsi, femoral quadriceps muscles and myocardium, varying from mild to moderate. One horse also showed a soft and yellowish focal area on the right temporal lobe white matter. Microscopically, alterations in skeletal and cardiac muscle tissues included striated muscle fibers and cardiomyocytes segmental necrosis, characterized by sarcoplasmic fragmentation with clusters of eosinophilic debris, cellular retraction and hypereosinophilia. Histological alterations in the central nervous system of one horse were characteristic of LEM.[...]