Replacement of milk fat by rapeseed oil stabilised emulsion in commercial yogurt.

The incorporation of lipid droplets and further characterization of matrices within dairy products may be possible using such adjacent particles as protein complexes/lipids. Among the range of varied emulsions and their functionalities, great attention has recently focused on the fabrication of high internal phase types. Feasibly, stable alternatives structured with health-beneficial lipids like those derived from plants could replace saturated fatty acids. As a fat replacement strategy, the fate of incorporated HIPE would require some adjustments either with storage stability and/or structural feat for the food matrix. Therefore, the replacement of milk fat by rapeseed oil stabilised emulsion in commercial yogurt was investigated. This involved 25%, 50% and 75% rapeseed oil respectively assigned as low (LIPE), medium (MIPE), and high internal phase emulsion (HIPE). Specifically, emulsions were examined by droplet size, encapsulation, pH, zeta potential, phase separation, and rheology. The fat free yogurt supplemented by HIPE were examined by droplet size, zeta potential, pH, color, sensory, texture and microbiological aspects against positive (regular milk fat) and negative (fat free) yogurt controls. Results showed increasing rapeseed oil contents would form smaller droplet-like emulsions. Within the yogurt matrix however, incorporating HIPE would seemingly reduce oil droplet size without much compromise to bacterial viability, sensory, or texture. Overall, this simple method of lipid alternation shows promise in dairy products.

Key volatile compound formation of rapeseed oil induced via the Maillard reaction during seed roasting.

This study was designed to investigate the influence of roasting (150 °C for 0-60 min) on key volatile compounds, sensory evaluation, free amino acids, sugars, and Maillard reaction products (MRPs) of five rapeseed varieties and their oils. During the roasting process, key volatile MRPs of fragrant rapeseed oils (FROs) that increased obviously in concentration were mainly pyrazines. After 60 min of roasting, the stronger nutty-like odor in oil from QH was possibly caused by the high levels of 2,5-dimethylpyrazine (21.72 mg/kg) and 3-ethyl-2,5-dimethylpyrazine (5.06 mg/kg). The 5-hydroxymethylfurfural contents and browning indices increased significantly, whereas reducing sugar and free amino acid contents decreased significantly (p < 0.05). This suggested the extent of the Maillard reaction increased with roasting time. Furthermore, the results of Maillard reaction model system demonstrated glycine, lysine, and histidine could react with glucose to generate 2,5-dimethylpyrazine. Hence, 2,5-dimethylpyrazine is identified as one of the important aroma-active MRPs for FRO.

Effect of date fruit waste extract as an antioxidant additive on the properties of active gelatin films.

In this work, date-fruit syrup waste extract (DSWE) was used as an antioxidant additive to develop active gelatin films with enhanced food preservation properties. The effect of DSWE content (5, 10, 15, and 25 wt%) on the mechanical, physical, and antioxidant properties of the gelatin films were analyzed. Total phenolic content and antioxidant assay analysis revealed that the active compounds in blend films are highly migrated to the aqueous phase than the fatty medium. In the canola oil stability studies, gelatin/25 wt% DSWE film immersed oil sample exhibited low peroxide (POV) and p-anisidine (PV) values of 28.6 and 7.1, respectively, compared to the control oil (POV = 41.7 and PV = 13.1) in the air atmosphere and 45 °C for 30 days. Totox values of canola oil samples were decreased as a function of DSWE content in the films, indicating that polyphenols in DSWE are significantly resistant to oil's lipid oxidation.

A novel deodorization method of edible oil by using ethanol steam at low temperature.

A novel deodorization method of edible oil by using ethanol steam at low-temperature was developed. We compared the chemical changes in predeodorized rapeseed oil after anhydrous ethanol steam distillation at low temperature (140 to 220 °C) (L-ESD) and conventional high-temperature (250 °C) water-steam distillation (H-WSD) in terms of odor characteristics, physicochemical properties, micronutrient contents, antioxidant performance, and fatty acid composition. Compared with H-WSD (250 °C for 60 min), L-ESD at 180 °C for 80 to 100 min resulted in lower response values of electronic nose, free fatty acid (0.03% to 0.07%), and peroxide value (0.00 to 0.67 meq/kg), but higher retention of tocopherols (554.93 to 551.59 mg/kg), total phenols (43.36 to 45.42 mgGAE/kg), total carotenoids (65.78 to 67.85 mg/kg), phytosterols (585.80 to 596.53 mg/100 g), polyunsaturated fatty acids (27.95 to 28.01%), and better antioxidant properties. In conclusion, L-ESD can mitigate the damage of oil and thus significantly improve the safety of vegetable oils with a high retention of nutrients compared with conventional H-WSD. PRACTICAL APPLICATION: The present study aimed to compare the chemical changes in predeodorized rapeseed oil after anhydrous ethanol steam distillation at low temperature (140 to 220 °C) (L-ESD) and conventional high-temperature (250 °C) water-steam distillation (H-WSD) in terms of odor characteristics, physicochemical properties, micronutrient contents, antioxidant performance, and fatty acid composition. Results indicated that this finding supplies a theoretical basis for developing a method with retaining more micronutrients and producing less harmful substances for the deodorization of rapeseed oil.

Quantification of phenolic compounds in vegetable oils by mixed-mode solid-phase extraction isotope chemical labeling coupled with UHPLC-MS/MS.

In the present work, a rapid, accurate and cost-effective method has been developed for the simultaneous quantification of phenolic compounds in oil using mixed-mode solid-phase extraction (SPE) coupled with chemical labeling UHPLC-MS/MS. Mix-mode SPE weak cation cartridges were selected to enrich and purify phenolic compounds in oil, and hydroxyl moiety was dansylation as stable-isotope internal standard. The major parameters that affected the extraction and chemical labeling efficiency were investigated, and the method was fully validated. The limit of quantifications and the limit of detections were 0.002 µg kg-1 ~ 0.10 µg kg-1 and 0.006 µg kg-1 ~ 0.30 µg kg-1, respectively. The recoveries were 61.2% ~ 129.3% with intra-day and inter-day precision less than 12%. The results for 38 rapeseed oils revealed that 14 phenolic compounds, including canolol, phenolic acids, phenolic alcohols, tyrosol and vanillin from trace levels to relatively high content.

Comparative Analysis of Rapeseed Oils Prepared by Three Different Methods.

Flavoured rapeseed oils prepared using traditional technologies (oils A and B) and a fragrant rapeseed oil obtained using an enzymatic Maillard reaction (oil C) were analysed to show that oil C featured basic indicators and a fatty acid composition similar to those of traditional oils while exhibiting a higher comprehensive sensory evaluation score. Volatile component, odour activity value (OAV), and relative odour activity value (ROAV) analyses revealed that oil C had an elevated content of pyrazines (20.83%) and aldehydes (38.15%), which resulted in stronger charred and caramel flavours. The aroma of oil C was directly impacted by 3-methylbutyraldehyde (OAV > 1) and was modified by 3-methylthiopropionaldehyde and nonanal (RAOV > 1 in both cases). Thus, the developed technology was found to be well suited for the production of novel and safe fragrant rapeseed oil.

The Use of Genetic and Gene Technologies in Shaping Modern Rapeseed Cultivars (Brassica napus L.).

Since their domestication, Brassica oilseed species have undergone progressive transformation allied with the development of breeding and molecular technologies. The canola (Brassica napus) crop has rapidly expanded globally in the last 30 years with intensive innovations in canola varieties, providing for a wider range of markets apart from the food industry. The breeding efforts of B. napus, the main source of canola oil and canola meal, have been mainly focused on improving seed yield, oil quality, and meal quality along with disease resistance, abiotic stress tolerance, and herbicide resistance. The revolution in genetics and gene technologies, including genetic mapping, molecular markers, genomic tools, and gene technology, especially gene editing tools, has allowed an understanding of the complex genetic makeup and gene functions in the major bioprocesses of the Brassicales, especially Brassica oil crops. Here, we provide an overview on the contributions of these technologies in improving the major traits of B. napus and discuss their potential use to accomplish new improvement targets.

Effects and mechanism of tea polyphenols on the quality of oil during frying process.

The effects and action mechanism of tea polyphenols (TP) on the quality of rapeseed oil during frying process were investigated. Results showed that compared with control, TP (0.04%, w/w) exhibited the remarkable ability to inhibit the deterioration of acid value, peroxide value, anisidine value, viscosity, and color of frying oil. By using gas chromatography-mass spectrometry, frying oil with TP showed the higher content of unsaturated fatty acids (72.79%) and lower content of trans fatty acids (3.36%) than those of control. Meanwhile, frying oil with TP had a higher total phenolic content than control at the same frying time. In addition, the thermo gravimetric-differential scanning calorimetry results showed that TP could increase the oxidation stability of rapeseed oil. Furthermore, according to the Fourier transform infrared and molecular dynamic simulation results, TP could reduce the breaking degree of = C-H bond, C-O-C bond, and C = C bond in oil molecules, and inhibit the oxidation of oil components by inhibiting the generation of free radicals and eliminating free radicals. All present results suggested that TP showed the potential value to be used for protecting the quality of oil during the frying process in food and chemical industries. PRACTICAL APPLICATIONS: The inhibitory effect of tea polyphenols on the deterioration of quality of rapeseed oil during frying was found and the mechanism had also preliminarily interpretation. This work provided a method for monitoring the quality of fry oil and provided the theoretical basis for the use of tea polyphenols in frying.

Determination of Triacylglycerols by HTGC-FID as a Sensitive Tool for the Identification of Rapeseed and Olive Oil Adulteration.

Triacylglycerols (TGs) are the most common compounds in food lipids, accounting for 95% of the weight of edible oils. The aim of this study was to scrutinize a procedure for quantitatively assessing possible adulteration of olive and rapeseed oil through GC-FID analysis of TGs. The recovery of TG standards ranged from 21% to 148%, and the relative response factor (RRF) ranged from 0.42 to 2.28. The limits of detection were in the range of 0.001 to 0.330 µg/mL, and the limits of quantitation from 0.001 to 1.000 µg/mL. The validated method was used to determine the TGs in olive oil (OO), refined rapeseed oil (RRO), and their blends. Eight TGs were detected in refined rapeseed oil, and 10 in olive oil. The addition of 1% of olive oil to rapeseed oil or vice versa can be detected using this method. Three triacylglycerols were pinpointed as indicators of adulteration of rapeseed oil with olive oil (PPO, PPL, PSO). The method described here can be used for controlling the quality of these oils.

Transfer assessment of carbendazim residues from rapeseed to oil production determined by HPLC-MS/MS.

It is crucial to develop practical procedures for the control and reduction of pesticide residues in oil productions from farm to dining table. In this study, the dissipation behaviors of typical fungicide from rapeseed to oil production were studied to reveal relationship among spraying stage, application dosage, household oil processing stage, and pesticide residues. In the field trials, rape plants were sprayed with carbendazim at three different dosages during flowering period. Transfer assessment of carbendazim residues from rapeseed to oil production during household oil processing via different press techniques was determined using high-performance liquid chromatography coupled with tandem mass spectrometry (HPLC-MS/MS). The recoveries of carbendazim in rapeseed samples, meals after squeezing samples, and rapeseed oil samples ranged from 82.5% to 93.6% with relative standard deviations (RSDs) ＜5.2%. The validation results illustrated that the methods were reliable and sensitive. The average processing factor (PF) during household oil processing via hot press technique and cold press technique was 0.15 and 0.51, respectively. This study demonstrated that household oil processing could significantly reduce the pesticide residues, especially by hot press technique.

Rapid Classification and Quantification of Camellia (Camellia oleifera Abel.) Oil Blended with Rapeseed Oil Using FTIR-ATR Spectroscopy.

Currently, the authentication of camellia oil (CAO) has become very important due to the possible adulteration of CAO with cheaper vegetable oils such as rapeseed oil (RSO). Therefore, we report a Fourier transform infrared (FTIR) spectroscopic method for detecting the authenticity of CAO and quantifying the blended levels of RSO. In this study, two characteristic spectral bands (1119 cm-1 and 1096 cm-1) were selected and used for monitoring the purity of CAO. In combination with principal component analysis (PCA), linear discriminant analysis (LDA), and partial least squares regression (PLSR) analysis, qualitative and quantitative methods for the detection of camellia oil adulteration were proposed. The results showed that the calculated I1119/I1096 intensity ratio facilitated an initial check for pure CAO and six other edible oils. PCA was used on the optimized spectral region of 1800-650 cm-1. We observed the classification of CAO and RSO as well as discrimination of CAO with RSO adulterants. LDA was utilized to classify CAO from RSO. We could differentiate and classify RSO adulterants up to 1% v/v. In the quantitative PLSR models, the plots of actual values versus predicted values exhibited high linearity. Root mean square error of calibration (RMSEC) and root mean square error of cross validation (RMSECV) values of the PLSR models were 1.4518%-3.3164% v/v and 1.7196%-3.8136% v/v, respectively. This method was successfully applied in the classification and quantification of CAO adulteration with RSO.

The effect of refining process on the physicochemical properties and micronutrients of rapeseed oils.

Information on the physicochemical variability in rapeseed oil from different varieties during each refining process is lacking. Our purpose was to investigate the physicochemical properties, micronutrients and oxidative stability of the oil extracted from the five varieties of rapeseeds during their different stages of refining process. Increase in the acid value, peroxide value and p-anisidine value were detected in the refining, while content of tocopherols, sterols, ß-carotene and phenols, which are regarded as important nutritional compounds diminished. Moreover, the loss rate of total phytosterols of all oils during neutralization (9.23-7.3%) and deodorization (9.97-8.27%) were higher than that of degumming (3.01-0.87%) and bleaching (2.75-1.18%). Deodorization affected total tocopherols contents the most, followed by bleaching, neutralization and degumming. There was a remarkable reduction in total content of phenol, ß-carotene and oxygen radical absorbance of all oils during refining. The accumulated information can be used in looking for the optimum condition to meet the basic requirements for oil and minimize micronutrients losses so as to increase their market value.

Profiling and quantification of lipids in cold-pressed rapeseed oils based on direct infusion electrospray ionization tandem mass spectrometry.

Microwave pretreatment of rapeseeds prior to cold-pressing is a simple and desirable method for producing high quality oils. In this study, a rapid and sensitive lipid profiling platform employing an accurate quantification strategy was established based on direct infusion electrospray ionization tandem mass spectrometry. Using this developed platform, we further investigated the effect of microwave pretreatment of rapeseeds on the contents of important lipids such as triglycerides (TAGs), phospholipids (PLs), and free fatty acids (FFAs) in 15 different rapeseed oils. Our results demonstrated that no significant changes of total FAs and TAGs contents were observed after microwave pretreatment, while FFA contents increased and PLs contents significantly increased up to 40 folds. The potential mechanism of lipid changes was also discussed. The established lipidomics profiling platform can provide reliable lipids profiling data and help to better understand the potential mechanism of microwave pretreatment in oil processing.

Quantification of polycyclic aromatic hydrocarbons and phthalic acid esters in deodorizer distillates obtained from soybean, rapeseed, corn and rice bran oils.

In this study, simple GC-MS methods for analysising sixteen PAHs and seven PAEs were individually established. The LOQs for PAHs and PAEs were ranging from 0.18 to 0.42 µg/kg and 0.19 to 1.50 µg/kg, respectively. The recoveries for DD samples were in the range of 84.8-115.5% and 84.2-109.3% for PAHs and PAEs, respectively. Furthermore, PAHs and PAEs concentrations in soybean, rapeseed, corn and rice bran oil distillates were evaluated. PAHs were found in all the DD samples and the concentrations of BaP, PAH4 and total PAHs were 0.89-55.58, 8.11-326.07 and 115.77-966.40 µg/kg, respectively. Correspondingly, total PAEs concentrations ranged from 2.45 to 24.52 mg/kg, and the mean value was 7.76 mg/kg. The results illustrated that the contents of PAHs and PAEs in the DDs were extremely higher than those in the edible oils, thus indicating that specific issues should be considered in the vegetable oil DDs and DD-based products.

Combination of thermal pretreatment and alcohol-assisted aqueous processing for rapeseed oil extraction.

BACKGROUND: The alcohol-assisted aqueous extraction processing (AAEP) of oil has many advantages such as no need for demulsification and relative low cost compared with enzymatic aqueous extraction processing (EAEP). Three kinds of thermal pretreatments including dry-heating, wet-heating and soak-heating followed by the AAEP of rapeseed oil were investigated. RESULTS: Both soak-heating and wet-heating had a higher contribution rate to oil yield than dry-heating due to the enhancement of heat transfer rate owing to the high moisture content in the rapeseed cells. However, oil from soak-heated rapeseeds showed a much lower level on peroxide value (0.41 mmol kg-1 ) than that of wet-heated rapeseeds (5.23 mmol kg-1 ). In addition, transmission electron microscopy images illustrated that promoting effects of soak-heating and wet-heating on oil release were attributed to the coalescence of oil bodies. A relative low concentration of alcohol solution as an extraction medium, the highest oil recovery of 92.77% was achieved when ground rapeseeds (mean particle size: 21.23 µm) were treated with 45% (v/v) alcohol for 2 h at 70 °C and pH 9.0. Both the acid value and the peroxide value are lower than the commercial oil produced by extrusion and hexane extraction. Furthermore, the oil produced from AAEP also had higher content of tocopherols and lower content of trans-fatty acids than the commercial oil. CONCLUSION: AAEP of oil from soak-heated rapeseeds is a promising alternative to conventional oil extraction methods. © 2019 Society of Chemical Industry.

Safety assessment of EPA+DHA canola oil by fatty acid profile comparison to various edible oils and fat-containing foods and a 28-day repeated dose toxicity study in rats.

The omega-3 long-chain polyunsaturated fatty acids (LC-PUFAs) eicosapentaenoic acid (EPA) and docosahexaenoic acid (DHA) are recognized for their health-promoting qualities. Marine fish and fish oil currently provide the main sources of EPA and DHA for human consumption. An alternative plant-based source of EPA and DHA is provided by EPA + DHA canola event LBFLFK (LBFLFK). A comparative analysis and a 28-day toxicity study assessed the safety of LBFLFK refined, bleached, and deodorized (RBD) oil. Thirty-one different commercially-obtained fat and oil samples were tested, and principal component analysis showed that the overall fatty acid profile of LBFLFK RBD oil was most similar to Mortierella alpina oil and salmon flesh. Samples with the fewest differences in the presence or absence of individual fatty acids compared to LBFLFK RBD oil were menhaden oil and some other fish oils. In a 28-day toxicity study, LBFLFK RBD oil was administered by oral gavage to male and female Wistar rats. No signs of toxicity were evident and no adverse effects were noted in clinical observations, clinical pathology, or histopathology. Overall, these studies support the safety of LBFLFK RBD oil as a source of EPA and DHA for human consumption.

Impact of the addition of 4-vinyl-derivatives of ferulic and sinapic acids on retention of fatty acids and terpenoids in cold-pressed rapeseed and flaxseed oils during the induction period of oxidation.

In the western diet there is an oversupply of n-6 fatty acids. This adverse trend can be balanced by the consumption of rapeseed and flaxseed oils rich in α-linolenic acid (n-3). However, the high share of this fatty acid contributes to low oxidative stability of oil. Oxidation decreases n-3 fatty acid and other bioactive compounds contents, which adversely affects oil nutritional value. In this study, the impact of ferulic and sinapic acids vinyl derivatives on the fatty acids and oil terpenoids (sterols, tocols, carotenoids, squalene) retention at the end of induction period during accelerated oxidation of rapeseed and flaxseed cold-pressed oils was investigated. It was found that the use of 4-vinylsyringol (4-VS) or 4-vinylquaiacol (4-VQ) increased the retention of intact sterols and carotenoids (at least 2-fold) and squalene (at least 4-fold). The 4-VQ addition also inhibited the α-linolenic acid loss. Unfortunately, both phenolic derivatives favoured α-tocopherol decay in rapeseed oil.

An integrated omics analysis reveals molecular mechanisms that are associated with differences in seed oil content between Glycine max and Brassica napus.

BACKGROUND: Rapeseed (Brassica napus L.) and soybean (Glycine max L.) seeds are rich in both protein and oil, which are major sources of biofuels and nutrition. Although the difference in seed oil content between soybean (~ 20%) and rapeseed (~ 40%) exists, little is known about its underlying molecular mechanism. RESULTS: An integrated omics analysis was performed in soybean, rapeseed, Arabidopsis (Arabidopsis thaliana L. Heynh), and sesame (Sesamum indicum L.), based on Arabidopsis acyl-lipid metabolism- and carbon metabolism-related genes. As a result, candidate genes and their transcription factors and microRNAs, along with phylogenetic analysis and co-expression network analysis of the PEPC gene family, were found to be largely associated with the difference between the two species. First, three soybean genes (Glyma.13G148600, Glyma.13G207900 and Glyma.12G122900) co-expressed with GmPEPC1 are specifically enriched during seed storage protein accumulation stages, while the expression of BnPEPC1 is putatively inhibited by bna-miR169, and two genes BnSTKA and BnCKII are co-expressed with BnPEPC1 and are specifically associated with plant circadian rhythm, which are related to seed oil biosynthesis. Then, in de novo fatty acid synthesis there are rapeseed-specific genes encoding subunits ß-CT (BnaC05g37990D) and BCCP1 (BnaA03g06000D) of heterogeneous ACCase, which could interfere with synthesis rate, and ß-CT is positively regulated by four transcription factors (BnaA01g37250D, BnaA02g26190D, BnaC01g01040D and BnaC07g21470D). In triglyceride synthesis, GmLPAAT2 is putatively inhibited by three miRNAs (gma-miR171, gma-miR1516 and gma-miR5775). Finally, in rapeseed there was evidence for the expansion of gene families, CALO, OBO and STERO, related to lipid storage, and the contraction of gene families, LOX, LAH and HSI2, related to oil degradation. CONCLUSIONS: The molecular mechanisms associated with differences in seed oil content provide the basis for future breeding efforts to improve seed oil content.

Erucic Acid (22:1n-9) in Fish Feed, Farmed, and Wild Fish and Seafood Products.

The European Food Safety Authority (EFSA) published a risk assessment of erucic acid (22:1n-9) in 2016, establishing a Tolerable Daily Intake (TDI) for humans of 7 mg kg-1 body weight per day. This report largely excluded the contribution of erucic acid from fish and seafood, due to this fatty acid often not being reported separately in seafood. The Institute of Marine Research (IMR) in Norway analyzes erucic acid and has accumulated extensive data from analyses of fish feeds, farmed and wild fish, and seafood products. Our data show that rapeseed oil (low erucic acid varieties) and fish oil are the main sources of erucic acid in feed for farmed fish. Erucic acid content increases with total fat content, both in farmed and wild fish, and it is particularly high in fish liver, fish oil, and oily fish, such as mackerel. We show that the current TDI could be exceeded with a 200 g meal of mackerel, as at the maximum concentration analyzed, such a meal would contribute 143% to the TDI of a 60 kg person. These data cover a current knowledge gap in the scientific literature regarding the content of erucic acid in fish and seafood.

Modeled replacement of traditional soybean and canola oil with high-oleic varieties increases monounsaturated fatty acid and reduces both saturated fatty acid and polyunsaturated fatty acid intake in the US adult population.

BACKGROUND: High-oleic (HO) seed oils are being introduced as replacements for trans fatty acid (TFA)-containing fats and oils. Negative health effects associated with TFAs led to their removal from the US Generally Recognized As Safe list. HO oils formulated for use in food production may result in changes in fatty acid intake at population levels. Objectives: The purposes of this study were to 1) identify major food sources of soybean oil (SO) and canola oil (CO), 2) estimate effects of replacing SO and CO with HO varieties on fatty acid intake overall and by age and sex strata, and 3) compare predicted intakes with the Dietary Reference Intakes and Adequate Intakes (AIs) for the essential fatty acids (EFAs) α-linolenic acid (ALA) and linoleic acid (LA). Design: Food and nutrient intakes from NHANES waves 2007-2008, 2009-2010, 2011-2012, and 2013-2014 in 21,029 individuals aged ≥20 y were used to model dietary changes. We estimated the intake of fatty acid with the replacement of HO-SO and HO-CO for commodity SO and CO at 10%, 25%, and 50% and evaluated the potential for meeting the AI at these levels. RESULTS: Each modeling scenario decreased saturated fatty acids (SFAs), although intakes remained greater than recommended for all age and sex groups. Models of all levels increased the intake of total monounsaturated fatty acids (MUFAs), especially oleic acid, and decreased the intake of total polyunsaturated fatty acids (PUFAs), particularly LA and ALA. Replacement of traditional with HO oils at 25-50% places specific adult age and sex groups at risk of not meeting the AI for LA and ALA. Conclusions: The replacement of traditional oils with HO varieties will increase MUFA intake and reduce both SFA and PUFA intakes, including EFAs, and may place specific age and sex groups at risk of inadequate LA and ALA intake.