Laboratory performance on analysis of mandatory nutrients and preparation of nutrition labelling.

This study assessed the performance of 17 laboratories in Thailand in analysing mandatory nutrients in salted, fried broad bean and in using data to prepare nutrition labels. Nutrient levels in the test material, as robust mean (x(∗)) and robust standard deviation (s(∗)), were assigned in line with ISO 13528. Data obtained from the laboratories were statistically evaluated against these values. Laboratories with satisfactory, questionable and unsatisfactory results for each nutrient were identified based on robust z-score. Laboratories achieving satisfactory analytical results (z-score⩽2) were for lipid, 82%; protein, 85%; Na, 82%; Ca, 62%; Fe, 81%; ash, 70%; and moisture, 62%. Reference values for some nutrients in broad bean powder were developed using data from satisfactorily performing laboratories. Less than 20% of the laboratories demonstrated good performance in preparing nutrition labels. Common mistakes were the nutrition information format, estimation of serving size and serving(s) per package.

Ochratoxin A in several grains in Iran.

Ochratoxin A content in 100 grain and derived products were determined by high-performance liquid chromatography with immunoaffinity column clean-up and fluorometric detection. Ochratoxin A was detected in 32% of green gram, 13.3% of chickpea, 10% of lentil and 17.5% of wheat flour. Ochratoxin contamination was below the regulatory limits of the European Union and of Iran. Recovery was 97% and the limit of detection was 0.12 ng g⁻¹.

Effect of milling and preparation method on the physical properties and quality of moin-moin (steamed paste).

Moin-moin is steamed cowpea paste native to Nigeria. This product is classified as a protein/starch gel with the dominate portion of the gel network consisting of cowpea starch. Moin-moin was prepared from starting materials (cowpea meal and cowpea flour) and compared to moin-moin prepared from dry, whole, undecorticated cowpea seeds. Texture profile measurements showed that moin-moin made from cowpea flour (small particle size) formed a firmer structure when compared to moin-moin made from either cowpea meal or whole, dry cowpea seeds. Starting materials with smaller particle sizes and longer cooking times produced stickier moin-moin. The cowpea solids to water ratio was shown to affect the firmness of moin-moin, where a 3.75:1 ratio of solids to water produced a firmer product than other concentrations. Generally, color was unaffected across treatment regimens as identified by an expert sensory panel, although instrumental color measurements showed significant differences for hue angle and chroma. This study demonstrated that the particle size of this food ingredient contributes significantly to its functionality in food formulations.

A comparative study on phenolic profiles and antioxidant activities of legumes as affected by extraction solvents.

The objective of this study was to investigate how 6 commonly used solvent systems affected the yields of phenolic substances and the antioxidant capacity of extracts from 8 major classes of food legumes. Several antioxidant-related phytochemical compositions, namely, total phenolic content (TPC), total flavonoids content (TFC), and condensed tannins content (CTC), were investigated. In addition, antioxidant activities were tested using 2,2-diphenyl-1-picryhydrazyl (DPPH) free radical scavenging, ferric-reducing antioxidant power (FRAP), and the oxygen radical absorbance capacity (ORAC). The results showed that the 50% acetone extracts exhibited the highest TPC for yellow pea, green pea, chickpea, and yellow soybean. Acidic 70% acetone (+0.5% acetic acid) extracts exhibited the highest TPC, TFC, and FRAP values for black bean, lentil, black soybean, and red kidney bean. The 80% acetone extracts exhibited the highest TFC, CTC, and DPPH-free radical scavenging activity for yellow pea, green pea, chickpea, and yellow soybean. The 70% ethanol extracts exhibited the greatest ORAC value for all selected legumes. These results indicated that solvents with different polarity had significant effects on total phenolic contents, extracted components, and antioxidant activities. High correlations between phenolic compositions and antioxidant activities of legume extracts were observed. The information is of interest to the nutraceutical food/ingredient industries since legumes are a rich source of antioxidants.

Comparative analyses of phenolic composition, antioxidant capacity, and color of cool season legumes and other selected food legumes.

The objective of this study was to characterize the phenolic compounds and antioxidant activities of U.S.-produced cool season legumes. A total of 33 cool season legume samples were selected. Some common beans and soybeans were included for comparisons. Total phenolic content (TPC), total flavonoid content (TFC), and condensed tannin content (CTC) were analyzed. Ferric reducing antioxidant power (FRAP), 2,2-diphenyl-1-picrylhydrazyl (DPPH) radical scavenging assay, and oxygen radical absorbance capacity (ORAC) were used for analyzing antioxidant properties. Color of the legume flour and the seed coat was also analyzed. TPC, TFC, CTC, FRAP, DPPH, and ORAC values of legumes were significantly different not only between classes but also among samples within each class. Among cool season legume classes, lentils possessed the highest concentrations of the phenolic compounds and antioxidant activities. Colored common beans and black soybeans exhibited higher TPC, TFC, CTC, FRAP, DPPH, and ORAC values than those of yellow peas, green peas, and chickpeas. Antioxidant activities (FRAP, DPPH, and ORAC) were strongly correlated (r= 0.96, 0.94, and 0.89, respectively, P < 0.01) with TPC. TPC and ORAC were moderately correlated (P < 0.01) with either the seed hull surface color or the flour color.

In vitro quality assessment of two tropical shrub legumes in relation to their extractable tannins contents.

The in vitro dry matter digestibility (IVDMD) of the two leguminous tree fodders Gliricidia sepium and Calliandra calothyrsus which differ in their tannin content was examined by the rumen simulation technique. Extractable condensed tannin (CT) concentrations ranged from 0.57% in G. sepium to 5.05% in C. calothyrsus using the butanol-HCl extraction. On the basis of their respective CT contents, G. sepium was classified as containing traces of CT, whereas C. calothyrsus had medium amounts of CT. Polyethylene glycol (PEG) was added at different concentrations (0, 1.5, 5 and 10 g/100 g plant material substrate) to assess the effect of tannins on IVDMD. The IVDMD was higher for G. sepium (range: 60-65%) than for C. calothyrsus (39.5-53.5%). In vitro gas production and IVDMD increased with increased PEG concentrations especially for C. calothyrsus. A non-significant response to increasing PEG concentrations for IVDMD of G. sepium confirms PEG binding with the tannins. On the basis of these results, it is assumed that G. sepium has a higher nutritive value than C. calothyrsus. Good relationship between PEG binding and the improvement of IVDMD confirms the usefulness of this technique for improving the nutritive value of tanniniferous tropical browses.

Protein quality evaluation in rats of typical diets for 4- to 6-year-old children from different socioeconomic areas living in Oaxaca, Mexico.

Legumes and cereals are principal sources of energy and protein in developing countries. In Oaxaca, Mexico, corn is the primary agricultural crop, therefore corn tortillas and beans are the main energy and protein sources. The objective of this study was to evaluate the protein quality in rats of typical diets for 4- to 6-year-old children from different socioeconomic areas in Oaxaca, Mexico. Composite diets representing the typical diets were formulated and fed to male weanling rats for 10 days. A control diet using casein as the reference diet and one free of nitrogen were included in the study. The apparent protein digestibility was determined in rats using the chromic oxide marker technique and the data was statistically analyzed for differences between control and experimental diets. Rats fed the diet of low income children gained about 2 g/day compared to about 3.8 g/day for the rats fed the control (casein) diet and had the lowest weight gain/g of protein intake. The NPR was 3.52 compared to 4.31 for the control diet. This diet is 67% vegetable protein and 33% animal protein. The diet for the medium income group contained a higher percentage of animal protein, 76% and thus higher digestibility, 78%. The results of this study indicate that the protein quality of children's diets in Oaxaca, Mexico, need to be improved.

Nutritional and sensory evaluation of akara made from blends of cowpea and hard-to-cook mottled brown dry beans.

The effect of replacing cowpea with hard-to-cook beans on the nutritional and sensory properties of akara were evaluated. Cowpea (Vigna unguiculata), traditionally used for making akara, was substituted 0%, 25%, 50%, 75%, and 100% with hard-to-cook (HTC) mottled brown beans (Phaseolus vulgaris). Cowpea (CP) soaked for 60 min HTC beans soaked for 18 h were separately decorticated, ground to a paste, and mixed in the following CP:MBB ratios: 0:100, 25:75, 50:50, 75:25, and 100:0. The paste mixtures were each whipped and fried into akara. The samples were analyzed for bulk density, nutritional composition, carbohydrate and protein digestibility, alpha-amylase inhibitor and trypsin inhibitor activity, and sensory attributes. The bulk density of paste as well as of akara increased with the increasing content of HTC bean. Akara made from composite paste had a relatively better amino acid profile. Frying beyond 5 min destroyed the alpha-amylase inhibitors as well as the trypsin inhibitor activity. No significant difference was observed in the overall acceptability of akara made from cowpea substituted up to 50% with HTC beans. Hence, this approach permits the utilization of hard-to-cook beans.

Variability in physicochemical and nutritional quality traits of parents, F2 and F3 generations of lentil crosses.

Ten physicochemical and nutritional quality traits (100-seed weight, seed volume, seed density, bulk density, hydration capacity, hydration index, swelling capacity, protein, tryptophan and energy value) were examined in the seed samples of parents, F2 and F3 generations of three microsperma x microsperma and two microsperma x macrosperma crosses of lentils. Significant variation for different traits was observed among the genotypes in both the groups and also among both types of crosses in F2 and F3 generations. Ranges, means and coefficients of variation (CV %) for various traits among parents, F2 and F3 generations of different crosses, along with the deviations between F2 and F3 generation means for various traits in different crosses are discussed. Also suggested is a breeding strategy for evolving lentil varieties with improved seed yield and nutritional quality parameters.

Nutritional evaluation of biologically treated white kidney beans (Phaseolus vulgaris L.) in pigs: ileal and amino acid digestibility.

We studied the effect of feeding young growing pigs a semisynthetic diet containing 7.5% white kidney beans-germinated (GB), pancreatin treated (PTB), or untreated (raw beans RB)--on protein and amino acid (AA) digestibilities at the terminal ileum. Eleven castrated male pigs (12.2 kg live weight) fitted with a post-valve T-cecal cannula and two blood catheters were used. The 15N-isotope dilution method was used to determine the amount of endogenous protein passing the terminal ileum and the true ileal protein digestibility. Ileal crude protein losses in pigs fed the RB, GB, and PTB diets were 51.9, 27.4, and 51.1 g/kg of DMI, respectively. The total amounts of AA passing the terminal ileum of the pigs fed the RB, GB, and PTB diets were 48.6, 21.4, and 42.2 g/kg DMI, respectively. The apparent ileal crude protein and AA digestibilities of the RB, GB, and PTB diets were 74, 87, and 75% and 76, 89, and 78%, respectively. True ileal protein digestibilities were 88, 93, and 93% for the RB, GB, and PTB diets, respectively. On the basis of this research, germination of white kidney beans improves the digestion of protein by decreasing the content of bean antinutritional factors and increasing the bean true ileal protein digestibility.

Effect of malting time on chemical composition and functional properties of soybean and bambara groundnut flours.

Soybean and bambara groundnut were malted for 0, 24, 48, 72, 96 and 120 h, respectively. The malted beans were dried, devegetated and milled into flour. The protein contents of unmalted soybean and bambara groundnut flours which were 48.3 and 18.8% (dry weight), respectively, increased on malting to maximum levels of 56.17 and 28.55% (dry weight) after 2 days before decreasing to 19.51 and 20.92% (dry weight) for soybean and bambara groundnut flours, respectively. The same pattern of change was observed for the fat, soluble sugar and nitrogen contents of the malted bean flours. Approximately 76 and 59% of the phytic acid contents of soybean and bambara groundnut flours were removed, respectively, on malting for 120 h. Malting significantly affected the water and oil absorption capacities as well as the viscosities of both bean flours. The optimum malting time for both beans was found to be between 72 and 96 h.

Nutritional quality of green beans (var. Tuf) fermented with starter culture.

Green beans (var. Tuf) were blanched at 90 degrees C for 20 min and then fermented in 3.08% salt solution with starter culture. Trypsin inhibitors, vitamins B1 and B2 and protein were determined before and during fermentation as well as after storage for 36 days. Trypsin inhibitors, vitamins B1 and B2 were reduced significantly (P < or = 0.05) during fermentation. A decrease in protein content was observed during the first 2 days of fermentation and thereafter the decrease was not significant (P > or = 0.05). Storage of pasteurised beans at 20 degrees for 36 days had no significant effect on the vitamins and protein.

Chemical composition and nutritional potential of yam bean seeds (Pachyrhizus erosus L. urban).

Pachyrhizus erosus seeds were analysed for proximate composition, minerals, protein fractions, antinutritional factors, and rotenoids. The seeds showed a high content of proteins, lipids, Fe and Ca, in comparison to other legumes. Glutelins constitute the highest protein fraction, followed by globulins. Antinutritional substances detected as tannins, hemagglutinating activity and trypsin inhibitory activity, were in low concentrations. Seeds were also processed to obtain a flour which showed proper characteristics, good in vitro digestibility, significant rotenoid reduction level and amino acid composition rich in essential amino acids, except methionine.

Effect of domestic processing on the cooking time, nutrients, antinutrients and in vitro protein digestibility of the African yambean (Sphenostylis stenocarpa).

The effects of processing (soaking, dehulling, fermentation and heat treatment) on the cooking time, protein, mineral, tannin, phytate and in vitro protein digestibility (IVPD) of the African yambean (AYB) were examined. The cooking time ranged from 90-155 minutes. Soaking reduced cooking time by about 50 percent. Soaking for 12 hours was the most appropriate to reduce cooking time, tannin and phytate levels. It improved in vitro protein digestibility (IVPD). Prolonged soaking (24 hours) decreased calcium (Ca) and iron (Fe) values by 19 percent and 35 percent, respectively. Dehulling showed that Ca, Fe, magnesium (Mg) and zinc (Zn) were concentrated in the seed coat of the AYB. The seeds soaked and dehulled retained Mg and Zn. Dehulling reduced tannin but had no significant effect on phytate and the IVPD of the AYB except for seeds soaked for 12 hours before dehulling. Soaking for 24 hours before dehulling significantly increased crude protein content by 16 percent (p < 0.05). Blanching and roasting increased the IVPD by 8-11 percent. Fermentation had no effect on the crude protein, Ca, Fe, Mg and Zn but significantly reduced phytate content of the AYB. Fermentation had no advantage over heat treatment with respect to improving the in vitro protein digestibility of the AYB.

Effects of altitude above sea level on the cooking time and nutritional value of common beans.

The present study was conducted with the objective to determine the effects of altitude above sea level, on the cooking time and nutritional value of common black beans (Phaseolus vulgaris). Three 100 g samples of the Ostua variety were cooked at 8 individual locations, ranging in altitude from 0 to 2256 meters, in Guatemala, to establish water uptake and cooking time. The cooked samples were separated into cooked beans and cooking broth for chemical analysis. This included moisture, protein, lysine, tannins, total and enzyme susceptible starch, and fiber fractionation. The cooking liquor was analyzed for total solids, moisture, protein, ash and K. A 1200 g sample was cooked for the cooking time established previously, for biological testing of nutritional value, which included Net Protein Ratio (NPR), Protein Efficiency Ratio (PER), and protein digestibility. Altitude influenced cooking time which increased from 78 min at 0 m, to 264 min at 2256 m. Final moisture content in the cooked bean was similar at all altitudes and there was a tendency to yield smaller amounts of solids in the cooking broth at higher altitudes. The increase in cooking time was significant. Bean water uptake at all times was significantly slower and smaller at ambient as compared to water uptake at boiling T, at all altitudes. Protein and lysine content were not affected by altitude, however, tannin and catechin were lower in cooked samples, as compared to the raw material. Altitude did not affect the content of these substances. Total starch and total sugars were higher in the raw sample, as compared to the cooked samples, but there was no effect of altitude. Enzyme susceptible starch (ESS) was lower in the raw sample as compared to the cooked samples, which contained similar amounts with respect to altitude. No change was observed in fiber fractions of the cooked beans. Likewise, the composition of the cooking broth was very similar between cooking locations. There was a small tendency to a lower protein quality, with respect to altitude, the effect of which was more obvious in the apparent protein digestibility values. Undercooking or overcooking at one location influenced protein quality values. The extended cooking time of beans at high altitudes, has important economic and environmental implications, since significant amounts of wood have to be used.

Effect of Egyptian cooking methods of faba beans on its nutritive value, dietary protein utilization and iron deficiency anemia. 1. The role of main technological pretreatments.

In order to study the effects of main technological pretreatments practised for preparing Egyptian faba bean products, i.e. decortication as well as soaking and germination followed by dehulling on the nutritional value, series of experiments were carried out. Such pretreatments had a significant effect on the changes in the chemical composition of faba beans. The proportion of the removed hulls reached generally about 14%. Data revealed also pronounced improvements on the nutritive value as a result of all studied pretreatments, especially germination being the most effective. Chemical scoring of all determined essential amino acids was > 60, except methionine and cystine showed the lowest score (< 20). Germinated seeds had the highest chemical score for the restricting amino acids beside the lowest GDR value [Grams consumed of product to cover the daily requirements for adult man in protein (63 g) and in energy (2900 kcal)]. All pretreatments caused a significant decrease in the antinutritional factors, especially soaking followed by dehulling, whereas decortication led to a significant increase in phytic acid content.

Effect of green lentils on colonic function, nitrogen balance, and serum lipids in healthy human subjects.

Green lentils are an increasingly popular food, but their effects on human colonic function and serum lipids have been studied little. Nine healthy males aged 19-38 y consumed for 3-wk periods a controlled Western diet and the same diet supplemented with 130 g dry lentils/d [which contained 11.8 g non-starch polysaccharide (NSP)] incorporated into loaves, cakes, and soups. Protein was equilibrated with soy protein isolate and carbohydrate with soft drinks. Radioopaque markers were used to calculate mean transit time (MTT) and to correct fecal weight for infrequency of bowel movements. Feces were collected throughout the study and blood was taken on 2 d at the end of each period. Lentils increased fecal weight from 131 +/- 12 g/d (means +/- SEM) to 189 +/- 17.4 g/d (44.9%) (P < 0.005). MTT was unchanged: 46 +/- 6 h for the control diet and 43 +/- 4 h for the lentils (NS). Fecal nitrogen was increased to 2.49 +/- 0.08 g/d for lentils compared with 1.74 +/- 0.09 g/d for the control diet (P < 0.001) and urine nitrogen decreased to 15.31 +/- 0.52 g/d with the lentils compared with 15.90 +/- 0.51 g/d for the control diet (P < 0.05); nitrogen balance was unaffected. Serum lipids were unchanged by addition of lentils to the diet. Green lentils were effective in increasing fecal weight and can therefore make a valuable contribution to a healthy diet.

Protein quality of some Nigerian traditional diets based on the African yambean (Sphenostylis stenocarpa) and pigeon pea (Cajanus cajan).

The protein quality of Nigerian traditional diets based on the African yambean (AYB) and pigeon pea (PP) were performed by in vivo and in vitro bioassays. The individual foods were processed, cooked, dried and mixed to resemble the traditional diets. Weanling male Wistar rats (45-55 g) were used for the bioassay. The rats were fed ad libitum for 35 days of which 28 days were for growth and 7 days for N-balance. All the eleven diets including casein (control) provided 1.6 g N/100 g diet. The parameters tested include PER, growth, N-balance, BV, NPU and apparent digestibility (AD). The rats fed the AYB diets, except AYB: Agidi (Ag), showed superiority in most of the parameters tested. There were significant positive correlations between PER and NPU (r = 0.925; p < 0.001); PER and AD (r = 0.908; p < 0.001); PER and body weight gain (r = 0.969; p < 0.001). The in vitro protein digestibility of the diets was significantly correlated (r = 0.80; p < 0.01) with the in vivo apparent digestibility. These parameters were used to rank the various diets. Crayfish protein was a better supplement to legume/cereal or legume starchy staple mixtures than leguminous oil seed. However, supplementation of PP: steamed corn (SC) diet with crayfish did not prove beneficial. The result showed that diets based on the African yambean, an under-exploited legume, are nutritious. The need for its reintroduction into the fare of the populace through increased production and appropriate processing technology is stressed. The results of this study can form a base for the standardization of Nigerian diets based on these legumes.

Effects of soaking, cooking and fermentation on composition, in-vitro starch digestibility and nutritive value of common beans.

A common bean variety, grown in Burundi, was either fermented, soaked and/or cooked, and then assessed for nutrient composition, in-vitro starch digestibility and protein nutritive value. A decrease in ash, most minerals, vitamins, and some essential amino acids was noted for soaked, cooked and soaked-cooked beans. Compared to untreated beans, soaking decreased soluble sugar (9.8 percent) but increased starch (7.3 percent) and soluble fiber (16.9 percent). In cooked beans, an increase in soluble sugar (1.5 percent), and a decrease in thiamine (81.7 percent), starch (24.6 percent) and soluble fiber (16.6 percent) and nitrogen (2.9 percent) contents were observed. Crude fiber (6.9 percent) and starch (10.0 percent) increased while fat (17.6 percent), fatty acids (linoleic: 10.7 percent; linolenic: 14.3 percent) and soluble sugars (25.4 percent) and nitrogen (14.4 percent) decreased in soaked-cooked beans. Fermentation increased potassium (11.6 percent), soluble fiber (18.9 percent), and some amino acids but decreased fatty acids (linoleic: 13.5 percent; linolenic: 19.9 percent), soluble sugar (75.2 percent) and vitamin (riboflavin: 41.0 percent; niacin: 24.5 percent) contents in common beans. However, the in-vitro starch digestibility was greatly improved (12.3 percent) by cooking while it decreased in soaked beans (29.2 percent). Soaking-cooking and fermentation did not have any significant effect on the digestibility of common bean starch. Finally, among the five treatments applied to common beans, only fermentation showed a significant improvement (8.3 percent) on the protein nutritive value of this legume.

Effect of alkali treatments on the nutritive value of common bean (Phaseolus vulgaris).

The effect of alkali treatments of common bean seeds with red seed coat on the stability of antinutritional factors such as tannins, phytates and trypsim inhibitors, vitamins such as niacin and riboflavin and on protein quality has been studied. The samples were processed by soaking and pressure cooking in alkalies such as sodium hydroxide, sodium carbonate and sodium bicarbonate. At low temperature sodium carbonate and at high temperature sodium bicarbonate were found to be most effective in the extraction of tannins. At both low and high temperatures sodium carbonate was found to be more efficient in destruction of phytates. In the case of trypsin inhibitors, extraction at both low and high temperatures with sodium bicarbonate was most effective. Sodium hydroxide treatment was found to be better as far as the retention of niacin and riboflavin was considered.