A Systematic Investigation Unveils High Coinfection Status of Porcine Parvovirus Types 1 through 7 in China from 2016 to 2020.

Porcine parvovirus genotype 1 (PPV1) causes reproductive disorder in swine and is prevalent in China. Recently, six new genotypes of PPVs (PPV2 through PPV7) have also been detected in Chinese swine herds. However, the coinfection status of all these seven genotypes of PPVs (PPV1-7) in China was not clarified yet. In this study, we developed a panel of PPV1-7 PCR assays with satisfied specificity, sensitivity and reproducibility and then applied to the detection of PPV1-7 in 435 clinical samples collected from eight provinces of China in 2016-2020. A total of 55.40% samples (241 out of 435) were PPV positive, while PPV2 and PPV3 (both 22.53%) belonging to the genus of Tetraparvovirus were the most prevalent genotypes. Noticeably, PPV1-7 strains were more prevalent in nursery and finishing pigs than in suckling pigs. In addition, coinfection could be detected in all eight provinces and 27.36% (119/435) samples were coinfected with two to five genotypes of PPVs. Meanwhile, the coinfection of PPVs with PCV2 was 22.30% (97/435). Twenty complete genomes of representative PPV1-7 were determined, and phylogenetic analysis confirmed the genotyping results by sequence comparisons and PCR assays. Remarkably, the PPV7 HBTZ20180519-152 strain from domestic pig was recombined from parental JX15-like and JX38-like isolates from wild boars. Selective pressure analysis based on VP2 sequences of PPV1-7 showed that they were predominantly under negative selection, while few positive selection sites could be detected in VP2 of PPV7. Overall, this systematic investigation unveils high prevalence and coinfection of PPV1-7 in China from 2016 to 2020. IMPORTANCE Porcine parvoviruses (PPVs) are prevalent in China associating with reproductive failure in swine. The coinfection of seven genotypes of PPVs (PPV1-7) might have synergistic effects on PPV1 associated SMEDI syndrome. However, the coinfection status of PPV1-7 in China is not clear yet. This study showed that PPV1-7 strains are highly prevalent (55.40%) in China and mainly in nursery and finishing pigs in recent years. In addition, the coinfections of different genotypes of PPVs (27.36%) and PPVs with PCV2 (22.30%) are common. Geographic analysis indicated that different genotypes of PPVs are widely cocirculating in China. Intriguingly, a PPV7 strain from the domestic pig was detected as a recombinant from two wild boar isolates. Selective pressure analyses showed that PPV1-7 are mainly under purifying selection. Our findings provide the first systematic investigation on the prevalence, coinfection, and evolution of PPV1 through PPV7 in Chinese swineherds from 2016 to 2020.

The first report of porcine parvovirus 7 (PPV7) in Colombia demonstrates the presence of variants associated with modifications at the level of the VP2-capsid protein.

There are a wide variety of porcine parvoviruses (PPVs) referred to as PPV1 to PPV7. The latter was discovered in 2016 and later reported in some countries in America, Asia, and Europe. PPV7 as a pathogenic agent or coinfection with other pathogens causing disease has not yet been determined. In the present study, we report the identification of PPV7 for the first time in Colombia, where it was found retrospectively since 2015 in 40% of the provinces that make up the country (13/32), and the virus was ratified for 2018 in 4/5 provinces evaluated. Additionally, partial sequencing (nucleotides 380 to 4000) was performed of four Colombian strains completely covering the VP2 and NS1 viral genes. A sequence identity greater than 99% was found when comparing them with reference strains from the USA and China. In three of the four Colombian strains, an insertion of 15 nucleotides (five amino acids) was found in the PPV7-VP2 capsid protein (540-5554 nt; 180-184 aa). Based on this insertion, the VP2 phylogenetic analysis exhibited two well-differentiated evolutionarily related groups. To evaluate the impact of this insertion on the structure of the PPV7-VP2 capsid protein, the secondary structure of two different Colombian strains was predicted, and it was determined that the insertion is located in the coil region and not involved in significant changes in the structure of the protein. The 3D structure of the PPV7-VP2 capsid protein was determined by threading and homology modeling, and it was shown that the insertion did not imply a change in the shape of the protein. Additionally, it was determined that the insertion is not involved in suppressing a potential B cell epitope, although the increase in length of the epitope could affect the interaction with molecules that allow a specific immune response.

Osmolyte enhanced aqueous two-phase system for virus purification.

Due to the high variation in viral surface properties, a platform method for virus purification is still lacking. A potential alternative to the high-cost conventional methods is aqueous two-phase systems (ATPSs). However, optimizing virus purification in ATPS requires a large experimental design space, and the optimized systems are generally found to operate at high ATPS component concentrations. The high concentrations capitalize on hydrophobic and electrostatic interactions to obtain high viral particle yields. This study investigated using osmolytes as driving force enhancers to reduce the high concentration of ATPS components while maintaining high yields. The partitioning behavior of porcine parvovirus (PPV), a nonenveloped mammalian virus, and human immunodeficiency virus-like particle (HIV-VLP), a yeast-expressed enveloped VLP, were studied in a polyethylene glycol (PEG) 12 kDa-citrate system. The partitioning of the virus modalities was enhanced by osmoprotectants glycine and betaine, while trimethylamine N-oxide was ineffective for PPV. The increased partitioning to the PEG-rich phase pertained only to viruses, resulting in high virus purification. Recoveries were 100% for infectious PPV and 92% for the HIV-VLP, with high removal of the contaminant proteins and more than 60% DNA removal when glycine was added. The osmolyte-induced ATPS demonstrated a versatile method for virus purification, irrespective of the expression system.

Genetic analysis of porcine parvoviruses detected in South Korean wild boars.

Porcine parvovirus 1 (PPV1) is a major cause of reproductive failure in pigs. To date, six additional porcine parvoviruses (PPV2-PPV7) have been identified. In this study, we detected 11 PPV1 strains, five PPV3 strains, three PPV4 strains, six PPV5 strains, five PPV6 strains, and one PPV7 strain in Korean wild boars. PPV1, -3, and -5, and PPV6 from Korean wild boars harbor conserved motifs within the Ca2+ binding loop and the catalytic center of the PLA1 motif. Intra-species recombination among PPV7 strains was also identified. Genetic characterization revealed that PPV1 from Korean wild boars may be similar to virulent PPV strains.

A molecular survey reveals high occurrence of co-infections in intensive pork production farms with increased rates of mummified swine fetuses in Southern Brazil / [Pesquisa molecular revela alta ocorrência de coinfecções em granjas de produção intensiva de suínos com altas taxas de mumificação fetal no sul do Brasil]

Neste estudo, 308 amostras de fetos mumificados foram testadas para parvovírus suíno (PPV), circovírus suíno tipos 2 e 3 (PCV2 e PCV3) e leptospiras patogênicas. A idade gestacional no momento da perda gestacional e a frequência da mumificação fetal de acordo com a ordem de parto também foram investigadas. As amostras foram coletadas em granjas comerciais de criação de suínos da região sul do Brasil que apresentassem taxas de mumificação fetal igual ou maiores a 2,5%. Fragmentos de pulmão, rim, fígado e coração de fetos suínos mumificados foram coletados para análise molecular. Resultados da PCR foram classificados de acordo com a região de origem das amostras, tendo Santa Catarina, Paraná e Rio Grande do Sul contabilizado 87 (28,25%), 89 (28,90%) e 132 (42,86%) do total de amostras de fetos suínos mumificados, respectivamente. Coinfecções foram observadas na maioria dos casos e PCV3 foi o agente mais prevalente detectado, encontrado em 298 amostras (96,75%). A maioria das perdas gestacionais foi observada entre 50 e 70 dias de gestação (168; 54,5%) e a mumificação fetal não foi associada à ordem de parto das matrizes. Os achados sugerem que as altas taxas de fetos suínos mumificados na região Sul do Brasil podem ser explicadas pela infecção com esses agentes virais.(AU)

Development of a SYBR Green I real-time PCR assay for detection of novel porcine parvovirus 7.

In this study, we developed a SYBR Green I real-time PCR method for the rapid and sensitive detection of novel porcine parvovirus 7 (PPV7). Specific primers were designed based on the highly conserved region within the Capsid gene of PPV7. The established method was 1,000 times more sensitive than the conventional PCR method and had a detection limit of 35.6 copies. This method was specific and had no cross-reactions with PCV2, PCV3, PRV, PEDV, PPV1, and PPV6. Experiments testing the intra and interassay precision demonstrated a high reproducibility. Testing the newly established method with 200 clinical samples revealed a detection rate up to 17.5% higher than that of the conventional PCR assay. The established method could provide technical support for clinical diagnosis and epidemiological investigation of PPV7.

Evidence of porcine circovirus type 2 and co-infection with ungulate protoparvovirus 1 (porcine parvovirus) in mummies and stillborn piglets in subclinically infected farm.

Porcine circovirus type 2 (PCV2) and protoparvovirus 1 (PPV) were detected as single infection (6/131) and (11/131) respectively, or co-infection (6/131) in fetuses and stillborn piglets from normal deliveries in a farm without reproductive problems. Twenty in twenty-three positive samples were over 70 days of gestation, which is when the fetus becomes immunocompetent, and the presence of a NADL-2 PPV strain suggests fetal immune system impairment. Phylogenetic analysis of sequences obtained showed that 8/9 sequences are related to cluster 13 and the remaining is grouped into cluster 11 sequences. An increase in variability in ORF2 sequences in Argentina was observed. It is not clear whether the detection of fetuses positive to PPV and PCV2 is of epidemiological importance in a subclinically affected farm. However, the results of this study showed that currently used vaccines and vaccine protocols do not fully protect against PPV or PCV2 fetus infection.

SYBR Green-based real-time polymerase chain reaction assay for detection of porcine parvovirus 6 in pigs.

In this study, a SYBR Green-based real-time quantitative polymerase chain reaction (qPCR) assay was developed for rapid detection of porcine parvovirus (PPV) 6. Primer pairs targeting the conserved regions of PPV6 Capsid gene were designed. Sensitivity analyses revealed the lowest detection limit of the SYBR Green-based real-time PCR assay to be 47.8 copies/µL, which indicated it was 1000 times higher than that found in the conventional PCR investigations. This assay was specific and showed no cross-species amplification with other six porcine viruses. The assay demonstrated high repeatability and reproducibility; the intra- and inter-assay coefficients of variation were 0.79% and 0.42%, respectively. The positive detection rates of 180 clinical samples with SYBR Green-based real-time PCR and conventional PCR were 12.22% (22/180) and 4.44% (8/180), respectively. Our method is sensitive, specific, and reproducible. The use of SYBR Green-based real-time PCR may be suitable for the clinical detection and epidemiological investigation of PPV6.

Establishment of a porcine parvovirus (PPV) LAMP visual rapid detection method.

Porcine parvovirus (PPV) is one of the major causes of reproductive pig disease. Due to its serious nature, wide spread and consequent great damage to the swine industry, an effective, rapid and convenient method for its detection is needed. A loop-mediated isothermal amplification (LAMP) assay was established to detect PPV infection. Two pairs of primers were specifically designed to recognize the six different sequences of open reading frame1 (ORF1) gene. The optimized LAMP program was as follows: 50 min at 59 °C followed by 3 min at 80 °C.The amplified products were analyzed both by visual inspection after staining with SYBR Green I dye and by conventional agarose gel electrophoresis. Both methods showed the same sensitivity. The limit of detection (LOD) for PPV by LAMP was 10 copies, which is 100-fold lower than conventional PCR. Our LAMP assay did not cross-react with other viruses. We used the established LAMP system to test 1100 field samples and detected 660 positives. The LAMP detection method for PPV represents a visual, sensitive and rapid assay which can detect the virus in the field, offering an attractive alternative for the PPV detection methods currently in use.

Simultaneous identification of 6 pathogens causing porcine reproductive failure by using multiplex ligation-dependent probe amplification.

We developed a multiplex ligation-dependent probe amplification (MLPA) assay for the simultaneous detection of 6 clinically relevant viral pathogens causing porcine reproductive failure, that is porcine reproductive and respiratory syndrome virus (PRRSV), Japanese encephalitis virus (JEV), classical swine fever virus (CSFV), porcine circovirus type 2 (PCV2), pseudorabies virus (PRV) and porcine parvovirus (PPV). The limits of detection for the assay varied among the 6 target organisms from 1 to 8 copies per MLPA assay. The MLPA assay was evaluated with 346 heparinized porcine umbilical cord blood specimens, and the results of the assay were compared to those of real-time PCR. The MLPA assay showed specificities and sensitivities of 99.2% and 100%, respectively, for PRRSV; 100% and 100%, respectively, for CSFV, PCV2, PRV and PPV. No sample was found to be positive for JEV by either the MLPA assay or the real-time PCR. In conclusion, the MLPA assay has comparable clinical sensitivity to that of real-time PCR assay and provides a useful tool for fast screening porcine reproductive failure-associated viruses.

PCR-based detection and genetic characterization of porcine parvoviruses in South Korea in 2018.

BACKGROUND: with the advantage of sequencing technology, many novel porcine parvoviruses (PPV) rather than PPV1 has been reported. This study ultilized specific PCR- based method and gene- based analysis to study the presence and genetic diversity of porcine parvoviruses in South Korea in 2018. RESULTS: The present study was conducted in 2018 and found PPV1 and PPV7 in nine out of 151 field samples (organs and semen) by the PCR method. Among these, the complete genome sequences of five strains (N2, N91, N108, N133, and N141) were recovered. Phylogenic analysis revealed that the strains N2, N91, and N108 belong to the PPV1 genotype, while N133 and N141 belong to PPV7 genotype. The PPV7 strains collected in this study had deletion mutations in the VP2 gene but differed from that of PPV7 strains collected in 2017. Among the PPV1 strains, the amino acid variations in the B cell epitopes of the VP2 protein were observed between three Korean PPV1 field strains (N2, N91, and N108) and the reference PPV1 strains. Those substitutions resulted in six out of 12 predicted epitopes having significant differences in antigenic index compared to the other PPV1 strains. CONCLUSIONS: This study confirmed the presence of different genotypes of porcine parvoviruses in South Korea. The PPVs circulating in South Korea were phylogenetically classified as PPV1 and PPV7 genotypes. Three Korean PPV1 strains collected in 2018 were predicted to have antigenic alteration in VP2 compared to several reference strains of PPV1.

A retrospective study of DNA prevalence of porcine parvoviruses in Mexico and its relationship with porcine circovirus associated disease.

Worldwide, many emerging porcine parvoviruses (PPVs) have been linked to porcine circovirus-2 (PCV2) associated disease (PCVAD), which includes post-weaning multi-systemic wasting syndrome (PMWS), PCV2-related reproductive failure (PCV2-RF), as well as other syndromes. To determine the DNA prevalence of PPVs and their relationship with PMWS and PCV2-RF in Mexico, 170 formalin-fixed paraffin-embedded tissues were selected from archival collections to detect PPVs using a nested polymerase chain reaction. The tissues were composed of 50 PMWS cases, 20 age-matched tissues from healthy pigs, 56 PCV2-related reproductive failure (PCV2+ -RF) cases, and 44 PCV2- -RF cases. Overall, PPV2 and PPV6 were the most prevalent species (90.0% and 74.7%, respectively). In 8-11 week old pigs, the highest prevalence was for PPV6 and PPV3. Concerning reproductive failure, the PCV2-affected farms had a significantly higher prevalence for PPV6 (61.6%) and PPV5 (36.4%) than the PCV2-unaffected farms (35.0% and 5.0%, respectively). The concurrent infection rate was high, being significant for PPV2/PPV4 and PPV1/PPV5 within the PMWS cases and for PPV6/PPV5 among the PCV2+ -RF tissues. PPV5 showed a significant relationship with PMWS, whereas PPV5 and PPV6 were significant for PCVAD. The prevalence and coinfection rate of PPVs in Mexico were markedly higher than that described in other countries, denoting that PPV5 and PPV6 might have a potential role in PCVAD in Mexico. It is concluded that it is likely that the density population of pigs in Mexico is contributing to high PPV inter-species and PCV2 coinfections which might lead to a different pathogenic outcome.

Full-genome sequences of porcine circovirus 3 (PCV3) and high prevalence in mummified fetuses from commercial farms in Brazil.

The clinical implications of recently discovered porcine circovirus 3 (PCV3) infections are still unknown. The potential role of this emerging virus in reproductive loss in swine has been described. Herein, we report a high prevalence of PCV3 in mummified fetuses from sows maintained in modern farms in Rio Grande do Sul, Santa Catarina, Paraná, Goiás, and Mato Grosso do Sul states, Brazil. For this analysis, 276 mummified fetuses from 11 commercial swine farms were included. The presence of PCV3 DNA was confirmed using PCR, and the complete sequence of five different viral strains was obtained. Sequences of PCV3 genomes available on GenBank were then used for phylogenetic tree construction. Of the 276 mummified fetuses examined, 270 (nearly 97%) were positive for PCV3. In 93.1% of the fetuses, co-infections with at least one of the following agents were identified: porcine parvovirus (PPV), porcine circovirus 2 (PCV2) and Leptospira spp. Twelve fetuses were positive for PCV3 alone. The amino acid sequence of the capsid gene for the five viral strains shared 98-100% homology among them. Analysis of the DNA sequence indicates that the viruses identified in this study belong to the PCV3a1 subgroup. In summary, PCV3 DNA was detected in mummified fetuses at a surprisingly high rate. The role of PCV3 in porcine circovirus-associated disease (PCVAD) is still uncertain. However, considering that PCV3 has been detected in a variety of conditions, even in healthy animals, the present results confirm the need to investigate PCV3 as a causative agent of fetal mummification in swine.

Two novel protein chips for the detection of antibodies against porcine parvovirus.

BACKGROUND: PPV is one of the most important pathogens causing porcine reproductive disorder. It has been shown in clinical cases to be a commonly mixed infection with other important swine diseases which can aggravate the severity of the disease and bring serious economic losses to the pig industry. Serological methods, such as hemagglutination inhibition assays (HAI), serum neutralization (SN), and the modified direct complement-fixation (MDCF) test were utilized earlier, whereas the enzyme-linked immunosorbent assay (ELISA) is the most frequently applied assay to detect PPV-specific antibodies. RESULTS: We establish the visible protein chip and the cyanine dye 3 (Cy3)-labeled protein chip to detect the clinical serum from pigs. In this study, the recombinant protein VP2 of PPV was expressed in E.coli, purified with nickel magnetic beads, and then printed onto epoxy-coated glass slides for preparation of the protein chip. After a series of experiments, the conditions of antigen protein concentration, incubation time of primary antibody or secondary antibody, and optimal serum dilution fold were optimized, resulting in a successful visible protein chip and Cy3-labeled protein chip. The results showed that the positive serum, diluted up to 6000-fold, can be detected by the visible protein chip, and the positive serum, diluted up to 12,800-fold, can be detected by the Cy3-labeled protein chip, suggesting the high sensitivity of these protein chips. Moreover, the positive detection ratio, sensitivity, and specificity of these two kinds of protein chips were higher than those of commercial ELISA antibody detection kits. CONCLUSION: Overall, these two protein chips can be used to rapidly diagnose clinical samples with high throughput.

Clearance of porcine circovirus and porcine parvovirus from porcine-derived pepsin by low pH inactivation and cation exchange chromatography.

The contamination of oral rotavirus vaccines by porcine circovirus (PCV) raised questions about potential PCV contamination of other biological products when porcine trypsin or pepsin is used in production process. Several methods can be potentially implemented as a safety barrier when animal derived trypsin or pepsin is used. Removal of PCV is difficult by the commonly used viral filters with the pore size cutoff of approximately 20 nm because of the smaller size of PCV particles that are around 17 nm. It was speculated that operating the chromatography step at a pH higher than pepsin's low pI, but lower than pIs, of most viruses would allow the pepsin to flow through the resin and be recovered from the flow through pool whilst the viruses would be retained on the resin. In this study, we investigated low pH inactivation of viruses including PCV Type 1 (PCV1) and PCV1 removal by cation exchange chromatography (CEX) in the presence of pepsin. Both parvovirus and PCV1 could be effectively inactivated by low pH and PCV1 could be removed by POROS 50HS CEX. The POROS 50HS method presented in this article is helpful for designing other CEX methods for the same purpose and not much difference would be expected for similar product intermediates and same process parameters. While the effectiveness needs to be confirmed for specific applications, the results demonstrate that both low pH (pH 1.7) and CEX methods were successful in eliminating PCV1 and thus either can be considered as an effective virus barrier.

Nanobody­horseradish peroxidase and -EGFP fusions as reagents to detect porcine parvovirus in the immunoassays.

BACKGROUND: Antibodies are an important reagent to determine the specificity and accuracy of diagnostic immunoassays for various diseases. However, traditional antibodies have several shortcomings due to their limited abundance, difficulty in permanent storage, and required use of a secondary antibody. Nanobodies, which are derived from single-chain camelid antibodies, can circumvent many of these limitations and, thus, appear to be a promising substitute. In the presented study, a sandwich ELISA-like immunoassay and direct fluorescent assay with high sensitivity, good specificity, and easy operation were the first time to develop for detecting porcine parvovirus (PPV). After screening PPV viral particles 2 (VP2) specific nanobodies, horseradish peroxidase (HRP) and enhanced green fluorescent protein (EGFP) fusions were derived from the nanobodies by recombinant technology. Finally, using the nanobody-HRP and -EGFP fusions as probes, the developed immunoassays demonstrate specific, sensitive, and rapid detection of PPV. RESULTS: In the study, five PPV-VP2 specific nanobodies screened from an immunised Bactrian camel were successfully expressed with the bacterial system and purified with a Ni-NTA column. Based on the reporter-nanobody platform, HRP and EGFP fusions were separately produced by transfection of HEK293T cells. A sandwich ELISA-like assay for detecting PPV in the samples was firstly developed using PPV-VP2-Nb19 as the capture antibody and PPV-VP2-Nb56-HRP fusions as the detection antibody. The assay showed 92.1% agreement with real-time PCR and can be universally used to surveil PPV infection in the pig flock. In addition, a direct fluorescent assay using PPV-VP2-Nb12-EGFP fusion as a probe was developed to detect PPV in ST cells. The assay showed 81.5% agreement with real-time PCR and can be used in laboratory tests. CONCLUSIONS: For the first time, five PPV-VP2 specific nanobody-HRP and -EGFP fusions were produced as reagents for developing immunoassays. A sandwich ELISA-like immunoassay using PPV-VP2-Nb19 as the capture antibody and PPV-VP2-Nb56-HRP fusion as the detection antibody was the first time to develop for detecting PPV in different samples. Results showed that the immunoassay can be universally used to surveil PPV infection in pig flock. A direct fluorescent assay using PPV-VP2-Nb12-EGFP as a probe was also developed to detect PPV in ST cells. The two developed immunoassays eliminate the use of commercial secondary antibodies and shorten detection time. Meanwhile, both assays display great developmental prospect for further commercial production and application.

Isolation and phylogenetic analysis of a new Porcine parvovirus strain GD2013 in China.

Porcine parvovirus (PPV), a causative agent of an infectious reproductive disorder causing stillbirth, mummification, embryonic death and infertility (SMEDI) syndrome in swine, is a threat to both domestic pigs and wild boars regardless of age and gender. Recent studies found that the observed average substitution rate in the PPV genome was close to those of the RNA viruses and new strains showing serological neutralization activities different from that of the vaccine strain NADL-2 have been reported. These observations have increased the need for the development of new commercial vaccine strains. In this study, a new PPV strain, GD2013, was isolated from Guangdong, China, and its entire genome sequenced. A phylogenetic tree based on the complete coding region of the genomes of 32 PPV strains was constructed using the Bayesian Markov Chain Monte Carlo (MCMC) method. The results showed that strain GD2013 fell into the same phylogenetic cluster as the classical vaccine strains NADL-2 and POVCAP, suggesting a close relationship to the vaccine strains. Multiple sequence alignments and amino acid mutation analyses of the PPV VP2 gene revealed a new amino acid polymorphism site at Thr45 on VP2 that could be used to identify low virulence strains as vaccine candidates. Selective pressure analysis of the NS1 and VP2 genes by calculating the mean rates of non-synonymous substitutions (dN) over synonymous substitutions (dS) implied that both of these genes were under negative selection. Therefore, by using phylogenetic and amino acid mutation analyses, a likely candidate strain suitable for evaluation as an attenuated vaccine strain was identified.

Viral safety of APOSECTM: a novel peripheral blood mononuclear cell derived-biological for regenerative medicine.

BACKGROUND: Viral reduction and inactivation of cell-derived biologicals is paramount for patients' safety and so viral reduction needs to be demonstrated to regulatory bodies in order to obtain marketing authorisation. Allogeneic human blood-derived biological medicinal products require special attention. APOSECTM, the secretome harvested from selected human blood cells, is a new biological with promising regenerative capabilities. We evaluated the effectiveness of inactivation of model viruses by methylene blue/light treatment, lyophilisation, and gamma irradiation during the manufacturing process of APOSECTM. MATERIALS AND METHODS: Samples of intermediates of APOSECTM were acquired during the manufacturing process and spiked with bovine viral diarrhoea virus (BVDV), human immunodeficiency virus type 1 (HIV-1), pseudorabies virus (PRV), hepatitis A virus (HAV), and porcine parvovirus (PPV). Viral titres were assessed with suitable cell lines. RESULTS: Methylene blue-assisted viral reduction is mainly effective against enveloped viruses: the minimum log10 reduction factors for BVDV, HIV-1, and PRV were ≥6.42, ≥6.88, and ≥6.18, respectively, with no observed residual infectivity. Viral titres of both HAV and PPV were not significantly reduced, indicating minor inactivation of non-enveloped viruses. Lyophilisation had minor effects on the viability of several enveloped model viruses. Gamma irradiation contributes to the viral safety by reduction of enveloped viruses (BVDV: ≥2.42; HIV-1: 4.53; PRV: ≥4.61) and to some degree of non-enveloped viruses as seen for HAV with a minimum log10 reduction factor of 2.92. No significant reduction could be measured for the non-enveloped virus PPV (2.60). DISCUSSION: Three manufacturing steps of APOSECTM were evaluated under Good Laboratory Practice conditions for their efficacy at reducing and inactivating potentially present viruses. It could be demonstrated that all three steps contribute to the viral safety of APOSECTM.

Mannitol-induced gold nanoparticle aggregation for the ligand-free detection of viral particles.

Traditional virus detection methods require ligands that bind to either viral capsid proteins or viral nucleic acids. Ligands are typically antibodies or oligonucleotides and they are expensive, have limited chemical stability, and can only detect one specific type of virus at a time. Here, the biochemical surface properties of viruses are exploited for ligand-free, nonspecific virus detection. It has been found that the osmolyte mannitol can preferentially aggregate virus, while leaving proteins in solution. This led to the development of a ligand-free detection of virus using gold nanoparticle (AuNP) aggregation. Porcine parvovirus (PPV) was incubated with AuNPs and aggregation of the PPV-AuNP complex with mannitol was detected by dynamic light scattering (DLS). The lowest detectable concentration of PPV was estimated to be 106 MTT50 per mL, which is lower than standard antibody assays. PPV was also detected when swabbed from a dry surface and in the presence of a protein solution matrix. The enveloped bovine viral diarrhea virus (BVDV) was also detected using mannitol-induced aggregation of BVDV-coated AuNPs. The lowest detectable concentration of BVDV was estimated to be 104 MTT50 per mL. This demonstrates that gold nanoparticle aggregation can detect virus without the use of specific ligands.

Tie line framework to optimize non-enveloped virus recovery in aqueous two-phase systems.

Viral particle purification is a challenge due to the complexity of the broth, the particle size, and the need to maintain virus activity. Aqueous two-phase systems (ATPSs) are a viable alternative for the currently used and expensive downstream processes. This work investigated the purification of two non-enveloped viruses, porcine parvovirus (PPV), and human rhinovirus (HRV) at various ATPS tie lines. A polyethylene glycol (PEG) 12 kDa-citrate system at pH 7 was used to study the behavior of the partitioning on three different thermodynamic tie line lengths (TLLs). It was experimentally determined that increasing the TLL, and therefore increasing the hydrophobic and electrostatic driving forces within the ATPS, facilitated higher virus recoveries in the PEG-rich phase. A maximum of 79% recovery of infectious PPV was found at TLL 36 w/w% and tie line (TL) ratio 0.1. Increased loading of PPV was studied to observe the change in the partitioning behavior and similar trends were observed for all the TLs. Most contaminants remained in the citrate-rich phase at all the chosen TLLs, demonstrating purification of the virus from protein contaminants. Moderate DNA removal was also measured. Net neutral charged HRV was studied to demonstrate the effects of driving forces on neutrally charged viruses. HRV recovery trends remained similar to PPV on each TLL studied, but the values were lower than PPV. Recovery of viral particles in the PEG-rich phase of the PEG-citrate system utilized the difference in the surface hydrophobicity between virus and proteins and showed a direct dependence on the surface charge of each studied virus. The preferential partitioning of the relatively hydrophobic viral particles in the PEG-rich phase supports the hypothesis that both hydrophobic and electrostatic forces govern the purification of viruses in ATPS.